Abstract
Carbon quantum dots (CQDs) have emerged as a new generation of photoluminescent nanomaterials with wide applications. Among the various synthetic routes for CQDs, the acid-refluxingmethod, which belongs to the group of “top-down” methods, offers the advantage of large-scale production of CQDs and uses cheap and abundantly available starting materials. In this study, we evaluated the potential of fullerene carbon soot (FCS), a by-product obtained during the synthesis of fullerene, as the starting material for CQD production. It was found that FCS can be successfully converted to CQDs in high production yield in mixed acids, i.e., concentrated HNO3 and H2SO4, under mild conditions. The fluorescence quantum yield (Φ) of the as-produced CQDs is in the range of 3%–5%, which is the highest value for CQDs obtained from “top-down” methods. Importantly, the CQDs prepared by this method show emission in the yellow range of the visible light, which is advantageous for their various potential applications. Further investigations reveal that the CQDs are highly photostable over a wide pH range and show good resistance against ionic strength and long-termUV irradiation. This further expands their potential use under harsh conditions.
摘要
碳量子点已经成为具有巨大应用潜力的新一代光致发光纳米材料. 在碳量子点的众多制备方法中, 归属于“自上而下”法的酸回流处理含碳块体材料的技术有望实现碳量子点的宏量制备. 其中, 来源丰富、价格低廉原材料的选择是关键. 本文中, 我们详细考察了以富勒烯工业化生产过程中副产的炭灰为原料制备碳量子点的实际应用潜力. 研究发现, 在浓硝酸和浓硫酸作用下, 富勒烯炭灰能够成功地转化为碳量子点. 与用其他原料通过类似方法制备的碳量子点相比, 富勒烯炭灰制备的碳量子点具有较高的荧光量子产率, 达3%–5%. 更为重要的是, 光激发下富勒烯炭灰制备的碳量子点能够发射黄色荧光, 从而在生命科学等领域具有潜在应用. 进一步研究表明, 富勒烯炭灰制备的碳量子点在很宽的pH值范围内具有稳定的光致发光行为, 且能够抵御高的离子强度和长时间光照, 进而拓宽了其在苛刻条件下的应用潜力.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Alivisatos AP. Semiconductor clusters, nanocrystals, and quantum dots. Science, 1996, 271: 933–937
Michalet X, Pinaud FF, Bentolila LA, et al. Quantum dots for live cells, in vivo imaging, and diagnostics. Science, 2005, 307: 538–544
Resch-Genger U, Grabolle M, Cavaliere-Jaricot S, et al. Quantum dots versus organic dyes as fluorescent labels. Nat Meth, 2008, 5: 763–775
Lovric J, Cho SJ, Winnik FM, et al. Unmodified cadmium telluride quantum dots induce reactive oxygen species formation leading to multiple organelle damage and cell death. Chem Biol, 2005, 12: 1227–1234
Hardman R. A toxicologic review of quantum dots: toxicity depends on physicochemical and environmental factors. Environ Health Perspect, 2006, 114: 165–172
Geys J, Nemmar A, Verbeken E, et al. Acute toxicity and prothrombotic effects of quantum dots: impact of surface charge. Environ Health Perspect, 2008, 116: 1607–1613
Xu X, Ray R, Gu Y, et al. Electrophoretic analysis and purification of fluorescent single-walled carbon nanotube fragments. JAm Chem Soc, 2004, 126: 12736–12737
Baker SN, Baker GA. Luminescent carbon nanodots: emergent nanolights. Angew Chim Int Ed, 2010, 49: 6726–6744
Li H, Kang Z, Liu Y, et al. Carbon nanodots: synthesis, properties and applications. J Mater Chem, 2012, 22: 24230–24253
Lim SY, Shen W, Gao Z. Carbon quantum dots and their applications. Chem Soc Rev, 2015, 44: 362–381
Yu C, Liu Z, Chen Y, et al. CoS nanosheets-coupled graphene quantum dots architectures as a binder-free counter electrode for high-performance DSSCs. Sci China Mater, 2016, 59: 104–111
Sun YP, Zhou B, Lin Y, et al. Quantum-sized carbon dots for bright and colorful photoluminescence. J Am Chem Soc, 2006, 128: 7756–7757
Hu SL, Niu KY, Sun J, et al. One-step synthesis of fluorescent carbon nanoparticles by laser irradiation. J Mater Chem, 2009, 19: 484–488
Li X, Wang H, Shimizu Y, et al. Preparation of carbon quantum dots with tunable photoluminescence by rapid laser passivation in ordinary organic solvents. Chem Commun, 2011, 47: 932–934
Wang J, Wang CF, Chen S. Amphiphilic egg-derived carbon dots: rapid plasma fabrication, pyrolysis process, and multicolor printing patterns. Angew Chem Int Ed, 2012, 51: 9297–9301
Zhou J, Booker C, Li R, et al. An electrochemical avenue to blue luminescent nanocrystals from multiwalled carbon nanotubes (MWCNTs). J Am Chem Soc, 2007, 129: 744–745
Zhao QL, Zhang ZL, Huang BH, et al. Facile preparation of low cytotoxicity fluorescent carbon nanocrystals by electrooxidation of graphite. Chem Commun, 2008, 5116
Lu J, Yang J, Wang J, et al. One-pot synthesis of fluorescent carbon nanoribbons, nanoparticles, and graphene by the exfoliation of graphite in ionic liquids. ACS Nano, 2009, 3: 2367–2375
Li H, Ming H, Liu Y, et al. Fluorescent carbon nanoparticles: electrochemical synthesis and their pH sensitive photoluminescence properties. New J Chem, 2011, 35: 2666–2670
Tao H, Yang K, Ma Z, et al. In vivo NIR fluorescence imaging, biodistribution, and toxicology of photoluminescent carbon dots produced from carbon nanotubes and graphite. Small, 2012, 8: 281–290
Peng J, Gao W, Gupta BK, et al. Graphene quantum dots derived from carbon fibers. Nano Lett, 2012, 12: 844–849
Qiao ZA, Wang Y, Gao Y, et al. Commercially activated carbon as the source for producingmulticolor photoluminescent carbon dots by chemical oxidation. Chem Commun, 2009, 46: 8812–8814
Ye R, Xiang C, Lin J, et al. Coal as an abundant source of graphene quantum dots. Nat Commun, 2013, 4: 2943
Hu C, Yu C, Li M, et al. Chemically tailoring coal to fluorescent carbon dots with tuned size and their capacity for Cu(II) detection. Small, 2014, 10: 4926–4933
Dong Y, Lin J, Chen Y, et al. Graphene quantum dots, graphene oxide, carbon quantum dots and graphite nanocrystals in coals. Nanoscale, 2014, 6: 7410–7415
Wu M, Wang Y, Wu W, et al. Preparation of functionalized watersoluble photoluminescent carbon quantum dots from petroleum coke. Carbon, 2014, 78: 480–489
Wang Y, Wu W, Wu M, et al. Yellow-visual fluorescent carbon quantum dots from petroleum coke for the efficient detection of Cu2+ ions. New Carbon Mater, 2015, 30: 550–559
Shao X, Wu W, Wang R, et al. Engineering surface structure of petroleum-coke-derived carbon dots to enhance electron transfer for photooxidation. J Catal, 2016, 344: 236–241
Liu H, Ye T, Mao C. Fluorescent carbon nanoparticles derived from candle soot. Angew Chem Int Ed, 2007, 46: 6473–6475
Tian L, Ghosh D, Chen W, et al. Nanosized carbon particles from natural gas soot. Chem Mater, 2009, 21: 2803–2809
Ko HY, Chang YW, Paramasivam G, et al. In vivo imaging of tumour bearing near-infrared fluorescence-emitting carbon nanodots derived from tire soot. Chem Commun, 2013, 49: 10290–10292
Bourlinos AB, Stassinopoulos A, Anglos D, et al. Photoluminescent carbogenic dots. Chem Mater, 2008, 20: 4539–4541
Bourlinos AB, Stassinopoulos A, Anglos D, et al. Surface functionalized carbogenic quantum dots. Small, 2008, 4: 455–458
Krysmann MJ, Kelarakis A, Dallas P, et al. Formation mechanism of carbogenic nanoparticles with dual photoluminescence emission. J Am Chem Soc, 2012, 134: 747–750
Zhai X, Zhang P, Liu C, et al. Highly luminescent carbon nanodots by microwave-assisted pyrolysis. Chem Commun, 2012, 48: 7955–7957
Egashira M, Okada S, Korai Y, et al. Toluene-insoluble fraction of fullerene-soot as the electrode of a double-layer capacitor. J Power Sources, 2005, 148: 116–120
Spassova I, Khristova M, Nickolov R, et al. Novel application of depleted fullerene soot (DFS) as support of catalysts for low-temperature reduction of NO with CO. J Colloid Interface Sci, 2008, 320: 186–193
Hu C, Yu C, Li M, et al. Preparation of single-walled carbon nanotubes from fullerene waste soot. ACS Sustainable Chem Eng, 2014, 2: 14–18
Ciesielski A, Haar S, Aliprandi A, et al. Modifying the size of ultrasound-induced liquid-phase exfoliated graphene: fromnanosheets to nanodots. ACS Nano, 2016, 10: 10768–10777
Jiang BP, Zhou B, Shen XC, et al. Selective probing of gaseous ammonia using red-emitting carbon dots based on an interfacial response mechanism. Chem Eur J, 2015, 21: 18993–18999
Chen X, Lee GS, Zettl A, et al. Biomimetic engineering of carbon nanotubes by using cell surface mucin mimics. Angew Chem Int Ed, 2004, 43: 6111–6116
Xin X, Xu G, Zhao T, et al. Dispersing carbon nanotubes in aqueous solutions by a starlike block copolymer. J Phys Chem C, 2008, 112: 16377–16384
Jiang K, Sun S, Zhang L, et al. Red, green, and blue luminescence by carbon dots: full-color emission tuning and multicolor cellular imaging. Angew Chem Int Ed, 2015, 54: 5360–5363
Hu S, Trinchi A, Atkin P, et al. Tunable photoluminescence across the entire visible spectrum fromcarbon dots excited by white light. Angew Chem Int Ed, 2015, 54: 2970–2974
Ding H, Yu SB, Wei JS, et al. Full-color light-emitting carbon dots with a surface-state-controlled luminescence mechanism. ACS Nano, 2016, 10: 484–491
Pan D, Zhang J, Li Z, et al. Observation of pH-, solvent-, spin-, and excitation-dependent blue photoluminescence from carbon nanoparticles. Chem Commun, 2010, 46: 3681–3683
Li H, He X, Kang Z, et al. Water-soluble fluorescent carbon quantum dots and photocatalyst design. Angew Chim Int Ed, 2010, 49: 4430–4434
Shen J, Zhu Y, Yang X, et al. One-pot hydrothermal synthesis of graphene quantum dots surface-passivated by polyethylene glycol and their photoelectric conversion under near-infrared light. New J Chem, 2012, 36: 97–101
Peng H, Travas-Sejdic J. Simple aqueous solution route to luminescent carbogenic dots from carbohydrates. Chem Mater, 2009, 21: 5563–5565
Li L, Wu G, Yang G, et al. Focusing on luminescent graphene quantum dots: current status and future perspectives. Nanoscale, 2013, 5: 4015–4039
Fan J, Chu PK. Group IV nanoparticles: synthesis, properties, and biological applications. Small, 2010, 6: 2080–2098
Bao L, Liu C, Zhang ZL, et al. Photoluminescence-tunable carbon nanodots: surface-state energy-gap tuning. Adv Mater, 2015, 27: 1663–1667
Wang L, Zhu SJ, Wang HY, et al. Common origin of green luminescence in carbon nanodots and graphene quantum dots. ACS Nano, 2014, 8: 2541–2547
Dong Y, Pang H, Yang HB, et al. Carbon-based dots co-doped with nitrogen and sulfur for high quantum yield and excitation-independent emission. Angew Chem Int Ed, 2013, 52: 7800–7804
Song Y, Zhu S, Xiang S, et al. Investigation into the fluorescence quenching behaviors and applications of carbon dots. Nanoscale, 2014, 6: 4676–4682
Wu ZL, Gao MX, Wang TT, et al. A general quantitative pH sensor developed with dicyandiamide N-doped high quantum yield graphene quantum dots. Nanoscale, 2014, 6: 3868–3874
Zhu S, Meng Q, Wang L, et al. Highly photoluminescent carbon dots for multicolor patterning, sensors, and bioimaging. Angew Chem Int Ed, 2013, 52: 3953–3957
Acknowledgments
This work was supported by the National Natural Science Foundation of China (21402215 and 61474124) and the Hundred Talents Program of the Chinese Academy of Sciences (Y20245YBR1).
Author information
Authors and Affiliations
Corresponding author
Additional information
Qinghong Zhang was born in 1992. She obtained her BSc degree in chemistry fromNorth University of China in 2015 and is currently a graduate student at China Research Institute of Daily Chemical Industry. She is now involved in the synthesis and applications of surfactants.
Xiaofeng Sun was born in 1989. He obtained his MSc degree in applied chemistry from China Research Institute of Daily Chemical Industry in 2015 and is currently a PhD candidate at Lanzhou Institute of Chemical Physics, Chinese Academy of Sciences under the supervision of Prof. Hongguang Li. His research is mainly focused on the preparation and applications of carbon quantum dots.
Hongguang Li was born in 1979. He obtained his BSc degree and PhD degree from Shandong University in 2003 and 2008, respectively. After three years of postdoctoral research, he joined the Laboratory of Clean Energy Chemistry and Materials, Lanzhou Institute of Chemical Physics, Chinese Academy of Sciences as a full professor. His current research interest includes the design of novel π-conjugated molecules and engineering carbon nanomaterials such as fullerenes and carbon quantum dots for applications in optoelectronic devices.
Electronic supplementary material
Rights and permissions
About this article
Cite this article
Zhang, Q., Sun, X., Ruan, H. et al. Production of yellow-emitting carbon quantum dots from fullerene carbon soot. Sci. China Mater. 60, 141–150 (2017). https://doi.org/10.1007/s40843-016-5160-9
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s40843-016-5160-9