Abstract
Reducing the quantity of waste for disposal and saving natural resources were main drivers for the introduction of the European Directive on waste electrical and electronic equipment (WEEE-directive). This policy focused on an extension of the producer responsibility (EPR) to the end-of-life-phase of their products. Because of the EPR concept, the national transposition of the WEEE-directive, especially the German transposition in the law ElektroG, caused changes in the organisation and material flows that are sometimes not in line with the aim of the directive, which is to enforce the waste management premise “avoidance prior recycling prior disposal”. Thus, the objective of this contribution is to analyse and compare the situation before and after implementation of the ElektroG in Germany, and deduce improvement potentials. Therefore, a co-operation of a municipality and a nearby disassembly company in Germany is analysed and evaluated, taking into account material flows and costs before/after implementation of the ElektroG, as well as degrees of freedom. Based on this analysis, recommendations are deduced for political decision makers and actors of the WEEE treatment system.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Dyckhoff H, Souren R, Keilen J (2004) The expansion of supply chains to closed loop systems—a conceptual framework and the automotive industry’s point of view. In: Dyckhoff H, Lackes R, Reese J, Fandel G (eds) Supply chain management and reverse logistics. Springer, Berlin, pp 13–34
ElektroG (2005) Gesetz über das Inverkehrbringen, die Rücknahme und die umweltverträgliche Entsorgung von Elektro- und Elektronikprodukten. BGBI I 762
European Parliament and Council of the European Union (2003) Directive 2002/96/EC of the European Parliament and the council on waste electrical and electronic equipment (WEEE). Off J Eur Communities L 37:24–39
EUWID (2003) Verbundsysteme als Lösungsansatz für die Rücknahme von Altgeräten—Mirec schlägt wettbewerbsorientiertes system zur WEEE-Umsetzung vor. Eur Wirtsch Re 6:17
Herrmann C, Luger T, Walther G, Spengler T, Steinborn J, Schöps D, Brüning R, Mücke S, Wentland A-K, Kratel W (2008) Empirical study on consumer acceptance and product return behavior. First world reuse forum in combination with the electronic goes Green 2008+, Berlin, pp 18–24
Kaebernick H, Ibbotson S, Kara S (2008) Cradle-to-cradle manufacturing. In: Newton PW (ed) Transitions—pathways towards sustainable urban development in Australia. CSIRO, Collingwood, pp 521–536
Koellner W, Fichtler W (1996) Recycling von Elektro- und Elektronikschrott—Einführung in die Wiederverwertung für Industrie, Handel und Gebietskörperschaften. Springer, Berlin
Lindqvist T (2000) Extended producer responsibility in cleaner production—policy principle to promote environmental improvements of product systems. PhD Thesis, Lund University
Lobas D, Schöps D (2007) The role of SME in recycling networks. In: Proceedings of the 2nd international conference ECO-X 2007: sustainable recycling management and recycling network centrope, 9–11 May 2007, Vienna, pp 173–178
Magalini F, Huisman J (2007) Management of WEEE and cost model across the EU could the EPR principle lead US to a better environmental policy? In: Proceedings of the 2007 IEEE international symposium on electronics and the environment, 7–10 May 2007, pp 143–148
NN (2003) The World Bank annual report. World Bank, New York
Organisation for Economic Co-operation and Development (OECD) (2001) Extended producer responsibility—a guidance manual for governments. OECD, Paris
Rose CM (2000) Design for environment: a method for formulating product end-of-life strategies. PhD thesis, Stanford University
Schröter M (2005) Strategisches Ersatzteilmanagement in closed-loop supply chains ein systemdynamischer Ansatz. DUV, Wiesbaden
Stiftung EAR (2008) Anzahl optierte örE je Sammelgruppe. http://www.stiftung-ear.de/aktuell/aktuelle_mitteilungen/kennzahlen/optierungen_oere. Accessed 13 November 2008
Thärichen H, Prelle R (2005) Die kommunale Eigenvermarktung von Elektro- und Elektronikaltgeräten nach dem Elektrogesetz. Zeitschrift für das Recht der Abfallwirtschaft 3:108–116
Verein deutscher Ingenieure e.V. (2008) Recycling elektrischer und elektronischer Geräte Logistik. VDI 2343, 2, Juli 2008, Beuth Verlag
Walther G (2005) Recycling von Elektro- und Elektronik-Altgeräten. DUV Gabler, Wiesbaden
Walther G, Spengler T (2005) Impact of WEEE directive on reverse logistics in Germany. Int J Phys Distrib Logistics Manag 35(5):337–361
Walther G, Spengler T (2004) Empirical analysis of collaboration potential of SMEs in product recovery networks in Germany. Prog Ind Ecology 1(4):363–384
Author information
Authors and Affiliations
Corresponding authors
Rights and permissions
About this article
Cite this article
Walther, G., Steinborn, J., Spengler, T.S. et al. Implementation of the WEEE-directive — economic effects and improvement potentials for reuse and recycling in Germany. Int J Adv Manuf Technol 47, 461–474 (2010). https://doi.org/10.1007/s00170-009-2243-0
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00170-009-2243-0