Abstract
Carbon nanofiber (CNF) / Polypyrrole (Ppy) composite materials were fabricated by two newly invented processes - filtering, washing and drying the mixture of CNF dispersion and Ppy-NMP solution (FWP process) and heating an aqueous solution of CNF (SH process). CNF/Ppy composite materials have never been reported before in any other research papers. Conductivities of the composite films were obtained by using a four-probe method. To compare the conductivity of CNF/Ppy with that of a pure single-walled carbon nanotube (SWNT), SWNT films were also fabricated and voltage was measured. SEM images were taken for both a surface and a cross-section of composite samples fabricated by the two processes. The CNF/Ppy by FWP was a little brittle because of the low solubility of Ppy in the NMP, and on the other hand, the same material by SH became flexible enough. The conductivity of the pure SWNT film was as high as double the similar case. The conductivity of the pure SWNT film was 20.11 S/cm and 0.013 cm thick. The CNF/Ppy composite films with the thicknesses of 0.062 cm and 0.085 cm gave a conductivity of 63.32 S/cm and 40.57 S/cm, respectively, which are higher than that of the pure SWNT film or SWNT/Polyaniline (PANi) film. The good conductivity of CNF/Ppy composites shows the improved potential for developing the materials for a small actuator.
Article PDF
Similar content being viewed by others
Explore related subjects
Discover the latest articles, news and stories from top researchers in related subjects.Avoid common mistakes on your manuscript.
References
L. Bay, K. West, P. Sommer-Larsen, P. Skaarup and M. Benslimane, A conducting polymer artificial muscle with 12% linear strain, Adv. Mater. 15 (2003) 310–313.
A. S. Hutchison, T. W. Lewis, S. E. Moulton, G. M. Spinks and G. G. Wallace, Development of polypyrrole based electromechanical actuators, Synth. Met. 113 (2000) 121–127.
I. W. Hunter and S. Lafontaine, A comparison of muscle with artificial actuators, Proc. of Technical Digest IEEE Solid-State Sensor Actuator Workshop, Hilton Head, South Carolina, USA. (1992) 178–185.
S. Iijima, Helical microtubules of graphitic carbon, Nature, 354 (1991) 56–58.
P. Burgmayer and R. W. Murray, An ion gate membrane: electrochemical control of ion permeability through a membrane with an embedded electrode, J. American Chemical Society, 104 (1982) 6139–6140.
M. Tahhan, V. Truong, G. M. Spinks and G. G. Wallace, Carbon nanotube and polyaniline composite actuators, Smart Materials and Structures, 12 (2003) 626–632.
C. Kim and X. Y. Liu, Electromechanical behaviors and application of carbon nanotube composite actuator consisting of bundles and mats, J. The Korean Society for Composite Materials, 18 (2005) 34–39.
B. Kim, L. Lee and I. Yu, Electrical properties of single-wall carbon nanotube and epoxy composites, J. Appl. Phys. 94 (2003) 6724–6728.
J. Xua, J. P. Donohoeb and C. U. Pittman Jr., Preparation, electrical and mechanical properties of vapor grown carbon fiber (VGCF)/vinyl ester composites, Composites: Part A, 35 (2004) 693–701.
J. R. Dygas, G. Fafil and M. W. Breiter, Study of grain boundary polarization by two-probe and four-probe impedance spectroscopy, Solid State Ionics, 119(1) (1999) 115–125.
Author information
Authors and Affiliations
Corresponding author
Additional information
This paper was recommended for publication in revised form by Associate Editor Maenghyo Cho
Cheol Kim received a B.S. degree in Mechanical Engineering from Yonsei University in 1985 after his military service. He then received his M.S. from Georgia Tech in 1989 and Ph.D. from U. of Illinois at Urbana-Champaign in 1994. Dr. Kim is currently a Professor at the School of Mechanical Engineering at Kyungpook National University (KNU) in Daegu, Korea. He is currently serving as an associate editor of the Transactions of the KSME A. Shuai Zhang is a Ph.D. candidate. He received his B.S. in 2003 from HIT in China and M.S. in 2006 from KNU.
Rights and permissions
About this article
Cite this article
Kim, C., Zhang, S. Conductivity of carbon nanofiber/polypyrrole conducting nanocomposites. J Mech Sci Technol 23, 75–80 (2009). https://doi.org/10.1007/s12206-008-0911-x
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12206-008-0911-x