Abstract
An experimental investigation was carried out on mobilization and very slow flow of oil slugs in a capillary tube. The pressure drop of the slug flow was measured at every stage of mobilizing and moving the oil slugs as a function of capillary number in the range of 4 × 10−7–6 × 10−6. The pressure drop across the oil slug experienced three stages: build-up, hold-up, and steady stages. During the build-up stage, the convex rear end of the slug was becoming concave into the oil slug and the convex front end of the slug moved ahead to form a new portion of the slug. At the hold-up stage, both the concave rear end and the front end continued to advance, and the initial contact line of the oil slug with the tube wall through a very thin water film was being shortened. At this stage, the pressure drop reached a maximum value and remained nearly constant. At the steady stage, after the oil slug was completely mobilized out of the original contact region, the differential pressure had a step-drop first, and then the oil slug flowed at a lower differential pressure depending on the flow rate. Numerous slug flow tests of this study showed that the hold-up pressure drop was always higher than the steady stage pressure drop. Results also showed that the measured extra pressure drop was significantly high compared to the pressure drop calculated from Poiseuille equation, which is still commonly used in network modeling of multiphase flow in porous media.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Aul R.W., Olbricht W.L.: Stability of a thin annular film in pressure-driven, low-Renolds-Number flow through a capillary. J. Fluid Mech. 215, 585–599 (1990). doi:10.1017/S0022112090002774
Brenner H.: Pressure drop due to the motion of neutrally buoyant particles in duct flows. II. Spherical droplets and bubbles. Ind. Eng. Chem. Fundam. 10(4), 539–543 (1971). doi:10.1021/i160040a001
Bretherton F.P.: The motion of long bubbles in tubes. J. Fluid Mech. 10, 166–188 (1961)
Chen J.D.: Measuring the film thickness surrounding a bubble inside a capillary. J. Colloid Interface Sci. 109(2), 341–349 (1986). doi:10.1016/0021-9797(86)90313-9
Dong M., Chatzis I.: An experimental investigation of retention of liquids in corners of a square capillary. J. Colloid Interface Sci. 273, 306–312 (2004). doi:10.1016/j.jcis.2003.11.052
Fairbrothers F., Stubbs A.: Studies in electroendosmosis. Part VI. The bubble-tube methods of measurement. J. Chem. Sci. 1, 527–529 (1935)
Goldsmith H.L., Mason S.G.: The flow of suspensions through tubes: II. Single large bubbles. J. Colloid Sci. 18, 237–261 (1963). doi:10.1016/0095-8522(63)90015-1
Hirasaki G.J.: Wettability: fundamentals and surface forces. SPE Form. Eval. 6(2), 217–226 (1991)
Ho B.P., Leal L.G.: The creeping motion of liquid drops through a circular tube of comparable diameter. J. Fluid Mech. 71, 361–383 (1975). doi:10.1017/S0022112075002625
Hou J.: Network modeling of residual oil displacement after polymer flooding. J. Petrol. Sci. Eng. 59, 321–332 (2007). doi:10.1016/j.petrol.2007.04.012
Hyman W.A., Skalak R.: Non-Newtonian behavior of a suspension of liquid drops in tube flow. Am. Inst. Chem. Eng. 18(1), 149–154 (1972)
Joekar-Niasar V., Hassanizadeh S.M., Leijnse A.: Insights into the relationships among capillary pressure, saturation, interfacial area and relative permeability using pore-network modeling. Transp. Porous Media 74, 201–219 (2008). doi:10.1007/s11242-007-9191-7
Koplik J., Lasseter T.J.: One- and two-phase flow in network models of porous media. Chern. Eng. Cornrnun. 26, 285–295 (1984)
Koplik J., Lasseter T.J.: Two-phase flow in random network models of porous media. SPE J. 2, 89–100 (1985)
Martinez M.J., Udell K.S.: Boundary integral analysis of the creeping flow of long bubbles in capillaries. J. Appl. Mech. 56, 211–217 (1989)
Martinez M.J., Udell K.S.: Axisymmetric creeping motion of drops through circular tubes. J. Fluid Mech. 210, 565–591 (1990). doi:10.1017/S0022112090001409
Melrose J.C., Brandner C.F.: Roles of capillary forces in determining microscopic displacement efficiency of oil recovery by water-flooding. J. Can. Petrol. Technol. 13(3), 54–62 (1974)
Morrow N.: Interplay of capillary, viscous, and buoyancy forces in mobilization of residual oil. J. Can. Petrol. Technol. 18(3), 35–46 (1979)
Mostefa M.N., Biesel B.D.: Two-phase flows in capillary tubes: effect of surfactants. Ann. Phys. 2, 63–65 (1988)
Olbricht W.L.: Pore scale prototypes of multiphase flow in porous media. Annu. Rev. Fluid Mech. 28, 187–213 (1996)
Olbricht W.L., Kung D.M.: The interaction and coalescence of liquid drops in flow through a capillary tube. J. Colloid Interface Sci. 120(1), 229–243 (1987). doi:10.1016/0021-9797(87)90345-6
Ratulowski J., Chang H.C.: Transport of gas bubbles in capillaries. Phys. Fluids A1(10), 1642–1655 (1989)
Ratulowski J., Chang H.C.: Marangoni effects of trace impurities on the motion of long gas bubbles in capillaries. J. Fluid Mech. 210, 303–328 (1990). doi:10.1017/S0022112090001306
Schwartz L.W., Princen H.M., Kiss A.D.: On the motion of bubbles in capillary tubes. J. Fluid Mech. 172, 259–275 (1986). doi:10.1017/S0022112086001738
Shen E.I., Udell K.S.: A finite element study of low Reynolds number two-phase flow in cylindrical tubes. J. Appl. Mech. 52, 253–256 (1985)
Singh M., Mohanty K.K.: Dynamic modeling of drainage through three-dimensional porous materials. Chem. Eng. Sci. 58, 1–18 (2003). doi:10.1016/S0009-2509(02)00438-4
Smith W.O., Crane M.D.: The Jamin effect in cylindrical tubes. J. Am. Chem. Soc. 52, 1345–1349 (1930). doi:10.1021/ja01367a007
Stark J., Manga M.: The motion of long bubbles in a network of tubes. Transp. Porous Media 40, 201–218 (2000). doi:10.1023/A:1006697532629
Taylor G.I.: Deposition of a viscous fluid on the wall of a tube. J. Fluid Mech. 10, 161–165 (1961). doi:10.1017/S0022112061000159
Treiber L.E., Archer D.L., Owens W.W.: A laboratory evaluation of the wettability of fifty oil-producing reservoirs. SPE J. 12(6), 531–540 (1972)
Tsai T.M., Miksis M.J.: Dynamics of a drop in a constricted capillary tube. J. Fluid Mech. 274, 197–217 (1994). doi:10.1017/S0022112094002090
van Dijke M.I.J., Sorbie K.S.: Pore-scale network model for three-phase flow in mixed-wet porous media. Phsical Rev. E 66, 046302 (2002)
Westborg H., Hassager O.: Creeping motion of long bubbles and drops in capillary tube. J. Colloid Interface Sci. 33(1), 135–147 (1989). doi:10.1016/0021-9797(89)90287-7
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Dong, M., Fan, Q. & Dai, L. An Experimental Study of Mobilization and Creeping Flow of Oil Slugs in a Water-Filled Capillary. Transp Porous Med 80, 455–467 (2009). https://doi.org/10.1007/s11242-009-9374-5
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11242-009-9374-5