Abstract
Instability of a thin electrolyte film undergoing a direct current electroosmotic flow has been investigated. The film with a compliant electrolyte–air interface is flowing over a rigid charged substrate. Unlike previous studies, inclusion of the Maxwell stresses in the formulation shows the presence of a new finite wavenumber shear-flow mode of instability, alongside the more frequently observed long-wave interfacial mode. The shear mode is found to be the dominant mode of instability when the electrolyte–solid and electrolyte–air interfaces are of opposite charge or of same charge but have very large zeta-potential at the electrolyte–air interface. The conditions for mode-switch (interfacial to shear) and the direction of the travelling waves are discussed through stability diagrams. Interestingly, the analysis shows that when the interfaces are of nearly same zeta potential, the ‘free’ electrolyte–air interface behaves more like a ‘stationary’ wall because of the ion transport in the reverse direction of the flow.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Lyklema J.: Fundamentals of Microfluidics. Academic Press, New York (1995)
Hunter R.J.: Introduction to Modern Colloid Science. Oxford University Press, New York (1996)
Li D.: Electrokinetics in Microfluidics. Eleseier, Amsterdam (2004)
Masliyah J.H., Bhattacharjee S.: Electrokinetic and Colloid Transport Phenomena. Wiley, New York (2006)
Anderson J.L.: Colloid transport by interfacial forces. Ann. Rev. Fluid Mech. 21, 61–99 (1989)
Yang J., Lu F., Kwok D.Y.: Dynamic interfacial effect of electroosmotic slip flow with a moving capillary front in hydrophobic circular microchannels. J. Chem. Phys. 121, 7443–7448 (2004)
Suresh V., Homsy G.M.: Stability of time-modulated electroosmotic flow. Phys. Fluids 16, 2349–2356 (2004)
Hadermann A.F., Waters P.F., Woo J.W.: High voltage electroosmosis. Pressure voltage behavior in the system—Alumina-2-Propanol. J. Phys. Chem. 78, 65–69 (1974)
Iverson B.D., Garimella S.V.: Recent advances in microscale pumping technologies: a review and evaluation. Microfluid. Nanofluidics 5, 145–174 (2008)
Brask A., Goranovic G., Bruus H.: Electroosmotic pumping of nonconducting liquids by viscous drag from a secondary conducting liquid. Tech. Proc. Nanotech 1, 190–193 (2003)
Brask A., Goranovic G., Jenson M.J., Bruus H.: A novel electro-osmotic pump design for nonconducting liquids: theoretical analysis of flow rate-pressure characteristics and stability. J. Micromech. Microeng. 15, 883–891 (2005)
Stone H.A., Stroock A.D., Ajdari A.: Engineering flows in small devices: microfluidics towards a lab-on-a-chip. J. Fluid Mech. 36, 381–411 (2004)
Gao Y., Wong T.N., Yang C., Ooi K.T.: Transient two-liquid electroosmotic flow with electric charges at the interface. Colloid Surf. A 266, 117–128 (2005)
Gao Y., Wong T.N., Yang C., Ooi K.T.: Two-fluid electroosmotic flow in microchannels. J. Colloid Interface Sci. 284, 306–314 (2005)
Gao Y., Wong T.N., Chai J.C., Yang C., Ooi K.T.: Numerical simulation of two fluid electroosmotic flow in microchannels. Int. J. Heat Mass Transf 48, 5103–5111 (2005)
Gao Y., Wang C., Wong T.N., Yang C., Nguyen N.T., Ooi K.T.: Electro-osmotic control of the interface position of two-liquid flow through a microchannel. J. Micromech. Microeng. 17, 358–366 (2007)
Ngoma G.D., Erchiqui F.: Pressure gradient and electroosmotic effects on two immiscible fluids in a microchannel between two parallel plates. J. Micromech. Microeng. 16, 83–91 (2006)
McShea J. A., Callaghan I.C.: Electrokinetic potentials at the gas-aqueous interface by spinning cylinder electrophoresis. Colloid Polym. Sci. 261, 757–766 (1983)
Joo S.W.: A new hydrodynamic instability in ultra-thin films induced by electroosmosis. J. Mech. Sci. Technol. 22, 382–386 (2008)
Joo S.W.: A nonlinear study on the interfacial instabilities in electroosmotic flows based on the Debye-Huckel approximation. Microfluid. Nanofluidics 5, 417–423 (2008)
Qian S., Joo S.W., Jiang Y., Cheney M.A.: Free-surface problems in electrokinetic micro- and nanofluidics. Mech. Res. Commun. 36, 82–91 (2009)
Sadiq I.M.R., Joo S.W.: Weakly nonlinear stability analysis of an electro-osmotic thin film free surface flow. Microgravity Sci. Technol. 21, 331–343 (2009)
Lee J.S.H, Li D.: Electroosmotic flow at a liquid-air interface. Microfluid. Nanofluidics 2, 361–365 (2006)
Lee J.S.H., Barvulovic-Nad I., Wu Z., Xuan X., Li D.: Electrokinetic flow in a free surface-guided microchannel. J. Appl. Phys. 99, 054905 (2006)
Melcher J.R., Taylor G.I.: Electrohydrodynamics: a review of the role of interfacial shear stresses. Annu. Rev. Fluid Mech. 1, 111–146 (1969)
Saville D.A.: Electrohydrodynamics: the Taylor–Melcher leaky dielectric model. Annu. Rev. Fluid Mech. 29, 27–64 (1997)
Burcham C.L., Saville D.A.: Electrohydrodynamic stability: Taylor–Melcher theory for a liquid bridge suspended in a dielectric gas. J. Fluid. Mech. 452, 163–187 (2002)
Choi W.S., Sharma A., Qian S., Lim G., Joo S.W.: Is free surface free in micro-scale electrokinetic flows?. J. Colloid Interface Sci. 347, 153–155 (2010)
Wang J., Wang M., Li Z.: Lattice Poisson–Boltzmann simulation of electro-osmotic flows in microchannels. J. Colloid Interface Sci. 296, 729–736 (2006)
Weideman J.A.C., Reddy S.C.: A MATLAB differentiation matrix suite. ACM Trans. Math. Softw. 26, 465–519 (2000)
Don W.S., Solomonoff A.: Accuracy and speed in computing the Chebyshev collocation derivative. SIAM J. Sci. Comput. 6, 1253–1268 (1995)
Author information
Authors and Affiliations
Corresponding authors
Additional information
Communicated by Zikanov.
Electronic Supplementary Material
The Below is the Electronic Supplementary Material.
Rights and permissions
About this article
Cite this article
Ray, B., Reddy, P.D.S., Bandyopadhyay, D. et al. Instabilities in free-surface electroosmotic flows. Theor. Comput. Fluid Dyn. 26, 311–318 (2012). https://doi.org/10.1007/s00162-011-0234-x
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00162-011-0234-x