Abstract
Gas hydrate formation may be encountered during deep-water drilling because of the large amount and wide distribution of gas hydrates under the shallow seabed of the South China Sea. Hydrates are extremely sensitive to temperature and pressure changes, and drilling through gas hydrate formation may cause dissociation of hydrates, accompanied by changes in wellbore temperatures, pore pressures, and stress states, thereby leading to wellbore plastic yield and wellbore instability. Considering the coupling effect of seepage of drilling fluid into gas hydrate formation, heat conduction between drilling fluid and formation, hydrate dissociation, and transformation of the formation framework, this study established a multi-field coupling mathematical model of the wellbore in the hydrate formation. Furthermore, the influences of drilling fluid temperatures, densities, and soaking time on the instability of hydrate formation were calculated and analyzed. Results show that the greater the temperature difference between the drilling fluid and hydrate formation is, the faster the hydrate dissociates, the wider the plastic dissociation range is, and the greater the failure width becomes. When the temperature difference is greater than 7°C, the maximum rate of plastic deformation around the wellbore is more than 10%, which is along the direction of the minimum horizontal in-situ stress and associated with instability and damage on the surrounding rock. The hydrate dissociation is insensitive to the variation of drilling fluid density, thereby implying that the change of the density of drilling fluids has a minimal effect on the hydrate dissociation. Drilling fluids that are absorbed into the hydrate formation result in fast dissociation at the initial stage. As time elapses, the hydrate dissociation slows down, but the risk of wellbore instability is aggravated due to the prolonged submersion in drilling fluids. For the sake of the stability of the wellbore in deep-water drilling through hydrate formation, the drilling fluid with low temperatures should be given priority. The drilling process should be kept under balanced pressures, and the drilling time should be shortened.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Ahmadi, G., Ji, C., and Smith, D. H., 2007. Production of natural gas from methane hydrate by a constant downhole pressure well. Energy Conversion and Management, 48 (12): 2053–2068, DOI: 10.1016/j.enconman.2007.01.015.
Birchwood, R., Singh, R., and Mese, A., 2008. Estimating the in situ mechanical properties of sediments containing gas hydrates. Proceedings of the 6th International Conference on Gas Hydrates. Vancouver, British Columbia, Canada.
Brown, K. M., Bangs, N. L., Froelich, P. N., and Kvenvolden, K. A., 1996. The nature, distribution, and origin of gas hydrate in the Chile Triple Junction region. Earth and Planetary Science Letters, 139 (3–4): 471–483, DOI: 10.1016/0012-821X(95)00243-6.
Cheng, Y. F., Li, L. D., Mahmood, S., and Cui, Q., 2013. Fluidsolid coupling model for studying wellbore instability in drilling of gas hydrate bearing sediments. Applied Mathematics and Mechanics, 34 (11): 1421–1432, DOI 10.1007/s10483- 013-1756-7.
Cheng, Y. F., Shen, H. C., Li., L. D., Zhou, J. L., and Li, Q. P., 2011. Comprehensive and dynamical modeling for physical parameters of natural gas hydrate reservoirs and its application. Acta Petrolei Sinica, 32 (2): 320–323, DOI: 10.7623/syxb201102021 (in Chinese with English abstract).
Freij-Ayoub, R., Tan, C., Clennell, B., Tohidi, B., and Yang, J., 2007. A wellbore stability model for hydrate bearing sediments. Journal of Petroleum Science and Engineering, 57 (1): 209–220, DOI: 10.1016/j.petrol.2005.10.011.
Kim, H. C., Bishnoi, P. R., Heidemann, R. A., and Rizvi, S. S. H., 1987. Kinetics of methane hydrate decomposition. Chemical Engineering Science, 42 (7): 1645–1653, DOI: 10.1016/0009-2509(87)80169-0.
Lee, M. W., 2004. Elastic velocities of partially gas-saturated unconsolidated sediments. Marine and Petroleum Geology, 21 (6): 641–650, DOI: 10.1016/j.marpetgeo.2003.12.004.
Liu, H., Zhang, B., and Tian, G., 2016. Analysis of the ocean environment in South China Sea area. Ship & Ocean Engineering, 45 (5): 86–90 (in Chinese with English abstract).
Lu, B., and Xu, Z., 2006. Mathematical model for fluid-solid coupling near wellbore in elastic-plastic oil reservoir. Acta Petrolei Sinica, 27 (5): 131–134 (in Chinese with English abstract).
Masuda, Y., Naganawa, S., and Ando, S., 1997. Numerical calculation of gas production performance from reservoirs containing natural gas hydrates. SPE Journal, 29 (3): 201–210.
Nazridoust, K., and Ahmadi, G., 2007. Computational modeling of methane hydrate dissociation in a sandstone core. Chemical Engineering Science, 62 (22): 6155–6177, DOI: 10.1016/j.ces.2007.06.038.
Ning, F., Jiang, G., Zhang, L., Wu, X., Dou, B., and Tu, Y., 2008. Analysis of key factors affecting wellbore stability in gas hydrate formations. Petroleum Drilling Techniques, 36 (3): 59–61, DOI: 10.3969/j.issn.1001-0890.2008.03.014 (in Chinese with English abstract).
Nixon, M. F., 2005. Influence of gas hydrates on submarine slope stability. Master thesis. Department of Civil Engineering, University of Calgary, Alberta.
Rutqvist, J., Moridis, G. J., Grover, T., Silpngarmlert, S., Collett, T. S., and Holdich, S. A., 2012. Coupled multiphase fluid flow and wellbore stability analysis associated with gas production from oceanic hydrate-bearing sediments. Journal of Petroleum Science and Engineering, 92-93 (4): 65–81, DOI: 10.1016/j.petrol.2012.06.004.
Su, M., Yang, R., Wang, H., Sha, Z., Liang, J., Wu, N., Qiao, S., and Cong, X., 2016. Gas hydrates distribution in the Shenhu area, northern South China Sea: Comparisons between the eight drilling sites with gas-hydrate petroleum system. Geologica Acta, 14 (2): 79–100, DOI: 10.1344/GeologicaActa2016.14.2.1.
Sultan, N., Foucher, J. P., Cochonat, P., Tonnerre, T., Bourillet, J. F., Ondreas, H., Cauquil, E., and Grauls, D., 2004. Dynamics of gas hydrate: Case of the Congo continental slope. Marine Geology, 206 (1–4): 1–18, DOI: 10.1016/j.margeo.2004.03.005.
Tan, C. P., Clennell, M. B., Freij-Ayoub, R., Tohidi, B., and Yang, J., 2005. Mechanical and petrophysical characterisation and wellbore stability management in gas hydrate-bearing sediments. The 40th U.S. Symposium on Rock Mechanics, Alaska, USA, ARMA-05-833.
Volonté, G., Scarfato, F., and Brignoli, M., 2013. Sand prediction: A practical finite-element 3D approach for real field applications. SPE Production & Operations, 28 (1): 95–108, DOI: 10.2118/134464-PA.
Winters, W. J., Waite, W. F., Mason, D. H., Mason, D. H., Gilbert, L. Y., and Pecher, I. A., 2007. Methane gas hydrate effect on sediment and strength properties. Journal of Petroleum Science and Engineering, 56 (13): 127–135, DOI: 10.1016/j.petrol.2006.02.003.
Yu, X., Wang, J., Liang, J., Li, S., Zeng, X., Sha, Z., Kuang, Z., and Li, W., 2014. Depositional accumulation characteristics of gas hydrate in the northern continental slope of South China Sea. Acta Petrolei Sinica, 35 (4): 253–264, DOI: 10.7623/sxyb201402005 (in Chinese with English abstract).
Yun, T. S., Santamarina, J. C., and Ruppel, C. D., 2007. Mechanical properties of sand, silt, and clay containing tetrahydrofuran hydrate. Journal of Geophysical Research, 112: B04106, DOI: 10.1029/2006JB004484.
Zhang, G., Xie, X., Wang, W., Liu, S., Wang, Y., Dong, W., and Shen, H., 2013. Tectonic types of petroliferous basins and its exploration potential in the South China Sea. Acta Petrolei Sinica, 34 (4): 611–627, DOI: 10.7623/SYXB201304001 (in Chinese with English abstract).
Zhang, J. H., Hu, Q., and Liu, Z. H., 1994. A theoretical model for mud-filtrate invasion in reservoir formations during drilling. Acta Petrolei Sinica, 15 (4): 73–78, DOI: 10.7623/syxb199404010 (in Chinese with English abstract).
Zhang, W., Li, X., Li, Q., and Cao, J., 2015. Study on excess pore pressure by natural gas hydrate dissociation. Journal of Southwest Petroleum University (Science & Technology Edition), 37 (4): 107–116, DOI: 10.11885/j.issn.1674-5086.2013.16.01 (in Chinese with English abstract).
Zhou, S., Li, Q., Zhu, H., Zhang, H., Fu, Q., and Zhang, L., 2016. The current state and future of offshore energy exploration and development technology. Engineering Sciences, 18 (2): 19–31, DOI: 10.15302/J-SSCAE-2016.02.003 (in Chinese with English abstract).
Zhou, S. W., 2014. Study on Development Strategy of China’s Marine Engineering and Technology: Marine Energy Volumes. China Ocean Press, 10pp.
Zoback, M. D., 2007. Reservoir Geomechanics. Cambridge University Press, Cambridge, 172pp.
Acknowledgements
This study was supported by the Program for Changjiang Scholars and Innovative Research Teams in University (IRT_14R58), the Fundamental Research Funds for the Central Universities (No. 16CX06033A), the State Key Laboratory Program of Offshore Oil Exploitation, the National Key Research and Development Program (No. 2016 YFC0304005), the National Basic Research Program of China (973 Program, No. 2015CB251201), and the Qingdao Science and Technology Project (No. 15-9-1-55-jch).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Zhang, H., Cheng, Y., Li, Q. et al. Numerical analysis of wellbore instability in gas hydrate formation during deep-water drilling. J. Ocean Univ. China 17, 8–16 (2018). https://doi.org/10.1007/s11802-018-3447-4
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11802-018-3447-4