Abstract
Diatomaceous earths (DEs) are able to successfully protect grain commodities from noxious stored-product insect and mite infestations; however, their effectiveness may be moderated by the grain hybrid or variety they are applied to. There is a gap of information on the comparison of the efficacy of different DEs when are applied on different maize hybrids against Prostephanus truncatus (Horn). Therefore, here we tested three commercially available DEs (DEA-P at 75 and 150 ppm, Protect-It at 500 ppm, and PyriSec at 500 ppm) on five different maize hybrids (Calaria, Doxa, Rio Grande, Sisco, and Studio) for the control of P. truncatus adults in terms of mortality (at 7 and 14 days), progeny production, properties of the infested maize hybrids (number and weight of kernels with or without holes, number of holes per kernel) and the adherence level of the tested DEs to the kernels. DEA-P was very effective at 75 ppm while a considerable proportion of the exposed P. truncatus adults was still alive after 14 days of exposure on all maize hybrids treated with 500 ppm of Protect-It or PyriSec, even though it was 3.3 times higher than the maximal application tested dose of DEA-P. Apart from parental mortality, DEA-P was able to reduce P. truncatus progeny production in all hybrids contrary to Protect-It or PyriSec. The adherence ratios were always higher for DEA-P than Protect-It or PyriSec to all maize hybrids. The highest numbers of kernels (or weight of kernels) without holes were noticed after their treatment with DEA-P. Doxa and Sisco performed better than Calaria, Rio Grande, or Studio based on the differences found concerning the numbers of kernels without holes at treatments with DEA-P and Protect-It. Overall, the findings of our study indicate the high potentiality of DEA-P as protectant of different maize hybrids to P. truncatus infestations at low doses, a fact that could help the eco-friendly management of this noxious species in the stored-product environment.
Similar content being viewed by others
Explore related subjects
Discover the latest articles, news and stories from top researchers in related subjects.Avoid common mistakes on your manuscript.
Introduction
The larger grain borer, Prostephanus truncatus (Horn) (Coleoptera: Bostrychidae) is a serious insect pest of stored maize and cassava tubers in Africa (Hill 2003, Muatinte et al. 2014) and falls under regional quarantine concerns (Tyler and Hodges 2002, Myers and Hagstrum 2012). After its accidental introduction in Africa from Mesoamerica four decades ago, this species is now spread in a wide zone, which includes numerous countries in Africa (i.e., Benin, Burkina Faso, Burundi, Ghana, Guinea, Kenya, Malawi, Niger, Nigeria, Rwanda, South Africa, Tanzania, Togo, Zambia), Central America (i.e., Costa Rica, El Salvador, Guatemala, Honduras, Nicaragua, Panama), North America (i.e., Mexico, USA), South America (Colombia), and Asia (China, India) (Dunstan and Magazini 1981; EPPO, European and Mediterranean Plant Protection Organization 2017). The adults are long-lived and can be devastating for several commodities, as P. truncatus can rapidly develop extremely high populations, within only a few weeks (Nansen and Meikle 2002; Hill et al. 2002). Moreover, this species is also present in high numbers outside of the storage ecosystems, such as in forests, feeding from wood as in the case of most members of the family Bostrychidae (Borgemeister et al. 1998; Hill et al. 2002; Muatinte et al. 2014), while it is particularly abundant in maize right before harvest (Hill et al. 2002). Its presence cannot be easily detected during the harvest period, which means that maize is already infested during its introduction on the storage facility (Borgemeister et al. 1994; Hill et al. 2002).
The control of P. truncatus is negatively affected by the fact that this species is tolerant to several organophosphorus compounds (OPs), at dose rates that are usually very effective against other major stored-product species (Golob 2002; Rumbos et al. 2013). Interestingly, this tolerance might be linked with the ease of P. truncatus to develop resistance to insecticides (Golob 2002). In a recent study, Rumbos et al. (2013) reported that the OP pirimiphos-methyl was unable to control P. truncatus and another species of major importance for grains at their post-harvest stages, the lesser grain borer, Rhyzopertha dominica (F.) (Coleoptera: Bostrychidae). For this purpose, the common practice to control this species in Africa is the simultaneous use of more than one active ingredients, of which usually one is pyrethroid (Golob 2002). Apparently, the continuous use of neurotoxic compounds meets with several major drawbacks that are related to environment and public health (Arthur 2012).
Diatomaceous earths (DEs) are efficacious alternatives to traditional grain protectants that have been evaluated with success in the case of most major stored-grain pests (Cook and Armitage 1999; Korunic 1998; Arthur 2001; Arnaud et al. 2005; Chanbang et al. 2007; Doumbia et al. 2014; Frederick and Subramanyam 2016). They are composed by the fossils of phytoplanktons (diatoms) and are known to have low mammalian toxicity (Round et al. 1990; Korunic 1998). At the same time, DEs are able to provide long-term protection against noxious stored-product insects (Vayias et al. 2006). However, considerable differences have been found among different commercially available DEs regarding their efficacy for the control of P. truncatus. In an earlier study, Stathers et al. (2004) found that Dryacide and Protect-It provided low (<0.25%) and average (<70%) mortalities respectively to P. truncatus adults while both DEs could not suppress offspring emergence on maize treated with 1000 g/ton at 27 °C and 50% relative humidity (RH) while values of mortality and progeny production were significantly lower and higher respectively at 60% RH. Similarly, Athanassiou et al. (2007) reported that some DEs were not effective at either lower and higher temperatures or lower and higher RH values. In contrast, the new DE, DEA-P (mixture of two natural substances, i.e., abamectin, freshwater DE) was used as a powder in the tests and was very effective against adults of P. truncatus, while this efficacy was not affected by temperature and RH at considerably lower doses as compared to other DEs. Furthermore, Kavallieratos et al. (2015) found that DEA-P was very effective for the control of other major stored-product beetle species, i.e., the rice weevil, Sitophilus oryzae (L.) (Coleoptera: Curculionidae), and R. dominica.
Previous studies have clearly documented that the type of commodity highly affects the efficacy of a given DE. For instance, Athanassiou and Kavallieratos (2005) reported that the DE PyriSec was not equally effective against R. dominica, when tested on eight different grains. Apart from different grain species, Kavallieratos et al. (2010) found that DEs provide different efficacy levels when applied at different wheat varieties, and this trend is manifested in more than one DE. In that study, the DEs Insecto, SilicoSec, and Protector differed in their efficacy against R. dominica, S. oryzae, and the confused flour beetle, Tribolium confusum Jacquelin du Val (Coleoptera: Tenebrionidae), regardless of the tested dose and the exposure interval. This characteristic is likely to be expressed more vigorously in the case of maize, due to the reduced efficacy of DEs on this commodity (Vayias and Stephou 2009). Thus, despite the fact that a given DE may provide a satisfactory level of efficacy, its effectiveness may be seriously moderated by the specific properties of the maize hybrid on which the DE is applied. In this context, there is still inadequate information on the comparison of maize hybrids in conjunction with DEs against P. truncatus. Therefore, the objective of the present study was to test three commercially available DEs on five different maize hybrids, for the eco-friendly control of P. truncatus adults. In addition to the efficacy levels, we also examined the progeny production of P. truncatus in both treated and untreated hybrids, the effect of the presence of P. truncatus to some properties of the infested maize hybrids and the adherence level of the tested DEs to the kernels.
Materials and methods
Insects and commodities
Adults of P. trunctatus, <1 week old, were used in the tests from a colony that was started in 2003 at the Laboratory of Agricultural Entomology, Benaki Phytopathological Institute and later was kept at the Laboratory of Agricultural Zoology and Entomology, Agricultural University of Athens since 2014. The insects were reared on whole maize at 30 °C, 65% RH at continuous darkness. The following untreated, clean, and free of infestations hybrids of maize Zea mays L. were used in the tests: the late Calaria (FAO 620), having 122–127 days biological cycle (i.e., days till physiological maturity), the late Doxa (FAO 750), having 138–140 days biological cycle, the late Rio Grande (FAO 700), having 130–135 days biological cycle, the semi-early Sisco (FAO 400), having 102 days biological cycle, and the late Studio (FAO 700), having 130–135 days biological cycle. All hybrids were provided by the Institute of Plant Breeding and Phytogenetic Resources, Hellenic Agricultural Organization “Demeter” (Thermi, Greece). Prior to the initiation of the experimentation, the maize hybrids were kept at 30 °C and 65% RH for 2 weeks to equilibrate their moisture content (Athanassiou et al. 2007).
DEs
The following three DEs were used in the experiments: (a) DEA-P, (b) Protect-It, and (c) PyriSec. DEA-P (Research and Consulting Inc., Toronto, ON, Canada) is a mixture of abamectin (MSD Agvet Division Merck and Co., Rahway, NJ, USA) and freshwater DE that contains 92.4% SiO2 (Kavallieratos et al. 2015). Protect-It (Hedley Technologies Inc., Mississauga, ON, Canada) is a DE that contains 83.7% SiO2 with 10% silica aerogel (Korunic and Fields 1995). PyriSec (Agrinova Gmbh, Obrigheim/Mühleim, Germany) contains natural pyrethrum, piperonyl butoxide, and SilicoSec, which is a DE of freshwater origin containing 92% SiO2 (Kavallieratos et al. 2007).
Bioassays
DEA-P was applied at 75 and 150 ppm while Protect-It and PyriSec at 500 ppm. For this purpose, lots of 1-kg grains each were prepared for each maize hybrid, DE, and dose. The lots were separately placed into 5 l glass jars. The DEs corresponding to each dose were placed into the jars. Following this, each jar was shaken manually for 5 min to achieve equal distribution of the DE particles on maize kernels. An additional series of untreated maize hybrid lots were used as controls. The three maize hybrid samples, of 50 g each, were taken from each treated or untreated lot and separately put into three glass vials, of 100 ml capacity each, with a different scoop that was inside each jar. All quantities of maize hybrids were weighed with a Precisa XB3200D compact balance (Alpha Analytical Instruments, Gerakas, Greece). Then, 50 P. truncatus adults were introduced into each vial. To prevent insects to escape, the internal “necks” of the vials were covered by polytetrafluoroethylene (60 wt% dispersion in water) (Sigma-Aldrich Chemie GmbH, Taufkirchen, Germany). The closure of each vial had a 2-cm diameter hole in the center that was covered by gauze to allow sufficient aeration inside the vial. All vials were placed into incubators set at 30 °C and 65% RH during the entire experimental period. The mortality of adult individuals was determined after 7 and 14 days of exposure. At each mortality check date, the content of each vial was carefully moved onto a different plastic dish (145 mm diameter) where it was spread as a layer with a brush. The internal “necks” of the dishes were covered by polytetrafluoroethylene as in the case of vials. Then, mortality was evaluated under an Olympus stereo microscope (SZX9, Bacacos S.A., Athens, Greece) by prodding each individual with a brush to detect any movement. After the examination of each dish, its content was carefully relocated back to the corresponding vial. Different brushes were used for each DE treatment and untreated controls. Dead individuals were discarded. After the 14-day mortality counts, all parental adults were discarded and vials returned into the incubators at the same conditions for 46 days. Then, the vials were opened and progeny production was estimated as described above. After insect counting, the number of kernels with or without holes and the number of holes per kernel made by P. truncatus were counted. Also, the kernels with or without holes were weighed using the Precisa XB3200D compact balance. The experiments were repeated three times, by preparing new lots, jars, and vials each time.
Adherence of DE to kernels
For the estimation of the adherence level of the tested DEs to the kernels, 500 g of each clean maize hybrid kernels were weighed. Next, the maize kernels of each hybrid were mixed with 0.5 g DEA-P or Protect-It or PyriSec in a well-closed glass vial and manually shaken for 1 min. Following this, each treated maize hybrid was sieved using a No. 10 sieve (2 mm openings, Retsch GmbH and Co., KG, Germany), with a closed cap and base, for 1 min, and the dust was collected and weighed. This amount was expressed as the percentage of DE adherence to each maize hybrid. The whole procedure was repeated six times for each DE and maize hybrid combination (Korunić 1997).
Data analysis
Control mortality was low (<5%), thus no correction was done for the mortality counts. The data were analyzed according to the repeated measures model (Sall et al. 2001). The repeated factor was the exposure interval, while mortality was the response variable. Maize hybrid and DE were the main effects. Progeny production counts were subjected to a two-way ANOVA, with maize hybrid, and DE as main effects. Progeny production in the untreated control vials was included in the analyses. Data for DEs adherence were subjected to a two-way ANOVA, with adherence (%) as response variable and maize hybrid and DE as main effects. For holes in the kernels and weight of kernels, two-way ANOVA was used, with number of kernels without holes, amount (g) of kernels without holes, number of kernels with holes, amount (g) of kernels with holes, and number of holes per kernel as response variables, and maize hybrid, and DE as main effects. In all cases, the associated interactions of main effects were incorporated in the analyses. All analyses were conducted by using the JMP 11 software (SAS Institute Inc. 2013). Means were separated by the Tukey-Kramer (HSD) test at 0.05 probability (Sokal and Rohlf 1995).
Results
Mortality and progeny of P. truncatus adults
Between exposure intervals, the main effect DE was significant (Table 1). Within exposure intervals, the main effect exposure x DE and the associated interaction exposure x maize hybrid x DE were significant. After 7 days of exposure, mortalities of P. truncatus adults were very high (≥98%) on all maize hybrids treated with DEA-P at any dose and significantly higher than those caused by Protect-It or PyriSec (Table 2). Indicatively, the maximum mortalities caused by Protect-It and PyriSec were 55.1 and 45.1% on Sisco and Studio, respectively. After 14 days of exposure, all P. truncatus adults died on Calaria, Doxa, Sisco, and Studio treated with 150 ppm DEA-P while the mortality did not exceed 61.6 and 56.9% in the cases of Sisco and Studio that were treated with Protect-It and PyriSec, respectively. No significant differences among P. truncatus adult mortality were observed on maize hybrids treated with any DE and exposure interval.
Concerning progeny production, the main effect DE was significant (F 4, 224 = 20.8, P < 0.01) while the main effect maize hybrid and the associated interaction maize hybrid x DE were not significant (F 4, 224 = 1.1, P = 0.34 and F 16, 224 = 0.1, P = 0.97, respectively). No or very low overall progeny production was noted on maize hybrids treated with DEA-P at any dose while the progeny was elevated in the cases of Protect-It (range, 61.0–104.6 adults per vial) or PyriSec (range, 32.6–111.9 adults per vial) (Table 3). No significant differences in offspring production were observed among maize hybrids treated with any DE.
Holes in kernels and weight of kernels by the activity of P. truncatus
For number of kernels without holes, the main effects were significant (Table 4). Significantly more kernels without holes were noted when all maize hybrids were treated with DEA-P at both doses than with Protect-It and PyriSec or remained untreated (Table 5). Treated Doxa and Sisco with either 75 or 150 ppm DEA-P showed significantly more kernels without holes than Calaria, Rio Grande, and Studio.
For weight of kernels without holes, the main effect DE was significant (Table 4). The kernels of all maize hybrids that were treated with both doses of DEA-P and found without holes were significantly heavier than the corresponding ones treated with Protect-It and PyriSec or the control kernels (Table 6). The overall weight of the former case of kernels ranged between 44.7 and 49.0 g while in the latter weight ranged between 23.0 and 37.5 g.
Concerning the number of kernels bearing holes, the main effect DE was significant (Table 4). Less than one kernel per vial with holes was found in vials that contained any maize hybrid treated with DEA-P (Table 7). No kernels with holes were found when Rio Grande was treated with DEA-P at both tested doses. In contrast, in the cases of all untreated hybrid maize kernels or treated with Protect-It or PyriSec, the numbers of kernels bearing holes per vial ranged from 28.1 to 53.0 and were always significantly higher than the corresponding numbers dealing with DEA-P.
For weight of kernels with holes, the main effect DE was significant (Table 4). The overall weight values of kernels with holes per vial did not exceed 0.2 g for all maize hybrids that had been treated with DEA-P at both doses and always were significantly lower than the values measured for maize hybrids remained untreated or treated with Protect-It or PyriSec (Table 8). No significant differences within maize hybrids were noted with the exception of DEA-P at 150 ppm.
For numbers of holes per kernel, all main effects and the associated interaction were significant (Table 4). Maize hybrid kernels that had been treated with DEA-P at both doses suffered by significantly less holes per kernel than kernels that remained untreated or treated with Ptotect-It and PyriSec (Table 9). Significantly less holes were counted on Sisco kernels than on Calaria kernels treated with Protect-It.
DE adherence
The main effects maize hybrid and DE and the associate interaction maize hybrid x DE were significant (F 4, 75 = 18.4, P < 0.01; F 2, 75 = 22.9, P < 0.01; F 8, 75 = 2.5, P = 0.01, respectively). Significantly higher retention of DEA-P than Protect-It and PyriSec was recorded in Doxa and Rio Grande (Table 10). Although no significant differences in the degree of adherence were found among the three tested DEs in Calaria, Sisco, and Studio, DEA-P always adhered more on these maize hybrids than Protect-It and PyriSec.
Discussion
It is well addressed that DEs have certain major advantages, i.e., they have nontoxic mode of action, they reach consumers cleansed from possible residues due to the overall procession of grains, and there is a high level of safety when instructions of use are followed properly (Korunić 2013). The present study is the first attempt to report on the simultaneous evaluation of the efficacy of DEs applied as grain protectants on several maize hybrids against P. truncatus. DEs exhibit reduced effect as maize protectants. For example Athanassiou et al. (2003) showed that the DE SilicoSec was considerably less effective on maize than on barley or rice, against adults of S. oryzae. Also, additional studies clearly indicate that DEs are generally less effective on maize than on other grains (Vayias et al. 2006; Vayias and Stephou 2009; Kavallieratos et al. 2015). Apart from DEs, there are studies showing that some grain protectants are less effective on maize, as compared with other grains, i.e., chlorfenapyr against R. dominica and S. oryzae (Kavallieratos et al. 2011), novel pyrrole derivatives against the Mediterranean flour moth, Ephestia kuehniella Zeller and T. confusum (Boukouvala et al. 2017), spinosad against S. oryzae (Chintzoglou et al. 2008), and spinetoram against S. oryzae (Vassilakos et al. 2015). Nevertheless, the factors that are responsible for this reduced efficacy of DEs on maize are poorly understood. In an earlier study, Athanassiou and Kavallieratos (2005), by using PyriSec, found that the adherence of this DE was significantly lower on maize than on barley, oats, rice, rye, triticale, and wheat, which means that the retention of DE particles is less on the external part of maize kernels than on the external part of the kernels of other grains. In this regard, we assume that there are specific interactions of DE particles with the external part of the maize kernel, which do not exist in the case of other grains. For spinosad, Chintzoglou et al. (2008), by using high-performance liquid chromatography/mass spectrometry method (LC/MS), noted that dissipation of the insecticide was higher on maize than on barley and wheat.
Our study shows that DE application can be very effective for the control of P. truncatus in several maize hybrids. In light of our findings, DEA-P was highly effective at low doses, if compared to those currently used for other DEs. For example, a considerable proportion of the exposed P. truncatus adults was still alive after 14 days of exposure on all maize hybrids treated with 500 ppm of Protect-It, even though it was 3.3 times higher than the maximal application tested dose of DEA-P. Similar results have been also found for PyriSec; this DE contains natural pyrethrum and has been proved more effective than many of the commonly used commercial DEs against different stored-product pests (Kavallieratos et al. 2007). On the other hand, DEA-P was very effective at dose rates as low as 75 ppm, given that mortality was 98% or higher, after 7 days of exposure, regardless of the hybrid tested. In fact, the increase of DEA-P dose to 150 ppm did not increase mortality further, which clearly suggests that 75 ppm can be used with success for the control of P. truncatus. These results support previous findings documenting that the new enhanced DEA-P was highly effective for the control of this species (Athanassiou et al. 2007). Apart from parental mortality, DEA-P was able to reduce P. truncatus progeny production in all hybrids. In fact, in most of the cases tested, progeny production was completely suppressed (100%), while in the cases where progeny was recorded, its numbers did not exceed 0.2 adults per vial. In contrast, for the other two DEs, progeny production was extremely high and did not differ than that in the control vials in almost all cases. This high suppression of progeny production for DEA-P is related with the increased parental mortality. Apparently, the high level of efficacy of DEA-P is mainly due to the presence of abamectin in the formulation. Abamectin, a neurotoxic insecticide that acts as an agonist to GABA receptors (White et al. 1997) has been found very effective for the control of stored-product insects. In an earlier study, Kavallieratos et al. (2009) noted that for R. dominica, abamectin caused 100% parental adult mortality on maize treated with 1 ppm at 20 and 30 °C. Abamectin, however, is not registered so far for direct application on grains, but it is formulated and registered against agricultural pests (i.e., leafminers, psyllids, thrips, and mites). Probably its use could be assessed in combination with other active ingredients. The same holds in the case of thiamethoxam, which is not registered as a grain protectant in Europe, but it is registered as a mixture with pirimiphos-methyl in Africa (Chigoverah et al. 2014).
Based on our results, given that the adherence ratios were always higher for DEA-P than Protect-It or PyriSec to all maize hybrids and that mortality levels along with progeny production were always by far higher and lower respectively than Protect-It or PyriSec on all maize hybrids, it can be concluded that adherence is probably a factor that determines the differences in the efficacy of DEA-P. Similar results have been found for the DE Insecto when it was applied on two wheat varieties (Athos and Pontos) against R. dominica, S. oryzae, and T. confusum (Kavallieratos et al. 2010). On the other hand, grain damage indices could be used as reliable indicators of insect infestation patterns and also varietal resistance (Throne et al. 2000). The number of maize kernels without holes showed that the presence of DEs reduced the infestation rates in most of the cases examined and also that DEA-P had the highest numbers of kernels (or weight of kernels) without holes. At the same time, the increase of the dose rate of DEA-P did not result in further decrease of infestation patterns. The number and weight of kernels with holes or the number of holes per kernel, illustrate more clearly the differences among DEs but also among hybrids. In this context, Doxa and Sisco performed better than Calaria, Rio Grande, or Studio based on the significant differences found concerning the numbers of kernels without holes at both doses of DEA-P tested. This trend was also evident when maize hybrids remained untreated or were treated with Protect-It, although no significant differences were detected. An additional indication about the adequacy of 75 ppm for the management of P. truncatus is provided by the fact that no significant differences were found in the number of kernels without holes with the 150 ppm treatment of any maize hybrid. For PyriSec and Protect-It, the numbers of kernels with holes and the weight of kernels with holes were comparable with those in the control vials, which further consists the reduced insecticidal effect of these DEs against P. truncatus.
Variant susceptibility of different varieties or hybrids of grains to stored-product insects, in conjunction with the application of contact insecticides, has not been examined in detail. In an earlier study, Kavallieratos et al. (2010) compared three wheat varieties, Athos, Pontos, and Sifnos regarding the insecticidal effect of three DEs and spinosad dust and found that all four insecticides were less effective when applied on Pontos for the control of R. dominica, S. oryzae, and T. confusum. Similarly, Fang et al. (2002) found that the insecticidal effect of liquid spinosad differed remarkably among different classes of wheat. These variations are manifested at two levels. Some stored-product insects are more prone to thrive in certain commodities. In this regard, population growth can be elevated in certain commodities. For example, Opit and Throne (2008) found that population growth of Lepinotus reticulatus Enderlein (Psocoptera: Trogiidae) was higher on oats, rice, barley, milo, and wheat than on maize. For some commodities, there are specific interactions with certain insecticides, which, indirectly, affect their insecticidal effect (Chintzoglou et al. 2008). Nevertheless, it is still unclear whether variations in insect mortality are correlated with some physical and chemical characteristics of the commodity. For DEs and spinosad, Kavallieratos et al. (2010) found that among three wheat varieties, survival of R. dominica, S. oryzae, and T. confusum was greater on the one that had a highest gluten index and kernel size. However, in that study, the authors did not found any relation between insecticidal effect and other grain properties, such as protein content. Similarly, Fang et al. (2002) found that there was no correlation between the insecticidal effects of spinosad against the saw-toothed grain beetle, Oryzaephilus surinamensis (L.) (Coleoptera: Silvanidae), the Indian mealmoth, Plodia interpunctella (Hübner) (Lepidoptera: Pyralidae), R. dominica, S. oryzae, and the red flour beetle, Tribolium castaneum (Herbst) (Coleoptera: Tenebrionidae) with some of wheat characteristics, such as kernel diameter, kernel hardness, kernel weight, protein content, dockage, and fiber. McGaughey et al. (1990) noted that kernel hardness negatively affected the oviposition of S. oryzae but not that of R. dominica. Still, the results for the effect of kernel characteristics on population growth of stored-product insects are not always consistent, and they are often controversial (Bhatia and Gupta 1969, Amos et al. 1986, Sinha et al. 1988, Throne et al. 2000, Toews et al. 2000). Our data indicate not only that the tested DEs had generally similar performance among maize hybrids but also that any differences observed in mortality, and progeny production could be mainly attributed to the characteristics of the formulations per se.
Overall, the findings of the present study show that DEA-P is very effective for the control of P. truncatus in a wide range of maize hybrids. At the same time, P. truncatus population growth was practically completely suppressed on the treated grains. The fact that DEA-P is effective at dose rates that are notably lower than other DEs means that the use of DEA-P may affect only minimally the test weight of the treated grains, which is the main disadvantage of DEs in “real world” applications by degrading their commercial value (Korunić 2016). In this regard, DEA-P and abamectin should be more thoroughly examined on the basis of potential registration at the post-harvest stages of agricultural commodities.
References
Amos TG, Semple RL, Williams P (1986) Multiplication of some stored grain insects on varieties of wheat. Gen Appl Entomol 18:48–52
Arnaud L, Lan HTT, Brostaux Y, Haubruge E (2005) Efficacy of diatomaceous earth formulations admixed with grain against populations of Tribolium castaneum. J Stored Prod Res 41:121–130
Arthur FH (2001) Immediate and delayed mortality of Oryzaephilus surinamensis (L.) exposed on wheat treated with diatomaceous earth: effects of temperature, relative humidity and exposure interval. J Stored Prod Res 37:13–21
Arthur FH (2012) Aerosols and contact insecticides as alternatives to methyl bromide in flour mills, processing plants, and food warehouses. J Pest Sci 85:323–329
Athanassiou CG, Kavallieratos NG (2005) Insecticidal effect and adherence of PyriSec in different grain commodities. Crop Prot 24:703–710
Athanassiou CG, Kavallieratos NG, Peteinatos GG, Petrou SE, Boukouvala MC, Tomanović Ž (2007) Influence of temperature and humidity on insecticidal effect of three diatomaceous earth formulations against larger grain borer (Coleoptera: Bostrychidae). J Econ Entomol 100:599–603
Athanassiou CG, Kavallieratos NG, Tsaganou FC, Vayias BJ, Dimizas CB, Buchelos CT (2003) Effect of grain type on the insecticidal efficacy of diatomaceous earth against Sitophilus oryzae (L.) (Coleoptera: Curculionidae). Crop Prot 22:1141–1147
Bhatia SK, Gupta M (1969) Resistance to stored grain pests in world collection of wheat-relative susceptibility of nine high yielding dwarf varieties to the rice weevil and the lesser grain borer. Bull Grain Technol 7:199–204
Borgemeister C, Adda C, Djomamou B, Degbey P, Agbaka A, Djossou F, Meikle WG, Markham RH (1994) The effect of maize cob selection and the impact of field infestation on stored maize losses by larger grain borer (Prostephanus truncatus [Horn] Coleoptera: Bostrichidae) and associated storage pests. In: Proceedings of the 6th international working conference on stored-product protection, 17–23 April 1994, Canberra, Australia, pp 906–909
Borgemeister C, Tchabi A, Scholz D (1998) Trees or stores? The origin of migrating Prostephanus truncatus collected in different ecological habitats in southern Bebin. Entomol Exp Appl 87:285–294
Boukouvala MC, Kavallieratos NG, Athanassiou CG, Losic D, Hadjiarapoglou LP, Elemes Y (2017) Insecticidal effect of two novel pyrrole derivatives against two major stored product insect species. Laboratory evaluation of five novel pyrrole derivatives as grain protectants against Tribolium confusum and Ephestia kuehniella larvae. J Pest Sci 90:569–585
Chanbang Y, Arthur FH, Wilde GE, Throne JE (2007) Efficacy of diatomaceous earth to control Rhyzopertha dominica (F.) (Coleoptera: Bostrichidae) in rough rice: impacts of temperature and relative humidity. Crop Prot 26:923–929
Chigoverah AA, Mvumi BM, Kebede AT, Tefera T (2014) Effect of hermetic facilities on stored maize insect infestation and grain quality. In: Proceedings of the 11th international working conference on stored-product protection, 24–28 November 2014, Chiang Mai, Thailand, pp 385–386
Chintzoglou GJ, Athanassiou CG, Markoglou AN, Kavallieratos NG (2008) Influence of commodity on the effect of spinosad dust against Rhyzopertha dominica (F.) (Coleoptera: Bostrychidae) and Sitophilus oryzae (L.) (Coleoptera: Curculionidae). Int J Pest Manag 54:277–285
Cook DA, Armitage DM (1999) The efficacy of Dryacide, an inert dust, against two species of astigmatid mites, Glycyphagus destructor and Acarus siro, at nine temperature and moisture content combinations on stored grain. Exp Appl Acarol 23:51–63
Doumbia M, Douan BG, Kwadjo KE, Kra DK, Martel V, Dagnogo M (2014) Effectiveness of diatomaceous earth for control of Sitophilus zeamais (Coleoptera: Curculionidae), Tribolium castaneum and Palorus subdepressus (Coleoptera: Tenebrionidae). J Stored Prod Res 57:1–5
Dunstan WR, Magazini IA (1981) The larger grain borer on stored products in Tanzania. FAO Plant Prot Bull 29:80–81
EPPO (European and Mediterranean Plant Protection Organization) (2017) EPPO global data base. Prostephanus truncatus. https://gd.eppo.int/taxon/PROETR/distribution. Accessed 10 Mar 2017
Fang L, Subramanyam B, Arthur FH (2002) Effectiveness of spinosad on four classes of wheat against five stored-product insects. J Econ Entomol 95:640–650
Frederick JL, Subramanyam B (2016) Influence of temperature and application rate on efficacy of a diatomaceous earth formulation against Tribolium castaneum adults. J Stored Prod Res 69:86–90
Golob P (2002) Chemical, physical and cultural control of Prostephanus truncatus. Int Pest Manag Rev 7:245–277
Hill DS (2003) Pests of storage foodstuffs and their control. Kluwer Academic Publishers, New York
Hill MG, Borgemeister C, Nansen C (2002) Ecological studies on the larger garin borer, Prostephanus truncatus (Horn) (Coleoptera: Bostrichidae) and their implications for integrated pest management. Int Pest Manag Rev 7:201–221
Kavallieratos NG, Athanassiou CG, Hatzikonstantinou AN, Kavallieratou HN (2011) Abiotic and biotic factors affect efficacy of chlorfenapyr for control of stored-product insect pests. J Food Prot 74:1288–1299
Kavallieratos NG, Athanassiou CG, Korunic Z, Mikeli NH (2015) Evaluation of three novel diatomaceous earths against three stored-grain beetle species on wheat and maize. Crop Prot 75:132–138
Kavallieratos NG, Athanassiou CG, Vayias BJ, Kotzamanidis S, Synodis SD (2010) Efficacy and adherence ratio of diatomaceous earth and spinosad in three wheat varieties against three stored-product insect pests. J Stored Prod Res 46:73–80
Kavallieratos NG, Athanassiou CG, Vayias BJ, Maistrou SN (2007) Influence of temperature on susceptibility of Tribolium confusum (Coleoptera: Tenebrionidae) populations to three modified diatomaceous earth formulations. Fla Entomol 90:616–625
Kavallieratos NG, Athanassiou CG, Vayias ΒJ, Mihail S, Tomanović Ž (2009) Insecticidal efficacy of abamectin against three stored product insect pests: influence of dose rate, temperature, commodity and exposure interval. J Econ Entomol 102:1352–1359
Korunić Z (1997) Rapid assessment of the insecticidal value of diatomaceous earths without conducting bioassays. J Stored Prod Res 33:219–229
Korunic Z (1998) Diatomaceous earths, a group of natural insecticides. J Stored Prod Res 34:87–97
Korunić Z (2013) Diatomaceous earths—natural insecticides. Pestic Phytomed 28:77–95
Korunić Z (2016) Overview of undesirable effects of using diatomaceous earths for direct mixing with grains. Pestic Phytomed 31:9–18
Korunic Z, Fields PG (1995) Diatomaceous earth insecticidal composition. USA patent 5(773):017
McGaughey WH, Speirs RD, Martin CR (1990) Susceptibility of classes of wheat grown in the United States to stored-grain insects. J Econ Entomol 83:1122–1127
Muatinte BL, Van den Berg J, Santos LA (2014) Prostephanus truncatus in Africa: a review of biological trends and perspectives on future pest management strategies. Afr Crop Sci J 22:237–256
Myers SW, Hagstrum DW (2012) Quarantine. In: Hagstrum DW, Phillips TW, Cuperus G (eds) Stored product protection. Kansas State University, Manhattan, pp 297–304
Nansen C, Meikle WG (2002) The biology of the larger grain borer, Prostephanus truncatus (Horn) (Coleoptera: Bostichidae). Int Pest Manag Rev 7:91–104
Opit GP, Throne JE (2008) Effects of diet on population growth of psocids Lepinitus reticulates and Liposcelis entomophila. J Econ Entomol 101:616–622
Rumbos CI, Dutton AC, Athanassiou CG (2013) Comparison of two pirimiphos-methyl formulations against major stored-product insect species. J Stored Prod Res 55:106–115
Round FE, Crawford RM, Mann DG (1990) The diatoms. Cambridge University Press, Cambridge
Sall J, Lehman A, Creighton L (2001) JMP start statistics, A guide to statistics and data analysis using JMP and JMP IN software. Duxbury Press, Belmont
SAS Institute Inc (2013) Using JMP 11. SAS Institute Inc, Cary
Sinha RN, Demianyk CJ, McKenzie RIH (1988) Vulnerability of common wheat cultivars to major stored-product beetles. Can J Plant Sci 68:337–343
Sokal RR, Rohlf FJ (1995) Biometry, 3rd edn. Freedman & Company, New York
Stathers TE, Denniff M, Golob P (2004) The efficacy and persistence of diatomaceous earth admixed with commodity against four tropical stored product beetle pests. J Stored Prod Res 40:113–123
Throne JE, Baker JE, Messina FJ, Kramer KJ, Howard JA (2000) Varietal resistance. In: Subramanyam B, Hagstrum DW (eds) Alternatives to pesticides in stored product IPM. Kluwer Academic Publishers, Norwell, pp 167–192
Toews MD, Cuperus GW, Phillips TW (2000) Susceptibility of eight U.S. wheat cultivars to infestation by Rhyzopertha dominica (Coleoptera: Bostrichidae). Environ Entomol 29:250–255
Tyler PS, Hodges RJ (2002) Phytosanitary measures against larger grain borer, Prostephanus truncatus (Horn) (Coleoptera: Bostrichidae), in international trade. Int Pest Manag Rev 7:279–289
Vassilakos TN, Athanassiou CG, Tsiropoulos NG (2015) Influence of grain type on the efficacy of spinetoram for the control of Rhyzopertha dominica, Sitophilus granarius and Sitophilus oryzae. J Stored Prod Res 64:1–7
Vayias BJ, Athanassiou CG, Kavallieratos NG, Tsesmeli CD, Buchelos CT (2006) Persistence and efficacy of two diatomaceous earth formulations and a mixture of diatomaceous earth with natural pyrethrum against Tribolium confusum Jacquelin du Val (Coleoptera: Tenebrionidae) on wheat and maize. Pest Manag Sci 62:456–464
Vayias BJ, Stephou VK (2009) Factors affecting the insecticidal efficacy of an enhanced diatomaceous earth formulation against three stored-product insect species. J Stored Prod Res 45:226–231
White SM, Dunbar DM, Brown R, Cartwright B, Cox D, Eckel C, Jansson RK, Moorkerjee PK, Norton JA, Peterson RF, Starner VR (1997) Emamectin benzoate: a novel avermectin derivative for control of lepidopterous pests in cotton. In: Proceedings of beltwide cotton conference, 7–10 January 1997, New Orleans, USA, pp 1078–1082
Acknowledgements
This work was partially supported by the project “Control of stored products insects” (Hellenic Ministry of Rural Development and Food, Directorate of Plant Protection).
Author information
Authors and Affiliations
Corresponding author
Additional information
Responsible editor: Philippe Garrigues
Rights and permissions
About this article
Cite this article
Kavallieratos, N.G., Athanassiou, C.G., Peteinatos, G.G. et al. Insecticidal effect and impact of fitness of three diatomaceous earths on different maize hybrids for the eco-friendly control of the invasive stored-product pest Prostephanus truncatus (Horn). Environ Sci Pollut Res 25, 10407–10417 (2018). https://doi.org/10.1007/s11356-017-9565-5
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11356-017-9565-5