Abstract
The kinematic viscosities of four biodiesel fuels—two natural soybean oil methyl esters, one genetically modified soybean oil methyl ester, and one yellow grease methyl ester—and their 75, 50, and 25% blends with No. 2 diesel fuel were measured in the temperature range from 20 to 100°C in steps of 20°C. The measurements indicated that all these fuels had viscosity-temperature relationships similar to No. 2 diesel fuel, which followed the Vogel equation as expected. A weighted semilog blending equation was developed in which the mass-based kinematic viscosity of the individual components was used to compute the mixture viscosity. A weight factor of 1.08 was applied to biodiesel fuel to account for its effect on the mixture viscosity. The average absolute deviation achieved with this method was 2.1%, which was better than the uncorrected mass average blending equation that had an average absolute deviation of 4.5%. The relationship between the viscosity and the specific gravity of biodiesel fuels was studied. A method that could estimate the viscosity from the specific gravity of biodiesel fuel was developed. The average absolute deviation for all the samples using this method was 2.7%. The accuracy of this method was comparable to the weighted mass-based semilog blending equation.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Graboski, M.S., J.D. Ross, and R.L. McCormick, Transient Emissions from No. 2 Diesel and Biodiesel Blends in a DDC Series 60 Engine. SAE, Warrendale, PA, 1996, SAE Technical Paper 961166.
McCormick, R.L., M.S. Graboski, A.M. Herring, and T.L. Alleman. Impact of Biodiesel Source Material and Chemical Structure on Emissions of Criteria Pollutants from a Heavy-Duty Engine, Environ. Sci. Technol. 35:1742–1747 (2001).
Tat, M.E., and J.H. Van Gerpen, The Kinematic Viscosity of Biodiesel and Its Blends with Diesel Fuel, J. Am. Oil Chem. Soc. 76:1511–1513 (1999).
Allen, C.A.W., K.C. Watts, R.G. Ackman, and M.J. Pegg, Predicting the Viscosity of Biodiesel from Their Fatty Acid Ester Composition, Fuel 78:1319–1326 (1999).
Kerschbaum, S., and G. Rinke, Measurement of the Temperature Dependent Viscosity of Biodiesel Fuels, —Ibid. 83:287–291 (2004).
ASTM D 445-88, Standard Test Method for Kinematic Viscosity of Transparent and Opaque Liquids (and the Calculation of Dynamic Viscosity), American Society for Testing and Materials, Philadelphia, 1986.
Reid, R.C., J.M. Prausnitz, and T.K. Sherwood, The Properties of Gases and Liquids, 4th edn., McGraw-Hill, New York, 1987.
Monnery, W.D., W.Y. Svrcek, and A.K. Mehrotra, Viscosity: A Critical Review of Practical Predictive and Correlative Methods. Can. J. Chem. Eng. 73:3–40 (1995).
Erhan, S.Z., S. Asadauskas, and A. Adhavaryu, Correlation of Viscosities of Vegetable Oil Blends with Selected Esters and Hydrocarbons, J. Am. Oil Chem. Soc. 79:1157–1161 (2002).
Allen, C.A.W., K.C. Watts, and R.G. Ackman, Predicting the Surface Tension of Biodiesel Fuels from Their Fatty Acid Composition, —Ibid. 79:317–323 (1999).
Rodenbush, C.M., F.H. Hsieh, and D.S. Viswanath, Density and Viscosity of Vegetable Oils, —Ibid. 76:1415–1419 (1999).
Swern, D., Dailey's Industrial Oil and Fat Products, 4th edn., Vol. I, Wiley, New York, 1979.
Yuan, W., A.C. Hansen, and Q. Zhang. The Specific Gravity of Biodiesel Fuels and Their Blends with Dieset Fuel, Agricultural Engineering International: The CIGR Journal of Scientific Research and Development, Vol. 6, Manuscript EE 04 004 (2004).
Author information
Authors and Affiliations
Corresponding author
About this article
Cite this article
Yuan, W., Hansen, A.C., Zhang, Q. et al. Temperature-dependent kinematic viscosity of selected biodiesel fuels and blends with diesel fuel. J Amer Oil Chem Soc 82, 195–199 (2005). https://doi.org/10.1007/s11746-005-5172-6
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/s11746-005-5172-6