Abstract
A major limitation associated with fermentative hydrogen production is the low substrate conversion efficiency. This limitation can be overcome by integrating the process with a microbial fuel cell (MFC) which converts the residual energy of the substrate to electricity. Studies were carried out to check the feasibility of this integration. Biohydrogen was produced from the fermentation of cane molasses in both batch and continuous modes. A maximum yield of about 8.23 mol H2/kg CODremoved was observed in the batch process compared to 11.6 mol H2/kg CODremoved in the continuous process. The spent fermentation media was then used as a substrate in an MFC for electricity generation. The MFC parameters such as the initial anolyte pH, the substrate concentration and the effect of pre-treatment were studied and optimized to maximize coulombic efficiency. Reductions in COD and total carbohydrates were about 85% and 88% respectively. A power output of 3.02 W/m3 was obtained with an anolyte pH of 7.5 using alkali pre-treated spent media. The results show that integrating a MFC with dark fermentation is a promising way to utilize the substrate energy.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Elam C C, Padró C E G, Sandrock G, Luzzi A, Lindblad P, Hagen E F. Realizing the hydrogen future: the International Energy Agency’s efforts to advance hydrogen energy technologies. International Journal of Hydrogen Energy, 2003, 28(6): 601–607
Nayak B K, Pandit S, Das D. Biohydrogen. In: Kennes C, Veigaría C, editors. Air Pollution Prevention and Control. JohnWiley & Sons Ltd, 2013, 345–381
Oh Y K, Raj S M, Jung G Y, Park S. Current status of the metabolic engineering of microorganisms for biohydrogen production. Bioresource Technology, 2011, 102(18): 8357–8367
Das D, Vezirolu T N. Hydrogen production by biological processes: A survey of literature. International Journal of Hydrogen Energy, 2001, 26(1): 13–28
Levin D B, Pitt L, Love M. Biohydrogen production: Prospects and limitations to practical application. International Journal of Hydrogen Energy, 2004, 29(2): 173–185
Jung G Y, Jung H O, Kim J R, Ahn Y, Park S. Isolation and characterization of Rhodopseudomonas palustris P4 which utilizes CO with the production of H2. Biotechnology Letters, 1999, 21(6): 525–529
Benemann J. Hydrogen biotechnology: progress and prospects. Nature Biotechnology, 1996, 14(9): 1101–1103
Mohan S V, Srikanth S, Velvizhi G, Babu ML. Microbial Fuel Cells for Sustainable Bioenergy Generation: Principles and Perspective Applications. In: Gupta V K, Tuohy M G, eds. Biofuel Technologies. Berlin: Springer Berlin Heidelberg, 2013, 335–368
Momirlan M, Veziroglu T. Current status of hydrogen energy. Renewable & Sustainable Energy Reviews, 2002, 6(1–2): 141–179
Lovley D R. The microbe electric: conversion of organic matter to electricity. Current Opinion in Biotechnology, 2008, 19(6): 564–571
Logan B E, Regan J M. Electricity-producing bacterial communities in microbial fuel cells. Trends in Microbiology, 2006, 14(12): 512–518
Torres C I, Marcus A K, Lee H S, Parameswaran P, Krajmalnik-Brown R, Rittmann B E. A kinetic perspective on extracellular electron transfer by anode-respiring bacteria. FEMS Microbiology Reviews, 2010, 34(1): 3–17
Oh S T, Kim J R, Premier G C, Lee T H, Kim C, Sloan W T. Sustainable wastewater treatment: How might microbial fuel cells contribute. Biotechnology Advances, 2010, 28(6): 871–881
Guwy A J, Dinsdale R M, Kim J R, Massanet-Nicolau J, Premier G. Fermentative biohydrogen production systems integration. Bioresource Technology, 2011, 102(18): 8534–8542
Sharma Y, Li B. Optimizing energy harvest in wastewater treatment by combining anaerobic hydrogen producing biofermentor (HPB) and microbial fuel cell (MFC). International Journal of Hydrogen Energy, 2010, 35(8): 3789–3797
Mohanakrishna G, Venkata Mohan S, Sarma P N. Utilizing acid-rich effluents of the fermentative hydrogen production process as a substrate for harnessing bioelectricity: An integrative approach. International Journal of Hydrogen Energy, 2010, 35(8): 3440–3449
Wang A, Sun D, Cao G, Wang H, Ren N, Wu W M, Logan B E. Integrated hydrogen production process from cellulose by combining dark fermentation, microbial fuel cells, and a microbial electrolysis cell. Bioresource Technology, 2011, 102(5): 4137–4143
Park M J, Jo J H, Park D, Lee D S, Park J M. Comprehensive study on a two-stage anaerobic digestion process for the sequential production of hydrogen and methane from cost-effective molasses. International Journal of Hydrogen Energy, 2010, 35(12): 6194–6202
Vatsala T M. Hydrogen production from (cane-molasses) stillage by Citrobacter freundii and its use in improving methanogenesis. International Journal of Hydrogen Energy, 1992, 17(12): 923–927
González T, Terrón MC, Yagüe S, Zapico E, Galletti G C, González A E. Pyrolysis/gas chromatography/mass spectrometry monitoring of fungal-biotreated distillery wastewater using Trametes sp. I-62 (CECT 20197). Rapid Communications in Mass Spectrometry, 2000, 14(15): 1417–1424
Singhania R R, Patel A K, Christophe G, Fontanille P, Larroche C. Biological upgrading of volatile fatty acids, key intermediates for the valorization of biowaste through dark anaerobic fermentation. Bioresource Technology, 2013, 145: 166–174
Poggi-Varaldo H M, Carmona-Martínez A, Vázquez-Larios A L, Solorza-Feria O.Effect of inoculum type on the performance of a microbial fuel cell fed with spent organic extracts from hydrogenogenic fermentation of organic solid wastes. Journal of New Materials for Electrochemical Systems, 2009, 12: 049–054
Kumar N, Das D. Enhancement of hydrogen production by Enterobacter cloacae IIT-BT 08. Process Biochemistry, 2000, 35(6): 589–593
Kumar N, Das D. Continuous hydrogen production by immobilized Enterobacter cloacae IIT-BT 08 using lignocellulosic materials as solid matrices. Enzyme and Microbial Technology, 2001, 29(4–5): 280–287
Khilari S, Pandit S, Ghangrekar M M, Das D, Pradhan D. Graphene supported α-MnO2 nanotubes as a cathode catalyst for improved power generation and wastewater treatment in single-chambered microbial fuel cells. RSC Advances, 2013, 3(21): 7902–7911
Behera M, Ghangrekar M M. Performance of microbial fuel cell in response to change in sludge loading rate at different anodic feed pH. Bioresource Technology, 2009, 100(21): 5114–5121
Lay J J, Li Y Y, Noike T. Influences of pH and moisture content on the methane production in high-solids sludge digestion. Water Research, 1997, 31(6): 1518–1524
Standard Methods for the Examination of Water and Wastewater. 20th Ed. American Public Health Association (APHA), American Water Works Association, Water Pollution Control Federation, Washington DC. 1998, 141
Logan B E, Hamelers B, Rozendal R, Schröder U, Keller J, Freguia S, Aelterman P, Verstraete W, Rabaey K. Microbial fuel cells: Methodology and technology. Environmental Science & Technology, 2006, 40(17): 5181–5192
Logan B E. Microbial Fuel Cells. 1st ed. Wiley-Interscience, 2008, 216
Loewus F A. Improvement in anthrone method for determination of carbohydrates. Analytical Chemistry, 1952, 24(1): 219–219
Das D, Veziroğlu T N. Hydrogen production by biological processes: a survey of literature. International Journal of Hydrogen Energy, 2001, 26(1): 13–28
Seol E, Kim S, Raj S M, Park S. Comparison of hydrogenproduction capability of four different Enterobacteriaceae strains under growing and non-growing conditions. International Journal of Hydrogen Energy, 2008, 33(19): 5169–5175
Bringi V, Dale B E. Enhanced yeast immobilization by nutrient starvation. Biotechnology Letters, 1985, 7(12): 905–908
Gavala H N, Skiadas I V, Ahring B K. Biological hydrogen production in suspended and attached growth anaerobic reactor systems. International Journal of Hydrogen Energy, 2006, 31(9): 1164–11
Gil G C, Chang I S, Kim B H, Kim M, Jang J K, Park H S, Kim H J. Operational parameters affecting the performance of a mediator-less microbial fuel cell. Biosensors & Bioelectronics, 2003, 18(4): 327–334
He Z, Huang Y, Manohar A K, Mansfeld F. Effect of electrolyte pH on the rate of the anodic and cathodic reactions in an air-cathode microbial fuel cell. Bioelectrochemistry (Amsterdam, Netherlands), 2008, 74(1): 78–82
Ren Z, Ward T E, Regan J M. Electricity production from cellulose in a microbial fuel cell using a defined binary culture. Environmental Science & Technology, 2007, 41(13): 4781–4786
Venkata Mohan S, Veer Raghavulu S, Sarma P N. Biochemical evaluation of bioelectricity production process from anaerobic wastewater treatment in a single chambered microbial fuel cell (MFC) employing glass wool membrane. Biosensors & Bioelectronics, 2008, 23(9): 1326–1332
Menicucci J, Beyenal H, Marsili E, Veluchamy, Demir G, Lewandowski Z. Veluchamy, Demir G, Lewandowski Z. Procedure for determining maximum sustainable power generated by microbial fuel cells. Environmental Science & Technology, 2006, 40(3): 1062–1068
Yuan Y, Zhao B, Zhou S, Zhong S, Zhuang L. Electrocatalytic activity of anodic biofilm responses to pH changes in microbial fuel cells. Bioresource Technology, 2011, 102(13): 6887–6891
Kim B H, Chang I S, Gadd G M. Challenges in microbial fuel cell development and operation. Applied Microbiology and Biotechnology, 2007, 76(3): 485–494
Kim B H, Chang I S, Gil G C, Park H S, Kim H J. Novel BOD (biological oxygen demand) sensor using mediator-less microbial fuel cell. Biotechnology Letters, 2003, 25(7): 541–545
Di Lorenzo M, Curtis T P, Head I M, Scott K. A single-chamber microbial fuel cell as a biosensor for wastewaters. Water Research, 2009, 43(13): 3145–3154
Lefebvre O, Tan Z, Kharkwal S, Ng H Y. Effect of increasing anodic NaCl concentration on microbial fuel cell performance. Bioresource Technology, 2012, 112: 336–340
Author information
Authors and Affiliations
Corresponding author
Additional information
Two authors have equal contribution
Rights and permissions
About this article
Cite this article
Pandit, S., Balachandar, G. & Das, D. Improved energy recovery from dark fermented cane molasses using microbial fuel cells. Front. Chem. Sci. Eng. 8, 43–54 (2014). https://doi.org/10.1007/s11705-014-1403-4
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11705-014-1403-4