Abstract
Carbonates are a class of compounds that have recently found increasing interest in commercial applications owing to their physical properties and relatively straightforward synthesis. In this work, physical and fuel properties of five straight-chain C17–39 and three branched C17–33 oleochemical carbonates were investigated. These properties included cetane number (CN), low-temperature properties, (kinematic) viscosity, lubricity, and surface tension. The carbonates studied had CN ranging from 47 to 107 depending on carbon chain length and branching. For the same number of carbons, the CN of carbonates were lower than those of FA alkyl esters owing to interruption of the CH2 chain by the carbonate moiety. Kinematic viscosities at 40°C ranged from 4.9 to 22.6 mm2/s whereas m.p. ranged from +3 to below −50°C depending on the carbonate structure. High-frequency reciprocating rig testing showed the neat carbonates to have acceptable lubricity that improved as chain length increased. Finally, the carbonate's ability to influence cold-flow properties in biodiesel (methyl soyate) and lubricity in low-lubricity ultra-low sulfur diesel were examined. The carbonates studied did not significantly affect cold flow or lubricity properties at concentrations up to 10,000 ppm (1 wt%). The properties of the carbonates resemble those of fatty alkyl esters with similar trends resulting from compound structure.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Shaikh, A.-A.G., and S. Sivaram, Organic Carbonates, Chem. Rev. 96:951–976 (1996).
Parrish, J.P., R.N. Salvatore, and K.W. Jung, Perspectives on Alkyl Carbonates in Organic Synthesis, Tetrahedron 56:8207–8237 (2000).
Buysch, H.-J., Carbonic Esters, in Ullmann's Encyclopedia of Industrial Chemistry, 6th edn., Wiley-VCH, Weinheim, 2003, pp. 427–455.
Roh, N.-S., B.C. Dunn, E.M. Eyring, R.J. Pugmire, and H.L.C. Meuzelaar, Production of Diethyl Carbonate from Ethanol and Carbon Monoxide over a Heterogeneous Catalytic Flow Reactor, Fuel Process Technol. 83:27–38 (2003).
Delledonne, D., F. Rivetti, and U. Romano, Developments in the Production and Application of Dimethylcarbonate, Appl. Cat. A: Gen. 221:241–251 (2001).
Ono, Y., Dimethyl Carbonate for Environmentally Benign Reactions, Catal. Today 35:15–25 (1997).
Fisicaro, G., and G. Gerbaz, Dialkylcarbonates, in Synthetic Lubricants and High-Performance Functional Fluids, edited by R.L. Shubkin, Marcel Dekker, New York, 1993, pp. 229–239.
Gryglewicz, S., F.A. Oko, and G. Gryglewicz, Synthesis of Modern Synthetic Oils Based on Dialkyl Carbonates, Ind. Eng. Chem. Res. 42:5007–5010 (2003).
Westfechtel, A., F. Bongardt, and A. Ansmann, Guerbet Carbonates, U.S. Patent 5,387,374 (1995).
Ansmann, A., U. Issberner, S. Bruening, B. Jackwerth, and D. Hoffmann, Wax-Based Compositions for the Preparation of Cosmetic Tissues and Wipes, WO Patent 2003005981 (2003).
Suetake, T., Oily Solid Cosmetics Containing Dialkyl Carbonates, Japanese Patent 20011328918 (2001).
Giolito, S.L., J.C. Goswami, and E. Weil, Carbonate Esters, Carbonate Ester Compositions, and Plasticized Compositions, U.S. Patent 4,403,056 (1983).
Knothe, G., A.C. Matheaus, and T.W. Ryan, III, Cetane Numbers of Branched and Straight-Chain Esters Determined in an Ignition Quality Tester, Fuel 82:971–975 (2003).
Foglia, T.A., L.A. Nelson, R.O. Dunn, and W.N. Marmer, Low-Temperature Properties of Alkyl Esters of Tallow and Grease, J. Am. Oil Chem. Soc. 74:951–955 (1997).
Geller, D.P., and J.W. Goodrum, Effects of Specific Fatty Acid Methyl Esters on Diesel Fuel Lubricity, Fuel 83:2351–2356 (2004).
Kenar, J.A., G. Knothe, and A.L. Copes, Synthesis and Characterization of Dialkyl Carbonates Prepared from Mid-, Long-Chain, and Guerbet Alcohols, J. Am. Oil Chem. Soc. 81:285–291 (2004).
American Society for Testing and Materials, D445, Standard Test Method for Kinematic Viscosity of Transparent and Opaque Liquids (and the Calculation of Dynamic Viscosity), in Annual Book of ASTM Standards, Vol. 05.03, ASTM International, West Conshohocken, PA, 2003.
American Society for Testing and Materials. D 5773, Standard Test Method for Cloud Point of Petroleum Products (Constant Cooling Rate Method), in Annual Book of ASTM Standards, Vol. 05.03, ASTM International, West Conshohocken, PA, 2003.
American Society for Testing and Materials, D 5949, Standard Test Method for Pour Point of Petroleum Products (Automatic Pressure Pulsing Method), in Annual Book of ASTM Standards, Vol. 05.03, ASTM International, West Conshohocken, PA, 2003.
Nadkarni, R.A.K., Guide to ASTM Test Methods for the Analysis of Petroleum Products and Lubricants, American Society for Testing and Materials, West Conshohocken, PA, 2000, pp. 66–67.
American Society for Testing and Materials D 6079, Standard Test Method for Evaluating Lubricity of Diesel Fuels by the High-Frequency Reciprocating Rig (HFRR), in Annual Book of ASTM Standards, Vol. 05.03, ASTM International, West Conshohocken, PA, 2003.
Knothe, G., and K.R. Steidley, Lubricity of Components of Biodiesel and Petrodiesel. The Origin of Biodiesel Lubricity, Energy Fuels, in press.
Knothe, G., R.O. Dunn, and M.O. Bagby, Surface Tension Studies on Novel allylic Mono- and Dihydroxy Fatty Compounds. A Method to Distinguish erythro/threo Diastereomers, J. Am. Oil Chem. Soc. 72:43–47 (1995).
Allen, C.A.W., K.C. Watts, R.G. Ackman, and M.J. Pegg, Predicting the Viscosity of Biodiesel Fuels from Their Fatty Acid Ester Composition, Fuel 78:1319–1326 (1999).
Gouw, T.H., J.C. Vlugter, and C.J.A. Roelands, Physical Properties of Fatty Acid Methyl Esters. VI. Viscosity, J. Am. Oil Chem. Soc. 43:433–434 (1966).
Knothe, G., and K.R. Steidley, Kinematic Viscosity of Biodiesel Fuel Components and Related Compounds. Influence of Compound Structure and Comparison to Petrodiesel Fuel Components, Fuel 84:1059–1065 (2005).
Ladommatos, N., M. Parsi, and A. Knowles, The Effect of Fuel Cetane Improver on Diesel Pollutant Emissions, —Ibid. 75:8–14 (1996).
Harrington, K.J., Chemical and Physical Properties of Vegetable Oil Esters and Their Effect on Diesel Fuel Performance, Biomass 9:1–17 (1986).
Author information
Authors and Affiliations
Corresponding author
About this article
Cite this article
Kenar, J.A., Knothe, G., Dunn, R.O. et al. Physical properties of oleochemical carbonates. J Amer Oil Chem Soc 82, 201–205 (2005). https://doi.org/10.1007/s11746-005-5173-5
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/s11746-005-5173-5