Abstract
The influence of each factor on the reaction of geopolymers material was investigated by using the orthogonal experimental design method, which got the optimal condition of reaction. Based on this results the performances of geopolymers were investigated. The results are as follows: (1) The effect of each factor on the compressive strength of geopolymers was different; (2) For paste the optimal condition of reaction is that the modulus and the concentration of sodium silicate solution are 1.2 and 40%, the calcined temperature and calcined time of kaolin are 800 °C and 2 h, and the liquid-solid ratio is 1.25; (3) When the pH value of solution is higher than 1, the compressive strength of Geopolymers will not decrease as that in the water; (4) As the calcined temperature of samples were lower than 700 °C the heat-resistant of geopolymers was good;(5) Geopolymers is unlikely to react with the active aggregate.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Della M Roy. Alkali-activated Cements-Opportunities and Challenges [J]. Cem. Concr. Res., 1999, 29(2): 249–254
Margie Morris. Archaeology and Technology[J]. Concr. Int., 1987, 12(9):28–35
Campbell, Donald H, Folk, et al. Ancient Egyptian Pyramids — Concrete or Rock[J]. Concr. Int.; Des. Const., 1991,13(8): 28, 30–38
Morris, Margie. Cast-in-place Theory of Pyramid Construction[J]. Concr. Int.; Des. Const., 1991,13(8):29, 39–44
R M Torres Sánchez, E I Basaldella, J F Marco. The Effect of Thermal and Mechanical Treatment on Kaolinite: Characterization by XPS and IEP Measurements[J]. J. Coll. Inter. Sci., 1999, 215:339–344
G Kakali, T Perraki, S Tsivilis, et al. Thermal Treatment of Kaolin: the Effect of Mineralogy on the Pozzolanic Activity[J]. Appl. Clay Sci., 2000, 120: 73–81
V Balek, M Murat. The Emanation Thermal Analysis of Kaolinite Clay Minerals[J]. Thermochimica Acta, 1996, 282/283:385–397
R Cioffi, L Maffucci, L Santoro. Optimization of Geopolymer Synthesis by Calcination and Polycondensation of a Kaolinitic Residue[J]. Resour. Conser. & Recy., 2003, 40: 27–38
Davidovits J. Geopolymers: Inorganic Polymeric New Materials[J]. J. Therm. Anal., 1997, 37:1 633–1 656
A Palomo, M T Blanco-Varela, M L Granizo, et al. Chemical Stability of Cementitious Materials Based on Metakaolin[J]. Cem. Concr. Res., 1999, 29:997–1 004
Author information
Authors and Affiliations
Corresponding author
Additional information
Funded by Guangzhou Technical Guide Project (No.2004-D038)
Rights and permissions
About this article
Cite this article
Guo, W., Wu, G., Wang, J. et al. Preparation and performance of geopolymers. J. Wuhan Univ. Technol.-Mat. Sci. Edit. 23, 326–330 (2008). https://doi.org/10.1007/s11595-007-3326-0
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11595-007-3326-0