Abstract
Crambe abyssinica is a promising new oil crop because of the specific properties of its oil. However, little information is available concerning the properties of the proteins, which constitute a major component of the seed. Therefore, a method for the isolation of proteins from Crambe seeds was developed. Protein extractability for whole and dehulled Crambe meal was studied as a function of pH. Highest extractability was obtained with dehulled meal at pH 11. Double extraction at this pH increased the extractability to about 66%. Protein precipitation from the above-mentioned extract was studied as a function of pH with and without addition of a precipitating agent, i.e., carboxymethylcellulose (CMC). Addition of CMC resulted in a protein recovery of about 75% at pH 4.4. Without CMC, about half of the protein was recovered by isoelectric precipitation. The remaining soluble protein could be concentrated by ultrafiltration with a recovery of about 65%. The developed process, not including CMC addition, results in two protein fractions, i.e., an isoelectric precipitate (protein content 75%) and a retentate (protein content 87%), which together account for about 50% of the protein present in Crambe meal. Application of heat decreased protein extractability, but the protein contents of the resulting fractions were comparable to those from non-heat-treated meal.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Erickson, D.B., and P. Bassin, in Rapeseed and Crambe: Alternative Crops with Potential Industrial Uses, Bulletin 656, Agricultural Experiment Station, Kansas State University, Manhattan, 1990, pp. 4–9.
Lazzeri, L., L.S. Conte, and S. Palmieri, Agronomical and Technological Characterization of Italian-Grown Crambe abyssinica, Agr. Med. 123:55–64 (1993).
Laghetti, G., A.R. Piergiovanni, and P. Perrino, Yield and Oil Quality in Selected Lines of Crambe abyssinica Hochst. ex R.E. Fries and C. hispanica L. Grown in Italy, Ind. Crops Prod. 4:203–212 (1995).
Princen, L.H., and J.A. Rothfus, Development of New Crops for Industrial Raw Materials, J. Am. Oil Chem. Soc. 61:281–289 (1984).
Lazzeri, L., L. Leoni, L.S. Conte, and S. Palmieri, Some Technological Characteristics and Potential Uses of Crambe abyssinica Products, Ind. Crops Prod. 3:103–112 (1994).
Nieschlag, H.J., and I.A. Wolff, Industrial Uses of High Erucic Oils, J. Am. Oil Chem. Soc. 48:723–727 (1971).
Leonard, E.C., High-Erucic Vegetable Oils, Ind. Crops Prod. 1:119–123 (1993).
Carlson, K.D., and H.L. Tookey, Crambe Meal as a Protein Source for Feeds, J. Am. Oil Chem. Soc. 60:1979–1985 (1983).
Steg, A., V.A. Hindle, and Y.-G. Liu, By-Products of Some Novel Oil-Seeds for Feeding: Laboratory Evaluation, Anim. Feed Sci. Technol. 50:87–99 (1994).
Baker, E.C., G.C. Mustakas, M.R. Gumbmann, and D.H. Gould, Biological Evaluation of Crambe Meals Detoxified by Water Extraction on a Continuous Filter, J. Am. Oil Chem. Soc. 54:392–396 (1977).
Baker, E.C., G.C. Mustakas, and V.E. Sohns, Crambe Processing: Glucosinolate Removal by Water Washing on a Continuous Filter, Ibid.:387–391 (1977).
Mustakas, G.C., L.D. Kirk, E.L. Griffin Jr., and A.N. Booth, Crambe Seed Processing: Removal of Glucosinolates by Water Extraction, Ibid.:12–16 (1976).
Liu, Y.-G., A. Steg, B. Smits, and S. Tamminga, Crambe Meal: Removal of Glucosinolates by Heating with Additives and Water Extraction, Anim. Feed Sci. Technol. 48:273–287 (1994).
Massoura, E., J.M. Vereijken, P. Kolster, and J.T.P. Derksen, Proteins from Crambe abyssinica Oilseed. II. Biochemical and Functional Properties, J. Am. Oil Chem. Soc. 75:329–335 (1998).
Gillberg, L., and B. Törnell, Preparation of Rapeseed Protein Isolates. Precipitation of Rapeseed Proteins in the Presence of Polyacids, J. Food Sci. 41:1070–1075 (1976).
Approved Methods of the American Association of Cereal Chemists, 9th edn., The American Association of Cereal Chemists, Inc., St. Paul, 1995.
Carlson, K.D., E.C. Baker, and G.C. Mustakas, Processing Crambe abyssinica Seed in Commercial Extraction Facilities, J. Am. Oil Chem. Soc. 62:897–905 (1985).
VanEtten, C.H., M.E. Daxenbichler, J.E. Peters, I.A. Wolff, and A.N. Booth, Seed Meal from Crambe abyssinica, J. Agric. Food Chem. 13:24–27 (1965).
Naczk, M., L.L. Diosady, and L.J. Rubin, Functional Properties of Canola Meals Produced by a Two-Phase Solvent Extraction System, J. Food Sci. 50:1685–1688, 1692 (1985).
Mansour, E., E. Dworschák, J. Perédi, and A. Lugasi, Preparation and Functional Properties of Proteins from Rapeseed and Pumpkin Seed, in Proceedings of the World Conference on Oilseed Technology and Utilization, edited by T.H. Applewhite, American Oil Chemists’ Society, Champaign, 1993, pp. 489–493.
Pearson, A.M., Soy Proteins, in Developments in Food Proteins—2, edited by B.J.F. Hudson, Applied Science, London, 1983, pp. 67–108.
Sosulski, F., and S.E. Fleming, Chemical, Functional, and Nutritional Properties of Sunflower Protein Products, J. Am. Oil Chem. Soc. 54:100A-104A (1977).
Lásztity, R., M. Goma, S. Tömösközi, and J. Nagy, Functional and Nutritive Properties of Sunflower Seed Protein Preparations, in Proceedings of the World Conference on Oilseed Technology and Utilization, edited by T.H. Applewhite, American Oil Chemists’ Society, Champaign, 1993, pp. 430–432.
Xu, L., and L.L. Diosady, Functional Properties of Chinese Rapeseed Protein Isolates, J. Food Sci. 59:1127–1130 (1994).
Author information
Authors and Affiliations
About this article
Cite this article
Massoura, E., Vereijken, J.M., Kolster, P. et al. Proteins from Crambe abyssinica oilseed. I. Isolation procedure. J Amer Oil Chem Soc 75, 323–327 (1998). https://doi.org/10.1007/s11746-998-0048-1
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/s11746-998-0048-1