Abstract
Water/oil flow characteristics in a water-wet capillary were simulated at the pore scale to increase our understanding on immiscible flow and enhanced oil recovery. Volume of fluid method was used to capture the interface between oil and water and a pore-throat connecting structure was established to investigate the effects of viscosity, interfacial tension (IFT) and capillary number (Ca). The results show that during a water displacement process, an initial continuous oil phase can be snapped off in the water-wet pore due to the capillary effect. By altering the viscosity of the displacing fluid and the IFT between the wetting and non-wetting phases, the snapped-off phenomenon can be eliminated or reduced during the displacement. A stable displacement can be obtained under high Ca number conditions. Different displacement effects can be obtained at the same Ca number due to its significant influence on the flow state, i.e., snapped-off flow, transient flow and stable flow, and ultralow IFT alone would not ensure a very high recovery rate due to the fingering flow occurrence. A flow chart relating flow states and the corresponding oil recovery factor is established.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Setiawan A, Suekane T, Deguchi Y, Kusano K. Three-dimensional imaging of pore-scale water flooding phenomena in water-wet and oil-wet porous media. Journal of Flow Control. Measurement & Visualization, 2014, 2(2): 25–31
Schlüter S, Berg S, Rücker M, Armstrong R T, Vogel H J, Hilfer R, Wildenschild D. Pore-scale displacement mechanisms as a source of hysteresis for two-phase flow in porous media. Water Resources Research, 2016, 52(3): 2194–2205
Kallel W, van Dijke M I J, Sorbie K S, Wood R, Jiang Z, Harland S. Modelling the effect of wettability distributions on oil recovery from microporous carbonate reservoirs. Advances in Water Resources, 2016, 95: 317–328
Raeini A Q, Bijeljic B, Blunt M J. Modelling capillary trapping using finite-volume simulation of two-phase flow directly on micro-CT images. Advances in Water Resources, 2015, 83: 102–110
Andrew M, Bijeljic B, Blunt M J. Pore-scale contact angle measurements at reservoir conditions using X-ray microtomography. Advances in Water Resources, 2014, 68: 24–31
Arns C H, Knackstedt M A, Pinczewski W V, Garboczi E J. Computation of linear elastic properties from microtomographic images: Methodology and agreement between theory and experiment. Geophysics, 2002, 67(5): 1396–1405
Meakin P, Tartakovsky AM. Modeling and simulation of pore-scale multiphase fluid flow and reactive transport in fractured and porous media. Reviews of Geophysics, 2009, 47(3): 1–47
Tryggvason G, Bunner B, Esmaeeli A, Juric D, Al-Rawahi N, Tauber W, Han J, Nas S, Jan Y J. A front-tracking method for the computations of multiphase flow. Journal of Computational Physics, 2001, 169(2): 708–759
Fukai J, Shiiba Y, Yamamoto T, Miyatake O, Poulikakos D, Megaridis C M, Zhao Z. Wetting effects on the spreading of a liquid droplet colliding with a flat surface: Experiment and modeling. Physics of Fluids, 1995, 7(2): 236–247
Hirt C W, Nichols B D. Volume of fluid (VOF) method for the dynamics of free boundaries. Journal of Computational Physics, 1981, 39(1): 201–225
Lv M, Wang S. Pore-scale modeling of a water/oil two-phase flow in hot water flooding for enhanced oil recovery. RSC Advances, 2015, 5(104): 85373–85382
Ferrari A, Lunati I. Direct numerical simulations of interface dynamics to link capillary pressure and total surface energy. Advances in Water Resources, 2013, 57: 19–31
Brackbill J U, Kothe D B, Zemach C. A continuum method for modeling surface tension. Journal of Computational Physics, 1992, 100(2): 335–354
Afkhami S, Zaleski S, Bussmann M. A mesh-dependent model for applying dynamic contact angles to VOF simulations. Journal of Computational Physics, 2009, 228(15): 5370–5389
Tomin P, Lunati I. Hybrid multiscale finite volume method for two-phase flow in porous media. Journal of Computational Physics, 2013, 250: 293–307
Yang X, Scheibe T D, Richmond MC, Perkins WA, Vogt S J, Codd S L, Seymour J D, McKinley M I. Direct numerical simulation of pore-scale flow in a bead pack: Comparison with magnetic resonance imaging observations. Advances in Water Resources, 2013, 54: 228–241
Horgue P, Augier F, Duru P, Prat M, Quintard M. Experimental and numerical study of two-phase flows in arrays of cylinders. Chemical Engineering Science, 2013, 102: 335–345
Roof J G. Snap-off of oil droplets in water-wet pores. Society of Petroleum Engineers Journal, 1970, 10(1): 85–90
Kiss É, Pintér J, Wolfram E. Dynamics of oil/water displacement in capillary tubes with periodically varying diameter. Colloid & Polymer Science, 1982, 260(8): 808–810
Yu L, Wardlaw N C. The influence of wettability and critical porethroat size ratio on snap-off. Journal of Colloid and Interface Science, 1986, 109(2): 461–472
Ransohoff T C, Gauglitz P A, Radke C J. Snap-off of gas bubbles in smoothly constricted noncircular capillaries. AIChE Journal. American Institute of Chemical Engineers, 1987, 33(5): 753–765
Ransohoff T C, Radke C J. Laminar flow of a wetting liquid along the corners of a predominantly gas-occupied noncircular pore. Journal of Colloid and Interface Science, 1988, 121(2): 392–401
Al-Gharbi M S, Blunt M J. Dynamic network modeling of twophase drainage in porous media. Physical Review. E, 2005, 71(1): 016308
Al-Gharbi M S. Dynamic pore-scale modelling of twophase flow. Dissertation for the Doctoral Degree. London: University of London, 2004, 1–132
Beresnev I A, Deng W. Theory of breakup of core fluids surrounded by a wetting annulus in sinusoidally constricted capillary channels. Physics of Fluids, 2010, 22(1): 012105
Beresnev I A, Li W, Vigil R D. Condition for break-up of nonwetting fluids in sinusoidally constricted capillary channels. Transport in Porous Media, 2009, 80(3): 581–604
Deng W. Quantitative aspects of vibratory mobilization and breakup of non-wetting fluids in porous media. Dissertation for the Doctoral Degree. Iowa: Iowa State University, 2010, 1–124
Deng W, Cardenas M B. Dynamics and dislodgment from pore constrictions of a trapped nonwetting droplet stimulated by seismic waves. Water Resources Research, 2013, 49(7): 4206–4218
Deng W, Cardenas M B, Bennett P C. Extended Roof snap-off for a continuous nonwetting fluid and an example case for supercritical CO2. Advances in Water Resources, 2014, 64: 34–46
Roman S, Abu-Al-Saud M O, Tokunaga T, Wan J, Kovscek A R, Tchelepi H A. Measurements and simulation of liquid films during drainage displacements and snap-off in constricted capillary tubes. Journal of Colloid and Interface Science, 2017, 507: 279–289
Abu-Al-Saud M O, Riaz A, Tchelepi H A. Multiscale level-set method for accurate modeling of immiscible two-phase flow with deposited thin films on solid surfaces. Journal of Computational Physics, 2017, 333: 297–320
Deng W, Balhoff M, Cardenas MB. Influence of dynamic factors on nonwetting fluid snap-off in pores. Water Resources Research, 2015, 51(11): 9182–9189
Raffa P, Broekhuis A A, Picchioni F. Polymeric surfactants for enhanced oil recovery: A review. Journal of Petroleum Science Engineering, 2016, 145: 723–733
Hirasaki G, Miller C A, Puerto M. Recent advances in surfactant EOR. SPE Journal, 2011, 16(04): 889–907
Ko K M, Chon B H, Jang S B, Jang H Y. Surfactant flooding characteristics of dodecyl alkyl sulfate for enhanced oil recovery. Journal of Industrial and Engineering Chemistry, 2014, 20(1): 228–233
Yu Q, Jiang H, Zhao C. Study of interfacial tension between oil and surfactant polymer flooding. Petroleum Science and Technology, 2010, 28(18): 1846–1854
Samanta A, Ojha K, Sarkar A, Mandal A. Surfactant and surfactant-polymer flooding for enhanced oil recovery. Advances in Petroleum Exploration and Development, 2011, 2(1): 13–18
Olajire A A. Review of ASP EOR (alkaline surfactant polymer enhanced oil recovery) technology in the petroleum industry: Prospects and challenges. Energy, 2014, 77: 963–982
Raffa P, Wever D A Z, Picchioni F, Broekhuis A A. Polymeric surfactants: Synthesis, properties, and links to applications. Chemical Reviews, 2015, 115(16): 8504–8563
Liu R C, Pallier A, Brestaz M, Pantoustier N, Tribet C. Impact of polymer microstructure on the self-assembly of amphiphilic polymers in aqueous solutions. Macromolecules, 2007, 40(12): 4276–4286
Meybodi H E, Kharrat R, Wang X. Study of microscopic and macroscopic displacement behaviors of polymer solution in waterwet and oil-wet media. Transport in Porous Media, 2011, 89(1): 97–120
Wever D A Z, Picchioni F, Broekhuis A A. Polymers for enhanced oil recovery: A paradigm for structure-property relationship in aqueous solution. Progress in Polymer Science, 2011, 36(11): 1558–1628
Abidin A Z, Puspasari T, Nugroho W A. Polymers for enhanced oil recovery technology. Procedia Chemistry, 2012, 4: 11–16
Brackbill J U, Kothe D B, Zemach C. A continuum method for modeling surface tension. Journal of Computational Physics, 1992, 100(2): 335–354
Bagrintseva K I. Carbonate Reservoir Rocks. New Jersey: Wiley, 2015, 1–285
Nelson P H. Pore-throat sizes in sandstones, tight sandstones, and shales. AAPG Bulletin, 2009, 93(3): 329–340
Dake L P. The Practice of Reservoir Engineering. Amsterdam: Elsevier, 2013, 1–518
White F M, Corfield I. Viscous Fluid Flow. New York: McGraw-Hill, 2006, 1–578
Bear J. Dynamics of Fluids in Porous Media. Massachusetts: Courier Corporation, 2013, 1–725
Setu S A, Zacharoudiou I, Davies G J, Bartolo D, Moulinet S, Louis A A, Yeomans J M, Aarts D G A L. Viscous fingering at ultralow interfacial tension. Soft Matter, 2013, 9(44): 10599–10605
Zhang H, Dong M, Zhao S. Which one is more important in chemical flooding for enhanced court heavy oil recovery, lowering interfacial tension or reducing water mobility? Energy & Fuels, 2010, 24(3): 1829–1836
Saffman P G, Taylor G I. The penetration of a fluid into a porous medium or Hele-Shaw cell containing a more viscous liquid. Proceedings of the Royal Society of London, 1958, 245(1242): 312–329
Sheng J J. Preferred calculation formula and buoyancy effect on capillary number. Asia-Pacific Journal of Chemical Engineering, 2015, 10(3): 400–410
Acknowledgements
This work was supported by European Research Council Consolidator Grant (Grant No. 648375) and the China Scholarship Council.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation,distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article’s Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article’s Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Zhao, J., Yao, G. & Wen, D. Pore-scale simulation of water/oil displacement in a water-wet channel. Front. Chem. Sci. Eng. 13, 803–814 (2019). https://doi.org/10.1007/s11705-019-1835-y
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11705-019-1835-y