Abstract
Models were derived for monolayer and bilayer growth into a substrate in which diffusion of the solute governs the growth kinetics, as in gas-solid reactions, for example. In the models, the composition dependence of the solute diffusivity in the phases constituting the layers was accounted for by appropriate definition of an effective diffusion coefficient for a (sub)layer. This effective diffusion coefficient is the intrinsic diffusion coefficient weighted over the composition range of the (sub)layer. The models were applied for analyzing the growth kinetics of a γ′-Fe4N1-x monolayer on an α-Fe substrate and the growth kinetics of an ε-Fe2N1-z/γ′-Fe4N1-x bilayer on an α-Fe substrate, as observed by gaseous nitriding in an NH3/H2-gas mixture at 843 K. The kinetics of layer development and the evolution of the microstructure were investigated by means of thermogravimetry, layer-thickness measurements, light microscopy, and electron probe X-ray microanalysis (EPMA). The effective and self-diffusion coefficients were determined for each of the nitride layers. The composition dependence of the intrinsic (and effective) diffusion coefficients was established. Re-evaluating literature data for diffusion in γ′-Fe4N1-x on the basis of the present model, it followed that the previous and present data are consistent. The activation energy for diffusion of nitrogen in γ′-Fe4N1-x was determined from the temperature dependence of the self-diffusion coefficient. The self-diffusion coefficient for nitrogen in ε-Fe2N1-z was significantly larger than that for γ′-Fe4N1-x. This was explained qualitatively, considering the possible mechanisms for interstitial diffusion of nitrogen atoms in the close-packed iron lattices of the ε and γ′ iron nitrides.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
T. Bell:Heat Treat. Met., 1975, vol. 2, pp. 39–49.
K. Sachs and D.B. Clayton:Heat Treat. Met., 1979, vol. 6, pp. 29–34.
Ya.D. Kogan and A.A. Bulgach:Metalloved. Term. Obrab. Met., 1984, vol. 13, pp. 10–20.
W. Jentzsch and S. Böhmer:Neue Hütte, 1979, vol. 24, pp. 249–53.
E. Metin, A.D. Romig Jr., O.T. Inal, and R.E. Semarge: inMicrobeam Analysis 1988, D.E. Newbury, ed. San Francisco Press Inc., San Francisco, CA, 1989, pp. 498–502.
D. Heger and D. Bergner:Härterei-Tech. Mitt., 1990, vol. 46, pp. 331–38.
Hong Du and J. Ågren:Mater. Sci. Forum, 1992, vol. 102–104, pp. 243–48.
A. Marciniak:Surf. Eng., 1985, vol. 1, pp. 283–88.
Z. Przylecki and L. Maldzinski: inCarbides, Nitrides and Borides, Poznan/Kolobrzeg, Poznan, Poland, 1987, pp. 153–162.
L. Maldzinski, Z. Przylecki, and J. Kunze:Steel Res., 1986, vol. 12, pp. 646–50.
K. Schwerdtfeger, P. Grieveson, and E.T. Turkdogan:Trans. AIME, 1969, vol. 245, pp. 2461–466.
B. Prenosil:Kovove Mater., 1965, vol. 3, pp. 69–87.
Yu.M. Lakhtin and Ya.D. Kogan:Nitriding of Steel, [(in Russian)] Mashinostroenie, Moscow, 1976.
L.S. Darken:Trans. AIME, 1948, vol. 175, pp. 184–94.
M.A.J. Somers and E.J. Mittemeijer:Surf. Eng., 1987, vol. 3, pp. 123–37.
W. Jost:Diffusion in Solids, Liquids and Gases, Academic Press Inc., New York, NY, 1960, pp. 71–72.
S. Crusius, G. Inden, U. Knoop, L. Höglund, and J. Ågren:Z. Metallkd., 1992, vol. 83, pp. 673–78.
J. Crank:The Mathematics of Diffusion, Clarendon Press, Oxford, 1956.
J. Colwell, G.W. Powell, and J.L. Ratliff:J. Mater. Sci., 1977, vol. 12, pp. 543–48.
H.J. Grabke:Ber. Bunsengesell, Phys. Chem., 1969, vol. 73, pp. 596–601.
B.J. Kooi, M.A.J. Somers, and E.J. Mittemeijer: Delft University of Technology, Delft, The Netherlands, unpublished research, 1993.
G.V. Kidson:J. Nucl. Mater., 1961, vol. 3, pp. 21–29.
C. Wagner:Acta Metall., 1969, vol. 17, pp. 99–107.
A.J. Hickl and R.W. Heckel:Metall. Trans. A, 1975, vol. 6A, pp. 431–40.
A.K. Sarkhell and L.L. Seigle:Metall. Trans. A, 1976, vol. 7A, pp. 899–902.
S.R. Shatynski, J.P. Hirth, and R.A. Rapp:Acta Metall., 1976, vol. 24, pp. 1071–78.
D.S. Williams, R.A. Rapp, and J.P. Hirth:Metall. Trans. A, 1981, vol. 12A, pp. 639–52.
Guan-Xing Li and G.W. Powell:Acta Metall. 1985, vol. 33, pp. 23–31.
E. Fromm:Z. Metallkd., 1966, vol. 57, pp. 60–65.
U. Roy:Acta Metall., 1968, vol. 16, pp. 243–53.
C.M. Brakman, A.W.J. Gommers, and E.J. Mittemeijer:J. Mater. Res., 1989, vol. 4, pp. 1354–70.
A. Wells:J. Mater. Sci., 1985, vol. 20, pp. 2439–445.
M.A.J. Somers, N.M. van der Pers, D. Schalkoord, and E. J. Mittemeijer:Metall. Trans. A, 1989, vol. 20A, pp. 1533–539.
G.F. Bastin, H.J.M. Heijligers, and F.J.J. van Loo:Scanning, 1984, vol. 6, pp. 58–68.
J.R.G. da Silva and R.B. McLellan:Mater. Sci. Eng., 1976, vol. 26, p. 83.
H.C.F. Rozendaal, E.J. Mittemeijer, P.F. Colijn, and P.J. van der Schaaf:Metall. Trans. A, 1983, vol. 14A, pp. 395–99.
E.J. Mittemeijer, M. van Rooijen, I. Wierzyllowski, H.C.F. Rozendaal, and P.F. Colijn:Z. Metallkd., 1983, vol. 74, pp. 473–83.
M.A.J. Somers and E.J. Mittemeijer:Metall. Trans. A, 1990, vol. 21A, pp. 189–204.
Liu Cheng and E.J. Mittemeijer:Metall. Trans. A, 1990, vol. 21A, pp. 13–26.
M.A.J. Somers and E.J. Mittemeijer:Metall. Trans. A, 1990, vol. 21A, pp. 901–12.
H.H. Podgurski and H.W. Knechtel:Trans. AIME, 1969, vol. 245, pp. 1595–1602.
H.A. Wriedt:Trans. AIME, 1969, vol. 245, pp. 43–46.
H.J. Grabke:Ber. Bunsengesell. Phys. Chem., 1968, vol. 72, pp. 533–48.
B.J. Kooi, M.A.J. Somers, and E.J. Mittemeijer:Metall. Mater. Trans. A, in press.
E. Lehrer:Z. Electrochem., 1930, vol. 36, pp. 383–92.
P. Ferguson and K.H. Jack:Proc. Heat Treatment ’81, The Metals Society, London, 1981, pp. 158–63.
D. Firrao, B. DeBenedetti, and M. Rosso:Metall. Ital., 1979, vol. 71, p. 373.
K.H. Jack:J. Appl. Cryst., 1952, vol. 5, pp. 404–11.
B. Pieraggi:Oxid. Met., 1987, vol. 27, pp. 177–185.
L. Torchane, P. Bilger, J. Dulcy, and M. Gantois:Mater. Sci. Forum, 1994, vol. 163–165, pp. 707–12.
A.M. Vredenberg: Ph.D. Thesis, University of Utrecht, 1991.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Somers, M.A.J., Mittemeijer, E.J. Layer-growth kinetics on gaseous nitriding of pure iron: Evaluation of diffusion coefficients for nitrogen in iron nitrides. Metall Mater Trans A 26, 57–74 (1995). https://doi.org/10.1007/BF02669794
Received:
Issue Date:
DOI: https://doi.org/10.1007/BF02669794