Abstract
The subject of this chapter is single-phase heat transfer in micro-channels. Several aspects of the problem are considered in the frame of a continuum model, corresponding to small Knudsen number. A number of special problems of the theory of heat transfer in micro-channels, such as the effect of viscous energy dissipation, axial heat conduction, heat transfer characteristics of gaseous flows in microchannels, and electro-osmotic heat transfer in micro-channels, are also discussed in this chapter.
Access provided by Autonomous University of Puebla. Download to read the full chapter text
Chapter PDF
Keywords
These keywords were added by machine and not by the authors. This process is experimental and the keywords may be updated as the learning algorithm improves.
References
Adams TM, Abdel-Khalik SI, Jeter SM, Qureshi ZH (1998) An experimental investigation of single-phase forced convection in micro-channels. Int J Heat Mass Transfer 41:851–857
Asako Y, Toriyama H (2005) Heat transfer characteristics of gaseous flows in micro-channels. Microscale Thermophys Eng 9:15–31
Baehr HD, Stephan K (1998) Heat and mass transfer. Springer, Berlin Heidelberg New York
Bailey DK, Ameel T, Warrington RO, Savoie TI (1995) Single phase forced convection heat transfer in micro-geometries: a review. In: Proceedings the 13th of Intersociety Energy Conversion Engineering Conference, San Diego, 20–25 August 1978. American Society of Mechanical Engineers, New York, pp 301–310
Bastanjian SA, Merzhanov AG, Xudiaev SI (1965) On hydrodynamic thermal explosion. Sov Phys Docl 163:133–136
Celata GP, Como M, Zummo G (2004) Thermal-hydraulic characteristics of single-phase flow in capillary pipes. Exp Thermal Fluid Sci 28:87–95
Celata GP, Cumo M, Marconi V, McPhail SJ, Zummo Z (2005) Micro-tube heat transfer scaling effects: an experimental validation. In: Proceedings of ECI International Conference on Heat Transfer and Fluid Flow in Microchannels, Caste/Vecchio Pascoli, Italy, 25–30 September 2005
Celata GP, Cumo M, Marconi V, McPhail SJ, Zummo Z (2006) Micro-tube liquid single phase heat transfer in laminar flow. Int. J. Heat Mass Transfer 49:3538–3546
Chakraborty S (2006) Analytical solutions of Nusselt number for thermally fully developed flow in microtubes under a combined action of electroosmotic forces and imposed gradients. Int J Heat Mass Transfer 49:810–813
Choi SB, Barron R, Warrington RQ (1991) Fluid flow and heat transfer in micro-tubes. In: Choi D et al. (eds) Micro-mechanical sensors, actuators and systems. ASME DSC 32:121–128
Davis EJ, Gill WN (1970) The effect of axial conduction in the wall on heat transfer with laminar flow. Int J Heat Mass Transfer 23:459–470
Dittus FW, Boelter LMK (1930) Heat transfer in automobile radiators of tubular type. University of California, Berkley. Publ Eng 2(13):443–461
Eckert E, Weise W (1941) Die Temperatur unbeheizter Körper in einem Gasstrom hoher Geschwindigkeit. Forsch Ing Wes 12:40–50
Gad-el-Hak M (1999) The fluid mechanics of micro-devices. The Freeman Scholar Lecture. J Fluid Eng 121:5–33
Gad-el-Hak M (2003) Comments on critical view on new results in micro-fluid mechanics. Int J Heat Mass Transfer 46:3941–3945
Gamart G, Favre-Marinet M, Asendrych D (2005) Conduction and entrance effects on laminar liquid flow and heat transfer in rectangular micro-channels. Int J Heat Mass Transfer 48:2943–2954
Gao P, Le Person S, Favre-Marinet M (2002) Scale effects on hydrodynamics and heat transfer in two-dimensional mini and micro-channels. Int J Thermal Sci 41:1017–1027
Garimella SV, Sobhan CB (2003) Transport in micro-channels – a critical review. Ann Rev Heat Transfer 13:1–50
Gnielinski V (1976) New equations for heat and mass transfer in turbulent pipe and channel flow. Int Chem Eng 16:359–368
Gruntfest J, Young JP, Johnson NL (1964) Temperatures generated by the flow of liquids in pipers. J Appl Phys 35:18–23
Gua Z-Y, Li Z-X (2003) Size effect on micro-scale single-phase flow and heat transfer. Int J Heat Mass Transfer 46:149–159
Harms TM, Kazmierzak MJ, Gerner FM (1999) Developing convective heat transfer in deep rectangular micro-channels. Int J Heat Fluid Flow 20:149–157
Hassan I, Phuttavong P, Abdelgawad M (2004) Micro-channel heat sinks: an overview of the state of the art. Microscale Thermophys Eng 8:183–204
Hehnecke DK (1968) Heat transfer by Hagen–Poiseuille flow in the thermal development region with axial conduction. Wazme Stoffubertz 1:177–184
Herwig H (2000) Flow and heat transfer in micro systems. Is everything different or just smaller. ZAMM 82:579–586
Herwig H, Hausner O (2003) Critical view on new results in micro-fluid mechanics: an example. Int J Heat Mass Transfer 46:935–937
Hetsroni G, Gurevich M, Mosyak A, Rozenblit R (2003) Surface temperature measurement of a heated capillary tube by means of an infrared technique. Meas Sci Technol 14:807–814
Hetsroni G, Gurevich M, Mosyak A, Rozenblit R (2004) Drag reduction and heat transfer of surfactants flowing in a capillary tube. Int J Heat Mass Transfer 47: 3797–3809
Hetsroni G, Mosyak A, Pogrebnyak E, Yarin LP (2005) Fluid flow in micro-channels Int J Heat Mass Transfer 48:1982–1998
Hetsroni G, Mosyak A, Segal Z (2001) Nonuniform temperature distribution in electronic devices cooled by flow in parallel micro-channels. IEEE Trans Comp Packag Technol 24(1):16–23
Ho CM, Tai Y-C (1998) Micro-electronic mechanic systems (MEMS) and fluid flows. Ann Rev Fluid Mech 30:5–33
Horiuchi K, Dutta P (2004) Joule heating effects in electroosmotically driven microchannel flows. Int J Heat Mass Transfer 47:3085–3095
Hunter RJ (1981) Zeta potential in colloid science: principles and applications. Academic, New York
Incropera FP, De Witt DP (1996) Fundamentals of heat and mass transfer, 4th edn. Wiley, New York
Judy J, Maynes D, Webb BW (2002) Characterization of friction pressure drop for liquid flows through micro-channels. Int J Heat Mass Transfer 45:3477–3489
Kandlikar S, Grande W (2002) Evolution of micro-channel flow passages – thermohydraulic performance and fabrication technology. In: Proceedings of IMEECE, ASME International Mechanical Engineering Congress and Exposition, New Orleans, November 2002, pp 1–13
Kandlikar SG, Joshi S, Tian S (2003) Effect of surface roughness on heat transfer and fluid flow characteristics at low Reynolds numbers in small diameter tubes. Heat Transfer Eng 24(3):4–16
Kays WM, Crawford ME (1993) Convective heat and mass transfer. McGraw-Hill, New York
Klein D, Hetsroni G, Mosyak A (2005) Heat transfer characteristics of water and APG surfactant solution in a micro-channel heat sink. Int J Multiphase Flow 31:393–415
Koo J, Kleinstreuer C (2004) Viscous dissipation effects in micro-tubes and micro-channels. Int J Heat Mass Transfer 47:3159–3169
Kostic M (1994) On turbulent drag and heat transfer reduction phenomena and laminar heat transfer enhancement in non-circular duct flow of certain non-Newtonian fluid. Int J Heat Mass Transfer 37:133–147
Kroeker CJ, Soliman HM, Ormiston SJ (2004) Three-dimensional thermal analysis of heat sinks with circular cooling micro-channels. Int J Heat Mass Transfer 47:4733–4744
Lee PS, Garimella SV, Liu D (2005) Investigation of heat transfer in rectangular micro-channels. Int J Heat Mass Transfer 48:1688–1704
Lelea D (2005) Some considerations on frictional losses evaluation of a water flow in micro-tubes. Int Comm Heat Mass Transfer 32:964–973
Lelea D, Nishio S, Takano K (2004) The experimental research on micro-tube heat transfer and fluid flow of distilled water. Int J Heat Mass Transfer 47:2817–2830
Li J, Peterson GP, Cheng P (2004) Three-dimensional analysis of heat transfer in a micro-heat sink with single phase flow. Int J Heat Mass Transfer 47:4215–4231
Lin TY, Yang CY (2007) An experimental investigation by method of fluid crystal thermography. Int. J. Heat Mass Transfer 50(23-24):4736-4742
Ma HB, Peterson GP (1997) Laminar friction factor in micro-scale ducts of irregular cross section. Microscale Thermophys Eng 1:253–265
Mala GM, Li D (1999) Flow characteristics of water in micro-tubes. Int J Heat Fluid Flow 20:142–148
Mala GM, Li D, Dale JD (1997a) Heat transfer and fluid flow in micro-channels. Int J Heat Mass Transfer 40:3079–3088
Mala GM, Li D, Werner C (1997b) Flow characteristics of water through a micro-channel between two parallel plates with electro kinetic effects. Int J Heat Fluid Flow 18:491–496
Male van P, Croon de MHJM, Tiggelaar RM, Derg van den A, Schouten JC (2004) Heat and mass transfer in a square micro-channel with asymmetric heating. Int J Heat Mass Transfer 47:87–99
Maranzana G, Perry I, Maillet D (2004) Mini- and micro-channels: influence of axial conduction in the walls. Int J Heat Mass Transfer 47:3993–4004
Maynes D, Webb BW (2003) Full developed electro-osmotic heat transfer in microchannels. Int J Heat Mass Transfer 46:1359–1369
Morini GL (2004) Single-phase convective heat transfer in micro-channels: overview of experimental results. Int J Thermal Sci 43:631–651
Morini GL (2005) Viscous heating in liquid flows in micro-channels. Int J Heat Mass Transfer 48:3637–3647
Nguyen NT, Bochnia D, Kiehnscherrf R, Dozel W (1996) Investigation of forced convection in micro-fluid systems. Sens Actuators A 55:49–55
Nguyen TV (1992) Laminar heat transfer for thermal developing flow in ducts. Int J Heat Mass Transfer 35:1733–1741
Owhaib W, Palm B (2004) Experimental investigation of single-phase convective heat transfer in circular micro-channels. Exp Thermal Fluid Sci 28:105–110
Peng XF, Peterson GP (1995) The effect of thermofluid and geometric parameters on convection of liquid through rectangular micro-channels. Int J Heat Mass Transfer 38:755–758
Peng XF, Peterson GP (1996) Convective heat transfer and flow friction for water flow in micro-channel structures. Int J Heat Mass Transfer 39:2599–2608
Peng XF, Wang BX, Peterson GP, Ma NB (1995) Experimental investigation of heat transfer in flat plates with rectangular micro-channels. Int J Heat Mass Transfer 38:127–137
Petukhov BS, Kurgano V, Gladuntsov A (1973) Heat transfer in turbulent pipe flow of gases with variable properties. Heat Transfer Sov Res 5:109–116
Petukhov BS (1967) Heat transfer and drag of laminar flow of liquid in pipes. Energy, Moscow
Qu W, Mala GM, Li D (2000) Heat transfer for water flow in trapezoidal silicon micro-channels. Int J Heat Mass Transfer 43:3925–3936
Qu W, Mudawar I (2002) Analysis of three-dimensional heat transfer in micro-channel heat sinks. Int J Heat Mass Transfer 45:3973–3985
Qu W, Mudawar I (2002) Experimental and numerical study of pressure drop and heat transfer in a single-phase micro-channel heat sink. Int J Heat Mass Transfer 45:2549–2565
Qu W, Mudawar I (2004) Measurement and correlation of critical heat flux in two-phase micro-channel heat sinks. Int J Heat Mass Transfer 47:2045–2059
Ren L, Qu W, Li D (2001) Interfacial electro kinetic effects on liquid flow in micro-channels. Int J Heat Mass Transfer 44:3125–3134
Reynaud S, Debray F, Frans J-P, Maitre T (2005) Hydrodynamics and heat transfer in two-dimensional mini-channels. Int J Heat Mass Transfer 48:3197–3211
Schlichting H (2000) Boundary layer theory, 8th edn. Springer, Berlin Heidelberg New York
Shah RK, London AL (1978) Laminar flow forced convection in ducts. Academic, New York
Sobhan CB, Garimella SV (2001) A comparative analysis of studies on heat transfer and fluid flow in micro-channels. Microscale Thermophys Eng 5:293–311
Tiselj I, Hetsroni G, Mavko B, Mosyak A, Pogrebhyak E, Segal Z (2004) Effect of axial conduction on the heat transfer in micro-channels. Int J Heat Mass Transfer 47:2551–2565
Toh KC, Chen XY, Chai JC (2002) Numerical computation of fluid flow and heat transfer in micro-channels. Int J Heat Mass Transfer 45:5133–5141
Tso CP, Mahulikar SP (1998) The use of the Brinkman number for single phase forced convective heat transfer in micro-channels. Int J Heat Mass Transfer 41:1759–1769
Tso CP, Mahulikar SP (1999) The role of the Brinkman number in analyzing flow transitions in micro-channels. Int J Heat Mass Transfer 42:1813–1833
Tso CP, Mahulikar SP (2000) Experimental verification of the role of the Brinkman number in micro-channels using local parameters. Int J Heat Mass Transfer 43:1837–1849
Tunc G, Bayazitoglu Y (2001) Heat transfer in micro-tubes with viscous dissipation. Int J Heat Mass Transfer 44:2395–2403
Turner SE, Sun H, Faghri M, Gregory OJ (1999) Local pressure measurement of gaseous flow through micro-channels. ASME HTD 364(3):71–80
Turner SE, Sun H, Faghri M, Gregory OJ (2000) Effect of surface roughness on gaseous flow through micro-channels. ASME HTD 366(2):291–298
Wang BX, Peng XF (1994) Experimental investigation on liquid forced-convection heat transfer through micro-channels. Int J Heat Mass Transfer 37(1):73–82
Warrier GR, Dhir VK, Momoda LA (2002) Heat transfer and pressure drop in narrow rectangular channels. Exp Thermal Fluid Sci 26:53–64
Weigand B, Lauffer D (2004) The extended Graetz problem with piecewise constant wall temperature for pipe and channel flows. Int J Heat Mass Transfer 47:5303–5312
Wu HY, Cheng P (2003) An experimental study of convective heat transfer in silicon micro-channels with different surface conditions. Int J Heat Mass Transfer 46:2547–2556
Wu PY, Little WA (1984) Measuring of the heat transfer characteristics of gas flow in fine channel heat exchangers for micro-miniature refrigerators. Cryogenics 24:415–420
Yang C, Li D (1998) Analysis of electro kinetic effects on the liquid flow in micro-channels. Coll Surf A Physicochem Eng Aspects 143:339–353
Yang CY, Lin TY (2007) Heat transfer characteristics of water flow in micro-tubes. Exp. Thermal and Fluid Science 32:432-439
Yoo JY (2006) Recent studies of fluid flow and heat transfer in thermal micro-devices. Nanoscale Microscale Thermophys Eng 10:67–81
Zel’dovich YaB, Barenblatt GI, Librovich VB, Maxhviladse GM (1985) Mathematical theory of combustion and explosion. Plenum, New York
Zhao CY, Lu TJ (2002) Analysis of micro-channels for electronic cooling. Int J Heat Mass Transfer 45:4857–4869
Rights and permissions
Copyright information
© 2009 Springer-Verlag Berlin Heidelberg
About this chapter
Cite this chapter
(2009). Heat Transfer in Single-Phase Flows. In: Fluid Flow, Heat Transfer and Boiling in Micro-Channels. Heat and Mass Transfer. Springer, Berlin, Heidelberg. https://doi.org/10.1007/978-3-540-78755-6_4
Download citation
DOI: https://doi.org/10.1007/978-3-540-78755-6_4
Publisher Name: Springer, Berlin, Heidelberg
Print ISBN: 978-3-540-78754-9
Online ISBN: 978-3-540-78755-6
eBook Packages: EngineeringEngineering (R0)