Abstract
The utilization of nutrients in sewage sludge partly alleviates the economic and environmental constraints, and the composting process has been proved a cost-efficient and simple approach for the recycling of sewage sludge. During the bio-oxidative process, the thermophilic phase is considered to be the most effective stage for the biodegradation of organic matter in sewage sludge composting systems. However, the maximum temperatures of conventional thermophilic composting systems only reach approximately 55–60 °C because of the activity limitations of thermophiles at higher temperatures. Notably, increasing temperatures can accelerate the humification process and shorten the composting cycle. Therefore, the effect of rising temperature on sewage sludge composting was examined as a specific mechanism. Further, the consequent hyperthermophilic composting (HTC) system created by rising temperatures was reviewed. Moreover, the potential techno-economic advantages and future challenges of HTC systems were discussed. Finally, the microbial communities necessary to ensure the efficiency of HTC systems were analyzed and suitable hyperthermophiles for sludge HTC systems were proposed.
Similar content being viewed by others
Explore related subjects
Discover the latest articles, news and stories from top researchers in related subjects.Avoid common mistakes on your manuscript.
Introduction
The treatment and disposal of sewage sludge has become an increasingly critical environmental issue because of growing production and potential pollution risks. The total amount of sewage sludge (80 wt.% moisture) generated by the three major economies (the USA, China, and the European Union) was 137 million tons in 2018 according to GEP Research (2018). However, the harmless disposal rate is still relatively low because of the improper management strategies, such as direct dumping or simple landfills, and low treatment efficiency [1]. Further, the associated economic cost is also of growing interest as approximately 35–65% of the total wastewater treatment plant operating cost is used for the disposing sewage sludge in accordance with the conditions of different countries. Sewage sludge is a carrier of energy and nutrients, which can be employed as an organic fertilizer. In particular, the organic matter (OM) contained in sewage sludge varies from 50 to 70% of the total solids, including the proteins, carbohydrates, and lipids [2, 3]. It should be stated that many of the chemical constituents, including nutrients, are important when considering the ultimate disposal of sewage sludge [4,5,6]. However, the direct use of raw sewage sludge as an agricultural fertilizer may damage soil and plants because of the phytotoxic and pathogenic effects of unstable and harmful substances [7,8,9]. The sustainable sludge treatment that meets requirements of efficient recycling of resources without supply of harmful substances to humans or the environment has been the key alternatives [3–9]. Therefore, the conversion of raw sewage sludge into safe and stable products, such as soil amendments and fertilizers, which are promising energy carriers, has been encouraged in several countries.
A composting process, which has been proved a cost-efficient and simple approach for the disposal of sewage sludge, has always been employed in the sewage sludge recycling of sewage treatment plants [10, 11]. The bio-oxidative process mainly involves the mineralization and partial humification of OM, leading to a stabilized and detoxicated final products [1, 12, 13], that could be utilized as a potential source of organic fertilizers or in soil amendments [10, 14]. Composted sewage sludge, as the biofertilizer, has been successfully applied to farmland, woodland, grassland, municipal green, and fruit and vegetable land, so as to restore vegetation on serious disturbance land and promote soil ripening, enhancing soil fertility and quality of energy crops [12, 14]. Bioprocesses are heavily dependent on dynamic interactions between biological, chemical, and physical mechanisms. The exothermic process is mainly determined by the initial temperature, biodegradability of the substrates, and the microbial activity [15]. Moreover, the physicochemical parameters, such as temperature, pH, particle size, moisture content, aeration, and electrical conductivity, play an important role in OM decomposition and the transformation and synthesis of humus under the action of microorganisms during a continuous process [16,17,18]. Among the multiple interacting factors in a complex system, temperature is regarded as the most critical [16, 19] (Fig. 1). Temperature can not only change the physicochemical characteristics of substrates but also affect the properties of microbial communities, such as the sludge morphology, microbial activity and OM degradation, oxygen transfer, and microbial succession [19,20,21,22,23,24]. The effects of a rising temperature on the four main bioprocesses in sewage sludge composting are (1) increasing solubilization of dissoluble solid OM, (2) accelerating diffusion of dissolved matrix, (3) enhancing the permeation and transmission of oxygen, and (4) improving the oxidation rate of dissolved matrix using aerobic microorganism [25]. In addition, higher temperature can further accelerate moisture evaporation, which reduces the sewage sludge mass. The moisture content of compost end products in a special hyperthermophilic composting (HTC) system with a maximum temperature of 93.4 °C can reach 38.8%, which is lower than that in conventional composting systems, which have a maximum temperature range of 55–60 °C [16, 26, 27].
Rich and Bharti [28] found that the optimum composting temperature range is from 40 to 65 °C, in which the highest activity of thermophilic microorganisms generally occurs at approximately 54 °C according to the levels of superoxide dismutase and catalase activity in thermophilic bacteria. Moreover, when the temperature is greater than 65 °C, most of the bacteria might be deactivated [16, 29]. In addition, higher temperature composting systems improve the deactivation of pathogenic bacteria and accelerate the moisture evaporation, which helps to achieve the quick recycling of small-scale and decentralized sewage sludge [26]. Therefore, the HTC system, which exploits a high temperature of about 80–100 °C, seems to have great advantages in the rapid recycling of sewage sludge. However, HTC systems have rarely been studied because most of the microorganisms are destroyed in their temperature range. Oshima and Moriya [30] proposed a special HTC system with a high temperature of 90 °C that was driven by the Calditerricola satsumensis (YMO81T) and Calditerricola yamamurae (YMO722T) strains [31]. As pointed out by Trautmann and Krasny [32], when the compost temperature was greater than 65 °C, the composting process reached a hyperthermophilic phase. Furthermore, increased efforts have been made to the exploration of the novel HTC system that reach higher than 80 °C as the maximum temperature of their hyperthermophilic phase [22, 24, 26, 33, 34]. Therefore, with the development of this emerging sludge treatment technology, we aimed to review the role of temperature in sewage sludge composting with emphasis on the hyperthermophilic system.
Present Status of Sewage Sludge Composting
The sewage sludge composting systems have been widely investigated, wherein the main areas of focus have been the following:
-
1)
The effects of various physicochemical parameters on the composting system, including temperature, pH, aeration, microbial activity, moisture content, and C/N ratio
-
2)
The bioavailability of different OM in sewage sludge, including the biodegradable matrix (saccharide, humic acid, protein, and lipid) and refractory organics, and improving bioavailability with different bulking agents, such as lignocellulosic amendments, biochar, recyclable plastic bulking agent (RPBA), medical stone and lime, pig and cow manure, coal fly ash, municipal solid waste, spent mushroom substrate, and sucrose
-
3)
Methods and technologies, including the continuous thermophilic composting (CTC) system, sequential anaerobic–aerobic composting, multistage inoculation strengthening composting, semipermeable cover composting, vermi-composting, and rotating-wall bioreactor composting
-
4)
The optimization strategies of composting, which mainly involves the statistical approaches (e.g., one variable-at-a-time, factorial designs, fuzzy logic estimation model, Markov chain approximation, and modified Gompertz model) and the kinetic models (such as the first-order model for OM degradation, microbial growth rates and formation of humification, Monod or Monod-type model for the oxygen uptake rates, and empirical model for the carbon dioxide generation)
-
5)
The maturity evaluation of composting, mainly including the changes of physical, chemical, and biological indexes, such as temperature, OM degradation, carbon mineralization, and germination index
This research has significantly promoted the efficacy of conventional thermophilic composting (TC) sewage sludge systems. Table 1 summarizes the effects of the aforementioned research focuses on regarding composting temperature; particularly almost all the improvements in composting efficiency are accompanied by a rise in temperature. This is because composting is driven by various microorganisms whose succession in community composition and population corresponds to temperature evolution.
Consequently, the process of sewage sludge composting can be divided into mesophilic, thermophilic, cooling, and maturing phases according to the temperature and microbial succession [41,42,43,44]. The maximum temperature of the thermophilic phase (55–60 °C) is consistent with the optimum growing temperature of thermophiles (45–60 °C) [10, 45, 46], in which the survived temperature of thermophiles is approximately equal to the upper temperature of composting system because of their thermostability, which is determined by their special protein [47, 48] and DNA structures [49]. Moreover, the thermophilic phase is the highest efficiency stage [46, 50, 51], as thermophiles have a high efficiency in degrading various pollutants, such as the long-chain alkane, benzopyrene, phenanthrene, azo dyestuffs, benzothiophene, petrol, etc. [52,53,54,55. Therefore, the interaction of temperature and microorganism activity has attracted the most composting research attention [16, 24, 26, 56]. A schematic illustration of the relationship between temperature and microbial communities is shown in Fig. 2. Notably, most of the microorganisms are deactivated when a composting system enters the hyperthermophilic stage, which has temperatures greater than 65 °C, with the exception of the distinctive hyperthermophilic microbial community in special HTC systems [16, 26, 29].
Effect of Temperature on Sewage Sludge Composting
Temperature is a critical factor in most chemical, physical, and biological processes. In the composting process of sewage sludge, a higher temperature has positive effects on water evaporation, deactivating pathogenic microorganisms, and degrading OM. However, if temperature is too high, most of microorganisms are destroyed, stopping the composting process. Therefore, the roles of temperature in the composting of sewage sludge should be further examined regarding its interaction with various factors.
Moisture Content and Dewatering Performance
Moisture removal determines the dewatering performance, which is important for reducing the sewage sludge mass. However, it is difficult to remove the capillary water, adhesive water, and internal water by mechanical force. Thus, more than 30% of the bound water cannot be removed effectively [57]. It was demonstrated that the key to achieving sludge dewatering is to destroy the structure of the flocculants in order to release the bound water [58]. Moreover, moisture removal is strongly dependent on temperature. The succession of microbial communities is continuous with rising temperature during the composting process. In particular, when the temperature exceeds the thermal limit of a microorganism, its cell structure is destroyed, causing cell lysis, and it releases a large number of extracellular polymeric substances (EPS) [59, 60]. EPS are mainly involved in microbial aggregation matrix formation, bacterial adhesion to solids, and microbial flocculation properties [61], which play key roles in the physicochemical and biological properties of sludge [62,63,64]. EPS mainly include the loose bound EPS (LB-EPS) and tightly bound EPS (TB-EPS), which are related to the sludge dewaterability. To date, the roles of EPS in dewatering sewage sludge can be divided into four different mechanisms, including (1) EPS has a high viscosity due to the amounts of polysaccharide and proteins that attach to the sludge surface, lowering the dewatering performance [65]; (2) sludge with a high EPS content has a strong shear resistance that is not easily broken, leading to a better filtration performance [66]; (3) an EPS content of 400–500 mg/L is most conducive to sludge dewatering whereas higher EPS concentrations diminish sludge dewaterability [63]; and (4) LB-EPS have a slight effect on the sludge dewatering, but excessive TB-EPS with a large amount of water can weaken the cell-to-cell binding and destroy the tight structure, resulting in a worse dewatering performance [64]. Therefore, the key to achieving extensive sludge dewatering is to destroy the moisture holding capacity of EPS. Moreover, it has been shown that higher temperature can destroy the links between EPS and water, causing the interstitial or combined water between sludge particles to be removed, thereby releasing the intracellularly bound water for either liquid separation or evaporation [67, 68]. However, a moisture content of 40–60% is necessary for composting. When the moisture content is lower than 40%, the microbial metabolic activity is inhibited as a certain moisture content is necessary for microorganisms proliferation and OM degradation [10]. In particular, for the HTC system, higher temperatures can further promote the reduction of sewage sludge mass, and the moisture content of the compost end product can be 38.8% [26].
Microbial Activity and Organic Matter Degradation
Microbial activity is a good indicator of the biotransformation and mineralization of organic waste because the enzyme catalytic reaction of microorganisms is an essential process in composting [69]. The effects between microbial activity and temperature are dynamic, wherein higher microbial activity can accelerate OM decomposition, thereby raising the temperature with metabolic heat. Meanwhile, the continually changing temperature may cause a certain succession of microbial communities, and various organic substrates can be decomposed and further humified by microbes in different phases. During the bio-oxidative process, OM is first adsorbed on the surface of enzymes, followed by a biocatalytic degradation reaction. According to the Michaelis–Menten mechanism, for the steady-state sewage sludge composting system, if excessive OM is provided, the maximum reaction rate can be derived:
where Vmax is the maximum degradation rate of OM, S is the OM, and \({\text{K}}_{\text{m}}\) is the Michaelis constant, which is a characteristic constant of enzyme in the steady-state sewage sludge composting system. Considering the redox reaction of enzymes, the Km increases gradually as a result of competitive inhibition when excessive OM is provided. As various substrates compete for the same enzyme binding sites, the Vmax is not affected. Therefore, the availability of sewage sludge is mainly affected by the content of biodegradable OM, in which the main restrictive degradation step is the oxidation of dissolved matrix [70].
The temperature dependence of biodegradable volatile solids (BVS) reaction rates in different composting systems follows the Arrhenius equation, in which the degradation of organic solids waste can be quantitatively predicted using a first-order reaction model [69]. According to typical Arrhenius plot of ln(k) versus 1/T, to determine the activation energy, the reaction rate constants and percentage of BVS degradation can be calculated as follows:
where K is the reaction rate constant, T is the reaction absolute temperature (K), \(\Delta\) BVSn is the amount of BVS degraded (kg), BVS0 denotes the amount of initial BVS (kg), and t is the degradation time. Therefore, the percentage of BVS degradation at different temperatures can be determined. As shown in Fig. 3, increasing the temperature accelerates the degradation process and improves the percentage of BVS degradation when the temperature is suitable for microorganisms [71].
Furthermore, the OM solubility and degradation pathway are dependent on temperature [72]. In particular, most OM fractions (except those that are gaseous) increase with increasing temperature, which improves its biodegradability and thus accelerates the metabolism of microorganisms and promotes the decomposition of metabolic or intermediate products [73,74,75]. Temperature also plays a vital role in the OM degradation pathway by affecting dissolution/hydrolysis, diffusion, active transport, and intracellular respiration during the compost process. Further, it has been confirmed that increasing temperature enhances OM degradation [76]. The succession laws of microbial communities also reveal the domination effect of temperature in the composting process [43]. It is generally agreed that when the temperature enters the thermophilic phase (temperatures above 45 °C) [39, 43, 77], most of the OM is degraded because of the interaction between higher temperature and thermophiles [11]. In the process, water-soluble OM is decomposed first, followed by the decomposition of refractory organics (such as cellulose, hemicellulose, and lignin) [78]. In particular, the removal of pollutants that are toxic to humans, such as antibiotic resistance genes (ARGs), mobile genetic elements (MGEs), and heavy metals, is significantly affected by temperature. Moreover, thermophilic conditions realize rapid antibiotic removal, including tetracyclines and chlortetracyclines [79, 80]. Further, the HTC system was found to be efficient in removing ARGs, MGEs, and heavy metals [81, 82]. Note that the microbial community composition plays a crucial role in removing such human-toxic pollutants [81].
Oxygen Transfer
In a sewage sludge composting system, microbial enzyme activity strongly depends on the oxygen content because the level of dissolved oxygen (DO) affects the microbial metabolic pathways, resulting in the deviation of target products [83]. A stabilized DO concentration can avoid not only metabolic abnormalities caused by insufficient oxygen supply but also the excessive energy consumption caused by oxygen supply. In general, an increasing temperature has a negative effect on the transfer of oxygen to water in gas–liquid system. However, the existence of solid particles, hydrocarbons, and some vegetable oils greatly increases the oxygen diffusion rate by increasing the transfer coefficient and effective surface area in the complex composting system [84]. Also, Fick’s law has revealed the effect of oxygen transfer on aerobic reaction, emphasizing the oxygen concentration and oxygen consumption rate [85]. However, both the temperature and viscosity of sewage sludge affect the mass transfer of oxygen in the complex aerobic composting systems. Therefore, Fick’s first law and Stokes–Einstein equation were combined to correlate temperature and oxygen diffusion, generating the diffusion flux \(\mathrm{J}\) as follows:
where \({N}_{\mathrm{A}}\) is the Avogadro’s number, \(R\) is the gas constant, \(\eta\) denotes the liquid viscosity coefficient, \(r\) represents the radius of oxygen, \(T\) is the temperature of oxygen transfer, and \(\frac{\mathrm{dC}}{\mathrm{dX}}\) is the concentration gradient. Thus, in a steady-state sewage sludge composting system, a positive relation was found between diffusion flux and the rising temperature when the excessive oxygen is provided.
Succession of Microbial Communities
The composting process is a complex, and involves several dynamic interactions, including the biological, chemical, and physical mechanisms, and the microbial communities succession laws that can reflect changes in temperature [38, 42, 44]. During this bioprocess, the microbial communities mainly comprise bacteria and fungi [86, 87]. The growth situation of microorganisms can be greatly affected by rising temperatures, as summarized in Table 2. Different microorganisms dominate different temperature ranges, wherein their continuous metabolism and rising temperature stabilize the community structures and microbial activity by eliminating the competition of other bacteria. In the mesophilic phase, most microorganisms are mesophilic degrading bacteria and fungi, such as Bacillus licheniformis and Thermoactinomyces, which can decompose the hydrolyzable substrate quickly, and the resultant metabolic heat can further increase temperature. In the thermophilic phase, Bacillus become the dominant bacteria, which can hydrolyze complex OM (such as proteins), and rising temperature can easily eliminate the potential pathogenic microorganisms by the heat generated in this stage [88]. Fungal populations play an intricate role in the early stages of composting. However, some fungi can also tolerate high temperatures. For instance, Aspergillus, Corynascus, Trichoderma, Penicillium, Phanerochaete, and Pseudallescheria were found in the thermophilic composting stage [89]. In the cooling phase, the exhaustion of easily degradable substrates leads to a decrease of heat production and thus a lower temperature. Meanwhile, in the maturing phase, the mesophiles (e.g., actinomycetes, bacteria, and fungi) revive and continue growing. Specifically, in this stage, the fungal community experiences a stronger ability to utilize amines, amino acids, and carbohydrates [90], while some nondegradable compounds (such as lignin-humus complexes) form [35, 39, 44, 75]. The results showed that temperature is crucial to changing the composition of both bacterial and fungal communities [35], and that changes in their community structure were dynamic and parallel [91]. Moreover, for the conventional sludge composting, the thermophilic phase is considered to be the most suitable stage as it has an abundance of heterogenic members belonging to the genus Bacillus, because it can decompose more extensive organic substances because it has a higher activity and metabolic rate, as compared with others [16]. Though the fungal species richness is relatively low during the composting process, maintaining a favorable fungal composition is vital for efficient and successful composting because the thermophilic fungal genus could potentially degrade carboxylic acids and polymers [90]. To date, several moderate functional thermophiles have been found to improve composting efficiency (as listed in Table 3). However, when temperature was greater than 65 °C, a decrease in bacterial abundance was observed because the high temperature might deactivate fungi, actinomycetes, and most of the bacteria that are essential in degradation during the thermophilic stages [16, 29]. Particularly for the special HTC system, the metabolized heat of special microbial communities gradually increases the temperature, revealing a distinctive microbial community in the hyperthermophilic phase. The results of high-throughput sequencing of microbial communities in the HTC system with a maximum temperature of 93.4 °C revealed that bacterial abundance decreased greatly, and Thermaceae (35.5–41.7%) became the predominant family species under hyperthermophilic conditions [22, 26]. However, as HTC systems are still not common because of their unique start-up inoculants from the volcanic region in Kagoshima, only a few studies have been published regarding their special microbial communities [26, 30].
Nitrogen Loss
Nitrogen emissions (N2O and NH3) from composting are also of concern as they contribute not only to greenhouse gas emissions but also to nutrient loss and lower nutrient quality of final compost products [103]. The volatilization of NH3 during chemical reactions, the emission of N2O from microbial mediated denitrification processes, and draining by leaching are the main causes of nutrient loss [104, 105]. Notably, NH3 volatilization consists of 40–80% of the total nitrogen loss during composting [106]. Therefore, decreasing NH3 volatilization may be an effective way to control nitrogen loss during composting. Regarding conventional TC processes, many studies have demonstrated that high temperatures could affect nitrogen metabolic processes, including nitrification and denitrification [107,108,109], and that higher temperatures could cause a higher emission rate of NH3 by enhancing the solubilization of non-dissolved nitrogen and evaporation of NH4+-N as NH3 gas. For example, the emissions of nitrogen as NH3 at 60 and 70 °C were 14.7 and 15.6%, respectively, which is much higher than that at 50 °C (9.0%) [14, 104]. Nitrogen emissions (e.g., NH3) are mainly derived from an incomplete OM humification process, especially the proteins. However, rising temperatures can accelerate the humification process, and high-molecular-weight recalcitrant humic substances (HSs), such as fulvic acids, humic acids, and humins, are major reservoirs of recalcitrant nitrogen in the compost and are mainly formed during the humification process [74, 75]. Thus, it may be ideal to reduce nitrogen loss by raising the composting temperature in order to accelerate the humification process and reduce the substrate for ammonification reactions. Recently, some studies have shown that the HTC system can accelerate the formation of HSs and contribute to the reduced nitrogen loss by decreasing NH3 emissions, ammonification enzyme activities, and the ammonifier relative abundance [22, 24]. Moreover, Peng et al. [110] revealed that a high temperature was key for lowering N2O emissions in an HTC system, mitigating approximately 90% of N2O emissions compared with that of a conventional TC system. This decrease was mainly due to the inhibition of the abundance of the bacterial amoA and norB genes, which decrease the nitrification rate and N2O formation, respectively [110]. Therefore, the special hyperthermophilic microbial communities play an important role in reducing nitrogen loss in sludge composting.
Role of Hyperthermophiles in the Hyperthermophilic Composting System
As the temperature of a HTC system is 20–30 °C higher than that of the conventional TC process, it significantly enhances the compost maturity and shortens the composting period. HTC systems can accelerate the formation of humic acid at the molecular level and improve the removal of ARGs and MGEs [24, 54, 109]. The enhanced humification process may increase the recalcitrant nitrogen reservoir, thereby decreasing the substrate content for the ammonification reactions, leading to 40.9% reduction of nitrogen loss in the HTC system [22]. Furthermore, OM loss in the HTC system in 24 d can reach 66.8%, which is higher than that of a TC system in 48 d (63.8%) [26]. These results are mainly because of the HTC system’s special hyperthermophiles, which can drive the process under hyperthermophilic condition. However, the proper hyperthermophiles are difficult to be directly isolated from the sludge composting because of their special growth environment. To date, many moderate functional thermophiles have been identified (Table 2), but of the hyperthermophiles with growth temperature above 80 °C, only Calditerricola satsumensis, Calditerricola yamamurae, and Thermaerobacter were isolated from the volcanic region in Kagoshima by Oshima’s group [26, 31, 38]. Note that Thermaerobacter is closely related to Thermaceae [26]. Therefore, the critical issue in the HTC system is the lack of suitable hyperthermophiles for the continuous degradation of OM. Thus, the other hyperthermophiles with a good performance in hyperthermia condition may have applicability in the HTC system. While more than 90 hyperthermophiles have been isolated from different environment conditions [112], there are no relevant researches regarding the proper hyperthermophiles to employ in an HTC system. Most microorganisms are inhibited when the temperature is above 65 °C as a result of thermal denaturation. However, hyperthermophiles have optimum growth temperature greater than 80 °C, and the Pyrodictium occultum strain can even survive in 121 °C for 1 h [100, 102, 113, 114]. Most hyperthermophiles belong to the archaea domain, while only a few exceptions (such as Aquificales and Thermotogales) belong to bacteria [115]. Hyperthermophiles have attracted significant attention because of their extreme thermostability, which can be explained using evolutionary theory [116, 117] and their special molecular structure [118]. Because of the extreme growth environment, the anaerobic is the main metabolic mode for most hyperthermophiles [114, 117, 119], wherein oxygen can be severely toxic to anaerobic hyperthermophiles at their growth temperature [101]. For the aerobic organotrophic metabolism mode, the main metabolic mechanism is the modified Embden-Meyerhof-Parnas pathway, in which the carbohydrates (such as sugars) can be completely oxidized to CO2 through the citric acid cycle [116]. Research regarding hyperthermophiles mainly focused on basic biology fields, including the growth environment, cell characteristics, proteins, thermostable hydrogenases, and genetic systems [115, 120]. Industrial applications of hyperthermophiles primarily involve detergent production, sugar chemistry, oil chemistry, food production, cellulose degradation and ethanol production, paper pulp bleaching, and molecular biology [118, 120]. Compared with other microorganisms, hyperthermophiles have numerous application advantages, including reduced costs of cooling large-scale thermophilic fermentations and less contamination in thermophilic conditions [120]. These advantages have stimulated efforts to explore their potential applications in thermostable protein nanostructures, robust biosensor devices, and hyperthermophile cell engineering [115]. However, their applications in biosolids recycling are limited because of their slow-evolving features and special growth conditions [116]. The proper strains for aerobic, organotrophic, and hyperthermophilic conditions may have potential application in HTC system. According to the characterizations of the Calditerricola satsumensis strain, several proper strains with the similar properties have been summarized, such as Pyrobaculum aerophilum, Aeropyrum camini, and Aeropyrum pemix, as listed in Table 4.
Techno-economic Analysis of Hyperthermophilic Composting System
The prominent advantages of an HTC system’s techno-economic costs were evaluated based on the currently available theoretical and practical research. To evaluate the techno-economic cost, the technological process of sewage sludge composting is shown in Fig. 4. Various technological characteristics including sludge transportation, composting additives, energy consumption, land-use efficiency, and end-product quality were considered for this analysis. Consequently, a comparison between HTC and TC systems was conducted, as summarized in Table 5. First, the HTC system significantly shortens the composting period, thereby lowering the energy consumption and raising the land-use efficiency. In addition, an HTC system can start with a C/N ratio lower than 10 [26], while a conventional TC system requires a ratio between 25 and 30 [26, 121, 122], which means the HTC system has a lower composting additive cost. Moreover, an HTC system only requires a space of 45 m2 (t wet sludge)−1, which is 40 m2 less than that required to treat the same volume of sludge using a conventional TC system [26]. Moreover, the HTC system can greatly decrease the sludge mass (41.2%), leading to lower end-product transportation costs. In addition, the agricultural value of a compost increases when a high nutrient content was obtained which requires a high degree of OM humification and reduction of N loss during the process [123]. Obviously, the HTC system’s lower N loss and higher OM degradation rates could lead to higher end-product quality and fewer odor emissions [22, 110]. At present, the immediate conversion of biowastes into bioenergy is the high cost of processing, rather than the cost or availability of biomass feedstock. Thus, to improve the utilization rate of bioenergy that can be produced sustainably by using biowastes has been a promising challenge [124]. Significantly, except the bioenergy potential of the compost production, the HTC system also has a huge advantage in heat recovery because of the extreme high temperature. For conventional TC system, the amount of heat recovery can be 1.2 to 2.6 × 105 kJ, about 12–24% of total heat production [125]. Especially, the direct heat recovery makes more sense for HTC system, because its temperature is 20–30 °C higher than that of the conventional TC process which means more heat production. Based on these findings, an HTC system may be employed as a novel technology for future sewage sludge treatment project.
Prospects of the Hyperthermophilic Composting System
The HTC system was first developed in 2008, but it is not commonly used because of its special microbial inoculants, which contain large numbers of hyperthermophilic bacteria. Therefore, the characterization of microbial communities associated with HTC systems remains unclear. In total, only two studies have evaluated some characteristics of its distinctive microbial communities [26, 30], in which the bacteria Calditerricola satsumensis, Calditerricola yamamurae, and Thermaerobacter were identified as the predominant families in the hyperthermophilic phase of a sewage sludge HTC system. Though several studies have evaluated HTC systems, all of them were based on these special inoculants and only focused on its superior performance. Thus, the change mechanism of the special microbial communities associated with sewage sludge HTC systems also remains unclear. Moreover, a critical issue in the HTC system is the lack of suitable hyperthermophiles for continuous OM degradation. Notably, more than 90 hyperthermophiles have been isolated from different environment conditions, but their bioavailability is seldom involved in the sewage sludge HTC system. Therefore, to obtain suitable hyperthermophiles for the sewage sludge HTC system, different amounts of hyperthermophiles were investigated, and several strains, such as Pyrobaculum aerophilum, Aeropyrum camini, and Aeropyrum pemix, may be suitable for the sludge HTC system, because they share similar features with Calditerricola satsumensis in degrading complex carbohydrates at hyperthermophilic conditions. Therefore, their application feasibility for the HTC system is a useful research topic. In addition, the isolation and culture conditions must be further studied as they remain challenging because of the strict growth environment required by hyperthermophiles.
Conclusions
Higher temperatures have positive effects on the sewage sludge composting process because increased temperatures can accelerate the humification process and shorten the composting cycle. However, most microorganisms degrade in higher temperature ranges, thereby limiting composting temperatures. Specifically, an HTC system, which has a high working temperature of approximately 80–100 °C, has greater techno-economic advantages in the rapid recycling of sewage sludge as compared with that of conventional TC systems. However, HTC systems are not yet widespread because of their special microbial communities. The lack of suitable hyperthermophiles for HTC systems is thus a critical issue restricting their development. Consequently, the application feasibility of other hyperthermophiles for the HTC system should be evaluated in future research.
Data Availability
The datasets generated and/or analyzed during the current study can be found from the corresponding author and the data will be released on reasonable request.
Code Availability
Not applicable
Abbreviations
- OM:
-
Organic matter
- TC:
-
Thermophilic composting
- HTC:
-
Hyperthermophilic composting
- CTC:
-
Continuous thermophilic composting
- RPBA:
-
Recyclable plastic bulking agent
- EPS:
-
Extracellular polymeric substances
- LB-EPS:
-
Loosely bound EPS
- TB-EPS:
-
Tightly bound EPS
- BVS:
-
Biodegradable volatile solids
- DO:
-
Dissolved oxygen
- HSs:
-
Humic substances
- ARGs:
-
Antibiotic resistance genes
- MGEs:
-
Mobile genetic elements
References
Guo J, Fang F, Yan P, Chen Y (2020) Sludge reduction based on microbial metabolism for sustainable wastewater treatment. Bioresour Technol 297:122506. https://doi.org/10.1016/j.biortech.2019.122506
Zhou W, Liu M, Chai Y, Chen Y, Chen M, Wei Y, Min Y (2018) Discussion on establishment of technical standard system of domestic wastewater in villages and towns of China. Water Wastewater Engin 44(9):2–14. https://doi.org/10.13789/j.cnki.wwe1964.2018.0029
Tan XB, Yang LB, Zhang WW, Zhao XC (2020) Lipids production and nutrients recycling by microalgae mixotrophic culture in anaerobic digestate of sludge using wasted organics as carbon source. Bioresour Technol 297:122379. https://doi.org/10.1016/j.biortech.2019.122379
Solmaz A, Işik M (2019) Effect of sludge retention time on biomass production and nutrient removal at an algal membrane photobioreactor. Bioenerg Res 12:197–204. https://doi.org/10.1007/s12155-019-9961-4
Nazia H, Morni N (2020) Co-pelletization of microalgae-sewage sludge blend with sub-bituminous coal as solid fuel feedstock. Bioenerg Res 13:618–629. https://doi.org/10.1007/s12155-019-10061-2
Kubátová P, Hejcman M, Száková J (2016) Effects of sewage sludge application on biomass production and concentrations of Cd, Pb and Zn in shoots of salix and populus clones: Improvement of phytoremediation efficiency in contaminated soils. Bioenerg Res 25(3):1–11. https://doi.org/10.1007/s12155-016-9727-1
Fischer D, Erben G, Dunst G, Glaser B (2018) Dynamics of labile and stable carbon and priming effects during composting of sludge and lop mixtures amended with low and high amounts of biochar. Waste Manage 78:880–893. https://doi.org/10.1016/j.wasman.2018.06.056
Kulikowska D, Sindrewicz S (2018) Effect of barley straw and coniferous bark on humification process during sewage sludge composting. Waste Manage 79:207–213. https://doi.org/10.1016/j.wasman.2018.07.042
Phoungthong K, Zhang H, Shao LM, He PJ (2018) Leaching characteristics and phytotoxic effects of sewage sludge biochar. J Mater Cycles Waste 20(4):2089–2099. https://doi.org/10.1007/s10163-018-0763-0
Meng L, Zhang S, Gong H, Zhang X, Wu C, Li W (2018) Improving sewage sludge composting by addition of spent mushroom substrate and sucrose. Bioresour Technol 253:197–203. https://doi.org/10.1016/j.biortech.2018.01.015
Lian Y, Zhang S, Wen Q, Chen Z, Yao W (2016) Maturity and security assessment of pilot-scale aerobic co-composting of penicillin fermentation dregs (PFDs) with sewage sludge. Bioresour Technol 204:185–191. https://doi.org/10.1016/j.biortech.2016.01.004
Zhang J, Chen G, Sun H, Zhou S, Zou G (2016) Straw biochar hastens organic matter degradation and produces nutrient-rich compost. Bioresour Technol 200:876. https://doi.org/10.1016/j.biortech.2015.11.016
Ramdani N, Hamou A, Lousdad A, Al-Douri Y (2015) Physicochemical characterization of sewage sludge and green waste for agricultural utilization. Environ Technol 36(9–12):1594–1604. https://doi.org/10.1080/09593330.2014.998716
Sierra J, Chopart JL, Guindé L (2016) Optimization of biomass and compost management to sustain soil organic matter in energy cane cropping systems in a tropical polluted soil: a modelling study. Bioenerg Res 9:798–808. https://doi.org/10.1007/s12155-016-9729-z
Boruszko D (2019) Research of effective microorganisms on dairy sewage sludge stabilization. J Ecol Eng 20(3):241–252. https://doi.org/10.12911/22998993/99787
Onwosi CO, Igbokwe VC, Odimba JN, Eke IE, Nwankwoala MO, Iroh IN, Ezeogu LI (2017) Composting technology in waste stabilization: On the methods, challenges and future prospects. J Environ Manage 190:140–157. https://doi.org/10.1016/j.jenvman.2016.12.051
Li Z, Lu H, Ren L, Li H (2013) Experimental and modeling approaches for food waste composting: A review. Chemosphere 93(7):1247–1257. https://doi.org/10.1016/j.chemosphere.2013.06.064
Raut MP, William SPMP, Bhattacharyya JK, Chakrabarti T, Devotta S (2008) Microbial dynamics and enzyme activities during rapid composting of municipal solid waste – A compost maturity analysis perspective. Bioresour Technol 99(14):6512–6519. https://doi.org/10.1016/j.biortech.2007.11.030
Zheng J, Wen QX, Chen ZQ, Zhang SH (2015) Effect of aeration rate on composting of penicillin mycelial dreg. J Environ Sci 37:172–178. https://doi.org/10.1016/j.jes.2015.03.020
Lin XG, Wang YM, Wei SP, Chen RR, Jing ZW (2015) N2O emissions and nitrogen transformation during windrow composting of dairy manure. J Environ Manage 160:121–127. https://doi.org/10.1016/j.jenvman.2015.06.021
Toledo M, Gutiérrez MC, Siles JA, Martín MA (2018) Full-scale composting of sewage sludge and market waste: Stability monitoring and odor dispersion modeling. Environ Res 167:739–750. https://doi.org/10.1016/j.envres.2018.09.001
Cui P, Liao H, Bai Y, Li X, Zhou S (2019) Hyperthermophilic composting reduces nitrogen loss via inhibiting ammonifiers and enhancing nitrogenous humic substance formation. Sci Total Environ 692:98–106. https://doi.org/10.1016/j.scitotenv.2019.07.239
Robledo-Mahón T, Martín MA, Gutiérrez MC, Toledo M, González I, Aranda E, Chica AF, Calvo C (2019) Sewage sludge composting under semi-permeable film at full-scale: Evaluation of odour emissions and relationships between microbiological activities and physico-chemical variables. Environ Res 177:108624. https://doi.org/10.1016/j.envres.2019.108624
Liu X, Hou Y, Li Z, Yu Z, Zhou S (2020) Hyperthermophilic composting of sewage sludge accelerates humic acid formation: elemental and spectroscopic evidence. Waste Manage 103:342–351. https://doi.org/10.1016/j.wasman.2019.12.053
Yamada Y, Kawase Y (2006) Aerobic composting of waste activated sludge: Kinetic analysis for microbiological reaction and oxygen consumption. Waste Manage 26(1):49–61. https://doi.org/10.1016/j.wasman.2005.03.012
Yu Z, Tang J, Liao H, Liu X, Zhou P, Zhi C, Christopher R, Zhou S (2018) The distinctive microbial community improves composting efficiency in a full-scale hyperthermophilic composting plant. Bioresour Technol 265:146–154. https://doi.org/10.1016/j.biortech.2018.06.011
Nguyen TB, Shima K (2019) Composting of sewage sludge with a simple aeration method and its utilization as a soil fertilizer. Environ Manage 63(4):455–465. https://doi.org/10.1007/s00267-017-0963-8
Rich N, Bharti A (2015) Assessment of different types of in-vessel composters and its effect on stabilization of MSW compost. Int Res J Eng Techno (IRJET) 02(03):37–42
Miyatake F, Iwabuchi K (2005) Effect of high compost temperature on enzymatic activity and species diversity of culturable bacteria in cattle manure compost. Bioresour Technol 96(16):1821–1825. https://doi.org/10.1016/j.biortech.2005.01.005
Oshima T, Moriya T (2008) A preliminary analysis of microbial and biochemical properties of high-temperature compost. Ann N Y Acad Sci 1125(1):338–344. https://doi.org/10.1196/annals.1419.012
Moriya T, Hikota T, Yumoto I, Ito T, Terui Y, Yamagishi A, Oshima T (2011) Calditerricola satsumensis gen. nov., sp. nov. and Calditerricola yamamurae sp. nov., extreme thermophiles isolated from a high-temperature compost. Int J Syst Evol Micr 61(3):631–636. https://doi.org/10.1099/ijs.0.018416-0
Trautmann N, Krasny M (1998) Composting in the classroom: Scientific Inquiry for high school students. Kendall/Hunt Publishing Company, pp. 6
Liao H, Lu X, Rensing C, Friman VP, Geisen S, Chen Z, Yu Z, Wei Z, Zhou S, Zhu Y (2017) Hyperthermophilic composting accelerates the removal of antibiotic resistance genes and mobile genetic elements in sewage sludge. Environ Sci Technol 52(1):266–276. https://doi.org/10.1021/acs.est.7b04483
Cheng Y, Inamori R, Ruike K, Inamori Y, Zhang Z (2018) Optimum dosage of hyper-thermophilic aerobic compost (HTAC) produced from sewage sludge for rice yield. Int J Biol 10(3):27. https://doi.org/10.5539/ijb.v10n3p27
Moreno J (2015) Dynamics of bacterial microbiota during lignocellulosic waste composting: studies upon its structure, functionality and biodiversity. Bioresour Technol 175:406–416. https://doi.org/10.1016/j.biortech.2014.10.123
Zeng GM, Hong LH, Dan LH, Xing ZY, Rong QJ, Man Y, Hong YY, Jia CZ, Ren YW, Xiao LL (2009) Effect of inoculating white-rot fungus during different phases on the compost maturity of agricultural wastes. Process Biochem 44(4):396–400. https://doi.org/10.1016/j.procbio.2008.11.012
Long YY, Fang Y, Zhang C, Du Y, Shentu J, Shen DS (2015) Degradation of polychlorinated biphenyls by sequential anaerobic–aerobic composting. Water Air Soil Poll 226(3):44. https://doi.org/10.1007/s11270-015-2333-6
Xiao Y, Zeng GM, Yang ZH, Ma YH, Huang C, Shi WJ, Xu ZY, Huang J, Fan CZ (2011) Effects of continuous thermophilic composting (CTC) on bacterial community in the active composting process. Microb Ecol 62(3):599–608. https://doi.org/10.1007/s00248-011-9882-z
Kulikowska D (2016) Kinetics of organic matter removal and humification progress during sewage sludge composting. Waste Manage 49:196–203. https://doi.org/10.1016/j.wasman.2016.01.005
Bialobrzewski I, Miks-Krajnik M, Dach J, Markowski M, Czekala W, Gluchowska K (2015) Model of the sewage sludge-straw composting process integrating different heat generation capacities of mesophilic and thermophilic microorganisms. Waste Manage 43:72–83. https://doi.org/10.1016/j.wasman.2015.05.036
Meng L, Li W, Zhang S, Wu C, Lv L (2016) Feasibility of co-composting of sewage sludge, spent mushroom substrate and wheat straw. Bioresour Technol 226:39–45. https://doi.org/10.1016/j.biortech.2016.11.054
Bialobrzewski I, Miks-Krajnik M, Dach J, Markowski M, Czekala W, Gluchowska K (2015) Model of the sewage sludge-straw composting process integrating different heat generation capacities of mesophilic and thermophilic microorganisms. Waste Manage 43:72–83. https://doi.org/10.1016/j.wasman.2015.05.036
Wang C, Dong D, Strong PJ, Zhu W, Ma Z, Qin Y, Wu W (2017) Microbial phylogeny determines transcriptional response of resistome to dynamic composting processes. Microbiome 5(1):103. https://doi.org/10.1186/s40168-017-0324-0
Ishii K, Fukui M, Takii S (2000) Microbial succession during a composting process as evaluated by denaturing gradient gel electrophoresis analysis. J Appl Microbiol 89(5):768–777. https://doi.org/10.1046/j.1365-2672.2000.01177.x
Fashola M, Ngole-Jeme V, Babalola O (2015) Diversity of acidophilic bacteria and archaea and their roles in bioremediation of acid mine drainage. Brit Microbiol Res J 8(3):443–456. https://doi.org/10.9734/BMRJ/2015/14365
Hashimoto K, Doi T, Okuda T, Nishijima W, Nishimura K (2015) Function of wood chips for composting of sewage sludge by thermophilic and aerobic digestion. J Residuals Sci Technol 12(2):53–59. https://doi.org/10.12783/issn.1544-8053/12/2/3
Lieph R, Veloso FA, Holmes DS (2006) Thermophiles like hot T. Trends Microbiol 14(10):423–426. https://doi.org/10.1016/j.tim.2006.08.004
Das R, Gerstein M (2000) The stability of thermophilic proteins: a study based on comprehensive genome comparison. Funct Integr Genomics 1(1):76–88. https://doi.org/10.1007/s101420000003
Redman RS, Litvintseva A, Sheehan KB, Henson JM, Rodriguez R (1999) Fungi from geothermal soils in Yellowstone National Park. Appl Environ Microbiol 65(12):5193. https://doi.org/10.1089/oli.1.1999.9.549
Qian X, Sun W, Gu J, Wang XJ, Zhang YJ, Duan ML, Li HC, Zhang RR (2016) Reducing antibiotic resistance genes, integrons, and pathogens in dairy manure by continuous thermophilic composting. Bioresour Technol 220:425–432. https://doi.org/10.1016/j.biortech.2016.08.101
Kinet RDJ, Hiligsmann S, Thonart P, Delhalle L, Taminiau B, Daube G, Delvigne F (2015) Thermophilic and cellulolytic consortium isolated from composting plants improves anaerobic digestion of cellulosic biomass: Toward a microbial resource management approach. Bioresour Technol 189:138–144. https://doi.org/10.1016/j.biortech.2015.04.010
Bhatia S, Sharma DK (2012) Thermophilic desulfurization of dibenzothiophene and different petroleum oils by Klebsiella sp. 13T. Environ Sci Poll Res 19(8):3491–3497. https://doi.org/10.1007/s11356-012-0884-2
Zhao Z, Selvam A, Wong WC (2011) Synergistic effect of thermophilic temperature and biosurfactant produced by Acinetobacter calcoaceticus BU03 on the biodegradation of phenanthrene in bioslurry system. J Hazard Mater 190 (1–3):345–350. https://doi.org/10.1016/j.jhazmat.2011.03.042
Zhao Z, Wong JW-C (2010) Rapid biodegradation of benzo[a]pyrene by Bacillus subtilis BUM under thermophilic condition. Environ Eng Sci 27(11):939–945. https://doi.org/10.1089/ees.2010.0101
Deive FJ, Domínguez A, Barrio T, Moscoso F, Morán P, Longo MA, Sanromán MA (2010) Decolorization of dye Reactive Black 5 by newly isolated thermophilic microorganisms from geothermal sites in Galicia (Spain). J Hazard Mater 182 (1–3):735–742. https://doi.org/10.1016/j.jhazmat.2010.06.096
Yuan J, Chadwick D, Zhang D, Li G, Chen S, Luo W, Du L, He S, Peng S (2016) Effects of aeration rate on maturity and gaseous emissions during sewage sludge composting. Waste Manage 56:403–410. https://doi.org/10.1016/j.wasman.2016.07.017
Xu Z, Zhang X, Zhou J, Xiang L (2018) Technical review of dewatering process for excess sludge of municipal sewage plant. Water Purif Technol 37(2):38–44. https://doi.org/10.15890/j.cnki.jsjs.2018.02.007
Li YY, Jin YY, Li H, Nie YF (2010) Effects and kinetics model of combined alkaline and thermal sludge treatment. China Environ Sci 30(9):1230–1234. https://doi.org/10.3724/SP.J.1088.2010.00432
Yan M, Prabowo BY, He L, Fang ZM, Xu ZG, Hu YJ (2017) Effect of inorganic coagulant addition under hydrothermal treatment on the dewatering performance of excess sludge with various dewatering conditions. J Mater Cycles Waste Manage 19(3):1279–1287. https://doi.org/10.1007/s10163-016-0522-z
Yu J, Guo M, Xu X, Guan B (2014) The role of temperature and CaCl2 in activated sludge dewatering under hydrothermal treatment. Water Res 50:10–17. https://doi.org/10.1016/j.watres.2013.11.034
Yan L, Fang HHP (2003) Influences of extracellular polymeric substances (EPS) on flocculation, settling and dewatering of activated sludge. Crit Rev Environ Sci Technol 33(3):237–273. https://doi.org/10.1080/10643380390814479
Ma W, Zhao L, Liu H, Liu Q, Ma J (2017) Improvement of sludge dewaterability with modified cinder via affecting EPS. Front Env Sci Eng 11(6):19. https://doi.org/10.1007/s11783-017-0967-x
Xin F, Deng J, Lei H, Tao B, Fan Q, Li Z (2009) Dewaterability of waste activated sludge with ultrasound conditioning. Bioresour Technol 100(3):1074–1081. https://doi.org/10.1016/j.biortech.2008.07.055
Li XY, Yang SF (2007) Influence of loosely bound extracellular polymeric substances (EPS) on the flocculation, sedimentation and dewaterability of activated sludge. Water Res 41(5):1022–1030. https://doi.org/10.1016/j.watres.2006.06.037
Geyik AG, Cecen F (2014) Production of protein- and carbohydrate-EPS in activated sludge reactors operated at different carbon to nitrogen ratios, J. Chem. Technol. Biotechnol 91(2): 522–531. https://doi.org/10.1002/jctb.4608
Mikkelsen LH, Keiding K (2002) Physico-chemical characteristics of full scale sewage sludges with implications to dewatering. Water Res 36(10):2451–2462. https://doi.org/10.1016/s0043-1354(01)00477-8
Wang L, Li A (2015) Hydrothermal treatment coupled with mechanical expression at increased temperature for excess sludge dewatering: The dewatering performance and the characteristics of products. Water Res 68:291–303. https://doi.org/10.1016/j.watres.2014.10.016
Wang W, Liu W, Wang L (2015) Characteristics research on sewage sludge under thin-layered hot-press treatment. Desalin Water Treat 57(44):1–7. https://doi.org/10.1080/19443994.2015.1110538
Bohacz J (2018) Microbial strategies and biochemical activity during lignocellulosic waste composting in relation to the occurring biothermal phases. J Environ Manage 206:1052–1062. https://doi.org/10.1016/j.jenvman.2017.11.077
Komilis DP (2006) A kinetic analysis of solid waste composting at optimal conditions. Waste Manag 26(1):82-91. https://doi.org/10.1016/j.wasman.2004.12.021
Bari QH, Koenig A, Tao G (2000) Kinetic analysis of forced aeration composting- I. Reaction rates and temperature. Waste Manage Res 18(4):303–312. https://doi.org/10.1177/0734242X0001800402
He F, Yu R, Zhang Y, Zhu J, Sun P (2015) Effects of ash forming temperature on water-soluble fraction of biomass ash and it’s elements. T Chinese Soc Agric Engin (TCSAE) 31(8):227–232. https://doi.org/10.3969/j.issn.1002-6819.2015.08.033
Reinscheid UM, Bauer MP, Müller R (1996) Biotransformation of halophenols by a thermophilic Bacillus sp. Biodegradation 7(6):455–461. https://doi.org/10.1007/BF00115292
Gao X, Tan W, Zhao Y, Wu J, Sun Q, Qi H, Xie X, Wei Z (2019) Diversity in the mechanisms of humin formation during composting with different materials. Environ Sci Technol 53(7):3653–3662. https://doi.org/10.1021/acs.est.8b06401
Li S, Li D, Li J, Li G, Zhang B (2017) Evaluation of humic substances during co-composting of sewage sludge and corn stalk under different aeration rates. Bioresour Technol 245:1299–1302. https://doi.org/10.1016/j.biortech.2017.08.177
Cai Y, He Y, He K, Gao H, Ren M, Qu G (2019) Degradation mechanism of lignocellulose in dairy cattle manure with the addition of calcium oxide and superphosphate. Environ Sci Poll Res 26(32):33683–33693. https://doi.org/10.1007/s11356-019-06444-9
Wu X, Wei Y, Zheng J, Zhao X, Zhong W (2011) The behavior of tetracyclines and their degradation products during swine manure composting. Bioresour Technol 102(10):5924–5931. https://doi.org/10.1016/j.biortech.2011.03.007
Lin H, Zhang J, Chen H, Wang J, Sun W, Zhang X, Yang Y, Wang Q, Ma J (2017) Effect of temperature on sulfonamide antibiotics degradation, and on antibiotic resistance determinants and hosts in animal manures. Sci Total Environ 607–608:725–732. https://doi.org/10.1016/j.scitotenv.2017.07.057
Liao H, Zhao Q, Cui P, Chen Z, Yu Z, Geisen S, Friman V-P, Zhou S (2019) Efficient reduction of antibiotic residues and associated resistance genes in tylosin antibiotic fermentation waste using hyperthermophilic composting. Environ Int 133:105203. https://doi.org/10.1016/j.envint.2019.105203
Tang J, Zhuang L, Yu Z, Liu X, Wang Y, Wen P, Zhou S (2019) Insight into complexation of Cu(II) to hyperthermophilic compost-derived humic acids by EEM-PARAFAC combined with heterospectral two dimensional correlation analyses. Sci Total Environ 656:29–38. https://doi.org/10.1016/j.scitotenv.2018.11.357
Bäumchen C, Arnd K, Bernward H, Juri S, Bernd M, Carsten D, Ghassem A, Jochen B (2007) Effect of elevated dissolved carbon dioxide concentrations on growth of Corynebacterium glutamicum on d-glucose and l-lactate. J Biotechnol 128(4):868–874. https://doi.org/10.1016/j.jbiotec.2007.01.001
Sauid SM, Murthy VVPS (2010) Effect of palm oil on oxygen transfer in a stirred tank bioreactor. J Appl Sci 10 (21):2745–2747. https://doi.org/10.3923/jas.2010.2745.2747
Zhang J, Zhao Y (2012) Kinetic analysis of sludge composting and engineering inspiration. China Water Wastewater 28 (4):6–10. https://doi.org/10.3969/j.issn.1000-4602.2012.04.002
Awasthi MK, Li J, Kumar S, Awasthi SK, Wang Q, Chen H, Wang M, Ren X, Zhang Z (2017) Effects of biochar amendment on bacterial and fungal diversity for co-composting of gelatin industry sludge mixed with organic fraction of municipal solid waste. Bioresour Technol 246:214–223. https://doi.org/10.1016/j.biortech.2017.07.068
Tortosa G, Castellano-Hinojosa A, Correa-Galeote D, Bedmar EJ (2017) Evolution of bacterial diversity during two-phase olive mill waste (“alperujo”) composting by 16S rRNA gene pyrosequencing. Bioresour Technol 224:101–111. https://doi.org/10.1016/j.biortech.2016.11.098
Fang Y, Jia X, Chen L, Lin C, Chen J (2019) Effect of thermotolerant bacterial inoculation on the microbial community during sludge composting. Can J Microbiol 65(2). https://doi.org/10.1139/cjm-2019-010
Sebők F, Dobolyi C, Bobvos J, Szoboszlay S, Kriszt B, Magyar D (2016) Thermophilic fungi in air samples in surroundings of compost piles of municipal, agricultural and horticultural origin. Aerobiologia 32(2):255–263. https://doi.org/10.1007/s10453-015-9396-0
Wang K, Yin X, Mao H, Chu C, Tian Y (2018) Changes in structure and function of fungal community in cow manure composting. Bioresour Technol 255:123–130. https://doi.org/10.1016/j.biortech.2018.01.064
Hansgate AM, Schloss PD, Hay AG, Walker LP (2005) Molecular characterization of fungal community dynamics in the initial stages of composting. FEMS Microbiol Ecol 51 (2):209–214. https://doi.org/10.1016/j.femsec.2004.08.009
Han Z, Sun D, Wang H, Li R, Bao Z, Qi F (2018) Effects of ambient temperature and aeration frequency on emissions of ammonia and greenhouse gases from a sewage sludge aerobic composting plant. Bioresour Technol 270:457–466. https://doi.org/10.1016/j.biortech.2018.09.048
Koyama M, Nagao N, Syukri F, Rahim AA, Kamarudin MS, Toda T, Mitsuhashi T, Nakasaki K (2018) Effect of temperature on thermophilic composting of aquaculture sludge: NH3 recovery, nitrogen mass balance, and microbial community dynamics. Bioresour Technol 265:207–213. https://doi.org/10.1016/j.biortech.2018.05.109
Vaz-Moreira I, Lopes AR, Falsen E, Schumann P, Nunes OC, Manaia CM (2008) Microbacterium luticocti sp. nov., isolated from sewage sludge compost. nt J Syst Evol Micr 58(7):1700–1704. https://doi.org/10.1099/ijs.0.65494-0
Vaz-Moreira I, Figueira V, Lopes AR, Brandt ED, Manaia CM (2010) Candidimonas nitroreducens gen. nov., sp. nov. and Candidimonas humi sp. nov., isolated from sewage sludge compost. Int J Syst Evol Microbiol 61(Pt 9):2238–2246. https://doi.org/10.1099/ijs.0.021188-0
Vaz-Mireura I, Mobre MF, Ferreira ACS, Schumann P, Nunes OC, Manaia CM (2008) Humibacter albus gen. nov., sp. nov., isolated from sewage sludge compost. Int J Syst Evol Micr 58(Pt 4):1014–1018. https://doi.org/10.1099/ijs.0.65266-0
Rodriguez-Diaz M, Cerrone F, Sanchez-Peinado M, Santacruz-Calvo L, Pozo C, Lopez JG (2014) Massilia umbonata sp. nov., able to accumulate poly-β-hydroxybutyrate, isolated from a sewage sludge compost-soil microcosm. Int J Syst Evol Micr 64(Pt 1):131–137. https://doi.org/10.1099/ijs.0.049874-0
Silóniz M-Id, Balsalobre L, Alba C, María-José V, Peinado JM (2002) Feasibility of copper uptake by the yeast Pichia guilliermondii isolated from sewage sludge. Res Microbiol 153(3):0–180. https://doi.org/10.1016/S0923-2508(02)01303-7
Sakai M, Deguchi D, Hosoda A, Kawauchi T, Ikenaga M (2015) Ammoniibacillus agariperforans gen. nov., sp. nov., a thermophilic, agar-degrading bacterium isolated from compost. Int J Syst Evol Micr 65(Pt 2):570–577. https://doi.org/10.1099/ijs.0.067843-0
Combet-Blanc Y, Ollivier B, Streicher C, Patel BKC, Dwivedi PP, Pot B, Prensier G, Garcia JL (1995) Bacillus thermoamylovorans sp. nov., a moderately thermophilic and amylolytic bacterium. Int J Syst Bacteriol 45(1):9–16. https://doi.org/10.1099/00207713-45-1-9
Shimaya C, Hashimoto T (2011) Isolation and characterization of novel thermophilic nitrifying Bacillus sp. from compost. Soil Sci Plant Nut 57(1):150–156. https://doi.org/10.1080/00380768.2010.548312
Hartman PA, Ralph Wellerson J, Tetrault PA (1955) Bacillus stearothermophilus. Appl Microbiol 3(1):124–129. https://doi.org/10.1016/S0769-2609(86)80099-0
Rees DC, Adams MW (1995) Hyperthermophiles: Taking the heat and loving it. Structure 3 (3):251-254. https://doi.org/10.1016/S0969-2126(01)00155-1
Hartman PA, Ralph Wellerson J, Tetrault PA (1955) Bacillus stearothermophilus. Appl Microbiol 3 (1):124–129. https://doi.org/10.1016/S0769-2609(86)80099-0
Cáceres R, Magrí A, Marfà O (2015) Nitrification of leachates from manure composting under field conditions and their use in horticulture. Waste Manage 44:72–81. https://doi.org/10.1016/j.wasman.2015.07.039
Nakhshiniev B, Perera C, Biddinika MK, Gonzales HB, Sumida H, Yoshikawa K (2014) Reducing ammonia volatilization during composting of organic waste through addition of hydrothermally treated lignocellulose. Int Biodeterior Biodegrad 96:58–62. https://doi.org/10.1016/j.ibiod.2014.08.011
Wang X, Pan S, Zhang Z, Lin X, Zhang Y, Chen S (2017) Effects of the feeding ratio of food waste on fed-batch aerobic composting and its microbial community. Bioresour Technol 224:397–404. https://doi.org/10.1016/j.biortech.2016.11.076
Courtens ENP, Spieck E, Vilchez-Vargas R, Bodé S, Boeckx P, Schouten S, Jauregui R, Pieper DH, Vlaeminck SE, Boon N (2016) A robust nitrifying community in a bioreactor at 50 °C opens up the path for thermophilic nitrogen removal. ISME J 10(9):2293–2303. https://doi.org/10.1038/ismej.2016.8
Xu X, Liu X, Li Y, Ran Y, Liu Y, Zhang Q, Li Z, He Y, Xu J, Di H (2017) High temperatures inhibited the growth of soil bacteria and archaea but not that of fungi and altered nitrous oxide production mechanisms from different nitrogen sources in an acidic soil. Soil Biol Biochem 107:168–179. https://doi.org/10.1016/j.soilbio.2017.01.003
Stetter KO (2013) A brief history of the discovery of hyperthermophilic life. Biochem Soc Trans 41:416-420. https://doi.org/10.1042/BST20120284
Huang YLD, Shah GM, Chen W, Wang W, Xu Y, Huang H (2019) Hyperthermophilic pretreatment composting significantly accelerates humic substances formation by regulating precursors production and microbial communities. Waste Manage 92:89–96. https://doi.org/10.1016/j.wasman.2019.05.021
Cui P, Chen Z, Zhao Q, Yu Z, Yi Z, Liao H, Zhou S (2018) Hyperthermophilic composting significantly decreases N2O emissions by regulating N2O-related functional genes. Bioresour Technol 272. https://doi.org/10.1016/j.biortech.2018.10.044
Volkl P, Huber R, Drobner E, Rachel R, Burggraf S, Trincone A, Stetter KO (1993) Pyrobaculum aerophilum sp. nov., a novel nitrate-reducing hyperthermophilic archaeum. Appl Environ Microbiol 59(9):2918. https://doi.org/10.1002/bit.260420616
Huber R, Kurr M, Jannasch HW, Stetter KO (1989) A novel group of abyssal methanogenic archaebacteria (Methanopyrus) growing at 110 °C. Nature 342(6251):833–834. https://doi.org/10.1038/342833a0
Hartman PA, Ralph Wellerson J, Tetrault PA (1955) Bacillus stearothermophilus. Appl Microbiol 3(1):124–129. https://doi.org/10.1016/S0769-2609(86)80099-0
Bustard MT, Burgess JG, Meeyoo V, Wright PC (2000) Novel opportunities for marine hyperthermophiles in emerging biotechnology and engineering industries. J Chem Technol Biot 75(12):1095–1109. https://doi.org/10.1002/1097-4660(200012)75:123.0.CO;2-3
Sakuraba H, Goda S, Ohshima T (2010) Unique sugar metabolism and novel enzymes of hyperthermophilic archaea. Chem Rec 3(5):281–287. https://doi.org/10.1002/tcr.10066
Segerer AH, Trincone A, Gahrtz M (1991) Stygiolobus azoricus gen. nov. sp. nov. represents a novel genus of anaerobic, extremely thermoacidophilic archaebacteria of the order sulfolobales. Int J Syst Bacteriol 41(4):495–501. https://doi.org/10.1099/00207713-41-4-495
Nakagawa S, Takai K, Horikoshi K, Sako Y (2004) Aeropyrum camini sp. nov., a strictly aerobic, hyperthermophilic archaeon from a deep-sea hydrothermal vent chimney. Int J Syst Evol Micr 54(Pt 2):329–335. https://doi.org/10.1099/ijs.0.02826-0
Vieille C, Zeikus GJ (2001) Hyperthermophilic enzymes: sources, uses, and molecular mechanisms for thermostability. Microbiol Mol Biol Rev 65(1):1–43. https://doi.org/10.1128/MMBR.65.1.1-43.2001
Rees DC, Adams MW (1995) Hyperthermophiles: Taking the heat and loving it. Structure 3(3):251–254. https://doi.org/10.1016/S0969-2126(01)00155-1
Atomi H, Sato T, Kanai T (2011) Application of hyperthermophiles and their enzymes. Curr Opin Biotechnol 22(5):618–626. https://doi.org/10.1016/j.copbio.2011.06.010
Wu J, Zhao Y, Qi H, Zhao X, Yang T, Du Y, Zhang H, Wei Z (2017) Identifying the key factors that affect the formation of humic substance during different materials composting. Bioresour Technol 244:1193–1196. https://doi.org/10.1016/j.biortech.2017.08.100
Şevik F, Tosun İ, Ekinci K (2018) The effect of FAS and C/N ratios on co-composting of sewage sludge, dairy manure and tomato stalks. Waste Manag 80:450–456. https://doi.org/10.1016/j.wasman.2018.07.051
Yanagi Y, Shindo H (2016) Assessment of long-term compost application on physical, chemical, and biological properties, as well as fertility, of soil in a field subjected to double cropping. Agr Sci 07(1):30–43. https://doi.org/10.4236/as.2016.71004
Antizar-Ladislao B, Turrion-Gomez JL (2008) Second-generation biofuels and local bioenergy systems. Biofuel Bioprod Bior 2(5):455–469. https://doi.org/10.1002/bbb.97
Irvine G, Lamont ER, Antizar-Ladislao B. (2010) Energy from waste: Reuse of compost heat as a source of renewable energy. Int J Chem Eng (3):1–10. https://doi.org/10.1155/2010/627930
Acknowledgments
Y.L. appreciated the support from the National Natural Science Foundation of China (22078194) and National Key Research and Development Program (No. 2017YFE0127100).
Funding
This work was supported by the National Natural Science Foundation of China (22078194). YL also appreciated the support from the National Key Research and Development Program (No. 2017YFE0127100).
Author information
Authors and Affiliations
Contributions
Zhiquan Wang: conceptualization, investigation, methodology, experiment, software, formal analysis, and writing (original draft preparation).
Deyi Wu: methodology, formal analysis, and investigation.
Xinze Wang: methodology, formal analysis, and investigation.
Yan Lin: methodology, writing (review and editing), visualization, supervision, and funding acquisition.
Corresponding author
Ethics declarations
Conflict of Interest
The authors declare no competing interests.
Ethical Approval
Not applicable
Consent to Participate
Not applicable
Consent to Publish
Not applicable
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Wang, Z., Wu, D., Lin, Y. et al. Role of Temperature in Sludge Composting and Hyperthermophilic Systems: a Review. Bioenerg. Res. 15, 962–976 (2022). https://doi.org/10.1007/s12155-021-10281-5
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12155-021-10281-5