Abstract
Objectives
To improve the potential value of feather, which is a valuable protein resource, we have separated and identified antioxidant peptide(s) from feather hydrolysate.
Results
Feather hydrolysate was prepared by fermentation with Bacillus subtilis S1–4. Antioxidative peptides were separated by sequential acid precipitation, cation exchange, and reversed-phase fast performance liquid chromatography. Finally, a peptide with antioxidative activity was identified as Ser-Asn-Leu-Cys-Arg-Pro-Cys-Gly by MALDI time-of-flight (TOF)/TOF analysis, and determined to represent a portion of feather keratin near its N-terminal. A synthesized peptide with the same sequence was used to characterize its antioxidative properties, including scavenging free radicals, reducing power, and Fe2+ chelation. In terms of the peptide’s amino acid composition, the antioxidative activity might be mainly attributed to Cys and other amino acid residues.
Conclusion
Feather keratin is a good source for the quantitative preparation of antioxidative peptides.
Similar content being viewed by others
Avoid common mistakes on your manuscript.
Introduction
Chicken feathers are produced in large amounts as a waste byproduct by the poultry industry (Lasekan et al. 2013). Feather mainly consists of keratin, an insoluble structural protein. Keratin is recognized as a useful protein resource and could be used to prepare animal feed or fertilizers (Brandelli et al. 2015). Prior to utilization of feather keratin, it is necessary to degrade feather keratin into soluble peptides or even amino acids. In consideration of economic costs and environmental constraints, feather biodegradation is the best prospect (Brandelli et al. 2015). Currently, in feather degradation studies, many microorganisms have been isolated or characterized that usually produce keratinases or proteases for catalyzing keratinolytic reactions to transform keratin into soluble peptides and free amino acids (Onifade et al. 1998; Brandelli et al. 2015).
Antioxidants play an important role in human health and food processing. Therefore, growing interest is turning to natural antioxidants, especially those from various protein hydrolysates (López-Barrios et al. 1997; Wu et al. 2015). Many antioxidative peptides have been identified and characterized. Feather hydrolysate has antioxidant activities (Fakhfakh et al. 2011; Fontoura et al. 2014) suggesting that it might present an interesting source of bioactive peptides.
In this work, an antioxidative peptide was separated and identified from chicken feather hydrolysate generated by bacterial fermentation followed by a series of separation procedures. The peptide’s antioxidative properties were characterized using a synthesized version of the peptide.
Materials and methods
Microorganism and feather
Bacillus subtilis S1–4 was isolated from chicken feathers (Yong et al. 2013) and grown in lysogeny broth or agar plate. Chicken feathers were collected from a local poultry farm and washed with distilled water.
Feather degradation with B. subtilis fermentation
Feather fermentation was performed, as described previously (Yong et al. 2013). Briefly, 100 ml salt solution, containing 0.02 g MgSO4·7H2O, 0.03 g K2HPO4, 0.04 g KH2PO4, 0.02 g CaCl2, and 5 g chopped feather fragments, in 500 ml flasks was autoclaved at 114 °C for 15 min. The flasks were then inoculated with 1 % (v/v) of an overnight culture of B. subtilis S1–4 and incubated 37 °C for 72 h with shaking. A clarified supernatant was obtained by filtration through four layers of gauze and centrifugation at 15,500×g for 10 min. The supernatant was used for antioxidative activity assay by the ferric reducing ability of plasma (FRAP) method described below.
Purification of antioxidative peptides from feather hydrolysate
The clear supernatant was adjusted to pH 2 with 6 M HCl and allowed to stand at 4 °C overnight. The pellet was then collected by centrifugation at 15,500×g for 10 min and lyophilized to dryness to yield feather hydrolysate product.
Feather hydrolysate was redissolved in dimethyl sulfoxide (DMSO)/80 % aqueous methanol (1/1, v/v) and then loaded onto a cation-exchange resin column (2.6 × 35 cm) previously equilibrated with 80 % aqueous methanol. The column was sequentially eluted with 0.1, 0.3, and 0.5 M NaCl in 80 % aqueous methanol at 2 ml/min. Fractions (5 ml each) showing antioxidant activity were pooled and lyophilized to dryness. The resulting samples were dissolved in DMSO and subjected to reversed-phase fast performance liquid chromatography (RP-FPLC) using a Resource 15RPC column (6.4 × 100 mm, GE Healthcare Bio Sciences). The column was eluted with a linear gradient (0–80 %) of acetonitrile containing 0.05 % trifluoroacetic acid (v/v) at 0.5 ml/min. Fractions showing antioxidant activity were collected and lyophilized.
Identification of amino acid sequence by MALDI TOF/TOF
After RP-FPLC purification, peptide samples were subjected to matrix-assisted laser desorption/ionization time-of-flight/TOF tandem mass spectroscopy (MS/MS) using an ABI 4800 Plus MALDI TOF/TOF system (Life Technologies) at the Shanghai Boyuan Institute of Biotechnology (Shanghai, China). Data were gathered in centroid mode covering the mass/charge (m/z) and used to search the NCBInr database on the Mascot Server (http://www.matrixscience.com) to identify the peptides’ amino acid sequences.
Peptide synthesis and antioxidative activity assay
Peptides with an identified amino acid sequence were chemically synthesized at the Top Institute of Biotechnology (Shanghai, China).
FRAP antioxidative activity was measured with a total antioxidant capacity assay kit (Beyotime Institution of Biotechnology, Nanjing, China) using the FRAP method following manufacturer’s instruction. Samples (5 μl) were mixed with 180 μl of FRAP working solution, incubated at 37 °C for 5 min, and their A593 measured. A standard curve was prepared using FeSO4 from 15 to 60 mM. FRAP activities for samples were evaluated as the equivalent FeSO4 concentrations according to a standard curve.
2,2,-Diphenyl-1-picrylhydrazyl (DPPH) radical-scavenging activity was assayed as described previously (Bougatef et al. 2010). Briefly, a sample aliquot (60 µl) was mixed with 60 µl 0.1 mM DPPH in 95 % aqueous ethanol. After 20 min in the dark, the OA517 was measured; 95 % (v/v) ethanol served as the blank control. Antioxidant activity was evaluated as %-inhibition of DPPH by the following equation:
where A0 is the blank control absorbance and AS is the sample absorbance.
An [2,2′-azinobis (3-ethyl-benzothiazoline-6-sulphonate)], ABTS radical-scavenging assay was conducted as previously described (Re et al. 1999). ABTS+ ions were generated by blending 7.4 mM ABTS stock solution with 2.6 mM K2S2O8, which was then diluted in phosphate buffer (pH 7.4) and equilibrated to an OD734 of 0.7 ± 0.02. Then, different sample concentrations (25 µl) were mixed with 100 µl of ABTS+ solution and the A734 recorded; 95 % (v/v) ethanol served as the blank control. ABTS+-scavenging activity was calculated by the following equation:
where A0 is the blank control absorbance and AS is the sample absorbance.
Reducing power was quantified based on reducing Fe3+ to Fe2+ following an established method (Yildirim et al. 2001). Samples (20 µl)were first mixed with 20 µl sodium phosphate buffer (pH 6.6) and 20 µl 10 mg ferricyanide/l. The mixture was incubated at 50 °C for 20 min, followed by addition of 20 µl 10 % (w/v) trichloroacetic acid to terminate the reaction. Then, 70 µl of the resulting solution was mixed with 70 µl ddH20 and 14 µl 10 mg FeCl3/ml. Finally, the A700 was recorded, with distilled water as the blank control.
The Fe2+-chelating activity was measured by the method of Decker and Welch (1990), with a slight modification. Briefly, a 25 µl sample was mixed with 50 µl 2 mM FeCl2 and 50 µl 0.05 mM ferrozine. After standing for 10 min, the A562 was recorded, with DMSO and EDTA as the blank and positive controls, respectively. Chelating activity was calculated as:
where A0 is the blank control absorbance and A1 is the sample absorbance.
Results and discussion
Preparation of feather hydrolysate by B. subtilis S1–4 fermentation
Degradation of chicken feather was performed by fermentation with B. subtilis S1–4. Under these conditions, feather is efficiently degraded to produce free amino acids, soluble peptides, and thiol groups (Yong et al. 2013). The resulting fermentation supernatant was sampled and used for evaluation of antioxidative activity by the FRAP assay. Antioxidative activity occurred across the whole time course of fermentation, being highest at 72 h, which was similar to previous studies even when feather fermentation was performed using other bacterial species (Fakhfakh et al. 2011; Fontoura et al. 2014).
The feather hydrolysate was prepared by acid precipitation. FRAP assay results indicated that antioxidative activity was only recovered from the pellet and that no activity remained in the supernatant (data not shown), suggesting that acid precipitation was effective for preparation of peptide-containing hydrolysate. Finally, the precipitate was lyophilized to dryness and regarded as feather hydrolysate.
Separation of an antioxidative peptide
An antioxidative peptide was isolated from the pellet by first dissolving the pellet in DMSO/80 % (v/v) aqueous ethanol (1/1, v/v) and then loaded onto a cation-exchange resin column. The eluate was monitored at 215 nm to trace peptide content, and antioxidative activity indicated by the A593 was then measured by FRAP assay for each fraction (5 ml). Figure 1a shows a typical elution profile, indicating that the major antioxidative activity (fractions 12–22 in this example) was eluted with 100 mM NaCl. Next, the fractions with high antioxidant activity were pooled and applied to preparative RP-FPLC eluted with a linear gradient of aqueous acetonitrile (0–80 % by volume). Figure 1b shows a representative RP-FPLC elution curve. FRAP assay results revealed four antioxidative peaks, assigned as Fa-1, Fa-2, Fa-3, and Fa-4. Fraction Fa-1 was applied to RF-HPLC again, and the resulting fractions possessing antioxidative activity were pooled and used for amino acid sequence identification.
Determination of peptide sequence
Fraction Fa-1 was subjected to tandem MS (MALDI TOF/TOF MS/MS) analysis. The first-order MS of Fa-1 was found to contain several peaks (data not shown), indicating that Fa-1 was a mixture. Further, the second-order mass spectrometric analysis for an individual peak was performed. Figure 2a shows the second-order MS of a peak with an m/z value of 849.3208. According to mass spectrometric data, the peptide’s amino acid sequence was identified as Ser-Asn-Leu-Cys-Arg-Pro-Cys-Gly by searching the database NCBInr via the Mascot Server. This peptide consisted of eight amino acids with a mass of 848.8 Da and a predicated pI value of 8.23.
Through a database search (http://blast.ncbi.nlm.nih.gov/) using this peptide’s amino acid sequence, several proteins annotated as feather keratin-1 were retrieved from the database (Fig. 2b). This indicated that the peptide was derived from feather keratin and encoded in feather keratin near its N-terminal, matching the 3rd–10th amino acid residues.
Characterization of the antioxidative peptide
The observed antioxidative activity derived from the identified peptide was confirmed by chemically synthesizing a peptide with the sequence Ser-Asn-Leu-Cys-Arg-Pro-Cys-Gly and then characterizing its antioxidative properties. The peptide was found to scavenge radicals of DPPH and ABTS with IC50 values of ~0.39 and ~0.35 mg/ml, respectively (Fig. 3a), which were almost equivalent to those of antioxidative peptides identified from enzymatic hydrolysate of crocein croaker (Pseudosciaena crocea) (Wang et al. 2013).
The reducing power and antioxidative activity of this peptide were also evaluated. The peptide’s antioxidative activity, as determined by FRAP assay, was linear in relation to peptide concentration (Fig. 3b), and the peptide was able to reduce Fe3+ to Fe2+ in a dosage-dependent manner (Fig. 3c). Finally, the peptide is also able to chelate Fe2+ with an IC50 value of ~1.85 mg/ml (Fig. 3d).
The antioxidative activities of a given peptide have been recognized to relate to its amino acid composition. For example, Dávalos et al. (2004) have reported that Cys residues have antioxidative activity, as a Cys –SH group in a peptide acts as an effective hydrogen donor to free radicals (Wu et al. 2015). In addition, Pro and Gly residues are commonly found in antioxidative peptides from various sources (López-Barrios et al. 2014; Wu et al. 2015). Furthermore, a high correlation commonly occurs between reducing power and antioxidative activity in some antioxidative peptides (Zhang et al. 2009). Taken together, the antioxidative properties of this particular peptide might be attributed to specific amino acid residues (e.g., Cys, Gly, Pro, and Arg) in this peptide.
Feather keratin consists of insoluble protein rich in Cys and hydrophobic amino acid residues (Fig. 2b), which are usually related to antioxidative activity (Wu et al. 2015). In addition to antioxidative activity, other bioactivities, such as inhibitory activities toward angiotensin I-converting enzyme and dipeptidyl peptidase-IV, have been demonstrated in feather hydrolysate (Fontoura et al. 2014). In fact, RP-FPLC analysis in the present study resolved more than one peak with antioxidative activity (Fig. 1b). Considering the considerable amounts of waste feather produced each year by the poultry industry, feather keratin is an attractive and potentially useful source of bioactive peptides.
Conclusions
To our knowledge, this is the first report identifying a novel antioxidant peptide from chicken feather hydrolysate. The peptide’s amino acid sequence was Ser-Asn-Leu-Cys-Arg-Pro-Cys-Gly, representing a portion of feather keratin-1. This peptide exhibited good antioxidative properties, such as free radical scavenging and reducing and effectively chelating Fe2+. These results suggested that feather keratin might be a good source for the quantitative preparation of antioxidative peptides.
References
Bougatef A, Nedjar-Arroume N, Manni L, Ravallec R, Barkia A, Guillochon D, Nasri M (2010) Purification and identification of novel antioxidant peptides from enzymatic hydrolysates of sardinelle (Sardinella aurita) by-products proteins. Food Chem 118:559–565
Brandelli A, Sala L, Kalil SJ (2015) Microbial enzymes for bioconversion of poultry waste into added-value products. Food Res Int 73:3–12
Dávalos A, Miguel M, Bartolomé B, López-Fandiño R (2004) Antioxidative activity of peptides derived from egg white proteins by enzymatic hydrolysis. J Food Prot 67:1939–1944
Decker EA, Welch B (1990) Role of ferritin as a lipid oxidation catalyst in muscle food. J Agric Food Chem 38:674–677
Fakhfakh N, Ktari N, Haddar A, Mnif IH, Dahmen I, Nasri M (2011) Total solubilisation of the chicken feathers by fermentation with a keratinolytic bacterium, Bacillus pumilus A1, and the production of protein hydrolysates with high antioxidative activity. Process Biochem 46:1731–1737
Fontoura R, Daroit DJ, Correa APF, Meira SMM, Mosquera M, Brandelli A (2014) Production of feather hydrolysates with antioxidant, angiotensin-I converting enzyme- and dipeptidyl peptidase-IV inhibitory activities. N Biotechnol 31:506–513
Lasekan A, Bakar FA, Hashim D (2013) Potential of chicken by-products as sources of useful biological resources. Waste Manag 33:552–565
López-Barrios L, Gutiérrez-Uribe JA, Serna-Saldívar SO (2014) Bioactive peptides and hydrolysates from pulses and their potential use as functional ingredients. J Food Sci 79:R273–R283
Onifade AA, Al-Sane NA, Al-Musallam AA, Al-Zarban S (1998) A review: potentials for biotechnological applications of keratin-degrading microorganisms and their enzymes for nutritional improvement of feathers and other keratins as livestock feed resources. Bioresour Technol 66:1–11
Re R, Pellegrini N, Proteggente A, Pannala A, Yang M, Rice-Evens C (1999) Antioxidant activity applying an improved ABTS radical cation decolorization assay. Free Radic Biol Med 26:1231–1237
Wang B, Wang YM, Chi CF, Luo HY, Deng SG, Ma JY (2013) Isolation and characterization of collagen and antioxidant collagen peptides from scales of crocein croaker (Pseudosciaena crocea). Mar Drugs 11:4641–4661
Wu R, Wu C, Liu D, Yang X, Huang J, Zhang J, Liao B, He H, Li H (2015) Overview of antioxidant peptides derived from marine resources: the sources, characteristic, purification, and evaluation methods. Appl Biochem Biotechnol 176:1815–1833
Yildirim A, Mavi A, Kara AA (2001) Determination of antioxidant and antimicrobial activities of Rumex crispus L. extracts. J Agric Food Chem 49:4083–4089
Yong B, Yang B-Q, Feng H (2013) Efficient degradation of raw chicken feather into soluble peptides and free amino acids by a newly isolated Bacillus subtilis S1–4. Res J Biotechnol 8:48–55
Zhang J, Zhang H, Wang L, Guo X, Wang X, Yao H (2009) Antioxidant activities of the rice endosperm protein hydrolysate: identification of the active peptide. Eur Food Res Technol 229:709–719
Acknowledgments
This work is supported in part by the National Science Foundation of China under the Grant (311710204) and the Innovation Team by the Education Department of Sichuan Province under the Grant (13TD0043).
Author information
Authors and Affiliations
Corresponding author
Additional information
Min-Yuan Wan and Ge Dong have contributed equally to this work.
Rights and permissions
About this article
Cite this article
Wan, MY., Dong, G., Yang, BQ. et al. Identification and characterization of a novel antioxidant peptide from feather keratin hydrolysate. Biotechnol Lett 38, 643–649 (2016). https://doi.org/10.1007/s10529-015-2016-9
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10529-015-2016-9