Abstract
A laboratory study was conducted to investigate the shear strength of bio cemented sands using enzyme-induced carbonate precipitation (EICP) via the direct shear test. Several specimens were prepared using four different application methods of EICP solution, namely spraying, mix-&-compact, percolation, and injection. Potential use of EICP for improving the sand-concrete interaction strength was also studied. Results indicated that the adopted application method of introducing the EICP solution to the soil affects the distribution pattern of CaCO3 precipitation in the soil matrix, thereby shear strength. Each method yielded a different response when sheared compared to untreated sand. The injection method was found to achieve higher shear strength and interparticle cementation under controlled rate and distribution followed by percolation. The spraying and mix-&-compact methods produced specimens with weaker particles’ bond and lower shear strength measurement but still showed relatively better performance than the untreated sands. Better cementation of soil grains was achieved in medium sand and when fine and organic materials were removed. Sands response to EICP-treatment was inferred to vary depending on the geotechnical characteristic of the soils. Moreover, the interfacial strength between sand and concrete was found to be enhanced after applying the EICP treatment as it coarsened soil particles.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Afrin H (2017) A review on different types soil stabilization techniques. International Journal of Transportation Engineering and Technology 3(2):19–24, DOI: https://doi.org/10.11648/j.ijtet.20170302.12
Ahenkorah I, Rahman MM, Karim MR, Beecham S (2021a) Optimisation of chemical constituents on enzyme-induced carbonate precipitation in test-tube and soil. Geotechnical Research 8(3):66–84, DOI: https://doi.org/10.1680/jgere.21.00006
Ahenkorah I, Rahman MM, Karim MR, Beecham S, Saint C (2021b) A review of enzyme induced carbonate precipitation (EICP): The role of enzyme kinetics. Sustainable Chemistry 2(1):92–114, DOI: https://doi.org/10.3390/suschem2010007
Almajed A (2017) Enzyme induced carbonate precipitation (EICP) for soil improvement. PhD Thesis, Arizona State University, Tempe, United States
Almajed A, Abbas H, Almusallam T, Al-Salloum Y (2021a) Stabilization of sand using energy efficient materials under normal and extreme hot weathers. Journal of Cleaner Production 285, DOI: https://doi.org/10.1016/j.jclepro.2020.124914
Almajed A, Abbas H, Arab MG, Alsabhan A, Hamid W, Al-Salloum Y (2020a) Enzyme-Induced Carbonate Precipitation (EICP)-Based methods for ecofriendly stabilization of different types of natural sands. Journal of Cleaner Production 274:122627, DOI: https://doi.org/10.1016/j.jclepro.2020.122627
Almajed A, Lateef MA, Moghal AAB, Lemboye K (2021b) State-of-the-art review of the applicability and challenges of microbial-induced calcite precipitation (MICP) and enzyme-induced calcite precipitation (EICP) techniques for geotechnical and geoenvironmental applications. Crystals 11(4):370, DOI: https://doi.org/10.3390/cryst11040370
Almajed A, Lemboye K, Arab MG, Alnuaim A (2020b) Mitigating wind erosion of sand using biopolymer-assisted EICP technique. Soils and Foundations 60(2):356–371, DOI: https://doi.org/10.1016/j.sandf.2020.02.011
Almajed A, Tirkolaei HK, Kavazanjian E (2018) Baseline investigation on enzyme-induced calcium carbonate precipitation. Journal of Geotechnical and Geoenvironmental Engineering 144(11):04018081, DOI: https://doi.org/10.1061/(asce)gt.1943-5606.0001973
Almajed A, Tirkolaei HK, Kavazanjian E, Hamdan NM (2019) Enzyme induced biocementated sand with high strength at low carbonate content. Scientific Reports 9(1):1135, DOI: https://doi.org/10.1038/s41598-018-38361-1
Arab MG, Alsodi R, Almajed A, Yasuhara H, Zeiada W, Shahin MA (2021a) State-of-the-art review of enzyme-induced calcite precipitation (EICP) for ground improvement: Applications and prospects. Geosciences 11(12):492, DOI: https://doi.org/10.3390/geosciences11120492
Arab MG, Omar M, Almajed A, Elbaz Y, Ahmed AH (2021b) Hybrid technique to produce bio-bricks using enzyme-induced carbonate precipitation (EICP) and sodium alginate biopolymer. Construction and Building Materials 284:122846, DOI: https://doi.org/10.1016/j.conbuildmat.2021.122846
Arab MG, Rohy H, Zeiada W, Almajed A, Omar M (2021c) One-Phase EICP Biotreatment of sand exposed to various environmental conditions. Journal of Materials in Civil Engineering 33(3): 04020489, DOI: https://doi.org/10.1061/(asce)mt.1943-5533.0003596
ASTM (2020) Determining the water (moisture) content, ash content, and organic material of peat and other organic soils. https://www.astm.org/d2974-20e01.html
ASTM (2012) Standard test method for direct shear test of soils under consolidated drained conditions, https://www.astm.org/standards/d3080
Cao J (2018) Bio-Inspired Geomaterial Improvement and Development of Innovative Characterization Methods. PhD Thesis, Missouri University of Science and Technology, Parker Hall, United States
Cao Z, Shen L, Zhao J, Liu L, Zhong S, Sun Y, Yang Y (2016) Toward a better practice for estimating the CO2 emission factors of cement production: An experience from China. Journal of Cleaner Production 139:527–539, DOI: https://doi.org/10.1016/j.jclepro.2016.08.070
Cerato AB, Lutenegger AJ (2006) Specimen size and scale effects of direct shear box tests of sands. Geotechnical Testing Journal 29(6):507–516, DOI: https://doi.org/10.1520/gtj100312
Chandra A, Ravi K (2021) Application of enzyme-induced carbonate precipitation (EICP) to improve the shear strength of different type of soils. Lecture Notes in Civil Engineering 88:617–632, DOI: https://doi.org/10.1007/978-981-15-6237-252
Das BM (2001) Soil Mechanics Laboratory Manual 6th Ed. Oxford University Press, USA., New York
Das BM (2003) Chemical and mechanical stabilization. Transportation Research Board http://onlinepubs.trb.org/onlinepubs/millennium/00018.pdf
Dejong JT, Fritzges MB, Nüsslein K (2006) Microbially induced cementation to control sand response to undrained shear. Journal of Geotechnical and Geoenvironmental Engineering 132(11):1381–1392, DOI: https://doi.org/10.1061/(ASCE)1090-0241(2006)132:11(1381)
Dejong JT, Soga K, Kavazanjian E, Burns S, van Paassen LA, AlQabany A, Aydilek A, Bang SS, Burbank M, Caslake LF, Chen CY, Cheng X, Chu J, Ciurli S, Esnault-Filet A, Fauriel S, Hamdan N, Hata T, Inagaki Y, Tsesarsky M (2013) Biogeochemical processes and geotechnical applications: Progress, opportunities and challenges. Geotechnique 63(4):287–301, DOI: https://doi.org/10.1680/geot.SIP13.P.017
Disu AA, Kolay PK (2021) A critical appraisal of soil stabilization using geopolymers: The past, present and future. International Journal of Geosynthetics and Ground Engineering 7(2), DOI: https://doi.org/10.1007/s40891-021-00267-w
Hamdan NM (2015) Applications of enzyme induced carbonate precipitation (EICP) for soil improvement. PhD Thesis, Arizona State University, Tempe, United States
Hamdan NM, Kavazanjian E (2016) Enzyme-induced carbonate mineral precipitation for fugitive dust control. Geotechnique 66(7):546–555. DOI: https://doi.org/10.1680/jgeot.15.P.168
Hamdan NM, Kavazanjian E, O’Donnell S (2013) Carbonate cementation via plant derived urease. 18th International Conference on Soil Mechanics and Geotechnical Engineering: Challenges and Innovations in Geotechnics, ICSMGE 2013 3(480):2489–2492, Paris, France
He J, Yang F, Qi YS, Fang CH, Yan BY, Zhang Y, Hang L, Gao YF (2021) Improvement in silty sand with enzyme-induced carbonate precipitation: Laboratory model experiment. Acta Geotechnica 17:2895–2905, DOI: https://doi.org/10.1007/s11440-021-01361-z
Iftikhar Y, He W, Wang Z (2016) Energy and CO2 emissions efficiency of major economies: A non-parametric analysis. Journal of Cleaner Production 139:779–787, DOI: https://doi.org/10.1016/j.jclepro.2016.08.072
Ismail MA, Joer HA, Randolph MF, Meritt A (2002) Cementation of porous materials using calcite. Geotechnique 52(5):313–324, DOI: https://doi.org/10.1680/geot.2002.52.5.313
Juran I, Riccobono O (1991) Reinforcing soft soils with artificially cemented compacted-sand columns. Journal of Geotechnical Engineering 117(7):1042–1060, DOI: https://doi.org/10.1061/(ASCE)0733-9410(1991)117:7(1042)
Kavazanjian E, Almajed A, Hamdan NM (2017) Bio-inspired soil improvement using EICP soil columns and soil nails. Grouting 2017 13–22, DOI: https://doi.org/10.1061/9780784480793.002
Kavazanjian E, Hamdan NM (2015) Enzyme induced carbonate precipitation (EICP) columns for ground improvement. IFCEE 2015, March 17–21, San Antonio, Texas, DOI: https://doi.org/10.1061/9780784479087.209
Krishnan V, Tirkolaei HK, Martin KK, Hamdan NM, van Paassen LA, Kavazanjian E (2021) Variability in the unconfined compressive strength of EICP-treated “Standard” sand. Journal of Geotechnical and Geoenvironmental Engineering 147(4):06021001, DOI: https://doi.org/10.1061/(asce)gt.1943-5606.0002480
Lemboye K, Almajed A, Alnuaim A, Arab M, Alshibli K (2021a) Improving sand wind erosion resistance using renewable agriculturally derived biopolymers. Aeolian Research 49:100663, DOI: https://doi.org/10.1016/j.aeolia.2020.100663
Lemboye K, Almajed A, Hamid W, Arab MG (2021b) Permeability investigation on sand treated using enzyme-induced carbonate precipitation and biopolymers. Innovative Infrastructure Solutions 6(3), DOI: https://doi.org/10.1007/s41062-021-00530-z
Li Y, Chan LS, Yeung AT, Xiang X (2013) Effects of test conditions on shear behaviour of composite soil. Proceedings of the Institution of Civil Engineers: Geotechnical Engineering 166(3):310–320, DOI: https://doi.org/10.1680/geng.11.00013
Lin H, Suleiman MT, Brown DG, Kavazanjian E (2016) Mechanical behavior of sands treated by microbially induced carbonate precipitation. Journal of Geotechnical and Geoenvironmental Engineering 142(2):04015066, DOI: https://doi.org/10.1061/(ASCE)GT.1943-5606.0001383
Liu KW, Jiang NJ, Qin JD, Wang YJ, Tang CS, Han XL (2021a) An experimental study of mitigating coastal sand dune erosion by microbial- and enzymatic-induced carbonate precipitation. Acta Geotechnica 16(2):467–480, DOI: https://doi.org/10.1007/s11440-020-01046-z
Liu J, Tong D, Zheng Y, Cheng J, Qin X, Shi Q, Yan L, Lei Y, Zhang Q (2021b) Carbon and air pollutant emissions from China’s cement industry 1990–2015: Trends, evolution of technologies, and drivers. Atmospheric Chemistry and Physics 21(3):1627–1647, DOI: https://doi.org/10.5194/acp-21-1627-2021
Makusa GP (2012) Soil stabilization methods and materials in engineering practice. Luleå tekniska universitet, Luleå Sweden
Martin KK, Tirkolaei HK, Kavazanjian E (2021a) Enhancing the strength of granular material with a modified enzyme-induced carbonate precipitation (EICP) treatment solution. Construction and Building Materials, 271:121529, DOI: https://doi.org/10.1016/j.conbuildmat.2020.121529
Martin KK, Tirkolaei HK, Kavazanjian E (2021b) Mid-scale biocemented soil columns via enzyme-induced carbonate precipitation (EICP). Soils and Foundations 61(6):1529–1542, DOI: https://doi.org/10.1016/j.sandf.2021.09.001
Martinez BC, Dejong JT (2009) Bio-mediated soil improvement: Load transfer mechanisms at the micro- and macro-scales. Advances in Ground Improvement, American Society of Civil Engineers, Reston, VA, DOI: https://doi.org/10.1061/41025(338)26
Muhammed AS, Kassim KA, Zango MU, Ahmad K, Makinda J (2021) Enhancing the strength of sandy soil through enzyme-induced calcite precipitation. International Journal of Geosynthetics and Ground Engineering 7(2):1–10, DOI: https://doi.org/10.1007/s40891-021-00289-4
Mujah D, Shahin MA, Cheng L (2017) State-of-the-art review of biocementation by microbially induced calcite precipitation (MICP) for soil stabilization. Geomicrobiology Journal 34(6):524–537, DOI: https://doi.org/10.1080/01490451.2016.1225866
Myhr A, Røyne F, Brandtsegg AS, Bjerkseter C, Throne-Holst H, Borch A, Wentzel A, Røyne A (2019) Towards a low CO2 emission building material employing bacterial metabolism (2/2): Prospects for global warming potential reduction in the concrete industry. PLoS One 14(4), DOI: https://doi.org/10.1371/journal.pone.0208643
Neupane D, Yasuhara H, Kinoshita N, Ando Y (2015a) Distribution of mineralized carbonate and its quantification method in enzyme mediated calcite precipitation technique. Soils and Foundations 55(2):447–457, DOI: https://doi.org/10.1016/j.sandf.2015.02.018
Neupane D, Yasuhara H, Kinoshita N, Putra H (2015b) Distribution of grout material within 1-m sand column in insitu calcite precipitation technique. Soils and Foundations 55(6):1512–1518, DOI: https://doi.org/10.1016/j.sandf.2015.10.015
Neupane D, Yasuhara H, Kinoshita N, Unno T (2013) Applicability of enzymatic calcium carbonate precipitation as a soil-strengthening technique. Journal of Geotechnical and Geoenvironmental Engineering 139(12):2201–2211, DOI: https://doi.org/10.1061/(asce)gt.1943-5606.0000959
Ossai R, Rivera L, Bandini P (2020) Experimental study to determine an EICP application method feasible for field treatment for soil erosion control. Geo-Congress 2020, American Society of Civil Engineers, Reston, VA, DOI: https://doi.org/10.1061/9780784482834.023
Pandey G (2018) Feasibility study of water based/polymer modified EICP for soil improvement involving recycled glass aggregate. MSc Thesis, University of Akron, United States
Park SS, Choi SG, Nam IH (2014) Effect of plant-induced calcite precipitation on the strength of sand. Journal of Materials in Civil Engineering 26(8):06014017, DOI: https://doi.org/10.1061/(asce)mt.1943-5533.0001029
Putra H, Yasuhara H, Kinoshita N (2017) Optimum condition for the application of enzyme-mediated calcite precipitation technique as soil improvement method. International Journal on Advanced Science, Engineering and Information Technology 7(8):2145–2151, DOI: https://doi.org/10.18517/ijaseit.7.6.3425
Ran D, Kawasaki S (2016) Effective use of plant-derived urease in the field of geoenvironmental/geotechnical engineering. Journal of Civil & Environmental Engineering 6(1):1–13, DOI: https://doi.org/10.4172/2165-784X.1000207
Rohy H, Arab MG, Zeiada W, Omar M, Almajed A, Tahmaz A (2019) One phase soil bio-cementation with eicp-soil mixing. World Congress on Civil, Structural, and Environmental Engineering, DOI: https://doi.org/10.11159/icgre19.164
Roy A (2017) Soil Stabilization using Rice Husk Ash and Cement. International Research Journal of Engineering and Technology (IRJET) 4(2):49–54
Schnaid F, Prietto PDM, Consoli NC (2001) Characterization of cemented sand in triaxial compression. Journal of Geotechnical and Geoenvironmental Engineering 127(10):857–868, DOI: https://doi.org/10.1061/(ASCE)1090-0241(2001)127:10(857)
Song JY, Sim Y, Jang J, Hong WT, Yun TS (2020) Near-surface soil stabilization by enzyme-induced carbonate precipitation for fugitive dust suppression. Acta Geotechnica 15(7):1967–1980, DOI: https://doi.org/10.1007/s11440-019-00881-z
Wang HL, Yin ZY (2021) Unconfined compressive strength of bio-cemented sand: state-of-the-art review and MEP-MC-based model development. Journal of Cleaner Production 315, DOI: https://doi.org/10.1016/j.jclepro.2021.128205
Yasuhara H, Hayashi K, Okamura M (2011) Evolution in mechanical and hydraulic properties of calcite-cemented sand mediated by biocatalyst. Geo-Frontiers 2011, American Society of Civil Engineers, Reston, VA, DOI: https://doi.org/10.1061/41165(397)407
Yasuhara H, Neupane D, Hayashi K, Okamura M (2012) Experiments and predictions of physical properties of sand cemented by enzymatically-induced carbonate precipitation. Soils and Foundations 52(3):539–549, DOI: https://doi.org/10.1016/j.sandf.2012.05.011
Yu X, Chu J, Yang Y, Qian C (2021) Reduction of ammonia production in the biocementation process for sand using a new biocement. Journal of Cleaner Production 286, DOI: https://doi.org/10.1016/j.jclepro.2020.124928
Yuan H, Ren G, Liu K, Zhao Z (2021) Effect of incorporating polyvinyl alcohol fiber on the mechanical properties of eicp-treated sand. Materials 14(11), DOI: https://doi.org/10.3390/ma14112765
Yuan H, Ren G, Liu K, Zheng W, Zhao Z (2020) Experimental study of EICP combined with organic materials for silt improvement in the yellow river flood area. Applied Sciences 10(21):7678, DOI: https://doi.org/10.3390/app10217678
Zehner J, Røyne A, Sikorski P (2021) A sample cell for the study of enzyme-induced carbonate precipitation at the grain-scale and its implications for biocementation. Scientific Reports 11(1):1–11 DOI: https://doi.org/10.1038/s41598-021-92235-7
Zhang M, Guo H, El-Korchi T, Zhang G, Tao M (2013) Experimental feasibility study of geopolymer as the next-generation soil stabilizer. Construction and Building Materials 47:1468–1478, DOI: https://doi.org/10.1016/j.conbuildmat.2013.06.017
Acknowledgments
The authors would like to acknowledge the Researchers Supporting Project number (RSP2023R285), King Saud University, Riyadh, Saudi Arabia.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Alwalan, M., Almajed, A., Lemboye, K. et al. Direct Shear Characteristics of Enzymatically Cemented Sands. KSCE J Civ Eng 27, 1512–1525 (2023). https://doi.org/10.1007/s12205-023-0817-2
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12205-023-0817-2