Abstract
In order to investigate the effect of sampling frequency and time on pressure fluctuations, the three-dimensional unsteady numerical simulations were conducted in a circulating water pump. Through comparison of turbulence models with hydraulic performance experiment, SST k-ω model was confirmed to study the rational determination of sampling frequency and time better. The Fast Fourier Transform (FFT) technology was then adopted to process those fluctuating pressure signals obtained. On these bases, the characteristics of pressure fluctuations acting on the tongue were discussed. It is found that aliasing errors decrease at higher sampling frequency of 17 640 Hz, but not at a lower sampling frequency of 1 764 Hz. Correspondingly, an output frequency range ten-times wider is obtained at 17 640 Hz. Compared with 8R, when the sampling time is shorter, the amplitudes may be overvalued, and the frequencies and amplitudes of low-frequency fluctuations can not be well predicted. The frequencies at the tongue are in good agreement with the values calculated by formula and the frequency compositions less than the blade passing frequency are accurately predicted.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
DONG R, CHU S, KATZ J. Effect of modification to tongue and impeller geometry on unsteady flow, pressure fluctuations, and noise in a centrifugal pump [J]. Journal of Turbomachinery, 1997, 119(3): 506–515.
CHOI J S, MCLAUGHLIN D K, THOMPSON D E. Experiments on the unsteady flow field and noise generation in a centrifugal pump impeller [J]. Journal of Sound and Vibration, 2003, 263(3): 493–514.
SPENCE R, AMARAL-TEIXEIRA J. Investigation into pressure pulsations in a centrifugal pump using numerical methods supported by industrial tests [J]. Computers and Fluids, 2008, 37(6): 690–704.
LEE Sang-hyuk, WANG Yi-qi, SONG Jung-il. Fourier and wavelet transformations application to fault detection of induction motor with stator current [J]. Journal of Central South University of Technology, 2010, 17(1): 93–101.
PARRONDO-GAYO J, GONZÁLEZ-PÉREZ J, FERNÁNDEZ-FRAN COS J. The effect of the operating point on the pressure fluctuations at the blade passage frequency in the volute of a centrifugal pump [J]. Journal of Fluids Engineering, 2002, 124(3): 784–790.
BARRIO R, PARRONDO J, BLANCO E. Numerical analysis of the unsteady flow in the near-tongue region in a volute-type centrifugal pump for different operating points [J]. Computers & Fluids, 2010, 39(5): 859–870.
WANG H, TSUKAMOTO H. Experimental and numerical study of unsteady flow in a diffuser pump at off-design conditions [J]. Journal of Fluids Engineering, 2003, 125(5): 767–778.
SOLIS M, BAKIR F, KHELLADI S. Pressure fluctuations reduction in centrifugal pumps: Influence of impeller geometry and radial gap [C]// ASME 2009 Fluids Engineering Division Summer Meeting. Vail, 2009: 253–265.
MAJIDI K. Numerical study of unsteady flow in a centrifugal pump [J]. Journal of Turbomachinery, 2005, 127(2): 363–371.
DAI Cui. Study on pressure fluctuation of miniature circulation pump [D]. Zhenjiang: Research Center of Fluid Machinery Engineering and Technology, Jiangsu University, 2009: 28. (in Chinese)
DONG Liang, LIU Hou-lin, TAN Ming-gao, LU Ming-zhen, WANG Yong, WANG Kai. Quality measurement criteria and optimization algorithm of tetrahedral mesh for centrifugal pumps [J]. Journal of Xi’an Jiao Tong University, 2011, 45(11):100–105. (in Chinese)
VASUDEVA-KARANTH K, YAGNESH-SHARMA N. Numerical analysis on the effect of varying number of diffuser vanes on impeller-diffuser flow interaction in a centrifugal fan [J]. World Journal of Modeling and Simulation, 2009, 5(1): 63–71.
LUO Xian-wu, XU Hong-yuan, LIU Shu-hong. Effect of blade lean on mini pump hydraulic performance [J]. Journal of Tsinghua University: Science and Technology, 2005, 45(5): 704–707. (in Chinese)
LIU S H, NISHI M, YOSHIDA K. Impeller geometry suitable for mini turbo-pump [J]. Journal of Fluids Engineering, 2001, 123(3): 500–506.
YAKHOT V, ORSZAG S A, THANGAM S, GATSKI T B, SPEZIALE C G. Development of turbulence models for shear flows by a double expansion technique [J]. Physics of Fluids A, 1992, 4(7): 1510–1520.
MENTER F R. Two-equation eddy-viscosity turbulence models for engineering applications [J]. AIAA Journal, 1994, 32(8): 1598–1605.
GB/T 3216—2005. Rotadynamic pumps-Hydraulic performance acceptance tests-Grade 1 and 2 [S]. Beijing: Standards Press of China, 2006. (in Chinese)
WANG Yang, DAI Cui. Analysis on pressure fluctuation of unsteady flow in a centrifugal pump [J]. Transactions of the Chinese Society for Agricultural Machinery, 2010, 41(3): 91–95. (in Chinese)
FANG Gen-sun. Whittaker-Kotelnikov-Shannon sampling theorem and aliasing error [J]. Journal of Approximation Theory, 1996, 85(2): 115–131.
Author information
Authors and Affiliations
Corresponding author
Additional information
Foundation item: Project supported by the Priority Academic Development Program of Jiangsu Higher Education Institutions, China; Project (CXZZ12 0680) supported by Postgraduate Innovation Foundation of Jiangsu Province, China; Project(12JDG082) supported by the Advanced Talent Foundation of Jiangsu University, China
Rights and permissions
About this article
Cite this article
Dai, C., Kong, Fy. & Dong, L. Pressure fluctuation and its influencing factors in circulating water pump. J. Cent. South Univ. 20, 149–155 (2013). https://doi.org/10.1007/s11771-013-1470-6
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11771-013-1470-6