Abstract
Novel, laboratory-scale, high-solids reactors operated under mesophilic conditions were used to study the anaerobic fermentation of processed municipal solid waste (MSW) to methane. Product gas rate data were determined for organic loading rates ranging from 2.99–18.46 g of volatile solids (VS) per liter (L) per day (d). The data represent the anaerobic fermentation at high-solids levels within the reactor of 21–32%, while feeding a refuse-derived fuel (RDF)/MSW feedstock supplemented with a vitamin/mineral/nutrient solution. The average biogas yield was 0.59 L biogas/g VS added to the reactor system/d. The average methane composition of the biogas produced was 57.2%. The data indicate a linear relationship of increasing total biogas production with increasing organic loading rate to the process. The maximum organic loading rate obtainable with high-solids anaerobic digestion is in the range of 18–20 g VS/L·d to obtain 80% or greater bioconversion for the RDF/MSW feedstock. This loading rate is approximately four to six times greater than that which can be obtained with comparable low-solids anaerobic bioreactor technology.
Article PDF
Similar content being viewed by others
Explore related subjects
Discover the latest articles, news and stories from top researchers in related subjects.Avoid common mistakes on your manuscript.
References
Goodman, B. J. (1987),SERI/CP-232-0300.
Hasselriis, F. (1984),Refuse Derived Fuel Processing, Ann Arbor Science (Butterworths), Boston, MA.
Schwartz, S.C. and Brunner, C.R. (1983),Energy and Resource Recovery from Waste, Noyes Data Corp., NJ.
US Environmental Protection Agency (1974),Third Report to Congress, Pub. No. SW-161, Washington, D.C.
Ohlosson, O. O., Pearson, C.V., and Lazar, J. (1988), A presentation at the American Power Conference, Chicago, IL, April 18–20.
Metcalf & Eddy, Inc. (1979),Wastewater Engineering: Treatment, Disposal, Reuse, McGraw-Hill, New York.
US Environmental Protection Agency (1979),Process Design Manual for Sludge Treatment and Disposal, EPA 625/79-011, Environmental Research Information, Cincinnati, OH.
Arora, M. L. (1980),Water and Sewage Works 127, 24.
Federal Register (1989), Standards for the Disposal of Sewage Sludge, Proposed Rule.
Rivard, C. J. (1989),J. Environ. Health 52, 99, 100.
Goebel, R. P. (1983),High Solids Anaerobic Digester for Rural Use, #DE-FG03-81 SF 11613, US Department of Energy, Washington, D.C.
Hall, S. J., Hawkes, D. L., Hawkes, F. R., and Thomas, A. (1985),J. Agric. Eng. Res. 32, 153–162.
Jewell, W. J. (1980),Anaerobic Fermentation of Agricultural Residue, Potential for Improvement and Implementations, US DOE Project #DE-AC02-76ET20051 US Department of Energy, Washington, D.C.
Lin, Y.-M. (1983),Coupled High Solids Fermentation and Anaerobic Filtration of Cellulosic Residues, Ph.D. Thesis, Michigan State University.
Molnar, L. and Bartha, I. (1988),Biomass 16, 173–182.
Snell Environmental Group (1983),Rapid Methane Generation from Solid Waste, #DE-FG02-81R510329, US Department of Energy, Washington, D.C.
Wujcik, W. J. and Jewell, W. J. (1979), inProc. from the Second Symp. on Biotechnology in Energy Production and Conservation, October 3–5, 43–65.
Begouen, O., Thiebaut, E., Pavia, A., and Peillex, J. P. (1988), inProc. of the Fifth Int. Symp. on Anaerobic Digestion, May 22–26, 789–792.
de Baere, L. and Verstraete, W. (1984)Biocycle 25, 30, 31.
Gaddy, J. L. and Clausen, E. C. (1985),SERI Anaerobic Digestion Program 1984 Annual Report, SERI/PR-231-2691, Solar Energy Research Institute, Golden, CO.
Goldberg, T., Bjerbaek, B., Djernaes, E., and Mouritzen, A. (1981), inProc. of the Int. Gas Res. Conf. 734–741.
Rivard, C.J., Himmel, M. E., Vinzant, T. B., Adney, W. S., Wyman, C. E., and Grohmann, K. (1989),Appl. Biochem. and Biotech. 20/21, 461–478.
Rivard, C. J., Himmel, M. E., Vinzant, T. B., Adney, W. S., Wyman, C. E., and Grohmann, K. (1990),Biotech. Lett. 12, 235–240.
Rivard, C. J., Vinzant, T. B., Adney, W. S., Grohmann, K., and Himmel, M. E. (1990),Biomass 23, 201–214.
Rivard, C. J., Vinzant, T. B., Adney, W. S., and Grohmann, K. (1989),J. Environ. Health 52, 96–99.
Owen, W. F., Stuckey, D. C., Healy, J. B., Young, L. Y., and McCarty, P. L. (1979),Water Res. 13, 485–492.
Greenberg, A. E., Conners, J. J., and Jenkins, D., eds. (1981), inStandard Methods for the Examination of Water and Wastewater, APHA, Washington, D. C.
Rivard, C. J., Himmel, M. E., and Grohmann, K. (1985),Biotech. Bioeng. Symp. 15, 375–385.
Gujer, W. and Zehnder, A. J. B. (1983),Water Sci. Tech. 15, 127–167.
Cecchi, Traverso, Clancy, Mata-Alvarez, and Zaror (1987), inBiomass Energy, Elsevier Applied Science Publishers, London.
Boone, D. R. (1982),Appl. Environ. Microbiol. 43, 57–64.
Noike, T., Endo, G., Chang, J.-E., Yaguchi, J.-I., and Matsumoto, J.-I. (1985),Biotech. Bioeng. 27, 1482–1489.
Rivard, C. J., Adney, W. S., and Himmel, M. E. (1991), inEnzymes in Biomass Conversion, Leatham, G. and Himmel, M., eds., ACS Books, Washington, D. C., pp. 22–35.
Vinzant, T. B., Adney, W. S., Grohmann K., and Rivard, C. J. (1990),Appl. Biochem. Biotech. 24/25, 765–771.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Rivard, C.J. Anaerobic bioconversion of municipal solid wastes using a novel high-solids reactor design. Appl Biochem Biotechnol 39, 71–82 (1993). https://doi.org/10.1007/BF02918978
Issue Date:
DOI: https://doi.org/10.1007/BF02918978