Abstract
This paper provides a comprehensive review of the past and recent developments in the area of single-phase power factor correction (PFC) techniques. The motivation for the research in this area, and the manifold directions into which the research has gained impetus, are clearly brought out. The various PFC techniques are broadly classified into (1) passive, (2) active, and (3) active-passive PFC techniques. The active PFC techniques, based on the output dynamics, are further classified into (1) conventional techniques which have slow output dynamics and (2) techniques with fast output dynamics. The critical issues within each PFC technique are discussed in detail. An extensive list of references is also provided at the end.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
J S Subjak, J S McQuilkin 1990 Harmonics — Causes, effects, measurements, and analysis: An update.IEEE Trans. Ind. Appl. IA-26: 1034–1042
R P Stratford 1980 Rectifier harmonics in power systems.IEEE Trans. Ind. Appl. Vol. IA-16: 271–276
W Shepherd, P Zand 1979Energy flow and power factor in nonsinusoidal circuits (London: Cambridge University Press)
N Mohan, T M Undeland, W P Robbins 1994Power electronics: Converters, applications, and design (New York: John Wiley & Sons)
Solid state.IEEE Spectrum, January 1994, p. 50
International Electrotechnical Commission Sub-Committee 77A 1992 Disturbances in supply systems caused by household appliances and similar electrical equipment. Draft Revision of IEC Publication 555.2
T S Key, Jih-Sheng Lai 1993 Comparison of standards and power supply design options for limiting harmonic distortion in power systems.IEEE Trans. Ind. Appl. 29: 688–695
J Klein, M K Nalbant 1990 Power factor correction — Incentives, standards and techniques.Power Conversion Intell. Motion (June): 26–30
D Maliniak 1992 DC supply keeps line power factor near unity.Electron. Design (May 28): 33–34
K Umezu 1993 AC power supply system measures harmonics from electronic equipment.Nikkei Electron. Asia (May): 52–55
F C Schwarz 1973 A time-domain analysis of the power factor for a rectifier filter system with over- and subcritical inductance.IEEE Trans. Ind. Electron. Control Instrum. IECI-20(2): 61–68
S B Dewan 1981 Optimum input and output filters for single phase rectifier power supply.IEEE Trans. Ind. Appl. IA-17: 282–288
Vorpe’rian, R Ridley 1990 A simple scheme for unity power-factor rectification for high frequency AC buses.IEEE Trans. Power Electron. 5: pp 77–87
P Jain 1994 A unity power factor resonant AC/DC converter for high frequency space power distribution system.IEEE Power Electron. Spec. Conf. Rec. 1:
A R Prasad, P D Ziogas, S Manias 1990 A novel passive waveshaping method for single phase diode rectifiers.IEEE Trans. Ind. Electron. IE-37: 521–530
K Yamashita 1994 Harmonics fighters pursue choke-coil, one converter power supplies.Nikkei Electron. Asia (August): 44–47
Jih-Sheng Lai, D Hurst, T Key 1991 Switch mode power supply power factor improvement via harmonic elimination methods.IEEE Appl. Power Electron. Conf., Rec., pp 415–422
A R Prasad, P D Ziogas, S Manias 1988 A comparative evaluation of SMR converters with and without active input waveshaping.IEEE Trans. Ind. Electron. IE-35(3): (August) 461–468
R Redl, L Balogh 1995 Power-factor correction in bridge and voltage-doubler rectifier circuits with inductors and capacitors.IEEE Appl. Power Electron. Conf., Rec., pp 466–472
N Mohan, T M Undeland, R J Ferraro 1984 Sinusoidal line current rectification with a 100 kHz B-SIT step-up converter.IEEE Power Electron. Spec. Conf., Rec.: 92–98
C P Henze, N Mohan 1986 A digitally controlledac-dc power conditioner that draws sinusoidal input current.IEEE Power Electron. Spec. Conf., Rec.: 531–540
M F Schlecht, B A Miwa 1987 Active power factor correction for switching power supplies.IEEE Trans. Power Electron. PE-2: 273–281
M F Schlecht 1986 Harmonic-free utility/DC power conditioning interfaces.IEEE Trans. Power Electron. PE-1: 231–239
R Oruganti, Y T Cham 1993 Power factor correction techniques in off-line switching power supplies.J. Inst. Eng. Singapore 33: 27–35
L H Dixon 1990 High power factor switching preregulator design optimization. Unitrode Power Supply Design Seminar Manual, SEM 700, pp 13-1 to 13-12
J LoCascio, M Nalabant 1990 Active power factor correction using a flyback topology.Power Conversion Intell. Motion, Conf., Rec.
B Andreycak, C H Yeam, J A O’Connor 1991 UC3852 controlled on-time zero current switched power factor correction preregulator. Design Guide (Preliminary), Application note U-132, Unitrode Power Supply Design Seminar Manual, SEM 800
P N Enjeti, R Martinez 1993 A high performance single phase AC to DC rectifier with input power factor correction.IEEE Appl. Power Electron. Conf., Rec., pp 190–195
E X Yang, Y M Jiang, G C Hua, F C Lee 1993 Isolated Boost Circuit for Power Factor Correction.IEEE Appl. Power Electron. Conf., Rec., pp 196–203
M S Dawande, G K Dubey 1995 Bang bang current control with predecided switching frequency for switch mode rectifiers.IEEE Power Electron. Drives Syst. Conf., Rec., pp 538–542
M S Dawande, G K Dubey 1993 Programmable input power factor correction method for switch mode rectifiers.IEEE Appl. Power electron. Conf., Rec.
C Zhou, R B Ridley, F C Lee 1990 Design and analysis of hysteretic boost power factor correction circuit.IEEE Power Electron. Spec. Conf., Rec.
C Zhou, M M Jovanovic’ 1992 Design trade-offs in continuous current-mode controlled boost power factor-correction circuits.Proceedings of the High Freq. Power Conversion Conf., Rec., May
J J Spangler, A K Behera 1993 A comparison between hysteretic and fixed frequency boost converters used for power factor correction.IEEE Appl. Power Electron. Conf., Rec., pp 281–286
W Tang, F C Lee, R B Ridley, I Cohen 1992 Charge control: Modelling, analysis and design.IEEE Power Electron. Spec. Conf., Rec.
W Tang, Y M Jiang, G C Hua, F C Lee, I Cohen 1993 Power factor correction with flyback converter employing charge control.IEEE Appl. Power Electron. Conf., Rec., pp 293–298
H Endo, T Yamashita, T Sugiura 1992 A high power factor buck converter.IEEE Power Electron. Spec. Conf., Rec.
Y M Jiang, F C Lee 1994 A new control scheme for buck + boost power factor correction circuit. Volume V of the Virginia Power Electronic Center publication series
M C Ghanem, K Al-Haddad, G Roy 1993 A new single-phase buck-boost converter with unity power factor.IEEE Ind. Appl. Soc. Annu. Meeting, Rec., pp 785–792
M C Ghanem, K Al-Haddad, G Roy 1996 A new control strategy to achieve sinusoidal line current in a cascade buck-boost converter.IEEE Trans. Ind. Electron. 43: 441–449
D Maksimovic, R Erickson 1995 Universal-input, high-power-factor, boost doubler rectifiers.IEEE Appl. Power Electron. Conf., Rec., pp 459–465
A H Mitwalli, S B Leeb, G C Verghese, V J Thottuvelil 1996 An adaptive digital controller for a unity power factor converter.IEEE Trans. Power Electron. 11(2): 374–382
J C Salomon 1993 Techniques for minimising the input current distortion of current-controlled single-phase boost rectifiers.IEEE Trans. Power Electron. 8: 509–520
J C Salomon 1993 Circuit topologies for single-phase voltage-doubler boost rectifiers.IEEE Trans. Power Electron. 8: 521–529
J T Boys, A W Green 1989 Current-forced single phase reversible rectifier.Inst. Elec. Eng. Proc. B136: 205–211
R Srinivasan, R Oruganti 1997 Analysis and design of single phase power factor correction with half bridge boost topology.IEEE Appl. Power Electron. Conf., Rec., 1: 489–499 (Also sent toIEEE Trans. Power Electron.)
Bakari M M Mwinyiwiwa, P M Birks, Boon-Teck Ooi 1992 Delta-modulated buck-type PWM converter.IEEE Trans. Ind. Appl. 28: 552–557
Boon-Teck Ooi, Bakari M M Mwinyiwiwa, X Wang, G Joos 1991 Operating limits of the current-regulated delta-modulated current-source PWM rectifier.IEEE Trans. Ind. Appl. 38: 268–274
S Funabiki, N Toita, A Mechi 1991 A single-phase PWM AC to DC converter with a step up/down voltage and sinusoidal source current.IEEE Ind. Appl. Soc., Annu. Mtg., Rec., pp 1017–1022
R Oruganti, M Palaniapan 1996 Inductor voltage controlled variable power factor buck typeac-dc converter.IEEE Power Electron. Spec. Conf., Rec., pp 230–237
R Srinivasan, M Palaniapan, R Oruganti 1997 A single phase two-switch buck type AC-DC converter topology with inductor voltage control.IEEE Power Electron. Spec. Conf., Rec. pp 556–563 (Also sent toIEEE Trans. Power Electron.)
M J Kocher, R L Steigerwald 1983 An AC-to-DC converter with high quality input waveforms.IEEE Trans. Ind. Appl. IA-19: 586–599
L Balogh, R Redl 1993 Power-factor correction with interleaved boost converters in continuous-inductor-current mode.IEEE Appl. Power Electron. Conf., Rec., pp 168–174
P C Todd 1993–94 UC3854 controlled power factor correction circuit design.Unitrode — Product Applications Handbook, Lexington, MA
Micro Linear Data Book 1993
Unitrode Applications Handbook 1987–88 Lexington, MA
L Dixon 1991 Average current mode control of switching power supplies. Unitrode Power Supply Design Seminar Manual. SEM 800
H Matsuo, N Aoike, F Kurokawa, A Hisako 1994 A new combined voltage-resonant inverter with high power factor and low distortion factor.IEEE Power Electron. Spec. Conf., Rec. 1:
A Ferrari de Souza, I Barbi 1994 A new ZVS-PWM unity power factor rectifier with reduced conduction losses.IEEE Power Electron. Spec. Conf., Rec. 1:
Gyu-Ha Choe, Min-Ho Park 1988 A new injection method for ac harmonic elimination by active power filter.IEEE Trans. Ind. Electron. 35: 141–147
J Nastran, R Cajhen, M Seliger, P Jereb 1994 Active power filter for non-linear ac loads.IEEE Trans. Power Electron. 9: 92–96
H Akagi 1994 Trends in active power line conditioners.IEEE Trans. Power Electron. 9: 263–268
H-L Jou, J-C Wu, H-Y Chu 1994 New single-phase active power filter.IEE Proc. Electron. Power Appl. 141: 129–134
D A Torrey, Adel M A M, Al-Zamel 1995 Single-phase active power filters for multiple non-linear loads.IEEE Trans. Power Electron. 10: 263–272
C A Canesin, I Barbi 1996 Analysis and design of constant-frequency peak-current-controlled high- power-factor boost rectifier with slope compensation.IEEE Appl. Power Electron. Conf., Rec., pp 807–813
J Lazar, S Cuk 1996 Feedback loop analysis for ac/dc rectifiers operating in discontinuous conduction mode.IEEE Appl. Power Electron. Conf., Rec., pp 797–806
R B Ridley 1994 Average small-signal analysis of the boost power factor correction circuit. Volume V of the Virginia Power Electron. Center Publication Series
F A Huliehel, F C Lee, B H Cho 1992 Small-signal modelling of the single -phase boost high power factor converter with constant frequency control.IEEE Power Electron. Spec. Conf., Rec., pp 475–482
P D Ziogas 1981 The delta modulation technique in static PWM converters.IEEE Trans. Ind. Appl. IA-17: 199–203
M S Elmore, W A Peterson, S D Sherwood 1991 A power factor enhancement circuit.IEEE Appl. Power Electron. Conf., Rec., pp 407–414
R Oruganti, C Y Thean 1994 A novel PFC scheme for AC to DC converter with reduced losses.IEEE Ind. Electron. Conf., Rec.
M B Harris, A W Kelly, J P Rhode, M E Baran 1994 Instrumentation for measurement of line impedance.IEEE Appl. Power Electron. Conf., Rec., pp 887–893
Valtkovic’, D Borojevic’, F C Lee 1996 Input filter design for power factor correction circuits.IEEE Trans. Power Electron. 11: 199–205
F S Dos Reis, J Sebastia’n, J Uceda 1994 Determination of EMI emission in power factor preregulators by design.IEEE Power Electron. Spec. Conf., Rec. 2:
M O Eissa, S B Leeb, G C Verghese, A M Stankovic 1996 Fast controller for a unity-power-factor PWM rectifier.IEEE Trans. Power Electron. 11: 1–6
G Spiazzi, P Mattavelli, L Rossetto 1995 Power factor preregulators with improved dynamic performance.IEEE Power Electron. Spec. Conf., Rec., pp 150–156
Y Jiang 1994 Development of advanced power factor correction techniques. Ph D Dissertation, Virginia Polytechnic Institute and State University, Blacksburg, VA
D M Divan, G Venkataramanan, C Chen 1992 A unity power factor forward converter.IEEE Ind. Appl. Soc., Annu. Mtg., Rec., pp 666–672
I Takahashi, R Y Igarashi 1991 A switching power supply of 99% power factor by the dither rectifier.IEEE Int. Telecommun. Energy. Conf., Rec., pp 714–719
M H Kheraluwala, A R Schnore, R L Steigerwald 1992 Performance characterisation of a high power factor power supply with a single power stage.IEEE Ind. Appl. Soc., Annu. Mtg, Rec., pp 659–665
I Takahashi, R Y Igarashi 1992 High power factor switching regulator with no rush current.IEEE Ind. Appl. Soc., Annu. Mtg., Rec., pp 673–680
R Redl, L Balogh, N O Sokal 1994 A new family of single-stage isolated power-factor correctors with fast regulation of the output voltage.IEEE Power Electron. Spec. Conf., Rec. 2: 1137–1144
M Madigan, R Erickson, E Ismail 1992 Integrated high quality rectifier-regulators.IEEE Power Electron. Spec. Conf., Rec., pp 1043–1051
R Redl, L Balogh 1992 RMS, DC, peak, and harmonic currents in high-frequency power-factor correctors with capacitive energy storage. IEEE catalog No. 0-7803-0485-3/92, pp 533–540
R Redl, L Balogh 1995 Design considerations for single-stage isolated power-factor-corrected power supplies with fast regulation of the output voltage.IEEE Appl. Power Electron. Conf., Rec., pp 454–458
M J Willers, M G Egan, J M D Murphy, S Daly 1994 A BIFRED converter with a wide load range.IEEE Ind. Electron. Conf., Rec., pp 226–231
M M Javanovic, D M C Tsang, F C Lee 1994 Reduction of voltage stress in integrated high-quality rectifier-regulators by variable-frequency control.IEEE Appl. Power Electron. Conf., Rec., pp 569–575
Y S Lee, K W Siu 1996 Single-switch fast response switching regulators with unity power factor.IEEE Appl. Power Electron. Conf., Rec., pp 791–796
M Brkovic, S Cuk 1995 A novel single-stage AC-DC full-bridge converter with magnetic amplifiers for input current shaping.IEEE Power Electron. Spec. Conf., Rec., pp 990–995
Y Jiang, F C Lee, G Hua, W Tang 1993 A novel single phase power factor correction scheme.IEEE Appl. Power Electron. Conf., Rec., pp 287–292
Y Jiang, F C Lee 1994 Single-stage single-phase parallel power factor correction scheme.IEEE Power Electron. Spec. Conf., Rec. 2:
J P Gegner, C-Y Hung, C Q Lee 1994 High power factor ac-to-dc converter using a reactive shunt regulator.IEEE Power Electron. Spec. Conf., Rec. 1: 349–355
R Srinivasan, R Oruganti 1996 A single phase parallel power processing scheme with power factor control.Int. J. Electron. 80: 291–306 (Also inIEEE Power Electron. Drive Syst. Conf., Rec. 1: 1995)
R Srinivasan, R Oruganti 1997 A single phase parallel power processing scheme with input-shunt power factor correction stage.IEEE Power Electron. Drive Syst. Conf., Rec.
W-I Tsai, Y-Y Sun, W-S Shieh 1991 Modelling and control of single phase switching mode rectifiers with near-optimum dynamic regulation.IEEE Ind. Electron. Conf., Rec., pp 501–506
B R Needham, P H Eckerling, K Siri 1994 Simulation of large distributed DC power system using averaged modelling techniques and the SABER simulator.IEEE Appl. Power Electron. Conf., Rec., pp 801–807
D Kimhi, S Ben-Yaakov 1991 SPICE model for current mode PWM converters operating under continuous inductor current conditions.IEEE Trans. Power Electron. 6: 281–286
K Mahabir, G Verghese, J Thottuvelil, A Heyman 1990 Linear averaged and sampled data models for large signal control of high power factor AC-DC converters.IEEE Power Electron. Spec. Conf., Rec., pp 372–381
S R Sanders, J M Noworolski, X Z Liu, G C Verghese 1991 Generalised averaging method for power conversion circuits.IEEE Trans. Power Electron. 6: 251–259
J Thottuvelil, D Chin, G C Verghese 1991 Hierarchical approaches to modelling high-power-factor AC-DC converters.IEEE Trans. Power Electron. 6: 179–187
P T Krein, J Bentsman, R M Bass, B L Lesieutre 1990 On the use of averaging for the analysis of power electronic systems.IEEE Trans. Power Electron. 5: 182–190
L Dixon 1989 High power factor preregulators for off-line switching power supplies. Unitrode Power Supply Design Seminar Manual, SEM 600
R Watson, G C Hua, F C Lee 1994 Characterisation of an active clamp flyback topology fordc-dc conversion and power factor correction alications.IEEE Appl. Power Electron. Conf., Rec., pp 412–418
R Watson, F C Lee, G C Hua 1994 Utilisation of an active-clamp circuit to achieve soft switching in flyback converters.IEEE Power Electron. Spec. Conf. Rec.
G C Hua, C S Leu, Y M Jiang, F C Lee 1992 Novel zero-voltage-transition PWM converters.IEEE Power Electron. Spec. Conf., Rec., pp 55–61
R Srinivasan 1998Single phase power factor correction — investigation and development of advanced techniques. Ph D thesis, National University of Singapore, Singapore
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Oruganti, R., Srinivasan, R. Single phase power factor correction — A review. Sadhana 22, 753–780 (1997). https://doi.org/10.1007/BF02745844
Issue Date:
DOI: https://doi.org/10.1007/BF02745844