Abstract
Key message
Tetraploidy improves overexpression of h6h and scopolamine production of H. muticus, while in H. senecionis, pmt overexpression and elicitation can be used as effective methods for increasing tropane alkaloids.
Abstract
The effects of metabolic engineering in a polyploid context were studied by overexpression of h6h in the tetraploid hairy root cultures of H. muticus. Flow cytometry analysis indicated genetic stability in the majority of the clones, while only a few clones showed genetic instability. Among all the diploid and tetraploid clones, the highest level of h6h transgene expression and scopolamine accumulation was interestingly observed in the tetraploid clones of H. muticus. Therefore, metabolic engineering of the tropane biosynthetic pathway in polyploids is suggested as a potential system for increasing the production of tropane alkaloids. Transgenic hairy root cultures of Hyoscyamus senecionis were also established. While overexpression of pmt in H. senecionis was correlated with a sharp increase in hyoscyamine production, the h6h-overexpressing clones were not able to accumulate higher levels of scopolamine than the leaves of intact plants. Applying methyl jasmonate was followed by a sharp increase in the expression of pmt and a drop in the expression of tropinone reductase II (trII) which consequently resulted in the higher biosynthesis of hyoscyamine and total alkaloids in H. senecionis.
Similar content being viewed by others
Avoid common mistakes on your manuscript.
Introduction
Tropane alkaloids (TAs) such as hyoscyamine and scopolamine are among the oldest drugs in medicine, with wide-ranging pharmaceutical applications for their mydriatic, antispasmodic, anticholinergic, analgesic, and sedative properties (Arroo et al. 2007; Yamada et al. 1990). Chemical synthesis of tropane alkaloids is not economically feasible, so commercial production of these compounds is entirely dependent on their isolation from various members of the Solanaceae family, including the genera Atropa, Duboisia, Datura, and Hyoscyamus (Mateus et al. 2000; Oksman-Caldentey and Arroo 2000). Scopolamine is the most valuable TA due to its higher pharmacological activity, fewer side-effects, and relatively limited supply (Rischer et al. 2013). The worldwide demand for scopolamine is about ten times greater than for hyoscyamine (Hashimoto et al. 1993; Oksman-Caldentey and Arroo 2000). Accordingly, there has been a long-standing interest in increasing the TA content of plants (especially scopolamine) and their in vitro cultured tissues by the conventional and biotechnological approaches (Dehghan et al. 2012; Palazón et al. 2003; Wang et al. 2011).
Hairy root cultures offer many advantages such as high genetic stability, rapid and hormone-free growth, and the ability to synthesize the same compounds as the roots of the intact plant. They have been considered as a promising approach to TA production in several solanaceous plants (Cardillo et al. 2010; Zhang et al. 2004). The biosynthetic pathway of tropane alkaloids and key enzyme genes has been identified (Kai et al. 2007; Li et al. 2006; Portsteffen et al. 1994) (Fig. S1). In the TA biosynthetic pathway, putrescine N-methyltransferase (PMT) is considered as the first rate-limiting upstream enzyme, while hyoscyamine 6β-hydroxylase (EC 1.14.11.11, H6H) is a key enzyme catalyzing the last two steps in scopolamine biosynthesis. Engineering of the tropane pathway genes, especially h6h and pmt, is reported to be a feasible approach to enhance the production of hyoscyamine and scopolamine in plants or in vitro cultures of H. muticus (Jouhikainen et al. 1999; Moyano et al. 2003), H. niger (Zhang et al. 2004, 2007), Duboisia hybrids (Palazón et al. 2003), Atropa baetica (Zárate et al. 2006), and Atropa belladonna (Wang et al. 2011).
Hyoscyamus senecionis var. bipinnatisectus is a rare herbaceous perennial medicinal plant belonging to the family Solanaceae, which grows at high altitudes in the Iranian plateau (Khatamsaz 1998). Our recent study indicated a higher content of scopolamine than its precursor hyoscyamine in H. senecionis (Dehghan et al. 2013); however, productivity of TA in its in vitro cultures has not been explored yet. Egyptian henbane (H. muticus) is another important TA-producing species, but with a high hyoscyamine and low scopolamine content. We previously reported the higher potential for scopolamine production in autotetraploid plants and hairy root cultures of this species, compared to their diploid counterparts (Dehghan et al. 2012). To explore the potential of metabolic engineering of the TA biosynthesis pathway, overexpression of pmt and h6h genes in hairy root cultures of H. senecionis and diploid and tetraploid plants of H. muticus (strain Cairo) was investigated. The expression levels of the key genes and metabolites of the TA pathway in methyl jasmonate-elicited hairy root cultures of H. senecionis were also studied.
Materials and methods
Bacterial strains
The Agrobacterium tumefaciens strain C58C1 (pRiA4), containing the pmt gene from Nicotiana tabacum L. under the control of the constitutive CaMV 35S promoter (Moyano et al. 2002, 2003), and A. rhizogenes strains, LBA9402, carrying pLAL21 plasmid, containing the h6h gene from H. niger under the control of CaMV 35S promoter (Jouhikainen et al. 1999) and A4 were used for plant transformation. The Agrobacterium strains were grown at 28 °C in YMB medium.
Establishment of hairy roots and culture conditions
Diploid and the seventh generation (C7) of induced autotetraploid plants of H. muticus (Dehghan et al. 2012) were grown from seeds under greenhouse conditions at 25 ± 2 °C, with a photoperiod of 16 h light/8 h darkness. Young leaves of diploid and tetraploid plants were used for transformation with the disarmed A. tumefaciens strain C58C1 carrying the pRiA4 of A. rhizogenes and the binary vector pBMI and A. rhizogenes strains, LBA9402, carrying the pLAL21 plasmid, and A4 as described before (Dehghan et al. 2012).
The transformed roots that developed at wound sites were excised and cultured individually in half-strength liquid MS medium (Murashige and Skoog 1962) containing 3% sucrose and 500 mg/l cefotaxime to eliminate the excess bacteria, and grown at 25 ± 2 °C on a gyratory shaker (Heidolph, Germany). Root clones were kept in darkness and subcultured by transferring about 125 mg fresh weight of young roots to 25 ml fresh medium at 4-week intervals.
Young sterilized leaves and nodal segments of H. senecionis plants grown under the stated greenhouse conditions were used for inoculation with A. tumefaciens strain C58C1 (pRiA4) and A. rhizogenes strains LBA9402 (carrying pLAL21 plasmid) and A4. Nodal segments were inoculated by the same aforementioned method for H. muticus and leaf explants were submerged in the bacterial suspension for 10 min. Transformed roots appeared after 1–4 weeks of culture, and were grown under the conditions described above.
MeJa treatment
The 3-week-old h6h-transgenic and pmt transgenic clones of H. senecionis with a good growth rate and normal phenotype were incubated in half-strength liquid MS medium and subjected to duplicate 100-μM MeJa (Sigma) treatments of 0, 12, 24, and 48 h. A portion of each sample was harvested for RNA extraction and the remainder was freeze-dried for alkaloid analyses. Plants were grown in the same conditions as mentioned earlier and MeJa (100 μM) was sprayed on the intact plants twice a day. Leaf samples were flash-frozen in liquid nitrogen, freeze-dried, and kept at −80 °C prior to alkaloid extraction.
Polymerase chain reaction analysis
PCR analyses were performed on DNA (Saghai-Maroof et al. 1984) extracted from transgenic and control samples. PCR primers and the procedure for rolC were designed and conducted according to Dehghan et al. (2012). To avoid the interference of Agrobacterium in the PCR results, Agrobacterium virD1 was used as negative control. The oligonucleotide primers of 5′-GAAAGATATATTTCTCAAGA-3′ and 5′-TCTCCAAATGAAATGAACTTC-3′, specific for the 35S promoter and 5′-GAACTCGTCAAGAAGGC-3′ and 5′-CAGGTTCTCCGGCCGCT-3′, specific for nptII, were used for the detection of transferred constructs in the transgenic h6h and pmt clones. Further confirmation was performed by the PCR primers of the pmt gene from N. tabacum L. according to Moyano et al. (2003). After separation by 1.2% agarose gel electrophoresis, amplified fragments were stained with DNA Green viewer and observed under UV light using a UVP transilluminator.
Flow cytometric (FCM) analysis
To determine the ploidy levels and genetic stability of transgenic and control hairy root cultures obtained from H. senecionis and diploid and tetraploid plants of H. muticus, flow cytometry analysis was conducted using a ploidy analyzer flow cytometer (Partec PA, Münster, Germany) equipped with a UV mercury arc lamp excitation source and filter combination for DAPI staining according to previously established protocol (Dehghan et al. 2012). Young leaves (about 2 cm2) or young tip (about 1.5 cm) of the hairy roots was used for extracting nuclei from the cells. Tissues were chopped in the nuclei extraction buffer (Partec PA, Germany), followed by DAPI staining (Partec PA, Germany) and measurement by flow cytometer. Signal intensity of at least 10,000 nuclei was quantified using ModFit LT™ program after removing debris and aggregates from the analysis.
Real-time RT-PCR analysis
Total RNA from transgenic H. senecionis and H. muticus clones as well as MeJa-treated and control samples was extracted and reverse transcribed to cDNA by procedures reported previously (Dehghan et al. 2013). Real-time quantitative PCR was performed using a Biorad Real-Time PCR System (C1000™ Thermal Cycler, Biorad) and Maxima SYBR Green kit (Fermentas). Primer pairs for specific amplification of pmt, h6h, trI, and trII genes were designed as shown in Table S1. ef-1α was also used as the reference gene. The conditions were set as follows: an initial polymerase activation step of 94 °C for 10 min, followed by 40 cycles of 30 s at 94 °C for denaturation, 30 s at 58 °C for annealing, and 30 s of extension at 72 °C. The reactions were carried out as described previously (Dehghan et al. 2013).
Tropane alkaloid extraction and GC and GC–MS analyses
About 100 mg lyophilized samples of leaves and hairy root cultures of H. senecionis and H. muticus were extracted as previously described (Dehghan et al. 2013). Hyoscyamine, scopolamine, littorine, and 3-hydroxy littorine content of the samples were analyzed as previously described (Dehghan et al. 2013; Li et al. 2006) with the exception that both GC/MS identification of peaks and GC quantitation of alkaloids were carried out using a 30 m × 0.25 mm DB-23 column with 0.25 um film thickness (Agilent), temperature programmed from 160 to 240 °C at 4 °C per min.
Statistical analyses
Data were processed using GraphPad Prism 7.02 program. All the experiments were run at least in three replicates and the significance of the results was analyzed using an unpaired, two-tailed Student’s t test where needed and data were presented as mean ± SD. A p value <0.05 was considered significant.
Results
Growth and morphology of the transgenic hairy roots
In both species, transgenic hairy roots emerged from the wounded sites about 1–4 weeks after Agrobacterium inoculation (Fig. S2). The transformation rate of leaves and nodal segments of H. senecionis was about 50% (data not shown). Considerable variation was observed among clones in terms of morphology, growth, and biomass production. Pmt and h6h transgenic root clones of H. muticus showed a more normal morphology than those of H. senecionis. Several pmt clones of H. senecionis were dark brown in color with dense short-branch morphology, while pmt clones of H. muticus showed a light brown color and longer branches. While h6h-transgenic roots of H. muticus showed a normal phenotype, a range of changes, including severe callus formation, callus suspension formation, and deformed roots with wide branches, were observed among h6h-transgenic clones of H. senecionis (Fig. S2).
It is also worth noting that we observed a lower transformation rate of tetraploid (6%) H. muticus versus its diploid (40%) counterpart. The growth rate of tetraploid pmt-transgenic clones was significantly (p < 0.05) lower than in the diploid clones (data not shown). We obtained 20 h6h-transgenic tetraploid clones with normal appearance and growth, while only eight pmt-transgenic tetraploid clones were established. All the tetraploid pmt-transgenic clones had low growth rates and were not analyzed further, while a few h6h-transgenic clones with normal growth rate were selected for the further analyses. The tetraploid clones were also more friable than the diploid ones, and a number of them grew after a lag phase of about 10 days after subculturing.
The majority of the pmt and h6h transgenic clones of H. senecionis and diploid H. muticus showed a normal growth rate similar to that of the controls. Compared to h6h, pmt overexpression was in accordance with a lower growth rate and biomass production shown in several transgenic tetraploid clones of H. muticus.
Identification of transformed root lines through PCR analysis
The presence of heterologous pmt and h6h genes in the genome of hairy roots was confirmed by PCR. Amplification of a 612-bp fragment confirmed the presence of rolC in hairy root clones. The expected fragments were amplified using the 35s promoter, nptII, tobacco pmt and h6h (F-35s and R-h6h) in the transgenic clones, which did not show up in the DNA of the normal adventitious roots. Using specific primers, PCR experiments confirmed the presence of transgenes in the transformed hairy root clones (Fig. S3).
Genetic stability and ploidy level of transgenic clones
Flow cytometry experiments were conducted to determine the genetic stability and ploidy levels of the transgenic h6h and pmt clones, as well as the control normal adventitious roots of H. senecionis and diploid and tetraploid plants of H. muticus. We also attempted to find a correlation between the morphology, particularly in callus-producing clones, and genetic instability of the cultures. DAPI fluorescence intensity of 85 transgenic and control clones for the two above mentioned Hyoscyamus species was studied. As expected, the majority of the clones were stable and their fluorescence intensity was similar to the controls. We did, however, detect a small number of unusual clones with a different FCM profile. One of the h6h-transgenic clones of H. senecionis, with severe callus formation morphology, showed a lower DNA fluorescence intensity than the controls, indicating possible aneuploidy (Fig. 1a, b). However, the other ten callus-producing clones that we tested were normal.
Flow cytometry experiments confirmed the tetraploidy of the induced hairy roots from the C7 generation of the tetraploid H. muticus (Fig. 1c, d). We also observed a tetraploid pmt-transgenic H. muticus clone that tended toward octaploidy and endoreduplication (Fig. 1f). This tetraploid clone was deformed, showed a low growth rate, and was not analyzed further.
Overexpression of pmt and h6h genes in transgenic clones of H. senecionis
Quantitative RT-PCR was conducted to reveal the level of expression of TA pathway genes in transgenic roots of both Hyoscyamus species. A considerable variation in the gene expression profiles of pmt, h6h, trI, and trII was observed among the transgenic clones. Transfer of pmt and h6h resulted in the overexpression of these genes in a number of the hairy root clones of H. muticus and H. senecionis. One of the pmt-transgenic clones of H. senecionis (P1) represented a 3100-fold increase in pmt expression. This clone was relatively dark brown and showed a moderate growth rate. The P4 and P5 clones also overexpressed the pmt gene about 40-fold higher than the controls (Fig. 2a). Considering the highest level of pmt expression, the amount of produced hyoscyamine and scopolamine was not as high as expected in the clone P1. However, this clone showed a higher level of littorine between all the studied H. senecionis clones (Fig. 2d). The highest content of hyoscyamine (6.3 mg/g DW) was observed in the clone P5 which was about 16.5-fold higher than in the intact plant leaves (0.4 mg/g DW) and sixfold higher than in the control non-transgenic samples. This clone also showed a good growth rate and the highest yield of hyoscyamine (56 mg/l) and total alkaloid (58.6 mg/l) among the studied H. senecionis clones (Fig. 2c, d).
When compared to the pmt-transgenic clones, transformation with h6h had a modest effect on h6h overexpression and conversion of hyoscyamine to scopolamine. The best clone, H2, showed a tenfold increase in h6h expression and scopolamine production compared to the control non-transgenic clones (Fig. 2b–e).
The effects of methyl jasmonate treatment on gene expression and tropane alkaloid accumulation
Having established the hairy root cultures of H. senecionis, we were interested to study TA productivity of in vitro cultures in response to MeJa elicitation. The added MeJa changed the gene expression profile of the TA pathway (Fig. 3a) by up-regulating expression of pmt and decreasing expression of trII. While expression of trI was moderately reduced, elicitation did not show a significant change in h6h expression compared to the control (Fig. 3a). The transgenic hairy root clones also produced higher amounts of total alkaloids than the controls. The highest increase in TA accumulation that was observed after 12 h treatment was about tenfold increase in littorine and threefold increase in 3′-hydroxylittorine and hyoscyamine. Scopolamine accumulation was also increased about 3.5-fold after 24-h treatment, although the total amount still is less than that of the observed in the intact plants (Fig. 3b, c).
The profile of tropane alkaloid accumulation was also changed by MeJa elicitation of H. senecionis intact plants. The leaves of the intact plants, treated with MeJa for 64 h, accumulated significantly higher amount of scopolamine and total alkaloids compared to that of the control untreated ones (Fig. 3c).
Overexpression of pmt and h6h genes in transgenic clones of H. muticus
The selected diploid and tetraploid clones of H. muticus represented a relatively good growth rate and biomass production. In this study, three h6h-transgenic and one control tetraploid hairy root clones, with normal growth rate and morphology, were selected and analyzed for gene expression patterns and alkaloid production. In contrary to the diploids, tetraploid h6h-transgenic clones of H. muticus showed a significantly (p < 0.05) higher growth rate than the obtained pmt overexpression clones (data not shown).
As shown in Figs. 4 and 5, a wide variation in gene expression and tropane alkaloid production was observed among the induced hairy root clones of diploid and tetraploid plants. A 45-fold increase in pmt expression and the highest hyoscyamine and total alkaloid production was observed in the P1 clone (Figs. 4a, 5a). Although pmt was up-regulated about 400-fold in P2, its alkaloid productivity was only two times higher than the control one thus remaining substantially lower than P1. In general, pmt-transgenic clones produced higher hyoscyamine, littorine, and 3′-hydroxylittorine than the h6h-transgenic clones (p < 0.05).
A sharp increase in h6h expression and scopolamine production was observed in H4 due to overexpression of the h6h gene under control of the 35S promoter (Fig. 4b), with scopolamine production being about 80-fold higher than in the control non-transgenic root clones (Fig. 5c). However, the hyoscyamine pool was not completely converted to scopolamine and the ratio of scopolamine to hyoscyamine did not increase more than 10%. The same phenomenon has been previously reported by Jouhikainen et al. (1999).
The ploidy level also had a great impact on the gene expression profile and scopolamine production of transgenic hairy roots. Comparing the expression level of the TA pathway genes in the tetraploid transgenic clones and non-transgenic control one with that of the diploid h6h-overexpressing clones, a significantly higher expression level of h6h (p < 0.05) was observed in all the tetraploid clones (Fig. 4c). Interestingly, the highest levels of h6h transgene expression and scopolamine accumulation were observed in the tetraploid clones (Figs. 4c, 5c). The mean scopolamine/hyoscyamine ratio was 0.4 and 13.5% in diploid and tetraploid h6h-overexpressing clones, respectively. Comparing non-transgenic clones of diploid and tetraploid, the tetraploid one produced 2.5- and 25-fold more hyoscyamine and scopolamine, respectively.
Discussion
Tropane alkaloids, especially scopolamine, are among the important medicines derived from natural sources with a wide range of pharmaceutical applications. With the growing demand for TAs, exploring unknown sources and establishing new techniques to improve the quantity and quality of them will help to guarantee the long-term supply of TAs.
Here, we report establishment and metabolic engineering of hairy root cultures of H. senecionis and diploid and tetraploid clones of H. muticus overexpressing pmt and h6h transgenes, for the first time. In a number of H. senecionis hairy root clones, the presence of the pmt transgene was accompanied by morphological alterations such as rapid aging and browning. These changes have been reported in a number of previous studies on metabolic engineering of the TA pathway (Jouhikainen et al. 1999; Moyano et al. 2002, 2003).
Flow cytometry (FCM) confirmed the tetraploidy of induced hairy roots from the C7 generation of tetraploid plants of H. muticus. The FCM analyses also indicated the genetic stability of the majority of transgenic clones and genetic instability of a few h6h-transgenic clones of H. senecionis and the diploid and tetraploid plants of H. muticus (Fig. 1). There was no correlation between the FCM profile and morphology, especially in the callus-forming clones of in vitro transgenic and non-transgenic hairy root cultures. The majority of the clones were genetically stable as it expected. These results differ from those reported by Ochatt et al. (2013) who claimed that insertion of the transgene does not exert any effect on the genetic stability of the transformed tissues.
Pmt overexpression in H. senecionis and H. muticus led to an increase in the production of hyoscyamine, littorine, and 3′-hydroxylittorine, suggesting that pmt overexpression might increase the total flux of the pathway by diverting the polyamine pool of the cells to the tropane alkaloid pathway. Our results agree with the study of Moyano et al. (2003), who reported an enhanced TA content in pmt-transgenic clones of H. muticus and Datura metel. However, overexpression of pmt in hairy root cultures of Duboisia hybrid, H. niger, and A. belladonna did not promote tropane alkaloid accumulation (Moyano et al. 2002; Sato et al. 2001; Zhang et al. 2007). This contradiction might be partly due to the difference in genetic regulation of the host plant pathway, including different posttranslational modifications and availability of different bottle necks through the pathways leading to production of TAs.
Although pmt overexpression led to a higher hyoscyamine and total alkaloid content in both Hyoscyamus species, no linear correlation was observed between these variables. This could be due to the role of the other genes of the pathway and the complex regulation of the TA biosynthetic pathway. For example, in the P2 clone of H. muticus, despite the enhanced metabolic flux of the pathway caused by pmt up-regulation, the higher expression of trII than trI led to the higher formation of calystegines (table S2) at the expense of TAs. Littorine mutase plays an important role in tropane alkaloid production. Although the expression level of the littorine mutase gene was not analyzed, its activity can be directly related to the accumulation of hyoscyamine and 3′-hydroxylittorine (Li et al. 2006). As represented in Figs. 2 and 5, the higher production of 3′-hydroxylittorine is usually associated with higher hyoscyamine and total alkaloid production. For example, the P1 clone of H. senecionis showed more than 3000-fold increase in pmt expression and a higher trI/trII expression ratio. The higher expression levels of trI than trII in P1 resulted in undetectable amount of calystegines and the greatest amount of littorine between all the H. senecionis clones but the 3′-hydroxylittorine and hyoscyamine content remained low, possibly because of lower activity of littorine mutase. Therefore, in addition to the pmt and h6h genes, the expression ratio of trI/trII and littorine mutase is other factors to be taken into account when trying to improve TA production and selecting elite clones.
When the TA content of three callus-forming hairy root lines of H. senecionis was analyzed, no correlation was observed between morphology and potential of TA production. This is in contrast with H. muticus hairy root cultures, where callus formation was associated with low alkaloid production in all cases (Jouhikainen et al. 1999). The observed difference may be due to organ-independent expression of TA pathway genes in H. senecionis (Dehghan et al. 2013). The established transgenic root cultures of H. senecionis showed great potential for hyoscyamine production but were unexpectedly weak in scopolamine production. Contrary to the level of h6h overexpression, the scopolamine content of hairy root cultures was lower than in H. senecionis aerial parts. The scopolamine/hyoscyamine ratio was about 1.50 in the leaves of H. senecionis, while it was about 0.04 in hairy root cultures. As previously discussed (Dehghan et al. 2013), this observation raises the question about the role of H6H in scopolamine production in green tissues and a hypothesis of de novo synthesis of TAs in aerial tissues (Kushwaha et al. 2013). Thus, we suggest future studies on the potential of scopolamine production in green hairy root cultures or in regenerated plants of H. senecionis from transgenic root cultures. Given that significant differences in scopolamine production have been reported between greenhouse and field grown plants of H. muticus (Oksman-Caldentey et al. 1987), the different scopolamine levels of H. senecionis root cultures and plants may also be a result of different growth conditions.
Rapid growth is seen as a beneficial feature when selecting clones, while a high content of products is usually associated with poor growth rate (Sevon and Oksman-Caldentey 2002). Thus, it is not surprising that most clones with a high content of alkaloids may be discarded in favor of selection of the rapidly growing clones. We also concluded that the regulation of scopolamine biosynthesis may be more complicated than that of hyoscyamine and it seems to be more sensitive to environmental and culture conditions (Dehghan et al. 2012; Oksman-Caldentey et al. 1987).
Our results indicate that MeJa has a considerable effect in changing the gene expression and TA production of H. senecionis. It has been previously reported that TA production is activated by MeJa treatment (Kai et al. 2012; Kang et al. 2004), but in this study, the elicitor affected TA pathway genes in other ways. While pmt was strongly overexpressed, the other genes of the TA pathway, especially trII, were down-regulated by MeJa treatment. As observed in the elicited clone of H. senecionis (Fig. 3), increasing pathway flux by up-regulation of pmt and down-regulation of trII was accompanied by a sharp increase in TA production. To increase the simultaneous expression of key TA pathway genes, we suggest using a combination of appropriate elicitors. The enhanced overexpression of pmt and TA production in elicited hairy root cultures of H. senecionis indicate the key role of MeJa in regulating TA production. In contrast, Biondi et al. (2000) reported that MeJa treatment only slightly stimulated alkaloid production in H. muticus. To our knowledge, this is the first report on the up-regulation of pmt and concomitant down-regulation of trII in a TA-producing plant after exposure to MeJa.
Manipulation of ploidy level, alone or combined with metabolic engineering, sharply increased the expression of h6h and associated production of scopolamine (Figs. 4, 5). The higher expression level of h6h in tetraploid control clone was consistent with our previous study, as tetraploid plants of H. muticus produced about 200% more scopolamine than their diploid counterparts (Dehghan et al. 2012). Interestingly, the insertion of a transgene of h6h in tetraploid plants was able to further improve h6h up-regulation and the conversion of hyoscyamine to scopolamine. In other words, tetraploid hairy roots represent a higher potential for transgene expression, and consequently, tetraploid plants of Egyptian henbane are a preferred genetic context for metabolic engineering and overexpression of h6h. To our knowledge, this is the first report about metabolic engineering of a secondary metabolite pathway in an artificially induced polyploid plant.
Conclusion
Genetically modified hairy root cultures of H. senecionis and H. muticus with an altered gene expression profile and metabolite accumulation were obtained by overexpression of two key enzyme genes, pmt and h6h. As scopolamine production in hairy root cultures of H. senecionis was moderate in comparison with green parts of the plant, we concluded that aerial parts might have an important role in scopolamine biosynthesis and accumulation. Elicitation with MeJa increased the flux thorough the tropane alkaloid pathway in H. senecionis root cultures by up-regulation of pmt and down-regulation of trII, which led to a modest increase in tropane alkaloid production. Although the amounts of the produced alkaloids in the in vitro conditions are not yet compatible to the commercially available Duboisia hybrid cultivation system, the in vitro systems not only are applicable as an alternative approach to provide tropane alkaloid resources, but also has opened a strong research tool to increase our knowledge about different aspects of biosynthesis and regulation of the TAs pathway. Applying polyploidy as a source of genetic variation, we suggest metabolic engineering of polyploid plants to increase the quality of TAs in the intact plants of Hyoscyamus or other TAs producing species. As mentioned for the P1 clone of H. senecionis, manipulation of other potential rate-limiting steps, such as littorine mutase, is worth trying along with the other enzymes in the future studies. In summary, the results of this study emphasize the importance of metabolic engineering, elicitation, and ploidy manipulation for increasing tropane alkaloid production in H. senecionis and H. muticus.
Author contribution statement
ED and FS designed the experiments; ED and ZH performed the experiments; DWR and PSC conducted GC and GC–MS analyses; JP prepared the binary vector pBMI; K-MO-C provided h6h construct; ED, K-MO-C, and JP wrote the manuscript.
Abbreviations
- BSTFA:
-
N,O-Bis (trimethylsilyl)trifluoroacetamide
- GC:
-
Gas chromatography
- GC–MS:
-
Gas chromatography–mass spectrometry
- MeJa:
-
Methyl jasmonate
- MS:
-
Murashige and Skoog
- PMT:
-
Putrescine N-methyltransferase
- TMCS:
-
Trimethylchlorosilane
- TRI:
-
Tropinone reductase I
- TRII:
-
Tropinone reductase II
- TA:
-
Tropane alkaloids
References
Arroo R, Woolley J, Oksman-Caldentey K-M (2007) Henbane, Belladonna, Datura and Duboisia. In: Pua E, Davey M (eds) Biotechnology in agriculture and forestry, Transgenic Crops VI, vol 61. Springer, Berlin, pp 189–204
Biondi S, Fornale S, Oksman-Caldentey KM, Eeva M, Agostani S, Bagni N (2000) Jasmonates induce over-accumulation of methylputrescine and conjugated polyamines in Hyoscyamus muticus L. root cultures. Plant Cell Rep 19:691–697
Cardillo AB, Otalvaro AAM, Busto VD, Talou JR, Velasquez LME, Giulietti AM (2010) Scopolamine, anisodamine and hyoscyamine production by Brugmansia candida hairy root cultures in bioreactors. Process Biochem 45:1577–1581
Dehghan E, Häkkinen S, Oksman-Caldentey K-M, Shahriari Ahmadi F (2012) Production of tropane alkaloids in diploid and tetraploid plants and in vitro hairy root cultures of Egyptian henbane (Hyoscyamus muticus L.). Plant Cell Tissue Organ Cult 110:35–44
Dehghan E, Shahriari Ahmadi F, Ghotbi Ravandi E, Reed DW, Covello PS, Bahrami AR (2013) An atypical pattern of accumulation of scopolamine and other tropane alkaloids and expression of alkaloid pathway genes in Hyoscyamus senecionis. Plant Physiol Biochem 70:188–194
Hashimoto T, Yun D, Yamada Y (1993) Production of tropane alkaloids in genetically engineered root cultures. Phytochemistry 32:713–718
Jouhikainen K, Lindgren L, Jokelainen T, Hiltunen R, Teeri TH, Oksman-Caldentey K-M (1999) Enhancement of scopolamine production in Hyoscyamus muticus L. hairy root cultures by genetic engineering. Planta 208:545–551
Kai G et al (2007) Molecular cloning and characterization of a new cDNA encoding hyoscyamine 6-beta-hydroxylase from roots of Anisodus acutangulus. J Biochem Mol Biol 40:715–722
Kai G, Yang S, Zhang Y, Luo X, Fu X, Zhang A, Xiao J (2012) Effects of different elicitors on yield of tropane alkaloids in hairy roots of Anisodus acutangulus. Mol Biol Rep 39:1721–1729
Kang SM, Jung HY, Kang YM, Yun DJ, Bahk JD, Yang JK, Choi MS (2004) Effects of methyl jasmonate and salicylic acid on the production of tropane alkaloids and the expression of PMT and H6H in adventitious root cultures of Scopolia parviflora. Plant Sci 166:745–751
Khatamsaz M (1998) Flora of Iran, vol 24. Research Institute of Forests and Rangelands, Iran
Kushwaha AK, Sangwan NS, Trivedi PK, Negi AS, Misra L, Sangwan RS (2013) Tropine forming tropinone reductase gene from Withania somnifera (Ashwagandha): biochemical characteristics of the recombinant enzyme and novel physiological overtones of tissue-wide gene expression patterns. PLoS One 8:e74777
Li R, Reed DW, Liu EW, Nowak J, Pelcher LE, Page JE, Covello PS (2006) Functional genomic analysis of alkaloid biosynthesis in Hyoscyamus niger reveals a cytochrome P450 involved in littorine rearrangement. Chem Biol 13:513–520
Mateus L, Cherkaoui S, Christen P, Oksman-Caldentey KM (2000) Simultaneous determination of scopolamine, hyoscyamine and littorine in plants and different hairy root clones of Hyoscyamus muticus by micellar electrokinetic chromatography. Phytochemistry 54:517–523
Moyano E, Fornalé S, Palazón J, Cusidó RM, Bagni N, Piñol MT (2002) Alkaloid production in Duboisia hybrid hairy root cultures overexpressing the pmt gene. Phytochemistry 59:697–702
Moyano E, Jouhikainen K, Tammela P, Palazon J, Cusido RM, Piñol MT, Teeri TH, Oksman-Caldentey K-M (2003) Effect of pmt gene overexpression on tropane alkaloid production in transformed root cultures of Datura metel and Hyoscyamus muticus. J Exp Bot 54:203–211
Murashige T, Skoog F (1962) A revised medium for rapid growth and bio assays with tobacco tissue cultures. Physiol Plant 15:473–497
Ochatt S, Jacas L, Patat-Ochatt EM, Djenanne S (2013) Flow cytometric analysis and molecular characterization of Agrobacterium tumefaciens-mediated transformants of Medicago truncatula. Plant Cell Tissue Organ Cult 113:237–244
Oksman-Caldentey K-M, Arroo R (2000) Regulation of tropane alkaloid metabolism in plants and plant cell cultures. In: Verpoorte R, Alfermann A (eds) Metabolic engineering of plant secondary metabolism. Kluwer, Dortrecht, pp 253–281
Oksman-Caldentey K-M, Vuorela H, Isenegger M, Strauss A, Hiltunen R (1987) Selection for high tropane alkaloid content in Hyoscyamus muticus plants. Plant Breed 99:318–326
Palazón J, Moyano E, Cusidó RM, Bonfill M, Oksman-Caldentey KM, Piñol MT (2003) Alkaloid production in Duboisia hybrid hairy roots and plants overexpressing the h6h gene. Plant Sci 165:1289–1295
Portsteffen A, Dräger B, Nahrstedt A (1994) The reduction of tropinone in Datura stramonium root cultures by two specific reductases. Phytochemistry 37:391–400
Rischer H, Häkkinen ST, Ritala A, Seppänen-Laakso T, Miralpeix B, Capell T, Christou P, Oksman- Caldentey K-M (2013) Plant cells as pharmaceutical factories. Curr Pharm Design 19:5640–5660
Saghai-Maroof MA, Soliman K, Gorgensen RA, Allard RW (1984) DNA spacer length polymorphism in Barley: Mendelian inheritance, chromosomal location and population genetics. Proc Natl Acad Sci USA 81:8014–8018
Sato F, Hashimoto T, Haciya A, Tamura K, Choi K-B, Morishige T, Fujimoto H, Yamada Y (2001) Metabolic engineering of plant alkaloid biosynthesis. Proc Natl Acad Sci USA 98:367–372
Sevon N, Oksman-Caldentey K-M (2002) Agrobacterium rhizogenes mediated transformation: root cultures as a source of alkaloids. Planta Med 68(10):859–868
Wang X, Chen M, Yang C, Liu X, Zhang L, Lan X, Tang K, Liao Z (2011) Enhancing the scopolamine production in transgenic plants of Atropa belladonna by overexpressing pmt and h6h genes. Physiol Plant 143:309–315
Yamada Y, Hashimoto T, Endo T (1990) Biochemistry of alkaloid production in vitro. In: Charlwood B, Rhodes MJC (eds) Secondary products from plant tissue culture. Clarendon Press, Oxford, pp 201–225
Zárate R, Jaber-Vazdekis N, Medina B, Ravelo Á (2006) Tailoring tropane alkaloid accumulation in transgenic hairy roots of Atropa baetica by over-expressing the gene encoding hyoscyamine 6β-hydroxylase. Biotechnol Lett 28:1271–1277
Zhang L et al (2004) Engineering tropane biosynthetic pathway in Hyoscyamus niger hairy root cultures. Proc Natl Acad Sci USA 101:6786–6791
Zhang L, Yang B, Lu B, Kai G, Wang Z, Xia Y, Ding R, Zhang H, Sun X, Chen W, Tang K (2007) Tropane alkaloids production in transgenic Hyoscyamus niger hairy root cultures over-expressing putrescine N-methyltransferase is methyl jasmonate-dependent. Planta 225:887–896
Acknowledgements
This research was financially supported by the Deputy of Research Affairs, Ferdowsi University of Mashhad, Iran.
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
The authors declare that they have no conflict of interest.
Additional information
Communicated by Maike Petersen.
Electronic supplementary material
Below is the link to the electronic supplementary material.
Rights and permissions
About this article
Cite this article
Dehghan, E., Reed, D.W., Covello, P.S. et al. Genetically engineered hairy root cultures of Hyoscyamus senecionis and H. muticus: ploidy as a promising parameter in the metabolic engineering of tropane alkaloids. Plant Cell Rep 36, 1615–1626 (2017). https://doi.org/10.1007/s00299-017-2178-0
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00299-017-2178-0