Abstract
The boiling heat transfer of evaporation cooling in a billet reheating furnace was simulated. The results indicate that the bubbles easily aggregate inside of the elbow and upper side of the horizontal regions in the π shaped support tubes. The circulation velocity increasing helps to improve the uniformity of vapor distribution and decrease the difference of vapor volume fraction between upper and down at end of the horizontal sections. With the increase of circulation velocity, the resistance loss and the circulation ratio both increase, but the former will decrease with the increase of work pressure.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
NUKIYAMA S. Maximum and minimum values of heat transmitted from a metal to boiling water under atmospheric pressure [J]. Journal of Soc Mechanics Eng, 1934, 37(206): 367–374.
BARTOLOMEJ G G, CHANTURIYA V M. Experimental study of true void fraction when boiling subcooled water in vertical tubes [J]. Thermal Engineering, 1967, 14: 123–128.
MIKIC B, ROHSENOW W M. A new correlation of pool-boiling data including the fact of heating surface characteristics [J]. ASME Journal of Heat Tansfer, 1969, 91(2): 245–250.
KLIMENKO V V, SUDARCHIKOV A M. Investigation of forced flow boiling of nitrogen in a long vertical tube [J]. Cryogenics, 1982, 23(7): 379–385.
KURUL N, PODOWSKI M Z. On the modeling of multidimensional effects in boiling channels [C]// 27th National Heat Transfer Conference. Minneapolis, Minnesota, USA: ANS, 1991: 28–31.
ISHIMOTO J, KAMIJO K. Numerical simulation of cavitating of liquid heliun in vertical channel [J]. Cryogenics, 2003, 43(1): 53–58.
BASU N, WARRIER G R, DHIR V K. Onset of nuclrate boiling and active nucleation site density during subcooled boiling [J]. Journal of Heat Transfer, 2002, 124(4): 717–728.
CHEN R F, LI Y Z, WANG S M. Numerical simulation of subcooled boiling water in vertical concentric annulus under low pressure [J]. Journal of Xi’an Jiaotong Unoversity, 2008, 42(7): 855–859.
LI S W, ZHANG H, JIANG S Y, YU J Y. Numerical simulation research of subcooled boiling water in vertical concentric annulus pipe under low pressure [J]. Nuclear Power Engineering, 2014, 35(1): 46–50.
UNAL H C. Maximum bubble diameter, maximum bubblegrowth time and bubble-growth rate during the subcooled nucleate flow boiling of water up to 17.7 MN/m2 [J]. International Journal of Heat and Mass Transfer, 1976, 19(5): 643–696.
DOU C C, MAO Y, WANG J, WANG J Y. Numerical simulation of subcooled boiling flow under high pressure and high subcooling condition [J]. Journal of Chemical Industry and Engineering, 2010, 51(3): 580–586.
FAN P, JIA D N, QIU S Z. CFD investigation of suncooled flow boiling model under low pressure [J]. Atomic Energy Science and Technology, 2011, 45(4): 412–420.
BYONG Y, ANDREW S, SIMON L, SONG C H. Prediction of a subcooled boiling flow with advanced two-phase models [J]. Nuclear Engineering and Design 253, 2012: 351–359.
ECKHARD K, ROLAND R. CFD for subcooled flow boiling: Simulation of DEBORA experiments [J]. Nuclear Engineering and Design, 2011, 241: 3851–3866.
FENG M J, WANG E G, HE J C. Numerical simulation on unsteady state heat transfer of work rolls during continuous hot strip rolling [J]. Acta Metallurgica Sinica, 2010, 46(8): 1009–1017.
LEMMERT M, CHAWLA J M. Influence of flow velocity on surface boiling heat transfer coefficient [M]. New York and Washington D. C: Academic Press and Hemisphere, 1977.
FRITZ H C. Maximum bubble diameter, maximum bubble growth time and bubble-growth rate [J]. International Journal of Heat and Mass Transfer, 1935, 36(5): 379–384.
COLER R. A photographic study of pool boiling in the region of the critical heat flux [J]. AIChE Journal, 1960, 6(4): 533–538.
ISHII M, ZUBER N. Drag coefficient and relative velocity in bubbly, droplet or particulate flows [J]. AIChE Journal, 1979, 25(5): 843–855.
DREW D A, LAHEY R T. The virtual mass and lift force on a sphere in rotating and straining inviscid flow [J]. International Journal of Multiphase Flow, 1987, 13(1): 113–121.
TOMIYAMA A. Struggle with computational bubble dynamics [C]// Third International Multiphase Conference. Lyon, France, 1998: 1–18.
ANGLART H, NYLUND O. CFD application to predicition of void distribution in two-phase bubbly flows in rod boundles [J]. Nuclear Engineering and Design, 1996, 163(1/2): 81–98.
RANZ W E, MARSHALL W R. Evaporation from drops [J]. Chemical Engineering Program, 1952, 48(1): 141–146.
LEE T H, PARK G C, LEE D J. Local flow characteristics of subcooled boiling flow of water in a vertical annulus [J]. International Journal of Multiphase Flow, 2002, 28(8): 1351–1368.
Author information
Authors and Affiliations
Corresponding author
Additional information
Foundation item: Project(51171041) supported by the National Natural Science Foundation of China
Rights and permissions
About this article
Cite this article
Feng, Mj., Wang, Eg., Wang, H. et al. Numerical simulation on boiling heat transfer of evaporation cooling in a billet reheating furnace. J. Cent. South Univ. 23, 1515–1524 (2016). https://doi.org/10.1007/s11771-016-3203-0
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11771-016-3203-0