Abstract
A minimal linear gene cassette (35S-phytase gene-nos) with T-DNA borders was acquired by PCR and directly introduced into soybean through the pollen tube pathway. A total of 13% of T1 plants were positive for phyA by specific PCR. Southern blot analyses showed that phyA insertions were harbored stably in T2 progeny. Phytase expression level increased 2.5-fold over a 6-week period; its highest activity was 150 U/mg protein, compared to 56 U/mg protein in untransformed controls. Activity of phytase increased to 125 FTU/kg in T3 transgenic seeds as compared to 64 FTU/kg in wild-type plants.
Similar content being viewed by others
Avoid common mistakes on your manuscript.
Introduction
Although it has adequate phosphate and protein content to meet animal and human growth requirements, up to 80% of total phosphorus in soybean is contained in phytate during seed maturation (Li et al. 1997) and phytate protein complex accounts for approximately 1% of the total weight in dry seeds (Hegeman and Grabau 2001). Phytate is largely indigestible by monogastric animals because they have no or limited phytase activity in their digestive tracts. The widespread use of soybean meal in livestock feed leads to serious environmental consequences. Introducing phytase genes into soybean meal can improve the bioavailability of phosphates and proteins and reduce phytic acid excretion, providing a less expensive alternative to phytase supplementation.
At present, in almost all processes of plant transformation, dominant selectable markers are used to select transgenic cells. However, this methodology has raised public concerns that the markers will be transferred to other organisms (Nap et al. 2003; Thompson 2000), although there is no evidence suggesting that the currently used antibiotic resistance markers pose any risks to humans, animals or the environment (Miki and McHugh 2004). In addition, routine transformation integrates vector backbone sequences into the genome that could lead to undesirable effects in situ (Kononov et al. 1997; Tingay et al. 1997), such as transgene rearrangements and multiple copies. It is common practice to remove all vector sequences before microinjecting foreign DNA into animal eggs or embryos (Palmiter and Brinster 1986).
The technique of pollen tube pathway transformation has been applied since 1978 (Wang et al. 2004; Luo and Wu 1989). Bt cottons produced by this technique have been commercially available since 1996. This tissue culture-independent procedure, which is more suitable for crops like soybean with low regeneration rates (Franklin et al. 2004), is simple, rapid and efficient.
This study describes the production of transgenic soybean expressing phytase using minimal linear transgene constructs that lack selectable markers and vector backbone sequences (“clean” DNA). This is the first report using minimal linear DNA fragment technology for the production of transgenic plants.
Materials and methods
Gene constructs
A full length phytase gene (GenBank accession no. DQ192035) was amplified from the strain Aspergillus awamori 3.324 by PCR. Phytase gene (PhyA) open reading frame was generated using the 5′ end primer 5′-GTTCTAGAGCCATGGGTGTCTCTGCCGTTCTACTTCCTTTGTACCTCCTGTCCGGAAGTCACCTCCGGACTGGCAG-3′ and the 3′ end primer 5′-GCCACGTGCTAAGCAAAACACTCCGCCCAATG-3′. A synthetic Kozak sequence GCCATGG for initiation of translation was placed right upstream of the codon beginning region, and the Xbal and SacI restriction sites were introduced into the 5′ and 3′ ends, respectively. The SacI restriction site in phyA was modified by PCR (GAGCTC changed to GAACTC). XbaI- and SacI-digested PhyA was subcloned into the pBI121 (CLONTECH) vector to obtain the expression construct pBI121-phyA.
The minimal transgene expression cassette was obtained (Fig. 1) from the above plasmid by PCR using the primer 1: 5′-GTTTACCCGCCAATATATCCTGTCATCTAGAGCCATGGGTGTCTCTGCCGTTC-3′; and primer 6: 5′-TGGCAGGATATATTGTGGTGTAAACA-3′. PCR amplification products were separated on 1% agarose gel and then purified using the Qiaex II agarose gel extraction kit (Qiagen).
Plant material and transformation
Transformation experiments were conducted with Chinese soybean cultivar genotypes Liaodou13, Liaodou14 and Tiefeng29, which were all kindly provided by Liaoning Academy of Agricultural Sciences in China. All experiments were performed on fresh flowers such that the height of the corolla was greater than that of the calyx. Two wing petals and one keel petal were removed to expose the stigmas of soybean flowers. The style and the top of the ovary were cut off, and the exposed ovary was dipped into 7 μl of the gene construct DNA solution (300 μg/ml). Treated flowers were tagged, and untreated flowers and buds at the same node were removed. The pods that developed from the treated flowers were harvested individually. Seeds derived from plants treated with 0.1 × SSC (3 M NaCl, 0.3 M sodium citrate, 1 mM EDTA) were harvested as negative controls.
Identification of transgenic plants by PCR
Genomic DNA was extracted from young leaf tissues using a modified CTAB method (Reichandt and Rogers 1994) for PCR analysis. PCR amplifications for detection of the minimal phyA expression cassette were achieved with the primer 4 (5′-GAGAGACACGCCAGACAAG-3′) spanning bases 741–759 of phyA in combination with either primer 3 (5′-CCAAGGGCAAGAAATACTCC-3′) or primer 2 (5′-CCACTATCCTTCGCAAGACC-3′), which correspond to bases 272–291 of phyA and 773–792 of CaMV 35S promoter, respectively (Fig. 1). The expected amplification fragments were 488 bp and 850 bp long.
Southern blot analysis
Genomic DNA was isolated from young leaves of transgenic and untransformed control plants using Plant DNA Extraction Kit (Roche). Integration of the phytase transgene was analyzed by digesting genomic DNA (∼20 μg) with appropriate restriction enzymes. The digested DNA was separated on a 1% agarose gel and transferred onto Hybond N+ membranes (Amersham Biosciences). The probe (Fig. 1) for phyA was generated by PCR using primer 3 and primer 4, the fragment was purified using the Qiaex II agarose gel extraction kit (Qiagen). Hybridization was performed at 42°C using ECL blotting kit following the manufacturer’s instructions (Pharmacia, Germany).
RNA isolation and RT-PCR
RNA was isolated from leaves of 4-week-old plants using Trizol kit (GIBCO) following the manufacturer’s instructions, and cDNA was synthesized from 2 μg RNA with the parameters of AMV reverse transcriptase along with Random 9mers (RNA PCR Kit Ver.2.1, TaKaRa). PCR on cDNA was performed using primers 3 and primers 5 (5′-ACAGCCATGCAGCGGAACAA-3′, corresponding to the region of 1292–1311 bp of phyA) (Fig. 1). The amplified fragments were 1040 bp long. Actin gene was also amplified as a native control using the forward primer (5′-CTCAACCCAAAGGTCAACAG-3′) and reverse primer (5′-ACCATCACCAGAGTCCAATA-3′).
Phytase activity assay
Total proteins were extracted from leaves (1 mg fresh sample) using 5 ml acetate buffer (50 mM sodium acetate, pH 5.5, 10 mM CaCl2, 1 mM PMSF). The homogenate was centrifuged at 12,000g for 20 min at 4°C, the supernatant was collected, and total protein concentration was determined by the Bradford method. Phytase activity was assayed using the molybdate-blue reaction method (Murphy and Riley 1962) and measured at 820 nm. Phytase activities were expressed as Units per mg total protein.
Mature seeds were milled and protein was extracted from 0.25 g flour by adding 2.5 ml 50 mM sodium acetate buffer (pH 5.5), including 10 mM CaCl2, 1 mM PMSF and Tween 20 (100 mg/l). The suspension was vortexed gently for 30 min at 4°C and centrifuged at 5,000g for 10 min. The supernatant was collected and assayed for phytase activity as Unit per kg seed.
Enzyme thermal stability
The thermal stabilities of the crude extracts from transgenic plants were compared with untransformed soybeans. All samples were pre-incubated for 10 min 37–90°C in a reaction mixture without sodium phytate, and allowed to cool to room temperature. Phytase activity was then assayed at 37°C, and pH 5.5.
Immunodetection of phytase
Total leaf protein (10 μg) was separated on 10% SDS-PAGE and transferred to nitrocellulose using a semi-dry blot apparatus (Bio-Rad). Chicken polyclonal antiserum against the A. awamori phytase was used as the primary antibody, with rabbit anti-chicken IgG peroxidase-conjugated (Sigma) as secondary antibody. Proteins were visualised by enhanced chemiluminescence (ECL; Amersham), processing and washing the membranes according to the instructions supplied with the ECL reagents.
Results
Transformation of soybean with phy A
Fertilization occurred approximately 6–8 h following self-pollination at the soybean ovary (Carlson and Lersten 1987). An overall success rate of 21% was achieved from 59 pods harvested from 279 flowers treated with phy A (Table 1). All T0 seeds were grown in a greenhouse. Because of lacking selectable marker gene in transgenic construct, the selection process was elided, PCR identification is used for transgenic screening. A total of 13 out of 99 T1 plants contained the gene cassette as evidenced by specific PCR amplifications of the 488 bp and 850 bp fragments (Fig. 2). PCR-positive seedlings were further confirmed by PCR-Southern, dot blot and PCR product sequencing (data not shown) and resulted in a transformation frequency of 13% of the germinated T1 plants. Of 473 T2 individuals determined by PCR using primer 3 and primer 4, 102 plants showed PCR-positive amplifications (Table 1). Mendelian segregation was not observed in the T2 generation. One plausible reason might be that nearly half of seeds did not germinate, PCR detection could not be carried on. In addition, our genomic DNA preparations used for PCR detection might be not reach the purity required for PCR analysis. Phytase assays were detected in the 95 T2 PCR-positive plants from genotype Liaodou14; L14-11-2 and L14-19-1 lines showed higher phytase activities than the others (data not show) and were selected for further analysis.
Progeny and transgene inheritance
In order to investigate the stability of transgene expression, T3 individuals derived from line L14-11-2 and line L14-19-1 were investigated by Southern blot analysis. Genomic DNA was digested with XbaI that cut once within the gene cassettes (Fig. 1); PCR product that was composed of the partial phytase gene (bp 272–759 of phyA) was used as a probe. Low copy number insertions were detected in our experiments. Plants from the L14-19-1 line showed only a single hybridizing band; plants from the L14-11-2 line showed two (Fig. 3). No signal could be detected in the control plants. All hybridizing fragments had much longer lengths than the expression cassette; these fragments presumably represent no truncation or partial deletion. Recently, similar studies (Fu et al. 2000; Loc et al. 2002) reported that minimal linear transgene constructs lacking vector backbone sequences to transform rice with marker genes by particle bombardment successfully produced predominantly ‘simple’ integration events (one or two bands on Southern blots) and a low frequency of transgene rearrangements, compared to supercoiled and linearized whole plasmid DNA.
Heterologous transgene expression
RNA from T3 transgenic soybeans (lines L14-11-2 and L14-19-1) was subjected to RT-PCR to test for the presence of phyA transcripts. The 1040 bp phyA transcription fragment was detected in the most of T3 transgenic plants but was absent in the non-transgenic controls (Fig. 4).
Phytase assay in transgenic soybean leaves and seeds
T3 progeny from lines L14-11-2 and L14-19-1 were used to analyze phytase accumulation in the leaves during plant growth (Fig. 5) and in the mature seeds. Leaf samples were collected each week (from 2 to 7 weeks) in the greenhouse for phytase activity assay. Phytase levels increased from week 2 to week 4 and then remained at a stable level for the following 2 weeks, declining slightly during week 7. Phytase activities in plants from line L14-19-1 were higher than those from line L14-11-2 from weeks 2 to 6. The highest expression level was observed in line L14-19-1 during week 4 (150 U/mg protein), about 3 times higher than the untransformed control (56 U/mg protein). Because the plants were grown in the greenhouse in winter, senescence of the soybean leaves occurred in advance during week 7, and phytase levels decreased slightly. Based on the amount of enzyme per soluble protein, the phytase level increased approximately 2.5-fold on average in a 6-week period.
In the mature seeds (n = 3), transgenics from L14-11-2-1 exhibited a substantially higher phytase activity (125 U/kg on average) than untransformed control (64 U/kg). Transgenic seeds displayed a 100% increase in phytase activity compared to wild-type. It is apparent that the increased phytase activity stably accumulated in the transgenic soybeans.
Enzyme thermal stability in crude extract of soybean seeds
The temperature stability of the plant-synthesized recombinant phytase in T3 transgenic soybeans was compared with the untransformed control after incubation at temperatures ranging from 37°C to 90°C for 10 min (Fig. 6). Only a small decrease in activity in all samples was detected when the temperature reached 55°C. Upon incubation at 60°C, 65°C and 70°C for 10 min, 70%, 40% and 10% of the activity, respectively, remained for crude extracts of transgenic seeds, whereas no activity was regained in untransformed control. Transgenic lines showed greater stability at the high temperature than did the control.
Expression of Phytase in transgenic soybean
The molecular mass of the mature fungal phytase based on the predicted amino acid sequence is 52 kDa. The reported molecular mass of 118 kDa (Wang et al. 2006) reflects the extensive glycosylation of the enzyme. Glycosylation is required for enzyme stability and/or activity. To determine the mass of the recombinant phytase synthesized in soybeans and to verify that it was glycosylated, recombinant phytase was compared with native fungal phytase by immunoblot analysis using polyclonal antiserum to A. awamori phytase (Fig. 7). Chemiluminescent detection of protein bands showed that the recombinant phytase migrated with an apparent molecular mass of approximately 73 kDa, similar to the size observed for recombinant phytase produced in tobacco (Pen et al. 1993). The apparent molecular mass of the recombinant phytase was higher than predicted by amino acid composition, which provides evidence that the recombinant enzyme is glycosylated.
Discussion
The period of exogenous DNA transformation by pollen tube pathway transgenic technology should be limited to the time between fusion of the sperm and egg and division of the zygote. In soybeans, the ripened pollen tube enters into the embryo sac 6 h after self-pollination when the height of the corolla is greater than that of the calyx. At 28 h after self-pollination, the zygote begins the first mitotic division. Thus, 6–28 h after pollination should be the time for exogenous DNA transformation in soybeans via the pollen tube pathway (Shen 1983). Furthermore, the mechanism of transformation holds that exogenous DNA enters into the embryo sacs through the interface connecting the stigmas and embryo sacs (Gong et al. 1988). Cutting off all of the style and the top of the ovary shortened the entrance pathway and greatly improved the capacity of the target DNA to enter into the embryo sacs (Wang and Shen 2006). In addition, this technique could be used to introduce total exogenous genomic DNA or plasmid DNA into plants, and it is also practical to introduce linear DNA fragments composed of only the target gene, flanking regulation elements and T-DNA border repeats into plants directly. In our experiment, a minimal linear transgenic construct was introduced into soybeans using this method and resulted in the Aspergillus phytase gene being inherited and expressed in progeny. The transformation efficiency of 13% by PCR screening was higher than that previously reported in soybeans using the same pathway, which was estimated as 3.8% (Yang et al. 2002).
A phytase that is stable at high temperature during the pelleting process is desirable for animal feed applications (Hamada et al. 2004). In addition, high temperature is necessary for soybean to inactivate endogenous trypsin inhibitors and other antinutrient proteins (Ponstein et al. 2002). Recombinant phytase in transgenic seeds showed a relatively small increase in thermostability than the untransformed control, but it did not appear sufficient to withstand processing temperatures. Thermostable phytase expression in soybean is one of the new current strategies for retention of phytase activity in feed after consumption by the monogastric animal.
References
Carlson JB, Lersten NR (1987) Reproductive morphology. In: Wilcox JR (ed) Soybeans: improvement, production, and uses, 2nd edn. American Society of Agronomy, Madison, Wisconsin, pp 95–134
Franklin G, Carpenter L, Davis E (2004) Factors influencing regeneration of soybean from mature and immature cotyledons. Plant Growth Regul 43:73–79
Fu XD, Duc LT, Fontana S et al (2000) Linear transgene constructs lacking vector backbone sequences generate low-copy-number transgenic plants with simple integration patterns. Transgenic Res 9:11–19
Gong ZZ, Shen WF, Zhou GY et al (1988) Introducing exogenous DNA into plants after pollination. Scientia Sinica (Series B) 9:1080–1084
Hamada A, Yamaguchit K, Ohnishi N, et al (2004) High-level production of yeast (Schwanniomyces occidentalis) phytase in transgenic rice plants by a combination of signal sequence and codon modification of the phytase gene. Plant Biotechnol J 2:1–13
Hegeman CE, Grabau EA (2001) A novel phytase with sequence similarity to purple acid phosphatases is expressed in cotyledons of germinating soybean seedlings. Plant Physiol 126:1598–1608
Kononov ME, Bassuner B, Gelvin SB (1997) Integration of T-DNA binary vector ‘backbone’ sequences into the tobacco genome: Evidence for multiple complex patterns of integration. Plant J 11:945–957
Li J, Hegeman CE, Hanlon RW et al (1997) Secretion of active recombinant phytase from soybean ceii-suspension cuitures. Plant Physiol 114:1103–1111
Loc NT, Tinjuangjun P, Gatehouse AMR et al (2002) Linear transgene constructs lacking vector backbone sequences generate transgenic rice plants which accumulate higher levels of proteins conferring insect resistance. Mol Breed 9:231–244
Luo ZX, Wu RA (1989) Simple method for the transformation of rice via the pollen-tube pathway. Plant Mol Biol Rep 7(1):69–77
Miki B, McHugh S (2004) Selectable marker genes in transgenic plants: applications, alternatives and biosafety. J Biotechnol 107:193–232
Murphy J, Riley JP (1962) A modified single solution method for the determination of phosphate in natural waters. Anal Chim Acta 27:31–36
Nap JP, Metz PL, Excaler AJ (2003) The release of genetically modified crops into the environment. Part I. Overview of current status and regulations. Plant J 33:1–18
Palmiter RD, Brinster RL (1986) Germline transformation of mice. Ann Rev Genet 20:465–491
Pen J, Verwoerd TC, van Paridon PA et al (1993) Phytase -containing transgenic seeds as a novel feed additive for improved phosphotus utilization. Biotechnology 11:811–814
Ponstein AS, Bade JB, Verwoerd TC et al (2002) Stable expression of Phytase (phyA) in canola (Brassica napus) seeds: towards a commercial product. Mol Breed 10:31–44
Reichandt M, Rogers S (1994) Preparation of Plant DNA using CTAB. In: Ausubel FM, Bernt R, Struhl K (eds) Current protocols in molecular biology [M]. Sarah Greene, Brooklyn, New York, pp 233–237
Shen JH (1983) Studies on fertilization in glycine max. Acta Bot Sin 25(3):213–219 (in Chinese)
Thompson J (2000) Topic 11: Gene transfer—mechanism and food safety risks. Joint FAO/WHO Expert Consultation on Foods Derived from Biotechnology, Geneva
Tingay S, McElroy D, Kalla R et al (1997) Agrobacterium tumefaciens-mediated barley transformation. Plant J 11:369–1376
Wang CL, Zhao L, Zong SHY (2004) Inheritance of herbicide resistance in offsprings of bar transgenic rice (Oryza sativa L.) obtained by pollen-tube pathway method. Acta Agron Sin 30(4):403–405 (in Chinese)
Wang GK, Gao XR, An LJ (2006) Purification and characterization of thermostable phytase from Aspergillus awamori. Food Ferment Ind 12:33–36 (in Chinese)
Wang YJ, Shen JH (2006) Probing into cytological embryology mechanism of pollen-tube pathway transgenic technology. Acta Boreal-occident Sin 26(3):628–634 (in Chinese)
Yang QK, Cao YP, Cui Y et al (2002) Study on introducing Bt gene into soybean by pollen tube path method. Chin J Oil Crop Sci 24:17–20 (in Chinese)
Acknowledgements
This work was supported by grants from the National Natural Science Foundation of the Dalian Government in China (2005J22JH044).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Gao, X.R., Wang, G.K., Su, Q. et al. Phytase expression in transgenic soybeans: stable transformation with a vector-less construct. Biotechnol Lett 29, 1781–1787 (2007). https://doi.org/10.1007/s10529-007-9439-x
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10529-007-9439-x