Abstract
The viscosity of CaO-SiO2 (-MgO)-Al2O3 slags was measured to clarify the effects of Al2O3 and MgO on the structure and viscous flow of molten slags at high temperatures. Furthermore, the infrared spectra of the quenched slags were analyzed to understand the structural role of Al2O3 in the polymerization or depolymerization of silicate network. The Al2O3 behaves as an amphoteric oxide with the composition of slags; that is, the alumina behaves as a network former up to about 10 mass pct Al2O3, while it acts as a network modifier, in parts, in the composition greater than 10 mass pct Al2O3. This amphoteric role of Al2O3 in the viscous flow of molten slags at the Newtonian flow region was diminished by the coexistence of MgO. The effect of Al2O3 on the viscosity increase can be understood based on an increase in the degree of polymerization (DOP) by the incorporation of the [AlO4]-tetrahedra into the [SiO4]-tetrahedral units, and this was confirmed by the infrared (IR) spectra of the quenched slags. The influence of alumina on the viscosity decrease can be explained on the basis of a decrease in the DOP by the increase in the relative fraction of the [AlO6]-octahedral units. The relative intensity of the IR bands for the [SiO4]-tetrahedra with low NBO/Si decreased, while that of the IR bands for [SiO4]-tetrahedra with high NBO/Si increased with increasing Al2O3 content greater than the critical point, i.e., about 10 mass pct in the present systems. The variations of the activity coefficient of slag components with composition indirectly supported those of viscosity and structure of the aluminosilicate melts.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
E.T. Turkdogan and P.M. Bills: Ceram. Bull., 1960, vol. 39, pp. 682–87.
P.M. Bills: J. Iron Steel Inst., 1963, vol. 201, pp. 133–40.
G. Urbain, Y. Bottinga, and P. Richet: Geochim. Cosmochim. Acta, 1982, vol. 46, pp. 1061–72.
R.A. Berryman and I.D. Sommerville: Proc. 3rd Int. Conf. on Molten Slags and Fluxes, Glasgow, June 27–29, 1988, IOM, London, 1989, pp. 202–06.
K.C. Mills: Iron Steel Inst. Jpn. Int., 1993, vol. 33, pp. 148–55.
N. Iwamoto: Trans. JWRI, 1979, vol. 8, pp. 139–49.
B.O. Mysen, D. Virgo, and I. Kushiro: Am. Mineral., 1981, vol. 66, pp. 678–701.
Y. Iguchi, K. Yonezawa, Y. Funaoka, S. Ban-ya, and Y. Nishina: Proc. 3rd Int. Conf. Molten Slags and Fluxes, Glasgow, June 27–29, 1988, IOM, London, 1989, pp. 169–71.
L.G. Hwa, S.L. Hwang, and L.C. Liu: J. Non-Cryst. Solids, 1998, vol. 238, pp. 193–97.
G. Jiang and X. Zhang: Proc. 4th Int. Conf. Molten Slags and Fluxes, Sendai, June 8–11, 1992, Iron and Steel Institute of Japan, Sendai, 1992, pp. 28–33.
R.G. Duan, K.M. Liang, and S.R. Gu: Mater. Trans., JIM, 1998, vol. 39, pp. 1162–63.
L. Zhang and S. Jahanshahi: Proc. 6th Int. Conf. Molten Slags, Fluxes, and Salts, Stockholm-Helsinki, June 12–17, 2000, KTH, Stockholm, CD-ROM paper 008.
L. Zhang, S. Sun, and S. Jahanshahi: Proc. 6th Int. Conf. Molten Slags, Fluxes, and Salts, Stockholm-Helsinki, June 12–17, (2000), KTH, Stockholm, CD-ROM Paper 074.
B.O. Mysen, D. Virgo, and C.M. Scarfe: Am. Mineral., 1980, vol. 65, pp. 690–710.
D.M. Zirl and S.H. Garofalini: J. Am. Ceram. Soc., 1990, vol. 73, pp. 2848–56.
T. Uchino, T. Sakka, Y. Ogata, and M. Iwasaki: J. Phys. Chem., 1993, vol. 97, pp. 9642–49.
H. Doweidar: J. Non-Cryst. Solids, 1998, vol. 240, pp. 55–65.
F.D. Richardson: Physical Chemistry of Melts in Metallurgy, Academic Press, London, 1974, vol. 1, pp. 106–11.
J.H. Park, D.J. Min, and H.S. Song: Metall. Mater. Trans. B, 2002, vol. 33B, pp. 723–29.
J.H. Park, H.S. Song, and D.J. Min: J. Kor. Inst. Met. and Mater., 2002, vol. 40, pp. 1111–17.
J.H. Park, D.J. Min, and H.S. Song: Iron Steel Inst. Jpn. Int., 2002, vol. 42, pp. 38–43.
J.H. Park, D.J. Min, and H.S. Song: Iron Steel Inst. Jpn. Int., 2002, vol. 42, pp. 344–51.
M. Kowalski, P.J. Spencer, and D. Neuschutz: Slag Atlas, 2nd ed., Verlag Stahleisen GmbH, Dusseldorf, 1995, pp. 99–180.
K.C. Mills: Slag Atlas, 2nd ed., Verlag Stahleisen GmbH, Dusseldorf, 1995, pp. 349–512.
T. Iida and Y. Shiraishi: Handbook of Physico-Chemical Properties at High Temperatures, Iron and Steel Institute of Japan Jpn., Tokyo, 1988, pp. 93–144.
J.S. Machin, T.B. Yee, and D.L. Hanna: J. Am. Ceram. Soc., 1952, vol. 35, pp. 322–25.
P. Kozakevitch: Rev. Metall., 1960, vol. 57, pp. 149–60.
Y.S. Lee, J.H. Park, D.J. Min, S.H. Yi, and W.W. Huh: 61st Iron-making Conf. Proc., Nashville, TN, Mar. 10–13, 2002, ISS-AIME, Warrendale, PA, 2002, pp. 155–65.
A. Paul: Chemistry of Glasses, 2nd ed., Chapman & Hall, London, 1990, pp. 16–50.
P. Kozakevitch and N. Misra: Rev. Metall., 1966, vol. 63, pp. 471–76.
T. Tsunawaki, N. Iwamoto, T. Hattori, and A. Mitsuishi: J. Non-Cryst. Solids, 1981, vol. 44, pp. 369–78.
P. McMillan: Am. Mineral., 1984, vol. 69, pp. 645–59.
R.W. Luth: Am. Mineral., 1988, vol. 73, pp. 297–305.
K. Kume, K. Morita, T. Miki, and N. Sano: Iron Steel Inst. Jpn. Int., 2000, vol. 40, pp. 561–66.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Park, J.H., Min, D.J. & Song, H.S. Amphoteric behavior of alumina in viscous flow and structure of CaO-SiO2 (-MgO)-Al2O3 slags. Metall Mater Trans B 35, 269–275 (2004). https://doi.org/10.1007/s11663-004-0028-2
Received:
Issue Date:
DOI: https://doi.org/10.1007/s11663-004-0028-2