Abstract
The SiC wafers implanted with Al were capped with AlN, C, or AlN and C and were annealed at temperatures as high as 1700°C to examine their ability to act as annealing caps. As shown previously, the AlN film was effective up to 1600°C, as it protected the SiC surface, did not react with it, and could be removed selectively by a KOH etch. However, it evaporated too rapidly at the higher temperatures. Although the C did not evaporate, it was not a more effective cap because it did not prevent the out-diffusion of Si and crystallized at 1700°C. The crystalline film had to be ion milled off, as it could not be removed in a plasma asher, as the C films annealed at the lower temperatures were. A combined AlN/C cap also was not an effective cap for the 1700°C anneal as the N or Al vapor blew holes in it, and the SiC surface was rougher after the dual cap was removed than it was after annealing at the lower temperatures.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
R.F. Davis, G. Kelner, M. Shur, J.W. Palmour, and J.A. Edmond, Proc. IEEE 79, 677 (1991).
M.V. Rao, P. Griffiths, J. Gardner, O.W. Holland, M. Ghezzo, J. Kretchmer, G. Kelner, and J.A. Freitas, Jr., J. Electron. Mater. 25, 75 (1996).
T. Troffer, M. Schadt, T. Frank, H. Itoh, G. Pensl, I. Heindl, H.P. Strunk, and M. Maier, Phys. Status Solidi A 162, 277 (1997).
T. Kimoto, N. Inoue, and H. Matsunami, Phys. Status Solidi A 162, 277 (1997).
S. Seshadri, G.W. Eldridge, and A.K. Agarwal, Appl. Phys. Lett. 72, 2026 (1998).
S. Adachi, M. Mohri, and T. Yamachina, Surf. Sci. 161, 479 (1985).
L. Muehlhoff, W.J. Choyke, M.J. Bozac, and J.T. Yates, Jr., J. Appl. Phys. 60, 2842 (1986).
K.A. Jones, P.B. Shah, K.W. Kirchner, R.T. Lareau, M.C. Wood, M.H. Ervin, R.D. Vispute, R.P. Sharma, T. Venkatesan, and O.W. Holland, Mater. Sci. Eng. B 61–62, 281 (1999).
C. Thomas and M. Spencer (Paper presented at MRS Conf., San Francisco, CA, April 1999).
R.D. Vispute, S. Choopun, R. Enck, A. Patel, V. Talyansky, R.P. Sharma, T. Venkatesan, W.L. Sarney, L. Salamanca-Riba, S.N. Andronescu, A.A. Iliadis, and K.A. Jones, J. Electron. Mater. 28, 275 (1999).
W.J. Schaffer, G.H. Negley, K.G. Irvine, and J.W. Palmour, Mater. Res. Soc. Proc. 339, 595 (1994).
T. Troffer, M. Schadt, T. Frank, H. Itoh, G. Pensl, J. Heindl, H.P. Strunk, and M. Maier, Phys. Status Solidi A 162, 277 (1997).
K.A. Jones, M.A. Derenge, T.S. Zheleva, K.W. Kirchner, M.H. Ervin, M.C. Wood, R.D. Vispute, R.P. Sharma, and T. Venkatesan, J. Electron. Mater. 29, 262 (2000).
M.A. Capano, S. Ryu, M.R. Melloch, J.A. Cooper, Jr., and M.R. Buss, J. Electron. Mater. 27, 370 (1998).
D. Panknin, H. Wirth, A. Mucklich, and W. Skorupa, Mater. Sci. Eng. B 61–62, 363 (1999).
K.A. Jones, P.B. Shah, and M.A. Derenge, U.S. Army Research Laboratory, unpublished research.
M.V. Rao, P. Griffiths, J. Gardner, W.W. Holland, M. Ghezzo, J. Kretchmer, G. Kelner, and J.A. Freitas, Jr., J. Electron. Mater. 25, 75 (1996).
J.H. Zhao, K. Tone, S.R. Weiner, M.A. Caleca, H. Du, and S.P. Withrow, IEEE J. Electron Dev. Lett. 18, 375 (1997).
E.M. Handy, M.V. Rao, K.A. Jones, M.A. Derenge, P.H. Chi, R.D. Vispute, T. Venkatesan, N.A. Papanicolaou, and J. Mittereder, J. Appl. Phys. 86, 746 (1999).
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Jones, K.A., Derenge, M.A., Shah, P.B. et al. A comparison of graphite and AlN caps used for annealing ion-implanted SiC. J. Electron. Mater. 31, 568–575 (2002). https://doi.org/10.1007/s11664-002-0127-2
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/s11664-002-0127-2