Abstract
Mg2(Si,Sn) compounds are promising candidate low-cost, lightweight, nontoxic thermoelectric materials made from abundant elements and are suited for power generation applications in the intermediate temperature range of 600 K to 800 K. Knowledge on the transport and mechanical properties of Mg2(Si,Sn) compounds is essential to the design of Mg2(Si,Sn)-based thermoelectric devices. In this work, such materials were synthesized using the molten-salt sealing method and were powder processed, followed by pulsed electric sintering densification. A set of Mg2.08Si0.4−x Sn0.6Sb x (0 ≤ x ≤ 0.072) compounds were investigated, and a peak ZT of 1.50 was obtained at 716 K in Mg2.08Si0.364Sn0.6Sb0.036. The high ZT is attributed to a high electrical conductivity in these samples, possibly caused by a magnesium deficiency in the final product. The mechanical response of the material to stresses is a function of the elastic moduli. The temperature-dependent Young’s modulus, shear modulus, bulk modulus, Poisson’s ratio, acoustic wave speeds, and acoustic Debye temperature of the undoped Mg2(Si,Sn) compounds were measured using resonant ultrasound spectroscopy from 295 K to 603 K. In addition, the hardness and fracture toughness were measured at room temperature.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
D.M. Rowe, CRC Handbook of Thermoelectrics (Boca Raton, FL: CRC Press, 1995).
J. Yang, ICT 2005 24th International Conference on Thermoelectrics, (2005), p. 170.
B.C. Blanke, J.H. Birden, K.C. Jordan, and E.L. Murphy, Report No. MLM-11271960.
R.J. Mehta, Y. Zhang, C. Karthik, B. Singh, R.W. Siegel, T. Borca-Tasciuc, and G. Ramanath, Nat. Mater. 11, 233 (2012).
K. Biswas, J. He, I.D. Blum, C.-I. Wu, T.P. Hogan, D.N. Seidman, V.P. Dravid, and M.G. Kanatzidis, Nature 489, 414 (2012).
V. Zaitsev, E. Tkalenko, and E. Nikitin, Fiz Tverd Tela 11, 3584 (1969).
T.J. Zhu, Y.Q. Cao, Q. Zhang, and X.B. Zhao, J. Electron. Mater. 39, 1990 (2009).
Y. Isoda, T. Nagai, H. Fujiu, Y. Imai, and Y. Shinohara, ICT ‘06. 25th International Conference on Thermoelectrics (2006), p. 406.
V.K. Zaitsev, M.I. Fedorov, E.A. Gurieva, I.S. Eremin, P.P. Konstantinov, A.Y. Samunin, and M.V. Vedernikov, Phys. Rev. B 74, 045207 (2006).
W. Liu, X. Tan, K. Yin, H. Liu, X. Tang, J. Shi, Q. Zhang, and C. Uher, Phys. Rev. Lett. 108, 166601 (2012).
W. Liu, X. Tang, H. Li, J. Sharp, X. Zhou, and C. Uher, Chem. Mater. 23, 5256 (2011).
H.L. Gao, T.J. Zhu, X.X. Liu, L.X. Chen, and X.B. Zhao, J. Mater. Chem. 21, 5933 (2011).
M. Søndergaard, M. Christensen, K.A. Borup, H. Yin, and B.B. Iversen, J. Electron. Mater. 42, 1417 (2013).
S.S. Manson, Thermal Stress and Low-Cycle Fatigue (New York: McGraw-Hill, 1966).
E.D. Case, Thermomechanical Fatigue and Fracture, ed. M.H. Alibadi (Southampton: WIT, 2002),
L.G. Zhao, T.J. Lu, and N.A. Fleck, J. Mech. Phys. Solids 48, 867 (2000).
Z.C. Olek, The Finite Element Method for Solid and Structural Mechanics (Boston: Butterworth-Heinemann, 2005).
V.N. Kaliakin, Introduction to Approximate Solution Techniques, Numerical Modeling, and Finite Element Methods (New York: Marcel Dekker, 2002).
F. Ren, E.D. Case, E.J. Timm, and H.J. Schock, J. Alloys Compd. 455, 340 (2008).
J.B. Wachtman, W.R. Cannon, and M.J. Matthewson, Mechanical Properties of Ceramics (New York: Wiley, 2009).
Z.A. Munir, U. Anselmi-Tamburini, and M. Ohyanagi, J. Mater. Sci. 41, 763 (2006).
I. Berkun, S.N. Demlow, N. Suwanmonkha, T.P. Hogan, and T.A. Grotjohn, 2012 MRS Fall Meeting Proceedings, (Boston, MA, 2012).
O.L. Anderson, J. Phys. Chem. Solids 24, 909 (1963).
J.L.S.A. Migliori, Resonant Ultrasound Spectroscopy: Applications to Physics, Materials Measurements, and Nondestructive Evaluation (New York: Academic, 1997).
J.E. Ni, E.D. Case, K.N. Khabir, R.C. Stewart, C.-I. Wu, T.P. Hogan, E.J. Timm, S.N. Girard, and M.G. Kanatzidis, Mater. Sci. Eng. B 170, 58 (2010).
R.D. Schmidt, J.E. Ni, E.D. Case, J.S. Sakamoto, D.C. Kleinow, B.L. Wing, R.C. Stewart, and E.J. Timm, J. Alloys Compd. 504, 303 (2010).
R.D. Schmidt, E.D. Case, J.E. Ni, J.S. Sakamoto, R.M. Trejo, and E. Lara-Curzio, Philos. Mag. 92, 727 (2012).
L.D. Landau and E.M. Lifshitz, Statistical Physics, Part 1, 3rd ed. (Oxford: Pergamon, 1980).
M.I. Fedorov, V.K. Zaitsev, and M. V. Vedernikov, ICT ‘06. 25th International Conference on Thermoelectrics (2006), p. 111.
G.N. Isachenko, V.K. Zaĭtsev, M.I. Fedorov, A.T. Burkov, E.A. Gurieva, P.P. Konstantinov, and M.V. Vedernikov, Phys. Solid State 51, 1796 (2009).
G.D. Mahan, Solid State Physics, ed. E. Henry and S. Frans (Edinburgh: Academic, 1997),
M.I. Fedorov, D.A. Pshenay-Severin, V.K. Zaitsev, S. Sano and M.V. Vedernikov, Twenty-second International Conference on Thermoelectrics, (2003).
M.I. Fedorov, The 5th European Conference on Thermoelectrics, (Odessa House of Scientists, Odessa, Ukraine, 2007).
G.A. Slack and M.A. Hussain, J. Appl. Phys. 70, 25 (1991).
T. Dasgupta, C. Stiewe, R. Hassdorf, A.J. Zhou, L. Boettcher, and E. Mueller, Phys. Rev. B 83, 235207 (2011).
Z. Du, T. Zhu, Y. Chen, J. He, H. Gao, G. Jiang, T.M. Tritt, and X. Zhao, J. Mater. Chem. 22, 6838 (2012).
R. Franz and G. Wiedemann, Annalen der Phys. 165, 497 (1853).
R.W. Keyes, Phys. Rev. 115, 564 (1959).
J. Tobola, S. Kaprzyk, and H. Scherrer, J. Electron. Mater. 39, 2064 (2010).
N.F. Mottt and E.A. Davis, Electronic Processes in Non-crystalline Materials (Oxford: Clarendon, 1971).
V. Milekhine, M.I. Onsøien, J.K. Solberg, and T. Skaland, Intermetallics 10, 743 (2002).
R.D. Schmidt, E.D. Case, J. Giles III, J.E. Ni, and T.P. Hogan, J. Electron. Mater. 41, 1210 (2012).
Z.W. Huang, Y.H. Zhao, H. Hou, and P.D. Han, Phys. B 407, 1075 (2012).
W.B. Whitten, P.L. Chung, and G.C. Danielson, J. Phys. Chem. Solids 26, 49 (1965).
F. Ren, E.D. Case, E.J. Timm, and H.J. Schock, Philos. Mag. 87, 4907 (2007).
G.H. Li, H.S. Gill, and R.A. Varin, Metall. Trans. A 24, 2383 (1993).
B. Kim, J. Jeon, K. Park, B. Park, Y. Park, and I. Park, Arch. Mater. Sci. Eng. 94, 94 (2008).
F. Ren, B.D. Hall, J.E. Ni, E.D. Case, J. Sootsman, M.G. Kanatzidis, E. Lara-Curzio, R.M. Trejo, and E.J. Timm, Mater. Res. Soc. Symp. Proc. 1044, 121 (2008).
L. Zhang, G. Rogl, A. Grytsiv, S. Puchegger, J. Koppensteiner, F. Spieckermann, H. Kabelka, M. Reinecker, P. Rogl, W. Schranz, M. Zehetbauer, and M.A. Carpenter, Mater. Sci. Eng. B 170, 26 (2010).
X. Fan, E.D. Case, X. Lu, and D.T. Morelli, J. Mater. Sci. 48, 7540 (2013).
F. Ren, E.D. Case, J.R. Sootsman, M.G. Kanatzidis, H. Kong, C. Uher, E. Lara-Curzio, and R.M. Trejo, Acta Mater. 56, 5954 (2008).
R.D. Schmidt, E.D. Case, G.J. Lehr, and D.T. Morelli, Intermetallics 35, 15 (2013).
J.B. Wachtman Jr, W.E. Tefft, D.G. Lam Jr, and C.S. Apstein, Phys. Rev. 122, 1754 (1961).
Y.P. Varshni, Phys. Rev. B 2, 3952 (1970).
J.M. Jackson, S.V. Sinogeikin, and J.D. Bass, Phys. Earth Planet. Inter. 161, 1 (2007).
L.C. Davis, W.B. Whitten, and G.C. Danielson, J. Phys. Chem. Solids 28, 439 (1967).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Gao, P., Berkun, I., Schmidt, R.D. et al. Transport and Mechanical Properties of High-ZT Mg2.08Si0.4−x Sn0.6Sb x Thermoelectric Materials. J. Electron. Mater. 43, 1790–1803 (2014). https://doi.org/10.1007/s11664-013-2865-8
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11664-013-2865-8