Abstract
The subject of Chap. 6 is boiling in micro-channels. Several aspects of boiling are also considered for conventional size channels and comparison with micro-channels was carried out. Significant differences of ONB in micro-channels have been discussed compared to conventional channels. Effect of dissolved gases on boiling in water and surfactant solution was revealed. Attention was paid on pressure drop and heat transfer, critical heat flux and instabilities during flow boiling in microchannels.
Access provided by Autonomous University of Puebla. Download to read the full chapter text
Chapter PDF
Keywords
These keywords were added by machine and not by the authors. This process is experimental and the keywords may be updated as the learning algorithm improves.
References
Agostini B, Revellin R, Thome J (2008) Elongated bubbles in micro-channels. Part I: Experimental study and modeling of elongated bubble velocity. Int. J. Multiphase Flow 34:590–601
Bankoff SG, Haute T (1957) Ebullition from solid surfaces in the absence of pre-existing gaseous phase. Trans ASME 79:735–740
Becker KM, Hernborg G, Bode M, Eriksson O (1965) Burnout data for flow of boiling water in vertical round ducts, annuli and rod clusters, AE-177. Aktiebolaget Atomenergi, Stockholm, Sweden
Becker R, Doring W (1935) The kinetic treatment of nuclear formation in superheated vapors. Ann Phys 24:719–752
Bergles AE, Rohsenow WW (1964) The Determination of Forced-Convection Surface-Boiling Heat Transfer. Trans ASME J Heat Transfer 86:365–372
Blander M, Katz JL (1975) Bubble nucleation in liquids. AIChE J 21:833–848
Bowers MB, Mudawar I (1994) High flux boiling in low flow rate, low pressure drop mini-channel and micro-channel heat sinks. Int. J. Heat Mass Transfer 37:321–332
Bowring RW (1972) A simple but accurate round tube uniform heat flux, dryout correlation over the pressure range 0.7–17 MN/m2 (100–2500 psia), AEEW-R 789. United Kingdom Atomic Energy Authority, Harwell
Brutin B, Tadrist L (2004) Pressure drop and heat transfer analysis of flow boiling in micro-channel: influence of the inlet condition on two-phase flow stability. Int J Heat Mass Transfer 47:2367–2377
Carey van P (1992) Liquid–vapor phase-change phenomena. An introduction to the thermophysics of vaporization and condensation processes in heat transfer equipment. Hemisphere, New York
Celata GP, Cumo M, Mariani A (1997) Experimental evaluation of the onset of subcooled flow boiling at high liquid velocity and subcooling. Int J Heat Mass Transfer 40:2979–2885
Celata GP, Cumo M, Mariani A (1993) Burnout in highly subcooled water flow boiling in small diameter tubes. Int J Heat Mass Transfer 36:1269–1285
Chen JC (1966) Correlation for boiling heat transfer to saturated fluids in convective flow. Ind Eng Chem Process Des Develop 5:322–329
Cole R (1974) Boiling nucleation. In: Advances in Heat Transfer 10. Academic, New York, pp 86–166
Cole R, Shulman HL (1966) Bubble growth rates at high Jacob numbers Int J Heat Mass Transfer 9:1377–1390
Collier G, Thome J (1994) Convective Boiling and Condensation, 3rd edn. Oxford University Press, Oxford
Davis EJ, Anderson GH (1966) The incipience of nucleate boiling in forced convection flow. AIChE 12:774–780
Dhir VK (1998) Boiling heat transfer. Ann Rev Fluid Mech 30:365–401
Farkas L (1927) The velocity of nucleus formation in superheated vapors. Z Phys Chem 125:236–240
Fritz WW (1936) Ende über den Verdampfungsvorgang nach kinematographischen Aufnahmen an Dampfblasen. Phys Z 37:391–401
Geld C (2004) Prediction of dynamic contact angle histories of a bubble growing at a wall. Int J Heat Fluid Flow 25:74–80
Ghiaasiaan SM, Chedester RC (2002) Boiling incipience in microchannels. Int J Heat Mass Transfer 45:4599–4606
Griffel J (1965) Forced convection boiling burnout for water in uniformly heated tubular test sections. USAEC Report NYO 187-7, TID-4500, Columbia University
Grohmann S (2005) Measurement and modeling of single-phase and flow-boiling heat transfer in micro-tubes. Int J Heat Mass Transfer 48:4072–4089
Hall DD, Mudawar I (2000) Critical heat flux (CHF) for water flow in tubes – II. Subcooled CHF correlations. Int J Heat Mass Transfer 43:2605–2640
Han CH, Griffith P (1965) The mechanism of heat transfer in nucleate pool boiling. Part I: Bubble initiation, growth and departure Int J Heat Mass Transfer 8:887–904
Hapke I, Boye H, Schmidt J (2000) Onset of nucleate boiling in micro-channels. Int J Therm Sci 39:505–513
Helden W, Geld C, Boot P (1995) Forces on bubbles growing and detaching in flow along a vertical wall. Int J Heat Mass Transfer 38:2075–2088
Hetsroni G, Mosyak A, Pogrebnyak E, Sher I, Segal Z (2006a) Bubble growth in saturated pool boiling in water and surfactant solution. Int J Multiphase Flow 22:159–182
Hetsroni G, Mosyak A, Pogrebnyak E, Segal S (2006b) Periodic boiling in parallel micro-channels at low vapor quality. Int J Multiphase Flow 32:1141–1159
Hetsroni G, Mosyak A, Pogrebnyak E, Segal S (2007) Natural convection boiling of water and surfactant in narrow horizontal annular channels. Int J Multiphase Flow 33:469–483
Hetsroni G, Mosyak A, Pogrebnyak E, Segal Z (2005) Explosive boiling of water in parallel micro-channels. Int J Multiphase Flow 31:371–392
Hetsroni G, Mosyak A, Segal Z, Pogrebnyak E (2003) Two-phase flow pattern in parallel micro-channels. Int J Multiphase Flow 29:344–360
Hetsroni G, Mosyak A, Segal Z, Ziskind G (2002a) A uniform temperature heat sink for cooling of electronic devices. Int J Heat Mass Transfer 45:3275–3286
Hetsroni G, Gurevich M, Mosyak A, Rozenblit R, Yarin LP (2002b) Subcooling boiling of surfactant solutions. Int J Multiphase Flow 28:347–361
Hino R, Ueda T (1985) Studies on heat transfer and flow characteristics in subcooled flow boiling. Part 1: Boiling characteristics. Int J Multiphase Flow 11:269–281
Hsu YY (1962) On size range of active nucleation cavities on a heating surface. J Heat Transfer 84:207–216
Hsu YY, Graham RW (1961) An analytical and experimental study of the thermal boundary layer and ebullition cycle in nucleate boiling. NASA TN D-594
Hwan YW, Kim MS (2006) The pressure drop in micro-tubes and correlation development. Int J Heat Mass Transfer 49:1804–1812
Inasaka F (1993) Critical heat flux of subcooled flow boiling in water under uniform heating conditions. Papers Ship Res Inst 30(4):1–69
Inasaka F, Nariai H (1987) Critical heat flux and flow characteristics of subcooled flow boiling in narrow tubes. JSME Int J 30:1595–1600
Inasaka F, Nariai H (1989) Critical heat flux of subcooled flow boiling with water. Proc NURETH-4 1:115–120
Jens WH, Lottes PA (1951) Analysis of heat transfer burnout drop and density data for high pressure water. US ANL Rep 4627
Kakac S, Bon B (2008) A review of two-phase flow dynamic instabilities in tube boiling systems. Int. J. Heat Mass Transfer 51:399–433
Kandlikar SG (2002) Fundamental issues related to flow boiling in mini-channels and micro-channels. Exp Thermal Fluid Sci 26:389–407
Kandlikar SG, Steinke ME, Tian S, Campbell LA (2001) High speed photographic observation of flow boiling of water in parallel mini-channels. In: 35th Proceeding of National Heat Transfer Conference, ASME, New York
Kandlikar SG, Balasubramanian P (2004) An extension of the flow boiling correlation to transition, laminar and deep laminar flows in mini-channels and micro-channels. Heat Transfer Eng 25:86–93
Kandlikar SG, Mizo V, Cartwright M, Ikenze E (1997) Bubble nucleation and growth characteristics in subcooled flow boiling water. National Heat Transfer Conference HTD-342. ASME, New York, pp 11–18
Kandlikar SG (2006) Nucleation characteristics and stability considerations during flow boiling in micro-channels. Exp. Thermal and Fluid Science 30:441–447
Katto Y, Ohno H (1984) An improved version of the generalized correlation of critical heat flux for the forced convective boiling in uniformly heated vertical tubes. Int J Heat Mass Transfer 27:1641–1648
Kays WM, Krawford ME (1993) Convective heat and mass transfer. McGraw-Hill, New York
Kennedy JE, Roach GM, Dowling ME, Abdel-Khalik SI, Chiaasiaan SM, Jeter SM, Quershi ZH (2000) The onset of flow instability in uniformly heated horizontal micro-channels. Trans ASME J Heat Transfer 122:118–125
Klausner JF, Mei R, Bernard D, Zeng L (1993) Vapor bubble departure in forced convection boiling. Int J Heat Mass Transfer 36:651–661
Klein D, Hetsroni G, Mosyak A (2005) Heat transfer characteristics of water and APG surfactant solution in a micro-channel heat sink. Int J Multiphase Flow 31:393–415
Kosar, A, Kuo, CJ, Peles, Y (2005) Boiling heat transfer with reentrant cavities. Int. J. Heat Mass Transfer 48:4867–4886
Kuo, CJ, Peles, Y (2007) Local measurements of flow boiling in structured surface micro-channels. Int. J. Heat Mass Transfer 50:4513–4526.
Kureta M (1997) Critical heat flux for flow boiling of water in small diameter tubes under atmospheric pressure. Dissertation, Kyoto University (in Japanese)
Kutateladze SS (1963) Fundamentals of heat transfer. Edward Arnold, London
Lazarek GM, Black SH (1982) Evaporative heat transfer, pressure drop and critical heat flux in a small vertical tube with R-113. Int J Heat Mass Transfer 25:945–959
Lee HC, Oh BD, Bae SW, Kim MH (2003) Single bubble growth in saturated pool boiling on a constant wall temperature surface. Int J Multiphase Flow 29:1857–1874
Lee HJ, Lee SY (2001a) Pressure drop correlations for two-phase flow within horizontal rectangular channels with small heights. Int J Multiphase Flow 27:782–796
Lee HJ, Lee SY (2001b) Heat transfer correlation for boiling flows in small rectangular horizontal channels with low aspect ratios. Int J Multiphase Flow 27:2043–2062
Lee J, Mudawar I (2005a) Two-phase flow in high-heat-flux micro-channel heat sink for refrigeration cooling applications. Part I: pressure drop characteristics. Int J Heat Mass Transfer 48:928–940
Lee J, Mudawar I (2005b) Two-phase flow in high-heat-flux micro-channel heat sink for refrigeration cooling applications. Part II: heat transfer characteristics. Int J Heat Mass Transfer 48:941–955
Lee PC, Tseng FC, Pan C (2004) Bubble dynamics in microchannels. Part 1: single microchannel. Int J Heat Mass Transfer 47:5575–5589
Lezzi AM, Niro A, Beretta GP (1994) Experimental data on CHF for forced convection water boiling in long horizontal capillary tubes. In: Hewitt GF (ed) Heat Transfer 1994: Proceedings of the 10th International Heat Transfer Conference, vol 7, Institution of Chemical Engineers, Rugby, pp 491–496
Li HY, Tseng FC, Pan C (2004) Bubble dynamics in micro-channels. Part II: two parallel micro-channels. Int J Heat Mass Transfer 47:5591–5601
Li J, Cheng P (2004) Bubble cavitation in a micro-channel. Int J Heat Mass Transfer 47:2689–2698
Liu D, Lee PS, Garimella SV (2005) Prediction of the onset of nucleate boiling in microchannel flow. Int J Heat Mass Transfer 48:5134–5149
Liu Z, Winterton RHS (1991) A general correlation for saturated and subcooled flow boiling in tubes and annuli, based on a nucleate pool boiling equation. Int J Heat Mass Transfer 34:2759–2766
Lockhart RW, Martinelli RC (1949) Proposed correlation of data for isothermal two-phase two-component flow in pipes. Chem Eng Prog 45:39–48
Lowdermilk WH, Lanzo CD, Siegel BL (1958) Investigation of boiling burnout and flow stability for water flowing in tubes, NACA TN 4382. National Advisory Committee for Aeronautics, Washington, DC
Mei R, Chen W, Klausner JF (1995a) Vapor bubble growth in heterogeneous boiling Int J Heat Mass Transfer 38:909–919
Mei R, Chen W, Klausner JF (1995b) Vapor bubble growth in heterogeneous boiling. Part I: growth rate and thermal fields. Int J Heat Mass Transfer 38:921–934
Mikic BB, Rohsenow WM, Griffith P (1970) On bubble growth rates. Int J Heat Mass Transfer 13:657–666
Mishima K, Hibiki T (1996) Some characteristics of air–water two-phase flow in small diameter vertical tubes. Int J Multiphase Flow 22:703–712
Moriyama K, Inoue A (1996) Thickness of the liquid film formed by growing bubble in a narrow gap between two horizontal plates. J Heat Transfer Trans ASME 118:132–139
Mudawar I, Bowers MB (1999) Ultra-high critical heat flux (CHF) for subcooled water flow boiling. I: CHF data and parametric effects for small diameter tubes. Int J Heat Mass Transfer 42:1405–1428
Nakoryakov VE, Pokusaev BG, Shreiberg IR (2000) Wave propagation in gas–liquid media, 2nd edn. CRC, Boca Raton
Nariai H, Inasak F, Uehara K (1989) Critical heat flux in narrow tubes with uniform heating. Heat Transfer Jpn Res 18:21–30
Nariai H, Inasaka F, Shimura T (1987) Critical heat flux of subcooled flow boiling in narrow tube. ASME JSME Thermal Eng Joint Conf Proc 5:455–462
Nigmatulin IR (1991) Dynamics of multiphase media and 2. Hemisphere, London
Ory E, Yuan H, Prosperetti A, Popinet S, Zaleski S (2000) Growth and collapse of vapor bubble in a narrow tube. Phys Fluids 12:1268–1277
Ozawa M, Akagawea K, Sakaguchi T (1989) Flow instabilities in parallel-channel flow systems of gas-liquid two-phase mixtures. Int J Multiphase Flow 15:639–657
Peles YP (1999) VLSI chip cooling by boiling-two-phase flow in micro-channels. Dissertation, Faculty of Mechanical Engineering, Technion–Israel Institute of Technology, Haifa
Peles YP, Yarin LP, Hetsroni G (2001) Steady and unsteady flow in heated capillary. Int J Multiphase Flow 22:577–598
Peng XF, Hu HY, Wang BX (1997) Boiling nucleation during liquid flow in micro-channels. Int J Heat Mass Transfer 41:101–106
Plesset MS, Zwick SA (1954) The growth of vapor bubbles in superheated. J Appl Phys 25:474–478
Prodanovic V, Fraser D, Salcudean M (2002) On transition from partial to fully developed subcooled flow boiling. Int J Heat Mass Transfer 45:4727–4738
Qu W, Mudawar I (2003a) Measurement and prediction of pressure drop in two-phase micro-channel heat sinks. Int J Heat Mass Transfer 46:2737–2753
Qu W, Mudawar I (2003b) Flow boiling heat transfer in two-phase micro-channel heat sink. I: Experimental investigation and assessment of correlation methods. Int J Heat Mass Transfer 46:2755–2771
Qu W, Mudawar I (2002) Prediction and measurement of incipient boiling heat flux in micro-channel heat sinks. Int J Heat Mass Transfer 45:3933–3945
Qu W, Mudawar I (2004) Measurement and correlation of critical heat flux in two-phase micro-channel heat sinks. Int J Heat Mass Transfer 47:2045–2059
Quiben JM, Thome JR (2007a) Flow pattern based two-phase pressure drop model for horizontal tubes. Part I. Diabatic and adiabatic experimental study. Int. J. Heat and Fluid Flow. 28(5):1049–1059
Quiben JM, Thome JR (2007b) Flow pattern based two-phase pressure drop model for horizontal tubes. Part II. New phenomenological model. Int. J. Heat and Fluid Flow. 28(5):1060–1072
Rayleigh JWS (1917) On the pressure developed in a liquid during the collapse of a spherical cavity. Phil Mag 34:94–98
Revellin R, Thome J. (2008) A theoretical model for the prediction of the critical hat flux in heated micro-channel. Int. J. Heat and Mass Transfer 51:1216–1225
Roach GM, Abdel-Khalik SI, Ghiaasiaan SM, Dowling MF, Jeter SM (1999) Low-flow critical heat flux in heated microchannels. Nucl Sci Eng 131:411–425
Robinson AJ, Judd RL (2001) Bubble growth in a uniform and spatially distributed temperature field. Int J Heat Mass Transfer 44:2699–2710
Sato T, Matsumura H (1964) On the conditions of incipient subcooled-boiling with forced convection. Bull Jpn Soc Mech Eng 7:392–398
Sedov LI (1993) Similarity and dimensional methods in mechanics, 10th edn. CRC, Boca Raton
Shah MM (1982) Chart correlation for saturated boiling heat transfer: equation and further study. ASHRAE Trans 88:185–196
Shah MM (1987) Improved general correlation for critical heat flux during upflow in uniformly heated vertical tubes. Int J Heat Fluid Flow 8:326–335
Shah RK, London AL (1978) Laminar flow forced convection in ducts: a source book for compact heat exchanger analytical data. Advances in Heat Transfer, suppl 1. Academic, New York
Sher I, Hetsroni G (2002) An analytical model for nucleate pool boiling with surfactant additives. Int J Multiphase Flow 28:699–706
Shuai J, Kulenovic R, Droll M (2003) Heat transfer and pressure drop for flow boiling of water in narrow vertical rectangular channels. In: Proceedings for 1st International Conference on Micro-channels, Rochester, New York, 24–25 April 2003, ICMM 2003-1084
Staniszewski BE (1959) Nucleate boiling bubble growth and departure MIT DSR Project N7-7673, Technical Report N16
Steinke ME, Kandlikar SG (2004a) Control and effect of dissolved air in water during flow boiling in micro-channels. Int J Heat Mass Transfer 47:1925–1935
Steinke M, Kandlikar SG (2004b) An experimental investigation of flow boiling characteristics of water in parallel micro-channels. Trans ASME J Heat Transfer 126:518–526
Stoddard RM, Blasick AM, Ghiaasiaan SM, Abdel-Khalik SI, Jeter SM, Dowling MF (2002) Onset of flow instability and critical heat flux in thin horizontal annuli. Exp Thermal Fluid Sci 26:1–14
Su S, Huang S, Wang X (2001) Study of boiling incipience and heat transfer enhancement in forced flow through narrow channels. Int J Heat Mass Transfer 31:253–260
Revellin R, Agostini B, Thome J (2008) Elongated bubbles in micro-channels Part II: Experimental study and modeling of bubble collisions. Int. J. Multiphase Flow 34:602–613
Thom JRS, Walker WM, Fallon TA, Reising GFS (1965) Boiling in subcooled water during flow up heated tubes or annuli. In: Symposium on Boiling Heat Transfer in Steam Generating Units and Heat Exchangers, Manchester, 15–16 September 1965. IMechE London
Thome JR, Dupont V, Jacobi AM (2004) Heat transfer model for evaporation in micro-channels. Part I: Comparison with database. Int J Heat Mass Transfer 47:3375–3385
Thompson B, Macbeth RV (1964) Boiling water heat transfer – burnout in uniformly heated round tubes: a compilation of world data with accurate correlations, AEEW-R 356. United Kingdom Atomic Energy Authority, Winfrith, UK
Thorncroft GE, Klausner JF, Mei R (1998) An experimental investigation of bubble growth and detachment in vertical upflow and downflow boiling. Int J Heat Mass Transfer 41:3857–3871
Thorncroft GE, Klausner JF, Mei R (2001) Bubble forces and detachment models Multiphase Sci Technol 13:35–76
Tran TN, Chyu M-C, Wambsganss MW, France DM (2000) Two-phase pressure drop of refrigerants during flow boiling in small channels: an experimental investigation and correlation development. Int J Multiphase Flow 26:1739–1754
Tran TN, Wambsganss MW, France DM (1996) Small circular and rectangular channel boiling with two refrigerants. Int J Multiphase Flow 22:485–498
Unal HC (1975) Determination of the initial point of net vapor generation in flow boiling system. Int J Heat Mass Transfer 18:1095–1099
van Stralen SJD (1966) The mechanism of nucleate boiling in pure liquids and in binary mixtures. Int J Heat Mass Transfer 9:995–1046
Vandervort CL, Bergles AE, Jensen MK (1994) An experimental study of critical heat flux in very high heat flux subcooled boiling. Int J Heat Mass Transfer 37:161–173
Volmer M, Weber A (1926) Nucleus formation in superheated systems. Z Phys Chem 119:277–281
Wang G, Cheng P, Bergles AE 2008 Effects of inlet outlet configurations on flow boiling instability in parallel micro-channels. Int. J. Mass Transfer 51:2267–2281
Warrier GR, Pan T, Dhir VK (2002) Heat transfer and pressure drop in narrow rectangular channels. Exp Therm Fluid Sci 26:53–64
Wojtan L, Revellin R, Thome J (2006) Investigation of critical heat flux in single uniformly heated micro-channels. Exp. Therm, Fluid Sci. 30:765–774
Wu HY, Cheng P (2004) Boiling instability in parallel silicon micro-channels at different heat flux. Int J Heat Mass Transfer 47:3631–3641
Wu HY, Cheng P (2003a) Liquid/two-phase/vapor alternating flow during boiling in micro-channels at high heat flux. Int Comm Heat Transfer 39:295–302
Wu HY, Cheng P (2003b) Visualization and measurements of periodic boiling in silicon micro-channels. Int J Heat Mass Transfer 46:2603–2614
Wu WT, Yang YM (1992) Enhanced boiling heat transfer by surfactant additives. In: Proceedings Engineering Foundation Conference On Pool and External Flow Boiling, Santa Barbara, California, 1992, pp 361–366
Yang YM, Maa JR (2003) Boiling heat transfer enhancement by surfactant additives. In: Proceedings of the 5th International Conference Boiling Heat Transfer, ICBHT, Montego Bay, Jamaica, 4–8 May 2003
Ye H, Naguib N, Gogotsi Y (2004) TEM study of water in carbon nanotubes. JEOL News 39:2–7
Yen T-H, Shji M, Takemura F, Suzuki Y, Kasagi N (2006) Visualization of convective boiling heat transfer in single micro-channels with different shaped cross-sections. Int J Heat Mass Transfer 49:3884–3894
Yen T-H, Kasagi N, Suzuki Y (2003) Forced convective boiling heat transfer in micro-tubes at low mass and heat fluxes. Int J Multiphase Flow 29:1771–1792
Yu W, France DM, Wambsganss MW, Hull JR (2002) Two-phase pressure drop, boiling heat transfer, and critical heat flux to water in a small-diameter horizontal tube. Int J Multiphase Flow 28:927–941
Zel’dovich YaB (1943) On the theory of new phase formation: cavitation. Acta Physicochim URSS 18:1–7
Zeng LZ, Klausner JF, Mei R (1993) A unified model for the prediction on bubble detachment diameters in boiling system. Part I: Pool boiling. Int J Heat Mass Transfer 36:2261–2270
Zhang W, Hibiki T, Mishima K, Mi Y (2006) Correlation of critical heat flux for flow boiling of water in mini-channels. Int J Heat and Mass Transfer 49:1058–1072
Zhang J, Manglik RM (2005) Additive absorption and interfacial characteristics of nucleate pool boiling in aqueous surfactant solutions. J Heat Transfer 127: 684–691
Zhang L, Koo J-M, Jiang L, Asheghi M, Goodson KE, Santiago JK (2002) Measurements and modeling of two-phase flow in micro-channels with nearly constant heat flux boundary conditions. J Microelectromech Syst 11: 12–19
Zuber N (1961) The dynamics of vapor bubbles in non-uniform temperature fields. Int J Heat Mass Transfer 2:83–98
Rights and permissions
Copyright information
© 2009 Springer-Verlag Berlin Heidelberg
About this chapter
Cite this chapter
(2009). Boiling in Micro-Channels. In: Fluid Flow, Heat Transfer and Boiling in Micro-Channels. Heat and Mass Transfer. Springer, Berlin, Heidelberg. https://doi.org/10.1007/978-3-540-78755-6_6
Download citation
DOI: https://doi.org/10.1007/978-3-540-78755-6_6
Publisher Name: Springer, Berlin, Heidelberg
Print ISBN: 978-3-540-78754-9
Online ISBN: 978-3-540-78755-6
eBook Packages: EngineeringEngineering (R0)