Abstract
The influence of pozzolanic materials on calcium-based soil stabilization technique has recently attracted researchers’ attention as such materials may catalyze the occurrence of pozzolanic reactions due to their high SiO2 and AL2O3 content. In this study, the effect of adding natural zeolite, which is a common pozzolanic material, on soil stabilized with cement kiln dust (CKD) is investigated. The optimal CKD content was determined by conducting tests on soil treated with percentages of CKD (0%, 2%, 4%, 6%, 8%, 10%, and 12%), and then, the optimal CKD treatment was applied on soil replaced by different zeolite percentages (1%, 3%, 5%, 10%, and 15%). Atterberg limits, swelling, California bearing ratio and unconfined compression tests were performed on all samples to evaluate the performance of additives in stabilization. Unconfined compression test samples were cured for 0, 7, 14 and 28 days to study the effect of time. Addition of CKD resulted in reduction of soil swelling and a significant increase in the long-term strength to an optimum of 10% that resulted in 3-folds of strength value higher than the based soil. Addition of 15% natural zeolite to the optimized CKD stabilized soil, caused 21% increase of strength higher than that with CKD optimized soil, however the swelling is only slightly reduced.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Akimkhan AM (2012) Structural and ion-exchange properties of natural Zeolite. In: Ion exchange technologies. InTech, London, UK, 262–282
Al-Homidy AA, Dahim MH, Abd El Aal AK (2017) Improvement of geotechnical properties of sabkha soil utilizing cement kiln dust. Journal of Rock Mechanics and Geotechnical Engineering 9(4):749–760, DOI: https://doi.org/10.1016/j.jrmge.2016.11.012
Al-Swaidani A, Hammoud I, Meziab A (2016) Effect of adding natural pozzolana on geotechnical properties of lime-stabilized clayey soil. Journal of Rock Mechanics and Geotechnical Engineering 8(5):714–725, DOI: https://doi.org/10.1016/j.jrmge.2016.04.002
Ansary MA, Noor MA, Islam M (2007) Effect of fly ash stabilization on geotechnical properties of chittagong coastal soil. In: Soil stressstrain behavior: Measurement, modeling and analysis. Springer, Dordrecht, Netherlands, 443–454
Anwar Hossain KM (2011) Stabilized soils incorporating combinations of rice husk ash and cement kiln dust. Journal of Materials in Civil Engineering 23(9):1320–1327, DOI: https://doi.org/10.1061/(ASCE)MT.1943-5533.0000310
ASTM D422 (2007) Standard test method for particle-size analysis of soils. ASTM D422, ASTM International, West Conshohocken, PA, USA
ASTM D854 (2014) Standard test methods for specific gravity of soil solids by water pycnometer. ASTM D854, ASTM International, West Conshohocken, PA, USA
ASTM D1883 (1999) Standard test method for california bearing ratio (CBR) of laboratory-compacted soils. ASTM D1883, ASTM International, West Conshohocken, PA, USA
ASTM D2166 (2016) Standard test method for unconfined compressive strength of cohesive soil. ASTM D2166, ASTM International, West Conshohocken, PA, USA, USA
ASTM D2487 (2017) Standard practice for classification of soils for engineering purposes (Unified Soil Classification System). ASTM D2487, ASTM International, West Conshohocken, PA, USA
ASTM D4318 (2017) Standard test methods for liquid limit, plastic limit, and plasticity index of soils. ASTM D 4318, ASTM International, West Conshohocken, PA, USA
ASTM D4546 (2014) Standard test methods for one-dimensional swell or collapse of soils. ASTM D4546, ASTM International, West Conshohocken, PA, USA
ASTM D6276 (2019) Standard test method for using pH to estimate the soil-lime proportion requirement for soil stabilization. ASTM D6276, ASTM International, West Conshohocken, PA, USA
Asuri S, Keshavamurthy P (2016) Expansive soil characterisation: An appraisal. INAE Letters 1(1):29–33, DOI: https://doi.org/10.1007/s41403-016-0001-9
Baghdadi ZA, Fatani MN, Sabban NA (1995) Soil modification by cement kiln dust. Journal of Materials in Civil Engineering 7(4):218–222, DOI: https://doi.org/10.1061/(ASCE)0899-1561(1995)7:4(218)
Behnood A (2018) Soil and clay stabilization with calcium- and non-calcium-based additives: A state-of-the-art review of challenges, approaches and techniques. Transportation Geotechnics 17:14–32, DOI: https://doi.org/10.1016/j.trgeo.2018.08.002
Bell FG (1996) Lime stabilization of clay minerals and soils. Engineering Geology 42(4):223–237, DOI: https://doi.org/10.1016/0013-7952(96)00028-2
Diamond S, Kinter EB (1965) Mechanisms of soil-lime stabilization. Highway Research Record 92:83–102
Eades JL, Grim RE (1960) A quick test to determine lime requirements for lime stabilization. Highway Research Board, National Research Council, Washington DC, USA, 61–72
Firoozi AA, Guney Olgun C, Baghini MS (2017) Fundamentals of soil stabilization. International Journal of Geo-Engineering 8(1):26, DOI: https://doi.org/10.1186/s40703-017-0064-9
Ghobadi MH, Abdilor Y, Babazadeh R (2014) Stabilization of clay soils using lime and effect of pH variations on shear strength parameters. Bulletin of Engineering Geology and the Environment 73(2):611–619, DOI: https://doi.org/10.1007/s10064-013-0563-7
Harichane K, Ghrici M, Gadouri H (2019) Natural pozzolana used as a source of silica for improving the behaviour of lime-stabilised clayey soil. Arabian Journal of Geosciences 12(15):447, DOI: https://doi.org/10.1007/s12517-019-4635-2
Hilt GH, Davidson DT (1960) Lime fixation in clayey soils. Highway Research Record 20–32
Hossain KMA, Mol L (2011) Some engineering properties of stabilized clayey soils incorporating natural pozzolans and industrial wastes. Construction and Building Materials 25(8):3495–3501, DOI: https://doi.org/10.1016/j.conbuildmat.2011.03.042
Ismail AIM, Belal ZL (2016) Use of cement kiln dust on the engineering modification of soil materials, Nile Delta, Egypt. Geotechnical and Geological Engineering 34(2):463–469, DOI: https://doi.org/10.1007/s10706-015-9957-6
Ismeik M, Shaqour F (2020) Effectiveness of lime in stabilising subgrade soils subjected to freeze-thaw cycles. Road Materials and Pavement Design 21(1):42–60, DOI: https://doi.org/10.1080/14680629.2018.1479289
Khalid U, Rehman Z (2018) Evaluation of compaction parameters of fine-grained soils using standard and modified efforts. International Journal of Geo-Engineering 9:15, DOI: https://doi.org/10.1186/s40703-018-0083-1
Khatib JM, Baalbaki O, ElKordi AA (2018) Metakaolin. In: Waste and supplementary cementitious materials in concrete. Elsevier, Amsterdam, Netherlands, 493–511
Kolay Parbir K, Wadiah N (2005) Effect of fine content on compaction characteristics of sandy soil. National Civil Engineering Conference (NACEC), Batu Pahat, Malaysia
Kunal, Siddique R, Rajor A (2012) Use of cement kiln dust in cement concrete and its leachate characteristics. Resources, Conservation and Recycling 61:59–68, DOI: https://doi.org/10.1016/j.resconrec.2012.01.006
Massazza F (1998) Pozzolana and pozzolanic cements. In: Lea’s chemistry of cement and concrete. Elsevier, Amsterdam, Netherlands, 471–635
Miller GA, Azad S (2000) Influence of soil type on stabilization with cement kiln dust. Construction and Building Materials 14(2):89–97, DOI: https://doi.org/10.1016/S0950-0618(00)00007-6
MolaAbasi H, Naderi Semsani S, Saberian M, Khajeh A, Li J, Harandi M (2020a) Evaluation of the long-term performance of stabilized sandy soil using binary mixtures: A micro- and macro-level approach. Journal of Cleaner Production 267:122209, DOI: https://doi.org/10.1016/j.jclepro.2020.122209
MolaAbasi H, Saberian M, Li J (2019) Prediction of compressive and tensile strengths of zeolite-cemented sand using porosity and composition. Construction and Building Materials 202:784–795, DOI: https://doi.org/10.1016/j.conbuildmat.2019.01.065
Mola-Abasi H, Saberian M, Semsani SN, Li J, Khajeh A (2020b) Triaxial behaviour of zeolite-cemented sand. Proceedings of the Institution of Civil Engineers — Ground Improvement 173(2):82–92, DOI: https://doi.org/10.1680/jgrim.18.00009
Mola-Abasi H, Shooshpasha I (2016) Influence of zeolite and cement additions on mechanical behavior of sandy soil. Journal of Rock Mechanics and Geotechnical Engineering 8(5):746–752, DOI: https://doi.org/10.1016/j.jrmge.2016.01.008
Mousavi SE (2018) Utilization of silica fume to maximize the filler and pozzolanic effects of stabilized soil with cement. Geotechnical and Geological Engineering 36(1):77–87, DOI: https://doi.org/10.1007/s10706-017-0305-x
Mousavi F, Abdi E, Rahimi H (2014) Effect of polymer stabilizer on swelling potential and CBR of forest road material. KSCE Journal of Civil Engineering 18(11):2064–2071, DOI: https://doi.org/10.1007/s12205-014-0137-7
Okafor FO, Egbe EA (2013) Potentials of cement kiln dust in sub-grade improvement. Nigerian Journal of Technology 32(1):109–116
Poon CS, Lam L, Kou SC, Lin ZS (1999) A study on the hydration rate of natural zeolite blended cement pastes. Construction and Building Materials 13(8):427–432, DOI: https://doi.org/10.1016/S0950-0618(99)00048-3
Salahudeen AB, Eberemu AO, Osinubi KJ (2014) Assessment of cement kiln dust-treated expansive soil for the construction of flexible pavements. Geotechnical and Geological Engineering 32(4):923–931, DOI: https://doi.org/10.1007/s10706-014-9769-0
Shaqour F, Ismeik M, Esaifan M (2017) Alkali activation of natural clay using a Ca(OH)2/Na2CO3 alkaline mixture. Clay Minerals 52:485–496, DOI: https://doi.org/10.1180/claymin.2017.052.4.06
Sharma RK (2017) Laboratory study on stabilization of clayey soil with cement kiln dust and fiber. Geotechnical and Geological Engineering 35(5):2291–2302, DOI: https://doi.org/10.1007/s10706-017-0245-5
Sharo AA, Alawneh, AS (2016) Enhancement of the strength and swelling characteristics of expansive clayey soil using nano-clay material. In: Geo-Chicago 2016. American Society of Civil Engineers, Reston, VA, USA, 451–457
Sharo AA, Alhowaidi YA, Al-Tawaha MS (2019) Improving properties of expansive soil using cement, quick lime and cement-lime blend. International Review of Civil Engineering (IRECE) 10(2):94, DOI: https://doi.org/10.15866/irece.v10i2.16064
Sharo AA, Ashteyat AM, Alawneh AS, Bany Khaled BA (2018) The use of oil shale fly ash to improve the properties of Irbid soil. World Journal of Engineering 15(5):614–625, DOI: https://doi.org/10.1108/WJE-10-2017-0325
Sivapullaiah PV, Sridharan A, Bhaskar Raju KV (2000) Role of amount and type of clay in the lime stabilization of soils. Proceedings of the Institution of Civil Engineers — Ground Improvement 4(1):37–45, DOI: https://doi.org/10.1680/grim.2000.4.1.37
Solanki P, Khoury N, Zaman MM (2009) Engineering properties and moisture susceptibility of silty clay stabilized with lime, class C fly ash, and cement kiln dust. Journal of Materials in Civil Engineering 21(12):749–757, DOI: https://doi.org/10.1061/(ASCE)0899-1561(2009)21:12(749)
Solanki P, Zaman M (2012) Microstructural and mineralogical characterization of clay stabilized using calcium-based stabilizers. In: Scanning electron microscopy. InTech, London, UK, 772–798
Sreekrishnavilasam A, Rahardja S, Kmetz R, Santagata M (2007) Soil treatment using fresh and landfilled cement kiln dust. Construction and Building Materials 21(2):318–327, DOI: https://doi.org/10.1016/j.conbuildmat.2005.08.015
Turkoz M, Vural P (2013) The effects of cement and natural zeolite additives on problematic clay soils. Science and Engineering of Composite Materials 20(4):395–405, DOI: https://doi.org/10.1515/secm-2012-0104
Wilson S (1970) Suggested method of test for moisture-density relations of soils using Harvard compaction apparatus. In: Special procedures for testing soil and rock for engineering purposes (fifth edition). ASTM International, West Conshohocken, PA, USA, 101–103
Yoobanpot N, Jamsawang P, Horpibulsuk S (2017) Strength behavior and microstructural characteristics of soft clay stabilized with cement kiln dust and fly ash residue. Applied Clay Science 141:146–156, DOI: https://doi.org/10.1016/j.clay.2017.02.028
Yukselen-Aksoy Y (2010) Characterization of two natural zeolites for geotechnical and geoenvironmental applications. Applied Clay Science 50(1):130–136, DOI: https://doi.org/10.1016/j.clay.2010.07.015
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Sharo, A.A., Shaqour, F.M. & Ayyad, J.M. Maximizing Strength of CKD — Stabilized Expansive Clayey Soil Using Natural Zeolite. KSCE J Civ Eng 25, 1204–1213 (2021). https://doi.org/10.1007/s12205-021-0786-2
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12205-021-0786-2