Abstract
Following the advances in pH sensors based on porous silicon (p-Si) in the late 20th century, several studies have been carried out to take advantage of the intrinsic properties of p-Si for development of chemical sensors. This study investigates the characteristics and pH sensitivity of an extended-gate field-effect transistor (EGFET) based on n-type p-Si with (111) orientation. Porous silicon was applied directly without coating. The x-ray diffractogram revealed only n-type (111) crystal orientation. p-Si was comparatively analyzed against a silicon wafer (flat and porous surface) in the pH range from 2 to 12. Regarding EGFET operation, p-Si exhibited significantly enhanced pH sensitivity of 56.13 mV/pH and linearity of 0.9857 (at drain–source current I DS of 0.1 mA, temperature of 300 K, and immersion time of 300 s) because of its high surface area, whereas the silicon wafer (flat and porous surface) exhibited comparatively poor sensitivity of 25.41 mV/pH and linearity of 0.99 under similar conditions. In addition, we demonstrate use of current as a second parameter with high linearity for pH sensing. The low hysteresis depth (9 mV) of the EGFET sensor based on p-Si indicates good stability and reversibility.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
L.T. Yin, J.C. Chou, W.Y. Chung, T.P. Sun, and S.K. Hsiung, Mater. Chem. Phys. 70, 12 (2001).
D.S. Kim, J.E. Park, J.K. Shin, P.K. Kim, G. Lim, and S. Shojii, Sens. Actuators B Chem. 117, 488 (2006).
R. van Hal, J. Eijkel, and P. Bergveld, Adv. Colloid Interface Sci. 69, 31 (1996).
C. Pan, R. Yu, S. Niu, G. Zhu, and Z.L. Wang, ACS Nano 7, 1803 (2013).
E.J. Guidelli, E.M. Guerra, and M. Mulato, ECS J. Solid State Sci. Technol. 1, N39 (2012).
S.M.J. Schöning, A. Kurowski, M. Thust, P. Kordos, J.W. Schultze, and H. Lüth, Sens. Actuators B Chem. 64, 59 (2000).
S.E. Letant and M.J. Sailor, Adv. Mater. 13, 355 (2001).
M.J. Sailor, Porous Silicon in Practice: Preparation, Characterization and Applications (New York: Wiley, 2012), pp. 104–216.
A. Jane, R. Dronov, A. Hodges, and N.H. Voelcker, Trends Biotechnol. 27, 230 (2009).
J.C. Vial and J. Derrien, Porous Silicon Science and Technology (Berlin Heidelberg: Springer, 1995), p. 36.
S. Rönnebeck, J. Carstensen, S. Ottow, and H. Föll, Electrochem. Solid State Lett. 2, 126 (1999).
X.G. Zhang, J. Electrochem. Soc. 151, C69 (2004).
N. Elfström, R. Juhasz, I. Sychugov, T. Engfeldt, A.E. Karlström, and J. Linnros, Nano Lett. 7, 2608 (2007).
E.J. Guidelli, E.M. Guerra, and M. Mulato, Mater. Chem. Phys. 125, 833 (2011).
G. Rong and S.M. Weiss, Phys. Status Solidi A 206, 1365 (2009).
H. Ouyang, C.C. Striemer, and P.M. Fauchet, Appl. Phys. Lett. 88, 163108 (2006).
M. Nazari and S. Khatami, Sens. Mater. 25, 131 (2013).
M. Archer, M. Christophersen, and P.M. Fauchet, Sens. Actuators B 106, 347 (2005).
J. Fritz, E.B. Cooper, S. Gaudet, P.K. Sorger, and S.R. Manalis, Proc. Natl. Acad. Sci. USA 99, 14142 (2002).
V. Lehmann and U. Gösele, Appl. Phys. Lett. 58, 856 (1991).
K. Kunimatsu, J. Res. Inst. Catal. Hokkaido Univ. 20, 20 (1972).
S. Porada, L. Weinstein, R. Dash, A. van der Wal, M. Bryjak, Y. Gogotsi, and P.M. Biesheuvel, ACS Appl. Mater. Interfaces 4, 1194 (2012).
P.M. Biesheuvel, Y. Fu, and M.Z. Bazant, Russ. J. Electrochem. 48, 580 (2012).
K.T. Chu and M.Z. Bazant, J. Colloid Interface Sci. 315, 319 (2007).
A. Mani and M.Z. Bazant, Phys. Rev. E 84, 061504 (2011).
F.A. Harraz, Sens. Actuators B Chem. 202, 897 (2014).
L. Zhang, H. Shen, and J. You, J. Electron. Mater. 42, 2464 (2013).
C.D. Fung, P.W. Cheung, and W.H. Ko, IEEE Trans. Electron Devices 33, 8 (1986).
L.L. Chi, J.C. Chou, W.Y. Chung, T.P. Sun, and S.K. Hsiung, Mater. Chem. Phys. 63, 19 (2000).
A. Das, D.H. Ko, C.H. Chen, L.B. Chang, C.S. Lai, F.C. Chu, L. Chow, and R.M. Lin, Sens. Actuators B Chem. 205, 199 (2014).
T.M. Pan, M.D. Huang, C.W. Lin, and M.H. Wu, Sens. Actuators B Chem. 144, 139 (2010).
N.H. Al-Hardan, M.A.A. Hamid, N.M. Ahmed, A. Jalar, R. Shamsudin, O.K. Othman, L.K. Keng, W. Chiu, and H.N. Al-Rawi, Sensors 16, 839 (2016).
R.R.K. Reddy, A. Chadha, and E. Bhattacharya, Biosens. Bioelectron. 16, 313 (2001).
M. Thust, M.J. Schöning, S. Frohnhoff, R. Arens-Fischer, P. Kordos, and H. Lüth, Meas. Sci. Technol. 7, 26 (1996).
F.A. Sabah, N.M. Ahmed, Z. Hassan, M.A. Almessiere, and N.H. Al-Hardan, JOM (2016). doi:10.1007/s11837-016-2165-x.
P.D. Batista, M. Mulato, C.D.O. Graeff, F.J.R. Fernandez, and F.D.C. Marques, Braz. J. Phys. 36, 478 (2006).
F.M. Zörgiebel, S. Pregl, L. Römhildt, J. Opitz, W. Weber, T. Mikolajick, L. Baraban, and G. Cuniberti, Nano Res. 7, 263 (2014).
S. Green and P. Kathirgamanathan, Mater. Lett. 52, 106 (2002).
Y.H. Lin, C.P. Chu, C.F. Lin, H.H. Liao, H.H. Tsai, and Y.Z. Juang, Biomed. Microdevices 17, 1 (2015).
W.D. Huang, H. Cao, S. Deb, M. Chiao, and J.C. Chiao, Sens. Actuators A Phys. 169, 1 (2011).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Ahmed, N.M., Kabaa, E.A., Jaafar, M.S. et al. Characteristics of Extended-Gate Field-Effect Transistor (EGFET) Based on Porous n-Type (111) Silicon for Use in pH Sensors. J. Electron. Mater. 46, 5804–5813 (2017). https://doi.org/10.1007/s11664-017-5604-8
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11664-017-5604-8