Abstract
Face passive failure can severely damage existing structures and underground utilities during shallow shield tunneling, especially in coastal backfill sand. In this work, a series of laboratory model tests were developed and conducted to investigate such failure, for tunnels located at burial depth ratios for which C/D = 0.5, 0.8, 1, and 1.3. Support pressures, the evolution of failure processes, the failure modes, and the distribution of velocity fields were examined through model tests and numerical analyses. The support pressure in the tests first rose rapidly to the elastic limit and then gradually increased to the maximum value in all cases. The maximum support pressure decreased slightly in cases where C/D = 0.8, 1, and 1.3, but the rebound was insignificant where C/D = 0.5. In addition, the configuration of the failure mode with C/D = 0.5 showed a wedge-shaped arch, which was determined by the outcropping shear failure. The configuration of failure modes was composed of an arch and the inverted trapezoid when C/D = 0.8, 1, and 1.3, in which the mode was divided into lower and upper failure zones.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Guglielmetti V, Grasso P, Mahtab A, Xu S L. Mechanized Tunneling in Urban Areas: Design Methodology and Construction Control. London: Taylor and Francis, 2008, 2–14
Qian W F, Huang M, Sun C M, Huang B, Wang G F, Liu H. Adaptability of earth pressure balance shield tunneling in coastal complex formations: A new evaluation method. Geomechanics and Engineering, 2021, 27: 425–440
Liao S, Liu J, Wang R, Li Z. Shield tunneling and environment protection in Shanghai soft ground. Tunnelling and Underground Space Technology, 2009, 24: 454–465
Sterpi D, Rizzo F, Renda D, Aguglia F, Zenti C. Soil nailing at the tunnel face in difficult conditions: A case study. Tunnelling and Underground Space Technology, 2013, 38: 129–139
Chen R P, Yin X, Tang L, Chen Y. Centrifugal model tests on face failure of earth pressure balance shield induced by steady state seepage in saturated sandy silt ground. Tunnelling and Underground Space Technology, 2018, 81: 315–325
Yin Z Y, Wang P, Zhang F S. Effect of particle shape on the progressive failure of shield tunnel face in granular soils by coupled FDM-DEM method. Tunnelling and Underground Space Technology, 2020, 100: 103394
Chen R P, Li J, Kong L G, Tang L J. Experimental study on face instability of shield tunnel in sand. Tunnelling and Underground Space Technology, 2013, 33: 12–21
Sun X H, Miao L C, Lin H S, Tong T Z. Soil arch effect analysis of shield tunnel in dry sandy ground. International Journal of Geomechanics, 2018, 18(6): 04018057
Liu W, Zhao Y, Shi P X, Li J Y, Gan P L. Face stability analysis of shield-driven tunnels shallowly buried in dry sand using 1–g large-scale model tests. Acta Geotechnica, 2018, 13(3): 693–705
Wong K S, Ng C W W, Chen Y M, Bian X C. Centrifuge and numerical investigation of passive failure of tunnel face in sand. Tunnelling and Underground Space Technology, 2012, 28(3): 297–303
Ng C W W, Wong K S. Investigation of passive failure and deformation mechanisms due to tunneling in clay. Canadian Geotechnical Journal, 2013, 50(4): 359–372
Liu W, Shi P X, Chen L J, Tang Q. Analytical analysis of working face passive stability during shield tunneling in frictional soils. Acta Geotechnica, 2020, 15(3): 781–794
Klotz U, Vermeer P, Klotz C, Möller S. A 3D finite element simulation of a shield tunnel in weathered Singapore Bukit Timah granite. Tunnelling and Underground Space Technology, 2006, 21(3–4): 272
Bezuijen A, Brassinga H M. Tunneling. A Decade of Progress. GeoDelft. London: Taylor and Francis, 2005, 143–148
Qi L Z. Study on blow-out face pressure of shield tunnels in sand. Thesis for the Master’s Degree. Hangzhou: Zhejiang University, 2012 (in Chinese)
GB 50157-2013. Code for Design of Metro. Beijing: Ministry of Housing and Urban-Rural Development of the People’s Republic of China, 2013 (in Chinese)
Li P F, Chen K Y, Wang F, Li Z. An upper-bound analytical model of blow-out for a shallow tunnel in sand considering the partial failure within the face. Tunnelling and Underground Space Technology, 2019, 91: 102989
Xu K, Huang M, Zhen J J, Xu C S, Cui M J. Field implementation of enzyme-induced carbonate precipitation technology for reinforcing a bedding layer beneath an underground cable duct. Journal of Rock Mechanics and Geotechnical Engineering, 2023, 15: 1011–1022
Horn N. Horizontal earth pressure on perpendicular tunnel face. In: Proceedings of the Hungarian National Conference of the Foundation Engineer Industry. Budapest: Akadémiai Kiadó, 1961, 7–16 (in Hungarian)
Broere W. Tunnel face stability and new CPT applications. Dissertation for the Doctoral Degree. Delft: Delft University of Technology, 2001
Hu X Y, Zhang Z X, Kieffer S. A real-life stability model for a large shield-driven tunnel in heterogeneous soft soils. Frontiers of Structural and Civil Engineering, 2012, 6(2): 176–187
Perazzelli P, Leone T, Anagnostou G. Tunnel face stability under seepage flow conditions. Tunnelling and Underground Space Technology, 2014, 43: 459–469
Anagnostou G, Perazzelli P. Analysis method and design charts for bolt reinforcement of the tunnel face in cohesive-frictional soils. Tunnelling and Underground Space Technology, 2015, 47: 162–181
Chen R P, Tang L J, Yin X S, Chen Y M, Bian X C. An improved 3D wedge-prism model for the face stability analysis of the shield tunnel in cohesionless soils. Acta Geotechnica, 2015, 10: 683–692
Huang M, Zhan J W. Face stability assessment for underwater tunneling across a fault zone. Journal of Performance of Constructed Facilities, 2019, 33(3): 04019034
Zhang X, Wang M N, Li J W, Wang Z L, Tong J J, Liu D G. Safety factor analysis of a tunnel face with an unsupported span in cohesive-frictional soils. Computers and Geotechnics, 2020, 117: 103221
Zhang X, Wang M N, Wang Z L, Li J W, Tong J J, Liu D G. A limit equilibrium model for the reinforced face stability analysis of a shallow tunnel in cohesive-frictional soils. Tunnelling and Underground Space Technology, 2020, 105: 103562
Cheng C, Ni P, Zhao W, Jia P, Gao S, Wang Z, Deng C. Face stability analysis of EPB shield tunnel in dense sand stratum considering the evolution of failure pattern. Computers and Geotechnics, 2021, 130: 103890
Leca E, Dormieux L. Upper and lower bound solutions for the face stability of shallow circular tunnels in frictional material. Geotechnique, 1990, 40(4): 581–606
Soubra A H, Dias D, Emeriault F, Kastner R. Three-dimensional face stability analysis of circular tunnels by a kinematical approach. In: Proceedings of GeoCongress 2008: Characterization, Monitoring, and Modeling of GeoSystems. New Orleans: ASCE, 2008: 894–901
Mollon G, Dias D, Soubra A H. Face stability analysis of circular tunnels driven by a pressurized shield. Journal of Geotechnical and Geoenvironmental Engineering, 2010, 136(1): 215–229
Mollon G, Dias D, Soubra A H. Probabilistic analysis of pressurized tunnels against face stability using collocation-based stochastic response surface method. Journal of Geotechnical and Geoenvironmental Engineering, 2011, 137(4): 385–397
Mollon G, Dias D, Soubra A H. Rotational failure mechanisms for the face stability analysis of tunnels driven by a pressurized shield. International Journal for Numerical and Analytical Methods in Geomechanics, 2011, 35(12): 1363–1388
Tang X W, Liu W, Albers B, Savidis S. Upper bound analysis of tunnel face stability in layered soils. Acta Geotechnica, 2014, 9(4): 661–671
Zhang C P, Han K H, Zhang D L. Face stability analysis of shallow circular tunnels in cohesive-frictional soils. Tunnelling and Underground Space Technology, 2015, 50: 345–357
Pan Q J, Dias D. Safety factor assessment of a tunnel face reinforced by horizontal dowels. Engineering Structures, 2017, 142: 56–66
Ding W T, Liu K Q, Shi P H, Li M J, Hou M L. Face stability analysis of shallow circular tunnels driven by a pressurized shield in purely cohesive soils under undrained conditions. Computers and Geotechnics, 2019, 107: 110–127
Li P F, Wei Y J, Zhang M J, Huang Q F, Wang F. Influence of non-associated flow rule on passive face instability for shallow shield tunnels. Tunnelling and Underground Space Technology, 2022, 119: 104202
Di Q D, Li P F, Zhang M J, Zhang W J, Wang X Y. Analysis of face stability for tunnels under seepage flow in the saturated ground. Ocean Engineering, 2022, 266: 112674
Di Q D, Li P F, Zhang M J, Guo C X, Wang F, Wu J. Three-dimensional theoretical analysis of seepage field in front of shield tunnel face. Underground Space, 2022, 7(4): 528–542
Ukritchon B, Yingchaloenkitkhajorn K, Keawsawasvong S. Three-dimensional undrained tunnel face stability in clay with a linearly increasing shear strength with depth. Computers and Geotechnics, 2017, 88: 146–151
Ding X B, Li K, Xie Y X, Liu S Z. Face stability analysis of large shield-driven tunnel in rock–soil interface composite formations. Underground Space, 2022, 7(6): 1021–1035
Li W, Zhang C P, Zhang D L, Ye Z J, Tan Z B. Face stability of shield tunnels considering a kinematically admissible velocity field of soil arching. Journal of Rock Mechanics and Geotechnical Engineering, 2022, 14(2): 505–526
Senent S, Jimenez R. A tunnel face failure mechanism for layered ground, considering the possibility of partial collapse. Tunnelling and Underground Space Technology, 2015, 47: 182–192
Chen R P, Tang L, Ling D, Chen Y. Face stability analysis of shallow shield tunnels in dry sandy ground using the discrete element method. Computers and Geotechnics, 2011, 38(2): 187–195
Zhang Z, Hu X, Scott K. A discrete numerical approach for modeling face stability in slurry shield tunneling in soft soils. Computers and Geotechnics, 2011, 38(1): 94–104
Zhang Z H, Xu W S, Nie W T, Deng L M. DEM and theoretical analyses of the face stability of shallow shield cross-river tunnels in silty fine sand. Computers and Geotechnics, 2021, 130: 103905
Chambon P, Corté J F. Shallow tunnels in cohesionless soil: Stability of tunnel face. Journal of Geotechnical Engineering, 1994, 120(7): 1148–1165
Idinger G, Aklik P, Wu W, Borja R I. Centrifuge model test on the face stability of shallow tunnel. Acta Geotechnica, 2011, 6(2): 105–117
Weng X L, Sun Y F, Yan B H, Niu H S, Lin R A, Zhou S Q. Centrifuge testing and numerical modeling of tunnel face stability considering longitudinal slope angle and steady state seepage in soft clay. Tunnelling and Underground Space Technology, 2020, 101: 103406
Kirsch A. Experimental investigation of the face stability of shallow tunnels in sand. Acta Geotechnica, 2010, 5(1): 43–62
Berthoz N, Branque D, Subrin D, Wong H, Humbert E. Face failure in homogeneous and stratified soft ground: theoretical and experimental approaches on 1g EPBS reduced scale model. Tunnelling and Underground Space Technology, 2012, 30: 25–37
Di Q D, Li P F, Zhang M J, Cui X P. Influence of relative density on deformation and failure characteristics induced by tunnel face instability in sandy cobble strata. Engineering Failure Analysis, 2022, 141: 106641
Di Q D, Li P F, Zhang M J, Cui X P. Experimental study of face stability for shield tunnels in sandy cobble strata of different densities. Tunnelling and Underground Space Technology, 2023, 135: 105029
Di Q D, Li P F, Zhang M J, Cui X P. Experimental investigation of face instability for tunnels in sandy cobble strata. Underground Space, 2023, 10: 199–216
Cheng C, Jia P J, Zhao W, Ni P P, Bai Q, Wang Z J, Lu B. Experimental and analytical study of shield tunnel face in dense sand stratum considering different longitudinal inclination. Tunnelling and Underground Space Technology, 2021, 113: 103950
Zhang X, Wang M, Lyu C, Tong J, Yu L, Liu D. Experimental and numerical study on tunnel faces reinforced by horizontal bolts in sandy ground. Tunnelling and Underground Space Technology, 2022, 123: 104412
Lei H Y, Zhang Y J, Hu Y, Liu Y N. Model test and discrete element method simulation of shield tunneling face stability in transparent clay. Frontiers of Structural and Civil Engineering, 2021, 15(1): 147–166
Ma S K, Duan Z B, Huang Z, Liu Y, Shao Y. Study on the stability of shield tunnel face in clay and clay-gravel stratum through large-scale physical model tests with transparent soil. Tunnelling and Underground Space Technology, 2022, 119: 104199
Lü X L, Zhou Y C, Huang M S, Zeng S. Experimental study of the face stability of shield tunnel in sands under seepage condition. Tunnelling and Underground Space Technology, 2018, 74: 195–205
Jia Z, Bai Y T, Liu C, Zhang D S, Ji Y P, Zhao H H. Visualization investigation on stability of shield tunnel face with transparent soil, considering different longitudinal inclination angles. Tunnelling and Underground Space Technology, 2023, 137: 105154
Saiyar M, Ni P, Take W A, Moore I D. Response of pipelines of differing flexural stiffness to normal faulting. Geotechnique, 2016, 66(4): 275–286
Tognon A R, Rowe R K, Brachman R W I. Evaluation of side wall friction for a buried pipe testing facility. Geotextiles and Geomembranes, 1999, 17(4): 193–212
TB 10001-2016. Technical Code for Design of Railway Tunnel. Beijing: National Railway Administration of People’s Republic of China, 2016 (in Chinese)
Fang Q, Liu X, Zeng K H, Zhang X D, Zhou M Z, Du J M. Centrifuge modelling of tunneling below existing twin tunnels with different types of support. Underground Space, 2022, 7(6): 1125–1138
Gioda G, Swoboda G. Developments and applications of the numerical analysis of tunnels in continuous media. International Journal for Numerical and Analytical Methods in Geomechanics, 1999, 23(13): 1393–1405
Acknowledgements
This work was supported by the National Natural Science Foundation of China (Grant No. 41972276), the Natural Science Foundation of Fujian Province (No. 2020J06013), and the “Foal Eagle Program” Youth Top-notch Talent Project of Fujian Province (No. 00387088). This financial support is gratefully acknowledged.
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Competing interests The authors declare that they have no competing interests.
Rights and permissions
About this article
Cite this article
Qian, W., Huang, M., Wang, B. et al. Experimental study of face passive failure features of a shallow shield tunnel in coastal backfill sand. Front. Struct. Civ. Eng. 18, 252–271 (2024). https://doi.org/10.1007/s11709-024-1059-1
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11709-024-1059-1