Abstract
An anaerobic thermophilic bacterial strain, A9 (NITE P-03545), that secretes β-glucosidase was newly isolated from wastewater sediments by screening using esculin. The 16S rRNA gene sequence of strain A9 had 100% identity with that of Thermobrachium celere type strain JW/YL-NZ35. The complete genome sequence of strain A9 showed 98.4% average nucleotide identity with strain JW/YL-NZ35. However, strain A9 had different physiological properties from strain JW/YL-NZ35, which cannot secrete β-glucosidases or grow on cellobiose as the sole carbon source. The key β-glucosidase gene (TcBG1) of strain A9, which belongs to glycoside hydrolase family 1, was characterized. Recombinant β-glucosidase (rTcBG1) hydrolyzed cellooligosaccharides to glucose effectively. Furthermore, rTcBG1 showed high thermostability (at 60°C for 2 days) and high glucose tolerance (IC50 = 0.75 M glucose), suggesting that rTcBG1 could be used for biological cellulose saccharification in cocultures with Clostridium thermocellum. High cellulose degradation was observed when strain A9 was cocultured with C. thermocellum in a medium containing 50 g/l crystalline cellulose, and glucose accumulation in the culture supernatant reached 35.2 g/l. In contrast, neither a monoculture of C. thermocellum nor coculture of C. thermocellum with strain JW/YL-NZ35 realized efficient cellulose degradation or high glucose accumulation. These results show that the β-glucosidase secreted by strain A9 degrades cellulose effectively in combination with C. thermocellum cellulosomes and has the potential to be used in a new biological cellulose saccharification process that does not require supplementation with β-glucosidases.
Key points
• Strain A9 can secrete a thermostable β-glucosidase that has high glucose tolerance
• A coculture of strain A9 and C. thermocellum showed high cellulose degradation
• Strain A9 achieves biological saccharification without addition of β-glucosidase
Similar content being viewed by others
Avoid common mistakes on your manuscript.
Introduction
The bioconversion of cellulosic biomass to sugars is a major bottleneck in the development of methods for the use of cellulosic feedstocks and the commercialization of bio-based chemicals and biofuels. This bottleneck occurs because cellulosic biomass is resistant to enzymatic degradation and the hydrolytic enzymes required are expensive. β-Glucosidase is a hydrolytic enzyme that can produce glucose from cellobiose and cellooligosaccharides (Meleiro et al. 2015). Cellobiose strongly inhibits both endoglucanase and exoglucanase (Chamoli et al. 2016; Murphy et al. 2013; Zhao et al. 2013), which is considered to be the main barrier to complete cellulose degradation (Singhania et al. 2013; Sørensen et al. 2013; Teugjas and Väljamäe 2013).
Many microorganisms capable of producing cellulolytic enzymes have been reported and characterized (Lynd et al. 2002). Clostridium thermocellum (Ruminiclostridium thermocellum, Hungateiclostridium thermocellum, Acetivibrio thermocellus)—an anaerobic thermophilic bacterium—is the most potent cellulose-degrading bacterium known to produce “cellulosomes” (Bayer et al. 2004; Lynd et al. 2002). These cellulosomes contain a large variety of enzymes, including enzymes with the potential to degrade cellulosic biomass (Bayer et al. 2004). However, feedback inhibition of cellulosomes and cellulosomal enzymes occurs as cellobiose accumulates as the final product because C. thermocellum is unable to produce extracellular β-glucosidases. Many efforts have been made to obtain low-cost β-glucosidases, including screening and engineering for β-glucosidases with higher activity (Gefen et al. 2012; Pei et al. 2012; Teugjas and Väljamäe 2013; Yi et al. 2013) and the development of novel processes for protein recycling (Waeonukul et al. 2012, 2013). To relieve the feedback inhibition and promote cellulose saccharification, we have demonstrated previously that glucose can be produced from cellulosic biomass by C. thermocellum cultures supplemented with thermostable β-glucosidases in a process called biological simultaneous enzyme production and saccharification (Prawitwong et al. 2013). Recently, Zhang et al. (Zhang et al. 2017) constructed a recombinant strain of C. thermocellum that produced an exoglucanase (named CelS) bearing heterologous β-glucosidase (BglA from Caldicellulosiruptor sp. F32), which was assembled in the cellulosome through a dockerin module of CelS. The production of reducing sugars from microcrystalline cellulose, such as Avicel, was enhanced using this system, which resolved the issue of feedback inhibition by hydrolyzing the accumulated cellobiose into glucose. However, to use recombinant C. thermocellum, it is still necessary to optimize suitable β-glucosidases for the cellulosomes. Additionally, biosafety issues must be considered when using genetically modified microbes in industrial applications (Friehs 2004; Kumar 2014).
Here, we report the newly isolated Thermobrachium celere strain A9. Strain A9 can secrete β-glucosidase into the culture medium. To the best of our knowledge, there are no reports on anaerobic thermophilic bacteria that can secrete appreciable amounts of β-glucosidase. Coculture of strain A9 and C. thermocellum has the potential to be used in the development of a new biological cellulose saccharification process that does not require any supplemental β-glucosidases or recombinant techniques.
Materials and methods
Materials, media, and cultivation methods
Samples of soil and wastewater sediment were collected from the layer 20 cm under the draining wastewater systems at different sampling sites at the Pilot Plant Development and Training Institute, King Mongkut’s University of Technology Thonburi, Thailand. The soil and wastewater sediment samples were stored in resealable zipper storage bags. The basal medium (BM7CO) (Waeonukul et al. 2012) was composed of (per liter) 2.9 g of K2HPO4, 1.5 g of KH2PO4, 2.1 g of urea, 6.0 g of yeast extract, 4.0 g of Na2CO3, 0.01 g of CaCl2·2H2O, 0.5 g of cysteine-HCl, 0.0005 g of resazurin, and 200 μl of mineral solution (all from FUJIFILM Wako Pure Chemicals, Osaka, Japan). BM7CO medium was degassed by boiling, then bubbled with high-purity CO2, and finally anaerobically distributed to Hungate tubes (Bellco Glass, Inc., Vineland, NJ, USA) and/or serum bottles. Clostridium thermocellum ATCC 27405T was obtained from the American Type Culture Collection (ATCC) and was grown on BM7CO medium containing 10 g/l microcrystalline cellulose Sigmacell type 20 (Sigma-Aldrich; St. Louis, MO, USA). T. celere-type strain JW/YL-NZ35 (DSM8682T) was obtained from the German Collection of Microorganisms and Cell Cultures GmbH (DSMZ). Strain JW/YL-NZ35 was grown on modified DSMZ616 (YTG) medium composed of (per liter): 0.36 g of Na2HPO4·2H2O, 0.08 g of KCl, 5.0 g of yeast extract, 10.0 g of Bacto™ tryptone (Thermo Fisher Scientific, MA, USA), 5.3 g of Na2CO3, 0.2 g of cysteine-HCl, 0.2 g of Na2S, and 0.0005 g of resazurin (pH 9.0) containing 5.0 g of D-glucose or cellobiose. The YTG medium was also degassed, followed by bubbling with high-purity N2. Escherichia coli BL21 (DE3) and the plasmid pET19b (Merck KGaA, Darmstadt, Germany) served as the cloning and expression host and vector, respectively.
Enrichment, screening, and isolation of anaerobic thermophilic bacteria secreting β-glucosidase
Approximately 1 g of each of the collected samples of soil and wastewater sediment was inoculated directly into 10 ml of BM7CO medium containing 0.5% (w/v) cellobiose. After inoculation, the cultures were incubated at 60°C for 2–3 days. The cultures were inoculated into the same fresh medium, and the enrichment culture was repeated five times. To select cultures with high β-glucosidase activity, the supernatants of the enrichment cultures were collected by centrifugation at 10,806 × g at 4°C for 10 min, and the β-glucosidase activity was measured using p-nitrophenol-β-D-glucoside (pNPG; FUJIFILM Wako Pure Chemicals) as the substrate (Ahamed and Vermette 2008). Cultures that exhibited high β-glucosidase activity were selected and the enrichment culture was repeated three times using the same medium containing cellobiose. Then, single colony isolation from the cultures chosen was carried out using the Hungate roll tube technique (Hungate 1969) and BM7CO-agar medium with 5 g/l cellobiose as a carbon source; this medium was supplemented with 1 g/l esculin (Tokyo Chemical Industry Co., Ltd., Tokyo, Japan) and 2.5 g/l ferric ammonium citrate (FUJIFILM Wako Pure Chemicals). Colonies producing extracellular β-glucosidases were detected by the formation of a dark brown halo (Fig. 1). Colonies that formed a dark brown halo following degradation of esculin were individually selected from the roll tubes and inoculated into the same medium with cellobiose as described above (Fig. 1). Eventually, strain A9 was identified as the bacterium producing the highest β-glucosidase activity in culture supernatants.
Identification and genome features of strain A9
Genomic DNA from strain A9 was extracted using a NucleoSpin® microbial DNA kit (Takara Bio, Shiga, Japan). The 16S rRNA gene was amplified using the bacterial domain-specific primers 27F and 1525R (Osborne et al. 2005). The 16S rRNA gene sequence was analyzed using the nucleotide BLAST program and manually aligned with sequences in the GenBank database using CLUSTAL_X v.1.81 (Thompson et al. 1994). A phylogenetic tree was prepared using the results of the 16S rRNA sequence comparison by the neighbor-joining method using the programs BioEdit (Hall 1999) and MEGA (Tamura et al. 2007).
Whole-genome sequence analysis of strain A9 was performed using the Ion GeneStudio S5 system, following the previously reported analytical method (Nakazono-Nagaoka et al. 2019). The genome was assembled de novo using CLC Genomics Workbench 20.0.1 (CLC Bio, Qiagen, Valencia, CA, USA). The whole-genome sequence was deposited in GenBank with accession number BMAP00000000. Average nucleotide identity (ANI) values, digital DNA–DNA hybridization (dDDH) values, and average amino acid identity (AAI) were calculated using the ANI calculator (www.ezbiocloud. Net/tools/ani) (Yoon et al. 2017), genome-to-genome distance calculator (GGDC) (http://ggdc.dsmz.de/distcalc2.php) (Meier-Kolthoff et al. 2013), and AAI calculator (http://enve-omics.ce.gatech.edu/aai) (Konstantinidis and Tiedje 2005), respectively.
Construction of β-glucosidase expression vector and production of recombinant protein
Two oligonucleotide primers for β-glucosidase (GenBank accession number: GFR35525.1) designed from the draft genome sequence data of strain A9, 5′-GGGGATCCATGCAAAAATACACTTTCCC-3′ with a BamHI site, and 5′-GGCTCAGCTCATTCACAAAGGCTATTAT-3′ with a Bpu1102 site, were synthesized to amplify the coding region of the β-glucosidase gene (TcBG1) by PCR. The PCR product was digested with BamHI and Bpu1102, and then ligated into pET19b. The recombinant E. coli clone was inoculated into Luria-Bertani medium supplemented with 100 μg/ml ampicillin and incubated at 37°C. Isopropyl-β-D-thiogalactopyranoside was added to induce protein expression. The recombinant enzyme was purified using the Profinia affinity chromatography system (Bio-Rad Laboratories, Hercules, CA, USA). The homogeneity of the purified protein was determined by sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE; ATTO, Tokyo, Japan). Molecular mass standards were from Bio-Rad Laboratories.
Enzyme activity and zymogram analysis
β-Glucosidase activity was determined by measuring the hydrolysis of pNPG. The reaction mixture contained 10 μl of enzyme and 100 μl of 1 mM pNPG in 100 mM sodium acetate buffer, pH 6.0. After incubation at 60°C for 10 min, the reaction was stopped by adding 200 μl of 0.4 M Na2CO3. The released p-nitrophenol was measured using a spectrophotometer at 405 nm (Waeonukul et al. 2012). One unit (U) of β-glucosidase activity was defined as the amount of enzyme that liberated 1 μmol of p-nitrophenol per min per ml. The activity of the enzyme toward cellobiose and cellooligosaccharides (cellotriose, cellotetraose, cellopentaose, and cellohexaose; Megazyme, Bray, Ireland) was also assayed at 60°C for 10 min. The reaction mixture contained 50 μl of enzyme and 50 μl of 50 mg/ml cellooligosaccharide in 100 mM sodium acetate buffer, pH 6.0. The concentration of glucose released from the cellooligosaccharides was determined using a glucose oxidase–peroxidase assay kit (FUJIFILM Wako Pure Chemicals). One U of enzyme activity was defined as the amount of enzyme that liberated 1 μmol of glucose per min per ml. To determine the mode of action toward cellooligosaccharides, reaction mixtures were collected after 10, 20, 30, 40, 50 and 60 s. Each substrate (10 mg/ml) was incubated with enzyme (0.5 U) at 60°C. The hydrolysis products were analyzed using thin-layer chromatography. Protein concentrations were determined using a Coomassie protein assay kit (Thermo Fisher Scientific, Waltham, MA, USA) with bovine serum albumin as the standard.
The optimum pH for enzyme activity was determined at 60°C with pNPG as substrate in buffers with pH values 4.0–9.0. The buffers used were 100 mM sodium acetate for pH 4.0–6.0, 100 mM phosphate for pH 6.0–8.0, and 100 mM Tris-HCl for pH 8.0–9.0. The optimal temperature for enzyme activity was determined at pH 6.0 (in sodium acetate buffer) from 40 to 80°C. Thermostability was determined by preincubating the enzyme (1 μg protein) without substrate in sodium acetate buffer (pH 6.0) for 1 h at 50–80°C; the residual β-glucosidase activity for each condition was then assayed at 60°C to determine thermostability. Also, enzyme in sodium acetate buffer (pH 6.0) was incubated at 60°C for 7 days; a sample of the incubated enzyme was collected every 24 h to measure the residual β-glucosidase activity. Glucose inhibition of β-glucosidase activity was measured by adding glucose at different concentrations (0–1.0 M) to the standard reaction mixture with pNPG as the substrate. The glucose concentration required to inhibit 50% of the initial β-glucosidase activity (the IC50 value) was determined. The relative activity (%) was defined as the value relative to the activity in the absence of glucose.
Native PAGE was performed at pH 8.3 using 10% acrylamide as the resolving gel with a 5% stacking gel (pH 6.8). After electrophoresis, the gel was soaked in 100 mM sodium acetate buffer (pH 6.0) for 10 min at room temperature. β-Glucosidase activity in the gel was detected by staining with esculin mixed with ferric ammonium citrate or using 4-methylumbelliferyl-β-D-glucoside (4-MUG; FUJIFILM Wako Pure Chemicals). For staining with esculin mixed with ferric ammonium citrate, the gel was incubated in 100 mM sodium acetate buffer containing 1 g/l esculin and 2.5 g/l ferric ammonium citrate for 10–30 min at 50°C (Kwon et al. 1994). For the detection of β-glucosidase using 4-MUG, the gel was incubated in 100 mM sodium acetate buffer containing 10 mM 4-MUG for 30 min at 50°C. The active bands in the gel were detected under UV light using a gel documentation system.
Monitoring of bacterial growth and extracellular β-glucosidase production
Strain A9 and T. celere-type strain JW/YL-NZ35 were cultured in BM7CO and YTG medium, respectively, containing 5 g/l cellobiose or other carbohydrates (e.g., xylose and arabinose). In the YTG medium, cellobiose or other carbohydrates were used as carbon sources instead of glucose. Cell growth was measured by cell turbidity determined using a spectrophotometer at 600 nm (Thermo Fisher Scientific) and 10-mm pathlength cuvettes. The total cell growth was determined by measuring the total protein concentration following a previous report (Shikata et al. 2018). The culture supernatants during cell growth were collected and analyzed for β-glucosidase activity using zymography.
Cells of strain A9 during the exponential phase were observed by scanning electron microscopy (SEM; Jeol JSM-6320F, Tokyo, Japan) in accordance with the manufacturer’s instructions.
Saccharification of microcrystalline cellulose by coculture of strain A9 and C. thermocellum
For subculturing, C. thermocellum ATCC27405T stock culture was inoculated by syringe into 5 mL of BM7CO medium containing 10 g/l cellulose and was incubated at 60°C in anaerobic conditions. The subculture of C. thermocellum ATCC27405T was inoculated again by syringe into BM7CO medium containing 50 g/l Sigmacell type 20 at 60°C for 2 days. To avoid the possibility of competitive growth inhibition of C. thermocellum in the coculture, the subculture of strain A9 or T. celere-type strain JW/YL-NZ35 was inoculated after cultivation of C. thermocellum for 2 days. The cocultures of C. thermocellum and strain A9 or type strain JW/YL-NZ35 were incubated at 60°C for 10 days in anaerobic conditions. The β-glucosidase activity and the concentration of accumulated glucose in the culture supernatants were monitored by an enzymatic assay using pNPG and high-performance liquid chromatography (Shimadzu Corp., Kyoto, Japan), respectively.
Repositories
National Institute of Technology and Evaluation (NITE): KM-A9 (NITE P-03545)
The GenBank accession numbers for the genome sequences of Thermobrachium celere strain A9 and T. celere type strain JW/YL-NZ35 are BMAP00000000 and CAVN000000000, respectively.
Results
Enrichment, screening, and isolation of anaerobic thermophilic bacteria producing extracellular β-glucosidases
More than 100 samples of soil and wastewater sediment were collected and individually cultured in BM7CO medium containing 5 g/l cellobiose as the sole carbon source in thermophilic growth conditions (i.e., 60°C). The cultures grew well on the cellobiose medium. To isolate bacteria that produced high β-glucosidase activity in the culture supernatants, enrichment culturing was performed at least five times. Single colonies were separated by the anaerobic Hungate roll tube technique using cellobiose as the sole carbon source in an agar medium supplemented with esculin and ferric ammonium citrate. Generally, pNPG and 4-MUG are used to screen for microbes producing β-glucosidase; however, these chemicals are unstable over long periods of incubation at >50°C, and, therefore, they are not suitable for use as substrates for the screening of thermophilic microbes producing β-glucosidase. Thus, esculin, which is stable during incubation at high temperatures, was used as the substrate. The principle of the assay is the formation of a dark brown color, which is a result of the chelation of esculetin, produced from esculin by β-glucosidase, with ferric ions in the medium (Fig. 1). Therefore, it is expected that bacteria that secrete β-glucosidase will show a dark brown halo around their colonies (Fig. 1). A dark brown halo was observed around many of the colonies in the roll tubes (Fig. 1). Colonies that formed a dark brown halo were picked up from the roll tubes and inoculated again into BM7CO liquid medium containing cellobiose. To confirm whether these colonies could secrete β-glucosidase into the culture medium, the β-glucosidase activity in the supernatants from each culture was measured. Approximately 20 cultures were observed to have relatively high β-glucosidase activity in the culture supernatant; strain A9 showed the highest β-glucosidase activity of all the cultures. To confirm the bacterial purity, strain A9 was verified by repeated single colony isolation from roll tube cultures and its morphology was investigated using microscopic analysis.
The full-length 16S rRNA gene sequence of the isolated strain A9 (GenBank accession number: OK_036794.1) was compared with other sequences from the GenBank database. Homology and phylogenetic analyses of sequences showed that the 16S rRNA gene of strain A9 had 100% identity with that of T. celere type strain JW/YL-NZ35 (DSM8682T) (Engle et al. 1996) (GenBank accession number: NR_026352.1), 99.0% identity with that of Caloramator indicus strain IndiB4 (Chrisostomos et al. 1996) (GenBank accession number: NR_026134.1), and 98.0% identity with that of Calo. coolhaasii strain Z (Plugge et al. 2000) (Fig. 2). The most similar bacterium, T. celere type strain JW/YL-NZ35, isolated from hot spring sediments in New Zealand, has been reported to produce hydrogen at high yields, and can produce an appreciable amount of ethanol depending on the growth conditions (Ciranna et al. 2011, 2012; Engle et al. 1996).
The whole-genome sequence of strain A9 was deposited in GenBank with accession number BMAP00000000. ANI values, dDDH values, and AAI were calculated between strain A9 and T. celere type strain JW/YL-NZ35. The ANI and dDDH values, which were based on the genomic sequences of strain A9 and type strain JW/YL-NZ35 (GenBank accession no. CAVN000000000), were 98.4% and 85.8%, respectively; these are above the defined thresholds for species delineation of 95–96% for ANI and 70% for GGDC (Goris et al. 2007; Richter and Rosselló-Móra 2009). T. celere strain A9 was deposited as KM-A9 (NITE P-03545) in the National Institute of Technology and Evaluation (NITE), Chiba, Japan.
T. celere is also known as Caloramator celer (Baena and Patel 2009; Ciranna et al. 2013); however, there is clear taxonomic reason for using this alternative name. When type strain T. celere JW/YL-NZ35 was isolated by Engle et al., there was a known relationship between T. celere and Calo. fervidus, which is formally named Clostridium fervidus (Patel et al. 1987), from 16S rRNA sequence analysis; however, there was no mention of Calo. celer. Additionally, type strain JW/YL-NZ35 is still listed as T. celere in the List of Prokaryotic Names with Standing in Nomenclature (https://lpsn.dsmz.de/species/thermobrachium-celere) and BacDive (https://bacdive.dsmz.de/strain/2516), which are popular worldwide databases for standardized bacterial information. We have used T. celere as the species name of strain A9 in this report to avoid confusion between genera.
Characterization of extracellular β-glucosidase from strain A9
To determine whether strain A9 could produce and secrete β-glucosidase into the culture medium during growth, the cell growth and extracellular β-glucosidase activity of strain A9 in BM7CO medium containing cellobiose as a carbon source were monitored (Fig. 3A). β-Glucosidase activity of 1.0 U/ml was detected in the culture medium after 4 h and this increased to 8.5 U/ml (8.29 U/mg protein) after 20 h (Fig. 3A). In contrast, no growth or extracellular β-glucosidase activity of T. celere type strain JW/YL-NZ35 was observed in cellobiose-containing medium based on YTG medium (Fig. 3A). One study reported that type strain JW/YL-NZ35 cannot use cellobiose as a carbon source (Engle et al. 1996). Strain JW/YL-NZ35 grew on the glucose medium; however, no extracellular β-glucosidase activity was observed in the culture medium (Fig. 3B). In contrast, in the glucose medium, the β-glucosidase activity and cell density of strain A9 were 7.17 U/ml (8.07 U/mg protein) and OD600 nm = 0.51, respectively, which are similar values to when strain A9 was grown on cellobiose medium (Fig. 3A). These results suggest that the expression of extracellular β-glucosidase by strain A9 may not be affected by the carbon source present in the medium.
To visualize the presence of β-glucosidases in the culture medium, colonies in roll tubes were analyzed using staining with esculin and ferric ammonium citrate, and culture supernatants of strain A9 during the logarithmic (4 h of cultivation) to stationary (16 h of cultivation) phases were analyzed for β-glucosidase activity by zymography with the same stain (Fig. 4A and B). A large, dark halo surrounded colonies of strain A9, indicating that this strain can grow in cellobiose medium and secrete β-glucosidase (Fig. 4A-1). Meanwhile, no colonies of T. celere type strain JW/YL-NZ35 were observed on YTG-agar containing cellobiose (Fig. 4A-2), and no halos were observed around colonies of T. celere type strain JW/YL-NZ35 grown on glucose medium (Fig. 4A-3). Zymogram analysis clearly showed the presence of secreted β-glucosidase (Fig. 4B) in the culture supernatants of strain A9, and the activity increased with cultivation time. To investigate whether strain A9 produced and secreted β-glucosidase from cells without cell lysis, cells of strain A9 during the exponential phase (16 h of cultivation) were imaged by SEM. The SEM results showed that the cells of strain A9 had a complete structure and did not show lysis or any other disruption (Fig. 4C). These data indicate that strain A9 secretes β-glucosidase into the culture medium without cell lysis.
Characterization of β-glucosidase (TcBG1) from strain A9
According to draft genome sequence analysis, strain A9 and T. celere type strain JW/YL-NZ35 have predicted β-glucosidases belonging to glycoside hydrolase (GH) families 1 (GenBank accession number: GFR35525.1) and 30 (GenBank accession number: GFR35524.1), and GH families 1 (GenBank accession number: CDF59168.1), 3 (GenBank accession number: CDF57462.1), and 30 (GenBank accession number: CDF59169.1), respectively. However, β-glucosidase activity is primarily found in GH families 1 and 3, and is less common in GH family 30 (Salgado et al. 2018). β-Glucosidases that belong to GH family 3 are strongly inhibited at low glucose concentrations. In contrast, most enzymes of GH family 1 show tolerance to glucose and have higher hydrolytic activity toward cellobiose than enzymes in GH family 3 (Srivastava et al. 2019). To understand the properties of the extracellular β-glucosidase from strain A9, we characterized the β-glucosidase (GFR35525.1) that had a molecular mass of approximately 50 kDa by zymogram analysis (Fig. 4B). The gene encoding this β-glucosidase was cloned and recombinant protein was produced.
The nucleotide sequence of the β-glucosidase gene (TcBG1) was 1,347 bp, encoding 448 amino acids with a calculated protein mass of 52 kDa. In SDS-PAGE analysis, the molecular mass of the recombinant β-glucosidase (rTcBG1) (Fig. 5-1 and -2) agreed with the molecular mass of the native β-glucosidase of strain A9 (Figs. 4B and 5-2). Zymogram analysis (Fig. 5-3, -4 and -5, -6) of rTcBG1 and the native β-glucosidase showed dark brown and white bands from the hydrolysis of esculin and 4-MUG, respectively. rTcBG1 exhibited its maximum enzymatic activity at pH 6.0–7.0 and 60–70°C. rTcBG1 was stable at 60°C for 72 h, retaining almost 100% of the initial activity (half-life 168 h) (Fig. 6A); after incubation at 70°C for 1 h, rTcBG1 retained 65% activity, but after incubation at 80°C for 1 h, >90% of the activity was lost (Fig. 6B). rTcBG1 retained 50% of the initial activity in the presence of a high glucose concentration (1 M) (Fig. 6C), which suggested that the extracellular β-glucosidase of strain A9 had a higher tolerance to glucose than GH1 β-glucosidases from other thermophilic anaerobic bacteria (Table 1). rTcBG1 also exhibited specific activity toward the cellooligosaccharides cellobiose, cellotriose, cellotetraose, cellopentaose, and cellohexaose with activities of 49.8, 47.6, 43.6, 30.7, and 28.8 U/mg protein, respectively (Table 2), suggesting that rTcBG1 can hydrolyze short-chain cellooligosaccharides faster than long-chain cellooligosaccharides (Fig. 7). These results for rTcBG1 indicate that the extracellular β-glucosidase of strain A9 has favorable properties as a supplemental enzyme source for the biological saccharification of high concentrations of cellulose using C. thermocellum.
Cellulose saccharification using a coculture of strain A9 and C. thermocellum
Studies have demonstrated that the cellulose degradation ability is drastically enhanced, and glucose is accumulated in the culture medium, when C. thermocellum cultures are supplemented with thermostable β-glucosidases (Gefen et al. 2012; Prawitwong et al. 2013). This enhancement occurs because feedback inhibition caused by cellobiose can be resolved by supplementation with extracellular β-glucosidases. To evaluate whether strain A9 can replace this supplementation with β-glucosidase, a coculture of strain A9 and C. thermocellum was investigated using a medium containing a high concentration of microcrystalline cellulose (Fig. 8). When strain A9 was cocultured with C. thermocellum in BM7CO medium containing 50 g/l microcrystalline cellulose, cellulose was effectively converted to glucose, and a high concentration of glucose accumulated in the culture supernatant. The saccharification profile of the coculture of strain A9 and C. thermocellum showed efficient cellulose degradation, and glucose accumulation was increased after 3 days. The cellulose was degraded almost entirely within 8 days and the glucose accumulation reached 35.2 g/l in the culture supernatant (70.4% of the theoretical glucose yield based on the loading of microcrystalline cellulose) (Fig. 8A and B), which was almost the same yield as that obtained with purified β-glucosidase supplementation to culture of C. thermocellum (Prawitwong et al. 2013).
In contrast, monoculture of C. thermocellum or coculture of C. thermocellum with T. celere type strain JW/YL-NZ35 did not efficiently hydrolyze cellulose and had low β-glucosidase activity (Fig. 8A and B). The accumulated glucose concentration was <11.7 g/l (23.4% glucose yield), and cellulose substrate remained in the culture medium after 8 days (Fig. 8A, B). Strain A9 alone could not be grown in the cellulose medium (Fig. 8A and B). These results indicate that the extracellular β-glucosidase of strain A9 can cooperate with C. thermocellum cellulosomes and efficiently resolve feedback inhibition of the cellulosomes by cellobiose. Thus, strain A9 may be useful in combination with C. thermocellum to achieve biological cellulose saccharification without any enzyme supplementation.
Discussion
When C. thermocellum is grown on a medium containing a high cellulose concentration supplemented with a thermostable β-glucosidase, glucose is accumulated as an end-product at a high concentration in the culture supernatant. This direct saccharification of cellulose may result from resolution of the feedback inhibition of cellulosomes and cellulases by cellobiose, and the low affinity glucose uptake and the kinetics of cellobiose and cellooligosaccharide use by C. thermocellum (Nataf et al. 2009; Strobel et al. 1995; Zhang and Lynd 2005). The high cellulose degradation ability and high glucose accumulation capacity of the combination of C. thermocellum and β-glucosidase are promising as a direct cellulose saccharification technology without the need for supplementation of any cellulases or hemicellulases. Recently, a method to avoid the extra addition of β-glucosidases, using a recombinant C. thermocellum that can secrete β-glucosidase, has been developed (Qi et al. 2021; Zhang et al. 2017). This method of cellulose saccharification, termed whole-cell catalysis, is a useful technology for supplementation with β-glucosidases.
The complexity of biomasses with components such as hemicellulose means that it may be challenging to promote efficient degradation using recombinant C. thermocellum alone. Compounds such as xylooligosaccharides have been shown to cause a reduction in cellulolytic activity and a reduction in the maximum saccharification rate of crystalline cellulose (Beri et al. 2021). Cocultures of C. thermocellum with hemicellulose-consuming microbes using high concentrations of corn fiber exhibited lower levels of unfermented hemicellulose hydrolysis products and the maximum saccharification rate was increased, compared with culture of C. thermocellum alone (Beri et al. 2021). Strain A9 can use pentoses, such as xylose, arabinose, and xylan (Table S1). According to the draft genome sequence, strain A9 and T. celere type strain JW/YL-NZ35 possess an enzyme from GH family 30 (GenBank accession numbers: GFR35524.1 and CDF59169.1), which is a relatively novel xylanase that can be exo-acting and liberates xylose and xylobiose from the non-reducing end of xylan (Puchart et al. 2021). Type strain JW/YL-NZ35 could not use xylose or xylan (Table S1). However, strain A9 may be an excellent partner for coculture with thermophilic microbes for biological saccharification. Thus, it is desirable to develop not only C. thermocellum metabolically engineered by recombinant techniques, but also microbes that are applicable in coculture systems.
To develop an efficient saccharification system using natural biomass for practical applications, it is necessary to investigate anaerobic thermophilic microbes that can secrete β-glucosidases into the culture supernatant to work in cooperation with cellulosomes and cellulases. To date, few reports have investigated the screening and isolation of aerobic microbes that can produce β-glucosidase (Ahamed and Vermette 2008). Most anaerobic thermophilic bacteria possess intracellular β-glucosidases (Aït et al. 1982; Katayeva et al. 1992; Yang et al. 2015). One study has reported that C. stercorarium can partially secrete β-glucosidase into the culture medium when grown on cellobiose; however, most of the β-glucosidase activity remained cell-bound, with secretion only of a low quantity of β-glucosidase into the medium (Bronnenmeier and Staudenbauer 1988). To the best of our knowledge, the present study is the first report of the isolation of an anaerobic thermophilic bacterium capable of secreting β-glucosidase. The presence of a signal sequence is essential for the secretion of enzymes outside of the cell wall. According to the signal peptide predictor tool SignalP-5.0 (http://www.cbs.dtu.dk/services/SignalP/), the β-glucosidases (GFR35525.1 and CDF59168.1) of strain A9 and T. celere type strain JW/YL-NZ35 have a signal peptide sequence at the N-terminus; however, at least one other β-glucosidase listed in Table 1 does not have this feature. The β-glucosidases of strains A9 and JW/YL-NZ35 were 100% identical in amino acid sequence. Strain A9 may have more useful properties for cellobiose culture and β-glucosidase production than type strain JW/YL-NZ35. Type strain JW/YL-NZ35 has shown only poor β-glucosidase activity and low growth on cellobiose medium, even though JW/YL-NZ35 possesses the same GH family 1 β-glucosidase gene with the same amino acid sequence as strain A9. It is still unclear what the differences are between strain A9 and type strain JW/YL-NZ35; however, further characterization of strain A9 may provide more information regarding the expression and control of endogenous β-glucosidases in anaerobic microbes.
According to the Carbohydrate-Active Enzymes database (CAZy; http://www.cazy.org), β-glucosidases are mainly found in GH families 1 and 3 (Singh et al. 2016). However, this classification based on amino acid sequence similarity and conserved motifs does not consider many important functional aspects of β-glucosidases, such as glucose tolerance and glucose stimulation. Recently, categorization of β-glucosidases based on the effect of glucose on catalytic activity has been proposed (Cao et al. 2015; Srivastava et al. 2019). This functional classification divides β-glucosidases into four classes: (I) β-glucosidases that are strongly inhibited by low concentrations of glucose; (II) β-glucosidases that are glucose tolerant; (III) β-glucosidases that are stimulated by low concentrations of glucose and inhibited by high concentrations of glucose; and (IV) β-glucosidases that are not inhibited by high glucose concentration. The β-glucosidases from strain A9 and other anaerobic thermophilic bacteria (Table 1) may belong to class II (Cao et al. 2015; Salgado et al. 2018). Most of the β-glucosidases categorized as class II that have been characterized to date belong to GH family 1 and they have been isolated from a wide variety of sources, including bacteria, fungi, and from screening metagenomic DNA libraries (Salgado et al. 2018).
The maximum β-glucosidase activity of strain A9 was 6.02 ± 0.18 U/ml (17.7 ± 0.2 U/mg protein) when cocultured with C. thermocellum, while the production of extracellular β-glucosidase by recombinant C. thermocellum was 4.91 ± 0.44 U/ml in medium containing 50 g cellulose/l (Qi et al. 2021). It is desirable to determine whether the extracellular β-glucosidase activity of strain A9 is sufficient for the complete degradation of cellulose at high concentrations (such as 100 g cellulose/l). β-Glucosidase activity of 30–50 U/g cellulose was necessary to completely degrade 100 g/l cellulose when C. thermocellum S14 was cultured with the addition of CglT (Table 1) (Prawitwong et al. 2013). If strain A9 can consistently produce 6 U/ml of β-glucosidase in coculture with C. thermocellum in medium containing 100 g/l cellulose, the β-glucosidase activity will reach 60 U/g cellulose; if this activity can be achieved, coculture with strain A9 may be able to provide sufficient β-glucosidase activity for the complete degradation of 100 g/l cellulose. A β-glucosidase secreted from recombinant C. thermocellum [a different enzyme (BglA of Caldicellulosiruptor sp. F32) (Qi et al. 2021) than those produced by strain A9 and CglT (Table 1)], had sufficient β-glucosidase activity in saccharification tests using 50 g/l microcrystalline cellulose to degrade an estimated 50 U/g glucan. Although higher β-glucosidase activity than that of BglA might be obtained if the gene from strain A9 were used in recombinant C. thermocellum, supplementation of recombinant BglA with >50 U of β-glucosidase resulted in no further enhancement of glucose accumulation (Qi et al. 2021). Using strain A9 can relieve the inhibitory effect of cellobiose on cellulosomes during the biological saccharification process. Thus, coculture of strain A9 and C. thermocellum has potential in the development of a new biological cellulose saccharification process that does not require supplementation with external β-glucosidases.
Data availability
The datasets generated and analyzed during the current study are available in the GenBank repository. Accession numbers for the genome sequence of Thermobrachium celere strain A9 and T. celere type strain JW/YL-NZ35 are BMAP00000000 [https://www.ncbi.nlm.nih.gov/nuccore/BMAP00000000.1/] and CAVN000000000 [https://www.ncbi.nlm.nih.gov/nuccore/CAVN000000000.1/], respectively.
Change history
23 February 2022
The article note text "Rattiya Waeonukul and Akihiko Kosugi (rattiya.wae@kmutt.ac.th) share equal contribution." has been corrected to "Akihiko Kosugi and Rattiya Waeonukul (rattiya.wae@kmutt.ac.th) share equal contribution."
References
Ahamed A, Vermette P (2008) Enhanced enzyme production from mixed cultures of Trichoderma reesei RUT-C30 and Aspergillus niger LMA grown as fed batch in a stirred tank bioreactor. Biochem Eng J 42(1):41–46. https://doi.org/10.1016/j.bej.2008.05.007
Aït N, Creuzet N, Cattaneo J (1982) Properties of β-Glucosidase Purified from Clostridium thermocellum. Microbiology 128(3):569–577. https://doi.org/10.1099/00221287-128-3-569
Baena S, Patel BK. 2009. Genus V. Caloramator. In Paul DV. (ed), Bergey's manual of systematic bacteriology, 2nd ed, vol 3 The Firmicutes Springer-Verlag, New York, NY p 834–838
Bayer EA, Belaich JP, Shoham Y, Lamed R (2004) The cellulosomes: multienzyme machines for degradation of plant cell wall polysaccharides. Annu Rev Microbiol 58:521–54. https://doi.org/10.1146/annurev.micro.57.030502.091022
Beri D, Herring CD, Blahova S, Poudel S, Giannone RJ, Hettich RL, Lynd LR (2021) Coculture with hemicellulose-fermenting microbes reverses inhibition of corn fiber solubilization by Clostridium thermocellum at elevated solids loadings. Biotechnol Biofuels 14(1):24. https://doi.org/10.1186/s13068-020-01867-w
Bronnenmeier K, Staudenbauer WL (1988) Purification and properties of an extracellular β-glucosidase from the cellulolytic thermophile Clostridium stercorarium. Appl Microbiol Biotechnol 28(4):380–386. https://doi.org/10.1007/BF00268200
Cao LC, Wang ZJ, Ren GH, Kong W, Li L, Xie W, Liu YH (2015) Engineering a novel glucose-tolerant β-glucosidase as supplementation to enhance the hydrolysis of sugarcane bagasse at high glucose concentration. Biotechnol Biofuels 8:202. https://doi.org/10.1186/s13068-015-0383-z
Chamoli S, Kumar P, Navani NK, Verma AK (2016) Secretory expression, characterization and docking study of glucose-tolerant β-glucosidase from B. subtilis. Int J Biol Macromol 85:425–33. https://doi.org/10.1016/j.ijbiomac.2016.01.001
Chrisostomos S, Patel BKC, Dwivedi PP, Denman SE (1996) Caloramator indicus sp. nov., a new thermophilic anaerobic bacterium isolated from the deep-seated nonvolcanically heated waters of an indian artesian aquifer. Int J Syst Evol Micr 46(2):497–501. https://doi.org/10.1099/00207713-46-2-497
Ciranna A, Larjo A, Kivistö A, Santala V, Roos C, Karp M (2013) Draft genome sequence of the hydrogen- and ethanol-producing anaerobic alkalithermophilic bacterium Caloramator celer. Genome Announc 1(4):e00471-13. https://doi.org/10.1128/genomeA.00471-13
Ciranna A, Santala V, Karp M (2011) Biohydrogen production in alkalithermophilic conditions: Thermobrachium celere as a case study. Bioresour Technol 102(18):8714–8722. https://doi.org/10.1016/j.biortech.2011.01.028
Ciranna A, Santala V, Karp M (2012) Enhancing biohydrogen production of the alkalithermophile Thermobrachium celere. Int J Hydrogen Energ 37(7):5550–5558. https://doi.org/10.1016/j.ijhydene.2011.12.105
Engle M, Li Y, Rainey F, Deblois S, Mai V, Reichert A, Mayer F, Messner P, Wiegel J (1996) Thermobrachium celere gen. nov., sp. nov., a rapidly growing thermophilic, alkalitolerant, and proteolytic obligate anaerobe. Int J Syst Evol Microbiol 46(4):1025–1033 https://doi.org/10.1099/00207713-46-4-1025
Friehs K (2004) Plasmid copy number and plasmid stability. Adv Biochem Eng Biotechnol 86:47–82. https://doi.org/10.1007/b12440
Gefen G, Anbar M, Morag E, Lamed R, Bayer EA (2012) Enhanced cellulose degradation by targeted integration of a cohesin-fused β-glucosidase into the Clostridium thermocellum cellulosome. Proc Natl Acad Sci USA 109(26):10298–10303. https://doi.org/10.1073/pnas.1202747109
Goris J, Konstantinidis KT, Klappenbach JA, Coenye T, Vandamme P, Tiedje JM (2007) DNA-DNA hybridization values and their relationship to whole-genome sequence similarities. Int J Syst Evol Microbiol 57(Pt 1):81–91. https://doi.org/10.1099/ijs.0.64483-0
Hall TA (1999) BioEdit : a user-friendly biological sequence alignment editor and analysis program for Windows 95/98/NT. Nucleic Acids Symp Ser 41:95–98
Hungate RE (1969) Chapter IV A roll tube method for cultivation of strict anaerobes. In: Norris JR, Ribbons DW (eds) Methods Microbiol. vol 3. Academic Press Inc. London, pp117–132. https://doi.org/10.1016/S0580-9517(08)70503-8
Katayeva IA, Golovchenko NP, Chuvilskaya NA, Akimenko VK (1992) Clostridium thermocellum β-glucosidases A and B: purification, properties, localization, and regulation of biosynthesis. Enzyme Microb Technol 14(5):407–412. https://doi.org/10.1016/0141-0229(92)90011-C
Konstantinidis KT, Tiedje JM (2005) Towards a genome-based taxonomy for prokaryotes. J Bacteriol 187(18):6258–64. https://doi.org/10.1128/jb.187.18.6258-6264.2005
Kumar S (2014) Biosafety issues of genetically modified organisms. Biosafety 3:e150. https://doi.org/10.4172/2167-0331.1000e150
Kwon KS, Lee J, Kang HG, Hah YC (1994) Detection of β-glucosidase activity in polyacrylamide gels with esculin as substrate. Appl Environ Microbiol 60(12):4584–4586. https://doi.org/10.1128/aem.60.12.4584-4586.1994
Lynd LR, Weimer PJ, Zyl WHV, Pretorius IS (2002) Microbial cellulose utilization: fundamentals and biotechnology. Microbiol Mol Biol Rev 66(3):506–577. https://doi.org/10.1128/MMBR.66.3.506-577.2002
Meier-Kolthoff JP, Auch AF, Klenk HP, Göker M (2013) Genome sequence-based species delimitation with confidence intervals and improved distance functions. BMC Bioinform 14:60. https://doi.org/10.1186/1471-2105-14-60
Meleiro LP, Salgado JCS, Maldonado RF, Alponti JS, Zimbardi ALRL, Jorge JA, Ward RJ, Furriel RPM (2015) A Neurospora crassa ß-glucosidase with potential for lignocellulose hydrolysis shows strong glucose tolerance and stimulation by glucose and xylose. J Mol Catal B Enzym 122:131–140. https://doi.org/10.1016/j.molcatb.2015.09.003
Murphy L, Bohlin C, Baumann MJ, Olsen SN, Sørensen TH, Anderson L, Borch K, Westh P (2013) Product inhibition of five Hypocrea jecorina cellulases. Enzyme Microb Technol 52(3):163–169. https://doi.org/10.1016/j.enzmictec.2013.01.002
Nakazono-Nagaoka E, Fujikawa T, Shikata A, Tachaapaikoon C, Waeonukul R, Pason P, Ratanakhanokchai K, Kosugi A (2019) Draft genome sequence data of Clostridium thermocellum PAL5 possessing high cellulose-degradation ability. Data Brief 25:104274. https://doi.org/10.1016/j.dib.2019.104274
Nataf Y, Yaron S, Stahl F, Lamed R, Bayer EA, Scheper T-H, Sonenshein AL, Shoham Y (2009) Cellodextrin and laminaribiose ABC transporters in Clostridium thermocellum. J Bacteriol 191(1):203–209. https://doi.org/10.1128/JB.01190-08
Osborne CA, Galic M, Sangwan P, Janssen PH (2005) PCR-generated artefact from 16S rRNA gene-specific primers. FEMS Microbiol Lett 248(2):183–187. https://doi.org/10.1016/j.femsle.2005.05.043
Patel BKC, Monk C, Littleworth H, Morgan HW, Daniel RM (1987) Clostridium fervidus sp. nov., a new chemoorganotrophic acetogenic thermophile. Int J Syst Evol Microbiol 37(2):123–126 https://doi.org/10.1099/00207713-37-2-123
Pei J, Pang Q, Zhao L, Fan S, Shi H (2012) Thermoanaerobacterium thermosaccharolyticum β-glucosidase: a glucose-tolerant enzyme with high specific activity for cellobiose. Biotechnol Biofuels 5(1):31. https://doi.org/10.1186/1754-6834-5-31
Plugge CM, Zoetendal EG, Stams AJ (2000) Caloramator coolhaasii sp. nov., a glutamate-degrading, moderately thermophilic anaerobe. Int J Syst Evol Microbiol 50(Pt 3):1155–1162. https://doi.org/10.1099/00207713-50-3-1155
Prawitwong P, Waeonukul R, Tachaapaikoon C, Pason P, Ratanakhanokchai K, Deng L, Sermsathanaswadi J, Septiningrum K, Mori Y, Kosugi A (2013) Direct glucose production from lignocellulose using Clostridium thermocellum cultures supplemented with a thermostable β-glucosidase. Biotechnol Biofuels 6(1):184. https://doi.org/10.1186/1754-6834-6-184
Puchart V, Šuchová K, Biely P (2021) Xylanases of glycoside hydrolase family 30 - An overview. Biotechnol Adv 47:107704. https://doi.org/10.1016/j.biotechadv.2021.107704
Qi K, Chen C, Yan F, Feng Y, Bayer EA, Kosugi A, Cui Q, Liu YJ (2021) Coordinated β-glucosidase activity with the cellulosome is effective for enhanced lignocellulose saccharification. Bioresour Technol 337:125441. https://doi.org/10.1016/j.biortech.2021.125441
Richter M, Rosselló-Móra R (2009) Shifting the genomic gold standard for the prokaryotic species definition. Proc Natl Acad Sci U S A 106(45):19126–31. https://doi.org/10.1073/pnas.0906412106
Salgado JCS, Meleiro LP, Carli S, Ward RJ (2018) Glucose tolerant and glucose stimulated β-glucosidases - A review. Bioresour Technol 267:704–713. https://doi.org/10.1016/j.biortech.2018.07.137
Shikata A, Sermsathanaswadi J, Thianheng P, Baramee S, Tachaapaikoon C, Waeonukul R, Pason P, Ratanakhanokchai K, Kosugi A (2018) Characterization of an anaerobic, thermophilic, alkaliphilic, high lignocellulosic biomass-degrading bacterial community, ISHI-3, isolated from biocompost. Enzyme Microb Technol 118:66–75. https://doi.org/10.1016/j.enzmictec.2018.07.001
Singh G, Verma AK, Kumar V (2016) Catalytic properties, functional attributes and industrial applications of β-glucosidases. 3 Biotech 6(1):3 https://doi.org/10.1007/s13205-015-0328-z
Singhania RR, Patel AK, Sukumaran RK, Larroche C, Pandey A (2013) Role and significance of beta-glucosidases in the hydrolysis of cellulose for bioethanol production. Bioresour Technol 127:500–507. https://doi.org/10.1016/j.biortech.2012.09.012
Sørensen A, Lübeck M, Lübeck PS, Ahring BK (2013) Fungal Beta-glucosidases: a bottleneck in industrial use of lignocellulosic materials. Biomolecules 3(3):612–631. https://doi.org/10.3390/biom3030612
Srivastava N, Rathour R, Jha S, Pandey K, Srivastava M, Thakur VK, Sengar RS, Gupta VK, Mazumder PB, Khan AF, Mishra PK (2019) Microbial beta glucosidase enzymes: Recent advances in biomass conversation for biofuels application. Biomolecules 9(6):220. https://doi.org/10.3390/biom9060220
Strobel HJ, Caldwell FC, Dawson KA (1995) Carbohydrate transport by the anaerobic thermophile Clostridium thermocellum LQRI. Appl Environ Microbiol 61(11):4012–4015. https://doi.org/10.1128/aem.61.11.4012-4015.1995
Tamura K, Dudley J, Nei M, Kumar S (2007) MEGA4: molecular evolutionary genetics analysis (MEGA) software version 4.0. Mol Biol Evol 24(8):1596–1599 https://doi.org/10.1093/molbev/msm092
Teugjas H, Väljamäe P (2013) Selecting β-glucosidases to support cellulases in cellulose saccharification. Biotechnol Biofuels 6(1):105. https://doi.org/10.1186/1754-6834-6-105
Thompson JD, Higgins DG, Gibson TJ (1994) CLUSTAL W: improving the sensitivity of progressive multiple sequence alignment through sequence weighting, position-specific gap penalties and weight matrix choice. Nucleic Acids Res 22(22):4673–80. https://doi.org/10.1093/nar/22.22.4673
Waeonukul R, Kosugi A, Prawitwong P, Deng L, Tachaapaikoon C, Pason P, Ratanakhanokchai K, Saito M, Mori Y (2013) Novel cellulase recycling method using a combination of Clostridium thermocellum cellulosomes and Thermoanaerobacter brockii β-glucosidase. Bioresour Technol 130:424–430. https://doi.org/10.1016/j.biortech.2012.12.059
Waeonukul R, Kosugi A, Tachaapaikoon C, Pason P, Ratanakhanokchai K, Prawitwong P, Deng L, Saito M, Mori Y (2012) Efficient saccharification of ammonia soaked rice straw by combination of Clostridium thermocellum cellulosome and Thermoanaerobacter brockii β-glucosidase. Bioresour Technol 107:352–357. https://doi.org/10.1016/j.biortech.2011.12.126
Yang F, Yang X, Li Z, Du C, Wang J, Li S (2015) Overexpression and characterization of a glucose-tolerant β-glucosidase from T. aotearoense with high specific activity for cellobiose. Appl Microbiol Biotechnol 99(21):8903–8915 https://doi.org/10.1007/s00253-015-6619-9
Yi Z-L, Zhang S-B, Pei X-Q, Wu Z-L (2013) Design of mutants for enhanced thermostability of β-glycosidase BglY from Thermus thermophilus. Bioresour Technol 129:629–633. https://doi.org/10.1016/j.biortech.2012.12.098
Yoon SH, Ha SM, Lim J, Kwon S, Chun J (2017) A large-scale evaluation of algorithms to calculate average nucleotide identity. Anton Van Leeuwenhoek 110(10):1281–1286. https://doi.org/10.1007/s10482-017-0844-4
Zhang J, Liu S, Li R, Hong W, Xiao Y, Feng Y, Cui Q, Liu YJ (2017) Efficient whole-cell-catalyzing cellulose saccharification using engineered Clostridium thermocellum. Biotechnol Biofuels 10:124. https://doi.org/10.1186/s13068-017-0796-y
Zhang Y-HP, Lynd LR (2005) Cellulose utilization by Clostridium thermocellum: bioenergetics and hydrolysis product assimilation. Proc Natl Acad Sci U S A 102(20):7321–7325. https://doi.org/10.1073/pnas.0408734102
Zhao L, Pang Q, Xie J, Pei J, Wang F, Fan S (2013) Enzymatic properties of Thermoanaerobacterium thermosaccharolyticum β-glucosidase fused to Clostridium cellulovorans cellulose binding domain and its application in hydrolysis of microcrystalline cellulose. BMC Biotechnol 13:101. https://doi.org/10.1186/1472-6750-13-101
Acknowledgements
R. Waeonukul acknowledges the Counterpart Researcher Invitation Program of the Japan International Research Center for Agricultural Sciences. We thank Victoria Muir, Ph.D., from Edanz (https://jp.edanz.com/ac) for editing a draft of this manuscript.
Funding
This work was supported financially by the Exploratory Research for Advanced Technology (ERATO) project [grant number JPMJER1502] of the Japan Science and Technology Agency (JST) and the Science and Technology Research Partnership for Sustainable Development (SATREPS) [grant number JPMJSA1801], the Japan Science and Technology Agency (JST)/Japan International Cooperation Agency (JICA), and the Qingdao independent innovation major project [grant number 21-1-2-23-hz]. S. Nhim was supported by the “Petchra Pra Jom Klao Ph.D. Research Scholarship” and King Mongkut’s University of Technology Thonburi under “KMUTT Research Center of Excellent Project, Grant number 7601.24/4054.”
Author information
Authors and Affiliations
Contributions
Conceived the study: SN, RW, AK. Performed the experiments: SN, RW. Analyzed the data: SN, RW, AU, SB, KR, CT, PP, AK. Curated information: SN, RW, AU, AK. Wrote the initial draft of the manuscript: SN, RW. Review and editing: KR, RW, CT, YL, AK. Supervision: RW, CT, YL, AK. Project administration: RW, KR, AK. Funding acquisition: RW, AK. Commented on working versions of the manuscript and agreed on the final version of the manuscript: all.
Corresponding author
Ethics declarations
Ethics approval
This article does not contain any studies with human participants or animals performed by any of the authors.
Competing interest
The authors declare no competing interests.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Supplementary Information
Below is the link to the electronic supplementary material.
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Nhim, S., Waeonukul, R., Uke, A. et al. Biological cellulose saccharification using a coculture of Clostridium thermocellum and Thermobrachium celere strain A9. Appl Microbiol Biotechnol 106, 2133–2145 (2022). https://doi.org/10.1007/s00253-022-11818-0
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00253-022-11818-0