Abstract
To improve the stability of sputter-deposited ZnO:Al (AZO) films at high temperature above 300∘C, an amorphous Zn-Sn-O (ZTO) film was deposited on the top of AZO films as an protective layer by co-sputtering of pure ZnO and SnO2 targets. Amorphous ZTO films had resistivity in the range from 10−2 to 10−3 Ωcm and were stable up to temperature of 400∘C. Heat treatments of bare AZO films in the atmosphere at 400∘C resulted in a dramatic increase in the resistivity accompanied by substantial decrease in carrier concentration and Hall mobility. The AZO films covered with the ZTO film showed remarkable improvement in thermal stability for subsequent heat treatments in the temperature range from 200 to 400∘C in the atmosphere as well as chemical stability in weak acidic solution. X-ray photoelectron spectroscopy analysis showed that the improvement was attained by ZTO layer acting as diffusion barrier of oxygens and/or water vapors.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
D.S. Ginley and C. Bright, MRS Bull., 25(8), 15 (2000).
K. Ellmer, J. Phys. D: Appl. Phys., 34, 3097 (2001).
T. Minami, MRS Bull., 25(8), 38 (2000).
T. Minami, H. Nanto, S. SHooji, and S. Takata, Thin Solid Films, 111, 167 (1984).
A. Valentini, F. Quaranta, M. Penza, and F.R. Rizzi, J. Appl. Phys., 73(3), 1143 (1992).
T. Minami, H. Sonohara, S. Takata, and H. Sato, Jpn. J. Appl. Phys., 33, L1693 (1994).
T. Minami, S. Takata, H. Sato, and H. Sonohara, J. Vac. Sci. Technol. A, 13(3), 1095 (1995).
T. Moriga, Y. Hayashi, K. Kondo, Y. Nishimura, K. Murai, and I. Nakabayashi, J. Vac. Sci. Technol., A 22(4), 1705 (2004).
Y. Hayashi, K. Kondo, K. Murai, T. Moriga, I. Nakabayashi, H. Fukumoto, and K. Tominaga, Vacuum, 74, 607 (2004).
K. Tominaga, N. Umezu, I. Mori, T. Ushiro, T. Moriga, and I. Nakabayashi, Thin Solid Films, 334, 35 (1998).
R.G. Gordon, MRS Bull., 25(8), 52 (2000).
S. Ghosh, A. Sarkar, S. Chaudhuri, and A.K. Pal, Thin Solid Films, 205, 64 (1991).
M.K. Puchert, P.Y. Timbrell, and R.N. Lamb, J. Vac. Sci. Technol., A 14(4), 2220 (1996).
H. Geistlinger, J. Appl. Phys., 80(3), 1370 (1996).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Kim, I.H., Ku, D.Y., Ko, J.H. et al. Improvement of the thermal and chemical stability of Al doped ZnO films. J Electroceram 17, 241–245 (2006). https://doi.org/10.1007/s10832-006-8315-8
Received:
Revised:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/s10832-006-8315-8