Abstract
In this study, thermal performance of double- and triple-pass solar air heater with longitudinal fins is mathematically evaluated. The effects of parameters, viz. mass flow rate, solar intensity and inlet temperature upon outlet temperature, thermal efficiency and increments in efficiency, power consumption are presented. The analytical solution for the mathematical model involving energy balance equations of different components of solar air heater is obtained using a MATLAB 8.1. Triple-pass solar air heater with fins exhibits better thermal performance, whereas double-pass solar air heater with fins is economically viable within the opted conditions. The results of the analytical models are in good agreement with experimental findings of earlier researchers.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
Abbreviations
- A c :
-
Surface area of the collector (m 2)
- A f :
-
Total surface area of the fins (m 2)
- B :
-
Fluid flow channel width (m)
- c p :
-
Specific heat of air at constant pressure (J/kg K)
- E :
-
Efficiency increment ratio
- G :
-
Air mass flow rate per unit area of collector (kg/m2 s)
- H :
-
Fluid flow channel height (m)
- h :
-
Heat transfer coefficient (W/m2 K)
- h b :
-
Conductive heat transfer coefficientacross the insulation (W/m2 K)
- I :
-
Incident solar radiation (W/m2)
- k s :
-
Thermal conductivity of absorber plate (W/m K)
- L :
-
Fluid flow channel length (m)
- L f :
-
Length of the fin (m)
- m :
-
Mass flow rate of air (kg/s)
- n :
-
Number of the fins
- P :
-
Power consumption increment ratio
- Q :
-
Useful energy gain of air (W)
- t :
-
Thickness of the fin (m)
- T :
-
Average temperature (K)
- U :
-
Power consumption (W)
- W f :
-
Height of the fin (m)
- α :
-
Absorptivity
- τ :
-
Transmissivity
- ɛ :
-
Emissivity
- η f :
-
Fin efficiency (%)
- η th :
-
Thermal efficiency (%)
- σ :
-
Stefan–Boltzmann constant (W/m2 K4)
- a:
-
Ambient
- ab:
-
Absorber plate
- b:
-
Back plate
- c:
-
Convection
- c1:
-
Cover-1
- c2:
-
Cover-2
- D:
-
Double pass
- f:
-
Fluid
- f1:
-
Fluid flow-1
- f2:
-
Fluid flow-2
- f3:
-
Fluid flow-3
- i:
-
Inlet
- o:
-
Outlet
- r:
-
Radiation
- S:
-
Single pass
- s:
-
Sky
- T:
-
Triple pass
- w:
-
Wind
References
Nandi S.K., Hoque M.N., Ghosh H.R., Chowdhury R.: Assessment of wind and solar energy resources in Bangladesh. Ar. J. Sci. Eng. 38(11), 3113–3123 (2013)
Yeh H.M., Lin T.T.: Efficiency improvements of flat plate solar air heaters. Energy 21(7), 435–443 (1996)
Lin W., Gao W., Liu T.: A parametric study on the thermal performance of cross-corrugated solar air collectors. App. Therm. Eng. 26, 1043–1053 (2006)
Akpinar E.K., Koçyiğit F.: Experimental investigation of thermal performance of solar air heater having different obstacle on absorber plates. Int. Commun. Heat Mass Transf. 37, 416–421 (2010)
Benli H.: Experimentally derived efficiency and exergy analysis of a new solar air heater having different surface shapes. Renew. Energy 50, 58–67 (2013)
Esen H.: Experimental energy and exergy analysis of a double flow solar air heater having different obstacles on absorber plates. Build. Environ. 43, 1046–1054 (2008)
Naphon P., Kongtragool B.: Theoretical study on heat transfer characteristics and performance of the flat plate solar air heaters. Int. Commun. Heat Mass Transf. 30, 1125–1136 (2003)
Sahu M.M., Bhagoria J.L.: Augmentation of heat transfer coefficient by using 90° broken transverse ribs on absorber plate of solar air heater. Renew. Energy 30, 2057–2073 (2005)
Omojaro A.P., Aldabbagh L.B.Y.: Experimental performance of single and double pass solar air heater with fins and steel wire mesh as absorber. Appl. Energy 87, 3759–3765 (2010)
Yeh H.M., Ho C.D., Hou J.Z.: Collector efficiency of double flow solar air heaters with fins attached. Energy 27, 715–725 (2002)
Karim M.A., Hawlader M.N.A.: Performance investigation of flat plate, v-corrugated and finned air collectors. Energy 31, 452–470 (2006)
El-Sebaii A.A., Aboul-Enein S., Ramadan M.R.I., Shalaby S.M., Moharram B.M.: Thermal performance investigation of double pass-finned plate solar air heater. Appl. Energy 88, 1727–1739 (2011)
Ramadan M.R.I., El-Sebaii A.A., About Enein S., El-Bialy E.: Thermal Performance of a packed bed double pass solar air heater. Energy 32, 1524–1535 (2007)
Languri E.M., Taherian H., Hooman K., Reisel J.: Enhanced double-pass solar air heater with and without porous medium. Int. J. Green Energy 8, 643–654 (2011)
Yeh H.M.: Upward-type flat-plate solar air heaters attached with fins and operated by an internal recycling for improved performance. J. Taiwan Inst. Chem. Eng. 43, 235–240 (2012)
Jafarkazemi F., Ahmadifard E.: Energetic and exergetic evaluation of flat plate solar collector. Renew. Energy 56, 55–63 (2013)
Ho C.D., Lin C.S., Chuang Y.C., Chao C.C.: Performance improvement of wire mesh packed double-pass solar air heaters with external recycle. Renew. Energy 57, 479–489 (2013)
El-Sebaii A.A., Al-Snani H.: Effect of selective coating on thermal performance of flat plate solar air heaters. Energy 35, 1820–1828 (2010)
Naphon P.: On the performance and entropy generation of the double-pass solar air heater with longitudinal fins. Renew. Energy 30, 1345–1357 (2005)
Mittal M.K., Varshney L.: Optimal thermohydraulic performance of a wire mesh packed solar air heater. Sol. Energy 80, 1112–1120 (2006)
Ho C.D., Chang H., Wang R.C., Lin C.S.: Performance improvement of a double-pass solar air heater with fins and baffles under recycle operation. Appl. Energy 100, 155–163 (2012)
Dhiman P., Thakur N.S., Chauhan S.R.: Thermal and thermohydraulic performance of counter and parallel flow packed bed solar air heaters. Renew. Energy 46, 259–268 (2012)
El-Sawi A.M., Wifi A.S., Younan M.Y., Elsayed E.A., Basily B.B.: Application of folded sheet metal in flat bed solar air collectors. Appl. Therm. Eng. 30, 864–871 (2010)
Sopian K., Alghoul M.A., Alfegi M.E., Sulaiman M.Y., Musa E.A.: Evaluation of thermal efficiency of double pass solar collector with porous-non porous media. Renew. Energy 34, 640–645 (2009)
Yeh H.M., Lin T.T.: The effect of collector aspect ratio on the collector efficiency of flat plate solar air heaters. Energy 20, 1041–1047 (1995)
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Velmurugan, P., Kalaivanan, R. Thermal Performance Studies on Multi-pass Flat-plate Solar Air Heater with Longitudinal Fins: An Analytical Approach. Arab J Sci Eng 40, 1141–1150 (2015). https://doi.org/10.1007/s13369-015-1573-5
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s13369-015-1573-5