Abstract
The Bombyx mori macula-like virus (BmMLV) is a member of the genus Maculavirus, family Tymoviridae, and contains a positive-sense single-stranded RNA genome. Previously, we reported that almost all B. mori-derived cell lines have already been contaminated with BmMLV via an unknown infection route. Since B. mori-derived cell lines are used for the baculovirus expression vector system, the invasion of BmMLV will cause a serious safety risk in the production of recombinant proteins. In this study, to determine the inactivation effectiveness of BmMLV, viruses were treated with various temperatures as well as gamma and ultraviolet (UV) light radiation. After these treatments, the virus solutions were inoculated into BmMLV-free BmVF cells. At 7 days postinoculation, the amount of virus in cells was evaluated by real-time reverse transcription PCR. Regarding heat treatment, conditions under 56°C for 3 h were tolerated, whereas infectivity disappeared after treatment at 75°C for 1 h. Regarding gamma radiation treatment, viruses were relatively stable at 1 kGy; however, their infectivity was entirely eliminated at a dose of 10 kGy. With 254 nm UV-C treatment, viruses were still active at less than 120 mJ/cm2; however, their infectivity was completely lost at greater than 140 mJ/cm2 UV-C radiation. These results provide quantitative evidence of the potential for BmMLV inactivation under a variety of physical conditions.
Similar content being viewed by others
Avoid common mistakes on your manuscript.
Introduction
The baculovirus expression vector system (BEVS) is a powerful eukaryotic method for producing difficult-to-express recombinant proteins with high yields. Since many of the posttranslational modifications present in eukaryotes are performed in baculovirus-infected insect cells, the overexpressed protein exhibits the proper biological activity and function. Accordingly, the BEVS has been utilized to develop next-generation vaccines, vectors for gene therapy, and other biopharmaceutical complex proteins (reviewed in Felberbaum 2015). Two of the most common baculovirus species used in the BEVS are Autographa californica multicapsid nucleopolyhedrovirus (AcMNPV) and Bombyx mori NPV (BmNPV) belonging to the group I Alphabaculovirus (reviewed in Rohrmann 2013). Mammalian cytokines have been produced using recombinant BmNPVs and were launched as antiviral and atopic dermatitis drugs for companion animals (reviewed in Kato et al. 2010). Recently, an influenza virus-like particle was produced in silkworm pupae infected with recombinant BmNPV (Nerome et al. 2015). For the BmNPV-based BEVS, B. mori-derived cell lines that are susceptible to BmNPV are indispensable for the generation and/or propagation of recombinant BmNPVs and production of recombinant proteins.
Previously, we reported that a B. mori ovary-derived cell line, BmN4, was persistently infected with a B. mori macula-like virus (BmMLV) (Katsuma et al. 2005). BmMLV is a member of the genus Maculavirus, family Tymoviridae, and contains a positive-sense single-stranded RNA genome. Interestingly, almost all B. mori-derived cell lines have already been contaminated with BmMLV via an unknown infection route (Iwanaga et al. 2012). As described above, since B. mori-derived cell lines are frequently used for BmNPV-based BEVS for the production of veterinary medicines, the contamination of B. mori cell lines with BmMLV will be a higher safety risk in the production of recombinant proteins.
To inactivate the virus, treatments with heat as well as gamma and ultraviolet (UV) light radiation are frequently used (Smith 1962; Spire et al. 1985; Burnouf and Radosevich 2000; Lowy et al. 2001; Thurston-Enriquez et al. 2003; De Benedictis et al. 2007; Song et al. 2010; Nims et al. 2011; Zou et al. 2013). This study evaluated the efficacy of several viral inactivation methods in eliminating BmMLV infectivity, including heat treatment and gamma and UV-C light radiation. Virus infectivity was assessed by real-time reverse transcription PCR (RT-PCR) and Western blot analysis. The results revealed that all of these methods were able to inactivate BmMLV.
Materials and Methods
Cells, the virus, and viral inoculation.
B. mori-derived BmMLV-positive BmN4 (Grace 1967) and BmMLV-negative BmVF (Iwanaga et al. 2012) cell lines were maintained as described previously on TC-100 and IPL-41 media, respectively, supplemented with 10% fetal bovine serum (FBS) (Iwanaga et al. 2004, 2012). BmMLV solution was prepared from BmN4 cells as described previously (Iwanaga et al. 2012). After viral inactivation treatments, 2 × 106 BmVF cells were inoculated with 4 × 104 BmN4 cell-derived BmMLV solution and incubated for 1 h. After virus inoculation, cells were washed twice with phosphate-buffered saline (PBS) and transported to a 60-mm culture dish. Samples were collected with a cell scraper at 7 days postinnoculation (dpi) and subjected to real-time RT-PCR and Western blot analysis.
Real-time RT-PCR analysis.
Total RNAs were prepared from BmMLV-inoculated BmVF cells by using RNAiso Plus reagents (Takara Bio, Shiga, Japan), and then, the first-strand complementary DNA (cDNA) was synthesized from 500 ng of total RNA with random hexamers and the PrimeScript RT reagent kit (Takara Bio). Subsequently, cDNA fragments were subjected to real-time PCR analysis using primers q-BmMLV-cp-F (5′-TTGACCTTTGTTGGACTACTGCTG-3′) and q-BmMLV-cp-F (5′-GATGACATCGACGATGATCCAAATG-3′) for BmMLV coat protein (cp) and qRT-actin-F (5′-GATGACATCGACGATGATCCAAATG-3′) and qRT-actin-R (5′CTCGGTCCTGTCTGAGCTCTCTTG-3′) for B. mori actin, which was performed by using the SYBR Premix Ex Taq II (Takara Bio) and the ABI PRISM 7500 Real-Time PCR System (Life Technologies, Carlsbad, CA). Statistical analysis was carried out using one-way ANOVA and Tukey post hoc test with KaleidaGraph computer software version 4.1 (Synergy Software, Reading, PA).
Western blot analysis.
Cell extracts were prepared from BmMLV-inoculated BmVF cells, electrophoresed, transferred on a Hybond ECL membrane (GE Healthcare, Buckinghamshire, UK), and subjected to Western blotting. Antibodies of BmMLV CP (Iwanaga et al. 2012) and beta-actin (Santa Cruz Biotechnology, Santa Cruz, CA) were used as probes. Anti-rabbit IgG conjugated to horseradish peroxidase (KPL, Gaitherburg, MD) and the Western blot substrate plus (Thermo Fisher Scientific, Waltham, MA) were used. Signal detection was carried out using the Light Capture II system (ATTO, Tokyo, Japan).
Heat treatment.
The viral solution was dispensed into 100 μl aliquots in tightly capped, 1.5-ml microcentrifuge tubes and then incubated in a dry bath with temperatures of 25, 37, 45, 56, 65, 75, and 100°C. At designated time points, samples were removed and transferred immediately into an ice-water bath to stop the effect of the heat. Subsequently, heat-denatured proteins were removed by centrifuging at 12,000×g at 4°C for 10 min, and then, the supernatants were used for virus inoculation.
Gamma radiation.
The viral solution was dispensed into 100 μl aliquots in tightly capped, 1.5-ml cryotubes and then exposed to doses of 0, 0.05, 0.1, 0.2, 0.5, 1, 10, 20, and 40 kGy of gamma radiation from a 60Co source using a gammacell (model PIIC-480C; Pony Industry, Osaka, Japan) with an average dose rate of approximately 141 Gy/min during the radiation exposure. The samples were kept at 4°C by adding crushed ice during gamma irradiation. After irradiation, samples were used as a virus solution.
UV-C light radiation.
The viral solution was placed on a parafilm (Bemis Company, Oshkosh, WI) and then exposed to a continuous 254-nm UV-C light at 0, 20, 40, 60, 100, 120, 140, 160, and 180 mJ/cm2, using a CL-1000 Ultraviolet Crosslinker (UVP, Upland, CA). Experiments were performed at room temperature. After radiation, samples were sterilized using a 0.2-μm syringe filter and then used for virus inoculation.
Results
Effect of heat treatment on BmMLV infectivity.
To evaluate the sensitivity of BmMLV to heat treatment, aliquots of BmMLV solution (derived from 4 × 104 BmN) were treated at seven temperatures (25, 37, 45, 56, 65, 75, and 100°C) for 30 min. As shown in Fig. 1A , with treatment at 75°C, the viral RNA at 7 dpi significantly decreased to 3.4% of that at 25°C (p < 0.001). Also, the RNA amounts sharply reduced to less than 0.1% with treatment at 100°C. To assess the effect of the incubation length on virus infectivity, viral solutions were treated at 56 and 75°C for 1, 2, and 3 h. As shown in Fig. 1B , while there were no significant differences when treated at 56°C for 2 h, the viral RNA significantly decreased to 25.1% with treatment for 3 h (p < 0.005). Also, the viral RNA completely diminished with treatment of more than 1 h at 75°C (p < 0.001). These results indicate that BmMLV can be completely inactivated with treatment at 75°C for more than 1 h or 100°C for 30 min.
Effect of gamma-ray radiation on BmMLV infectivity.
Next, to evaluate the effect of gamma radiation on BmMLV infectivity, aliquots of BmMLV solution (derived from 4 × 104 BmN) were given doses of 0 to 40 kGy from a 60Co source of gammacell. As shown in Fig. 2, although viral RNA at 7 dpi declined to 50.2% with 1 kGy radiation, there was no significant difference between 0 and 1 kGy radiation (p > 0.001). However, the viral RNA abruptly disappeared following treatment with more than 10 kGy radiation (p < 0.001) (Fig. 2), thereby indicating that BmMLV can be completely inactivated by more than 10 kGy of gamma-ray radiation.
Effect of UV-C light radiation on BmMLV infectivity.
Finally, to examine the effect of continuous UV-C light on BmMLV infectivity, aliquots of BmMLV solution (derived from 4 × 104 BmN) were placed on a parafilm and subjected to UV-C light radiation from 0 to 180 mJ/cm2. As shown in Fig. 3, although the viral RNA at 7 dpi declined to 34.9% with treatment of 100 mJ/cm2, there were no significant differences between 0 and 100 mJ/cm2 (p > 0.001). On the other hand, the RNA amounts were sharply reduced to less than 1% following treatment with 120 mJ/cm2 radiation (p < 0.001). Also, the viral RNA was completely diminished with treatment of more than 140 mJ/cm2 UV-C light (p < 0.001). These results indicate that BmMLV can be completely inactivated by more than 140 mJ/cm2 UV-C radiation.
Confirmation of BmMLV inactivation by Western blot analysis.
To verify the results of real-time RT-PCR analysis, 1 × 105 BmVF cells were inoculated with BmMLV solution that was inactivated by heat, gamma ray, or UV-C. At 7 dpi, cell extracts were electrophoresed and subjected to Western blotting with anti-CP antibody. As shown in Fig. 4, while a viral CP signal was detected with treatment at 56°C for 3 h, no signal was detected with treatment at 75°C for 1, 2, or 3 h. Also, distinct viral CP signals were detected when treated with both 0.5 and 1 kGy gamma-ray radiation; however, there was no detectable signal when treated with 10 kGy radiation (Fig. 4). Furthermore, although there were clear viral CP signals during treatment with both 100 and 120 mJ/cm2 UV-C radiation, no detectable signal was observed during treatment with 140 mJ/cm2 radiation (Fig. 4). Combined with the results of real-time RT-PCR analysis (Figs. 1, 2, and 3), we concluded that BmMLV was inactivated with treatment at 75°C for 1 h, 10 kGy gamma radiation, and 140 mJ/cm2 UV-C radiation.
Discussion
In this study, a detailed analysis was conducted as to the efficacy of several conventional viral inactivation procedures, i.e., heat treatment and gamma and UV-C radiation for eliminating BmMLV infectivity.
Heat treatment is a widely used viral inactivation method that is effective against both enveloped and nonenveloped viruses (Burnouf and Radosevich 2000). Since high temperature causes the denaturation of viral proteins, some enveloped viruses are easily inactivated by heat treatment. The infectivity of both lymphadenopathy-associated virus, of the family Retroviridae, and avian influenza A (H7N9), of the family Orthomyxoviridae, is entirely eliminated with treatment at 56°C for 30 min (Spire et al. 1985; Zou et al. 2013). On the other hand, the family Tymoviridae generally survives at slightly higher temperatures, and the thermal inactivation point is 60–65°C to greater than 80°C for some tymoviruses (Martelli et al. 2002). In the current study, BmMLV showed heat tolerance at both 56°C for 3 h and 75°C for 30 min (Figs. 1 and 4). Considering that BmMLV belongs to the family Tymoviridae, the virion structure of this family may be resistant to heat treatment. As shown in Fig. 4, inactivation of BmMLV succeeded with treatment at 75°C for 1 h. However, this condition may cause serious denaturation of the recombinant protein expressed by BEVS. The heat inactivation method may be applied to the expression of specified low molecular weight peptides.
Gamma-ray treatment is a powerful tool for viral inactivation. A total radiation dose of 25–40 kGy fully inactivates many viruses and mycoplasma in animal sera (reviewed in Nims et al. 2011). In the current study, real-time RT-PCR and Western blot analysis showed that the infectivity of BmMLV can be entirely eliminated by gamma radiation at a dose of 10 kGy (Figs. 2 and 4). For BEVS, it is important to prevent the denaturation of recombinant proteins. In general, gamma radiation inactivates microorganisms through direct and indirect actions (Thomas et al. 1981). Direct action is a result of interactions of the radiation with nucleic acids of the microorganism that can cause base mutations, strand cross-linking, and strand breakage. Indirect action consists of the radiation’s interaction with the milieu and includes the creation of free radicals (Sommer et al. 2001). Therefore, in the case of the influenza virus, the primary targets by which gamma radiation brings about virus inactivation are strand breaks of viral nucleic acids rather than denaturation of the virion structure (reviewed in De Benedictis et al. 2007). Also, gamma radiation inactivates viruses without detrimentally impacting the antigenic structure and biological integrity of proteins (Lowy et al. 2001). Therefore, the gamma radiation method for inactivating BmMLV represents a major advantage in the expression of recombinant proteins using BEVS.
UV-C radiation is another commonly used physical method for viral inactivation. This method inhibits viral replication by inducing the formation of thymine dimmers, a pyrimidine base (Perdiz et al. 2000). It was reported that the doses of UV required to achieve 99% inactivation of adenovirus type 40, of the family Adenoviridae, and feline calicivirus, of the family Caliciviridae, were 109 and 16 mJ/cm2, respectively (Thurston-Enriquez et al. 2003). Additionally, the hepatitis C virus, of the family Flaviviridae, was inactivated completely by UV-C radiation at a dose of 27 mJ/cm2 (Song et al. 2010). In the current study, the infectivity of BmMLV was fully inactivated by 140 mJ/cm2 UV-C radiation (Figs. 3 and 4). Since UV-C light causes a protein-nucleic acid cross-link that plays a significant role in the inactivation of the microorganism (Smith 1962), it will be necessary for BEVS to confirm whether the recombinant protein exhibits the proper biological activity and functions under this UV-C-mediated viral inactivation method. Additionally, it is well known that gamma radiation is the most expensive method, and thus, UV-C light methods may prove to be more suitable for small-scale BEVS.
In the present study, several physical treatments for eliminating BmMLV were evaluated. There is a possibility that these virus inactivation methods can be applied to at least three steps. The first step is to inactivate BmMLV in the recombinant protein-containing solution after biochemical purification because we cannot exclude the possibility that BmMLV is still contaminated. Some proteins are sensitive to heat treatment; thus, application of heat inactivation methods depends on the feature of the recombinant protein expressed by BEVS. Also, since the target of gamma and UV-C light radiation is the nucleic acid of viral genome, these inactivation methods may be useful to inactivate BmMLV in the recombinant protein-containing solution. The second step is to inactivate BmMLV in the recombinant BmNPV-containing solution. Since BmNPV could be damaged by gamma and UV-C radiation, it may be difficult to selectively inactivate BmMLV in the recombinant BmNPV-containing solution by these methods. The third step is to inactivate BmMLV when researchers maintain BmN4 cells. However, it is somewhat difficult to maintain BmN4 cells under BmMLV-free condition because the origin of this virus is still unknown. In this case, it is better to use BmMLV-free cell line VF that we have established before (Iwanaga et al. 2012, 2014). In conclusion, this study demonstrated that all physical methods we tested can completely inactivate BmMLV, indicating that these inactivation methods could be applied to BmNPV-based BEVS.
References
Burnouf T, Radosevich M (2000) Reducing the risk of infection from plasma products: specific preventative strategies. Blood Rev 14:94–110
De Benedictis P, Beato MS, Capua I (2007) Inactivation of avian influenza viruses by chemical agents and physical conditions: a review. Zoonoses Public Health 54:51–68
Felberbaum RS (2015) The baculovirus expression vector system: a commercial manufacturing platform for viral vaccines and gene therapy vectors. Biotechnol J 10:702–714
Grace TDC (1967) Establishment of a line of cells from the silkworm Bombyx mori. Nature 216:613
Iwanaga M, Hitotsuyama T, Katsuma S, Ishihara G, Daimon T, Shimada T, Imanishi S, Kawasaki H (2012) Infection study of Bombyx mori macula-like virus (BmMLV) using a BmMLV-negative cell line and an infectious cDNA clone. J Virol Methods 179:316–324
Iwanaga M, Takaya K, Katsuma S, Ote M, Tanaka S, Kamita SG, Kang W, Shimada T, Kobayashi M (2004) Expression profiling of baculovirus genes in permissive and nonpermissive cell lines. Biochem Biophys Res Commun 323:599–614
Iwanaga M, Tsukui K, Uchiyama K, Katsuma S, Imanishi S, Kawasaki H (2014) Expression of recombinant proteins by BEVS in a macula-like virus-free silkworm cell line. J Invertebr Pathol 123:34–37
Kato T, Kajiwara M, Maenaka K, Park EY (2010) Silkworm expression system as a platform technology in life science. Appl Microbiol Biotechnol 85:459–470
Katsuma S, Tanaka S, Omuro N, Takabuchi L, Daimon T, Imanishi S, Yamashita S, Iwanaga M, Mita K, Maeda S, Kobayashi M, Shimada T (2005) Novel macula-like virus identified in Bombyx mori cultured cells. J Virol 79:5577–5584
Lowy RJ, Vavrina GA, LaBarre DD (2001) Comparison of gamma and neutron radiation inactivation of influenza A virus. Antivir Res 52:261–273
Martelli GP, Sabanadzovic S, Abou-Ghanem Sabanadzovic N, Edwards MC, Dreher T (2002) The family Tymoviridae. Arch Virol 147:1837–1846
Nerome K, Sugita S, Kuroda K, Hirose T, Matsuda S, Majima K, Kawasaki K, Shibata T, Poetri ON, Soejoedono RD, Mayasari NL, Agungpriyono S, Nerome R (2015) The large-scale production of an artificial influenza virus-like particle vaccine in silkworm pupae. Vaccine 33:117–125
Nims RW, Gauvin G, Plavsic M (2011) Gamma irradiation of animal sera for inactivation of viruses and mollicutes—a review. Biologicals 39:370–377
Perdiz D, Grof P, Mezzina M, Nikaido O, Moustacchi E, Sage E (2000) Distribution and repair of bipyrimidine photoproducts in solar UV-irradiated mammalian cells. Possible role of Dewar photoproducts in solar mutagenesis. J Biol Chem 275:26732–26742
Rohrmann GF (2013) Baculovirus molecular biology, 3rd edn. National Center for Biotechnology Information, Bethesda (MD)
Smith KC (1962) Dose dependent decrease in extractability of DNA from bacteria following irradiation with ultraviolet light or with visible light plus dye. Biochem Biophys Res Commun 8:157–163
Sommer R, Pribil W, Appelt S, Gehringer P, Eschweiler H, Leth H, Cabaj A, Haider T (2001) Inactivation of bacteriophages in water by means of non-ionizing (UV-253.7 nm) and ionizing (gamma) radiation: a comparative approach. Water Res 35:3109–3116
Song H, Li J, Shi S, Yan L, Zhuang H, Li K (2010) Thermal stability and inactivation of hepatitis C virus grown in cell culture. Virol J 7:40
Spire B, Dormont D, Barré-Sinoussi F, Montagnier L, Chermann JC (1985) Inactivation of lymphadenopathy-associated virus by heat, gamma rays, and ultraviolet light. Lancet 26:188–189
Thomas FC, Davis AG, Dulac GC, Willis NG, Papp-Vid G, Girard A (1981) Gamma ray inactivation of some animal viruses. Can J Comp Med 45:397–399
Thurston-Enriquez JA, Haas CN, Jacangelo J, Riley K, Gerba CP (2003) Inactivation of feline calicivirus and adenovirus type 40 by UV radiation. Appl Environ Microbiol 69:577–582
Zou S, Guo J, Dong L, Zhang Y, Dong J, Bo H, Qin K, Shu Y (2013) Inactivation of the novel avian influenza A (H7N9) virus under physical conditions or chemical agents treatment. Virol J 10:289
Acknowledgments
This work was supported by JSPS KAKENHI Grant Number 25450482 and the A-STEP feasibility study program of the Japan Science and Technology Agency, Grant Number 241FT0093.
Author information
Authors and Affiliations
Corresponding author
Additional information
Editor: Tetsuji Okamoto
Rights and permissions
About this article
Cite this article
Uchiyama, K., Fujimoto, H., Katsuma, S. et al. Inactivation of Bombyx mori macula-like virus under physical conditions. In Vitro Cell.Dev.Biol.-Animal 52, 265–270 (2016). https://doi.org/10.1007/s11626-015-9972-1
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11626-015-9972-1