Abstract
It is shown that the addition of 0.1 pct Ti to a low carbon Ni-Cr steel can eliminate most of the susceptibility to temper embrittlement due to both step cooling and isothermal aging. The mechanism by which Ti acts is complex and not yet clear. It suppresses carbide formation during the embrittlement heat treatment, which should retard the rate of embrittlement (cf. Part I). However, it also appears to interact with Ni and Sb by enhancing the segregation of Ni to grain boundaries and by mitigating the embrittling effect of Sb.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
H. Ohtani, H. C. Feng, C. J. McMahon, Jr., and R. A. Mulford:Met. Tram. A, 1976, vol. 7A, p. 87.
C. J. McMahon, Jr., E. Furubayashi, H. Ohtani, and H. C. Feng:Acta Met., in press.
M. Nageswararao, C. J. McMahon, Jr., and H. Herman:Met. Trans., 1974, vol. 5, p. 1061.
C. J. McMahon, Jr.:Proc. Fourth Bolton Landing Conference, J. L. Walter et al, ed., p. 525, Claitor’s, Baton Rouge, 1975.
H. Ohtani and C. J. McMahon, Jr.:Acta Met., 1975, vol. 23, p. 377.
H. Ohtani, H. C. Feng, and C. J. McMahon, Jr.:Met. Trans., 1974, vol. 5, p. 516.
A. T. Aldred:J. Phys. C, 1968, vol. l, p. 1103.
T. M. Shrinivasan, H. Claus, R. Viswanathan, P. A. Beck, and D. I. Bardos:inPhase Stability in Metals and Alloys, P. S. Rudman, ed., McGraw Hill, New York, 1966.
e.g. J. Friedel:inThe Physics of Metals, J. M. Ziman, ed., Cambridge, 1969.
E. Furubayashi:unpublished research, National Research Institute for Metals, Tokyo, 1974.
H. C. Fng, E.A. Wilson, and C. J. McMahon, Jr.:inProc. 3rd Intnl. Conf. on Strength of Metals and Alloys, p. 129, Institute of Metals and Iron and Steel Institute, London, 1973.
H. G. Suzuki:MS Thesis, University of Pennsylvania, 1974.
J. R. Low and R. G. Feustel:Acta Met., 1953, vol. l, p. 185.
C. J. McMahon, Jr.:Acta Met., 1966, vol. 14, p. 839.
J. R. Rellick and C. J. McMahon, Jr.:Met. Trans., 1970, vol. 1, p. 929.
P. Jolly and C. Goux:Mem. Sci. Rev. Met., 1969, vol. 66, p. 605.
C. Pichard, J. Rieu, and C. Goux:Mem. Sci. Rev. Met., 1973, vol. 70, p. 13.
C. J. McMahon, Jr. and M. Cohen:Acta Met., 1965, vol. 13, p. 591.
H. C. Feng, H. G. Suzuki, and C. J. McMahon, Jr.:unpublished research.
Author information
Authors and Affiliations
Additional information
Formerly a Post-Doctoral Fellow.
Rights and permissions
About this article
Cite this article
Ohtani, H., Feng, H.C. & Mcmahon, C.J. Temper embrittlement of Ni-Cr steel by antimony:II. Effects of addition of titanium. Metall Trans A 7, 1123–1131 (1976). https://doi.org/10.1007/BF02656594
Received:
Issue Date:
DOI: https://doi.org/10.1007/BF02656594