Abstract
In this study, the heat transfer and friction factor of a shell and helically coiled tube heat exchanger using Al2O3 / water nanofluid at 0.1%, 0.4% and 0.8% particle volume concentration were tested. The test was conducted under laminar flow condition at 5100 < Rei < 8700. It is found that the overall heat transfer coefficient, inner heat transfer coefficient and experimental inner Nusselt number are 24%, 25% and 28%, respectively, higher than water at 0.8% particle volume concentration of nanofluid. It is observed that the presence of nanoparticles further intensify the formation of secondary flow and proper mixing of fluid when nanofluid passes through the helically coiled tube. Apart from further flow intensification, higher thermal conductivity of nanofluid and random movement of nanoparticles contribute to the enhanced heat transfer coefficient. Also found that the friction factor increases over particle volume concentration and this is due to increased nanofluid viscosity while increasing particle volume concentration.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
X. Wang, Xu and S. U. S. Choi, Thermal conductivity of nanoparticles fluid mixture, J. Thermo phy. and Heat Ttrans, 13 (1999) 474–480.
S. U. S. Choi and J. A. Eastman, Measuring of thermal conductivity of fluids containing oxide nanoparticles, J. Heat Trans, 121 (1999) 280–289.
Y. Xuan and W. Roetzel, Conceptions for heat transfer correlation of nanofluids, Int. J. Heat and Mass Trans, 43 (2000) 3701–3707.
S. K. Das, N. Putra and W. Roetzel, Temperature dependence of thermal conductivity for nanofluids, ASME J. Heat Trans, 125 (2003) 567–574.
Z. Y. Yang, G. Zhang, E. Grulke, B. William, Anderson and Gefei, Heat transfer properties of nanoparticle-in- fluid dispersions in laminar flow, Int. J. Heat and Mass Trans, 48 (2005) 1107–1116.
Y. Xuan and Qiang, Investigation on convective heat transfer and flow features of nanofluids. J. Heat Trans, 125 (2003) 151–155.
M. Chandrasekar, S. Suresh and R. Srinivasan, New analytical models to investigate thermal conductivity of nanofluids, J. Nano sci. and Nano Tech, 9 (2009) 533–538.
H. Xie, J. Wang, T. Xi, Y. Liu, F. Ai and Q. Wu, Thermal conductivity enhancement of suspensions containing nanosized Alumina particles, J. Appl. Phy, 91 (2002) 4568–4572.
B. C. Pak and Y. L. Cho, Hydrodynamic and heat transfer study of Dispersed fluids with submicron metallic oxide particles, Exp. Heat Trans, 11 (1998) 151–170.
H. E. Patel, S. K. Das, T. Sundrarajan and T. Pradeep, A micro convection model for thermal conductivity of nanofluids, Pramana-J. Phy, 65(5) (2005) 863–869.
S. Syamsunder, K. V. Sharma and S. Ramanathan, Experimental investigation of heat transfer enhancement with Al2O3 and twisted tape insert in a circular tube, Int. J. Nanotech and Appl, 2 (2007) 21–28.
M. Chandrasekar, S. Suresh and A. C. Bose, Experimental studies on heat transfer and friction factorcharacteristics of Al2O3 / water nanofluid in a circular pipe under laminar flow with wire coil inserts, Exp. Thermal and Fluid Sci, 34 (2010) 122–130.
L. B. Mapa and S. Mazhar, Heat transfer in mini heat exchanger using nanofluids, ASEE Northern Illinois University, Dekalb, IL/IN Sectional Conference (2005).
W. R. Dean, Note on the motion of fluid in a curved pipe, Philos. Mag, 4 (1927) 208–223.
A. N. Dravid, K. A. Smith, E. W. Merrill and P. L. T. Brain, Effect of secondary fluid motion on laminar flow heat transfer in helically coiled tubes, AlChE J, 17 (1971) 114–1122.
D. Wen and Y. Ding, Formulation of nanofluids for natural convective heat transfer applications, Int. J. Heat and Fluid flow, 26 (2005) 855–864.
L. A. M. Janssen and C. J. Hoogendoorn, Laminar convective heat transfer in helically coiled tubes, Int. J. Heat Mass Trans, 21 (1978) 1197–1206.
D. G. Prabhanjan, G. S. V. Ragavan and T. J. Rennie, Comparison of heat transfer rates between a straight tube heat exchanger and helically coiled heat exchanger, Int. Comm. of Heat Mass Trans. 29 (2002) 185–191.
M. R. Salimpour, Heat transfer coefficients of shell and coiled tube heat exchangers, Exp. Thermal and Fluid Sci, 33 (2009) 203–207.
M. R. Salimpour, Heat transfer characteristics of a temperature -dependent property fluid of shell and coiled tube heat exchangers, Int. Commn. in Heat and Mass Trans, 35 (2008) 1190–1195.
P. S. Srinivasan, S. N. Purkar and F. A. Holland, Friction factor for coils, Int.J. Chemical Engg., Transaction, 48 (1970) T156–T161.
A. Akbarinia, Impacts of nanofluids flow on skin friction factor and Nusselt number in curved tubes with constant mass flow, Int. J.Heat and Fluid Flow, 29 (2008) 229–241.
H. W. Coleman and W. G. Steele, Experimental and Uncertainty analysis for engineers, Wiley, New York (1989).
ANSI/ ASME, 1986, Measurement Uncertainty, PTC 19, 1-1985 (1986).
W. Yu, D. M. France, S. U. S. Choi and J. L. Routbort, Review and assessment of nanofluid technology for transportation and other applications, Argonne National Laboratory, April (2007).
B. Farajollahi, S. Gh. Etemed and M. Hojjat, Heat transfer of nanofluids in a shell and tube heat exchanger, Int. J. Heat and Mass Trans, 53 (2012) 12–17.
Author information
Authors and Affiliations
Corresponding author
Additional information
Recommended by Editor Yong Tae Kang
Mukesh Kumar P.C. was born in Tamil nadu, India in 1975. He received his Bachelor degree in Mechanical Engineering in 1997 under Madras University, Tamilnadu, India and Master’s degree on Energy Engineering in Regional Engineering College Trichy (currently NITT), Trichy, Tamilnadu, India in 2002. His research interest includes heat transfer, helically coiled heat exchanger with alumina nanofluid. He is working as Assistant Professor in Mechanical Engineering in Anna University of Technology Trichy of Tamilnadu India. He has published seven research papers in international journals and published one research article in international level conference.
Rights and permissions
About this article
Cite this article
Mukesh Kumar, P.C., Kumar, J. & Suresh, S. Experimental investigation on convective heat transfer and friction factor in a helically coiled tube with Al2O3/water nanofluid. J Mech Sci Technol 27, 239–245 (2013). https://doi.org/10.1007/s12206-012-1206-9
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12206-012-1206-9