Abstract
The present study deals with the problem of determining drag force acting on spherical particles by slow flow through the particles in random arrays. Effective-medium theories using simplified models such as EM-I, EM-II, EM-III, and EM-IV are presented to predict the drag on the spheres in random arrays. These predictions are compared with numerical simulations. The EM-IV model in which the volume exclusion effect near the representative sphere is taken into account in defining the effective-medium is found to compare very well with the numerical simulations up to the volume fraction of spheres Ø=0.5. In addition, Carman’s correlation is given for comparison. This empirical correlation is shown to be in good agreement with the simulation results beyond Φ=0.4. Therefore, it is found that selective use of EM-IV and Carman’s correlation depending on Φ is practically the best way to obtain accurate predictions of the drag for full range ofØ Finally, the estimations are compared with the previous experimental results for the gas pressure drop across a micropacked bed reactor. The comparison shows a reasonable agreement between the experimental results and the estimations by Carman’s correlation.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Acrivos, A. and Chang, E. Y., “A model for estimating transport quantities in two-phase materials,”Phys. Fluids, 29, 3 (1986).
Ajimera, S. K., Losey, M. W., Jensen, K. F. and Schmidt, M. A., “Micro-fabricated packed-bed reactor for phosgene synthesis,”AIChE J.,47, 1639(2001).
Bossis, G. and Brady, J. F., “Dynamic simulation of sheared suspensions. I. general method,”J. Chem. Phys.,80, 5141 (1984).
Brady, J. F. and Bossis, G., “Stokesian dynamics,”Annu. Rev. Fluid Mech., 20, 111(1988).
Carman, P. C., “Fluid flow through granular beds,”Trans. Inst. Chem. Eng.,15, 150 (1937).
Choi, M. J., Kim, J.-S., Kim, H.-K., Lee, S.-B., Kang, Y. and Lee, K.-W., “Hydrogenation of CO2 over Fe-K based catalysts in a fixed bed reactor at elevated pressure,”Korean J. Chem. Eng., 18,646 (2001).
Chong, J. S., Christiansen, E. B. and Baer, A. D., “Rheology of concentrated suspensions,”J. Appl. Polymer. Sci., 15, 2007 (1971).
Dodd, T. L., Hammer, D. A., Sangani, A. S. and Koch, D. L., “Numerical simulation of the effect of hydrodynamic interactions on diffusivities of integral membrane proteins,”J. Fluid Mech., 293, 147 (1995).
Durlofsky, L., Brady, J. F. and Bossis, G., “Dynamic simulation of hydrodynamically interacting particles,”J. Fluid Mech.,180, 21 (1987).
Ehrfeld, W., Hessel, V. and Lowe, H.,Microreactors, Wiley-VCH, Wein-heim(2000).
Ergun, S., “Fluid flow through packed columns,”Chem. EngngProg., 48,93(1952).
Ganatos, P., Pfeffer, R. and Weinbaum, S., “A numerical solution technique for three dimensional Stokes flow, with application to the motion of strongly interacting spheres in a plane,”J. Fluid Mech.,84, 79(1978).
Hashin, Z., “Analysis of composite materials,”J. Appl. Mech., 50, 481 (1983).
Hill, R., “A self consistent mechanics of composite materials,”J. Mech. Phys. Solids, 13, 213 (1965).
Jensen, K. F., “Microchemical systems: status, challenges, and opportunities,”AIChE J., 45, 2051 (2001).
Koo, S., “Numerical computation of pressure drop by slow flow through micropacked bed reactors,”J. Ind. Eng. Chem., Accepted (2006.2).
Koo, S. and Sangani, A. S., “Mass transfer coefficients for laminar longitudinal flow in hollow-fibre contactors,”J. Fluid Mech., 484, 255 (2003).
Kusakabe, K., Morooka, S. and Maeda, H., “Development of a micro-channel catalytic reactor system,”Korean J. Chem. Eng., 18, 271 (2001).
Ladd, A. J. C., “Hydrodynamic interactions in a suspension of spherical particles,”J. Chem. Phys.,88, 5051 (1988).
Ladd, A. J. C., “Hydrodynamic transport coefficients of random dispersion of hard spheres,”J. Chem. Phys., 93, 3484 (1990).
Losey, M. W., Jensen, K. F. and Schmidt, M. A., “Microfabricated multiphase packed-bed reactors: characterizaion of mass transfer and reactions,”Ind. Eng. Chem. Res.,40, 2555 (2001).
Mazur, P. and Saarloos, W. V., “Many-sphere hydrodynamic interactions and mobilities in a suspension,”Physica A,115, 21 (1982).
Mo, G. and Sangani, A. S., “A method for computing Stokes flow interactions among spherical objects and its application to suspensions of drops and porous particles,”Phys. Fluids, 6, (1994).
Percus, J. K. and Yevick, G J., “Analysis of classical statistical mechanics by means of collective coordinates,”Phys. Rev.,110, 1 (1958).
Sangani, A. S. and Yao, C., “Transport processes in random arrays of cylinders. II. viscous flow,”Phys. Fluids, 31, 2435 (1988).
Sotowa, K.-I., Miyoshi, R., Lee, C.-G., Kang, Y. and Kusakabe, K., “Mixing and enzyme reactions in a microchannel packed with glass beads,”Korean J. Chem. Eng.,22, 552 (2005).
Wang, J., Jiang, D. M., Baeg, J. O. and Lee, C. W., “Hydroisomerization of n-Heptane over modified USY-supported H3PW12O40 catalysts: effect of hydrothermal treatment for USY,”J. Ind. Eng. Chem., 10, 454(2004).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Koo, S. Estimation of drag force acting on spheres by slow flow and its application to a microfluidic device. Korean J. Chem. Eng. 23, 176–181 (2006). https://doi.org/10.1007/BF02705712
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/BF02705712