Abstract
The precipitation rate of intentionally introduced iron during low-temperature heating is studied among a variety of single-crystal and polycrystalline silicon solar cell materials. A correlation exists between the iron precipitation rate and the carrier recombination rate in dislocation-free as-grown material, suggesting that diffusion-length-limiting defects in as-grown material are structural defects which accelerate iron precipitation. Phosphorous diffusion gettering was found to be particularly ineffective at improving diffusion length after intentional iron contamination in materials with high iron precipitation rates. We propose that intragranular structural defects in solar cell silicon greatly enhance transition metal precipitation during cooling from the melt and become highly recombination-active when decorated with these impurities. The defects then greatly impair diffusion length improvement during phosphorus gettering and limit carrier lifetimes in as-grown material.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
M.A. Green,Semicond. Sci. Technol. 8, 1 (1993).
F.V. Wald,Solar Energy Mater. 23, 175 (1991).
MRS Bulletin 18 (1993).
S. Narayanan, S.R. Wenham and M.A. Green,IEEE Trans. Electron Dev. 37, 382 (1990).
W. Shockley and J.W.T. Read,Phys. Rev. 87, 835 (1952).
R. N. Hall,Phys. Rev. 87, 387 (1952).
V. Higgs and M. Kittler,Appl. Phys. Lett. 63, 2085 (1993).
M. Kittler, W. Seifert and V. Higgs,Phys. Stat. Sol. (a) 137, 327 (1993).
R. Gleichmann, B. Cunningham and D. Ast,J. Appl. Phys. 58, 223 (1985).
D. P. Singh and P. S. Basak.Indian J. Pure and Appl. Phys. 29, 717 (1991).
T. Abe, T. Samizo and S. Maruyama,Jpn. J. Appl. Phys. 5, 458 (1966).
A.J.R. De Kock,Appl. Phys. Lett. 16, 100 (1970).
P.M. Petroff and A.J.R. De Kock,J. Cryst. Growth 30, 117 (1975).
A.J.R. De Kock,Defects in Semiconductors, eds. J. Narayan and T.Y. Tan (Amsterdam: North-Holland, 1981), p. 309.
T.F. Ciszek,J. Electrochem. Soc. 120, 94 (1973).
X. Zong, Y. Chen, H. Cao, X. Gu and J. Zheng,Chin. J. Semicond. 3, 413 (1982).
T. Yamauchi, Y. Tsumori, T. Nakashizu, H. Esaka, S. Takao and S. Shinoyama,Jpn. J. Appl. Phys. 2, Lett. 31, L439 (1992).
T.H. Wang, T.F. Ciszek and T. Schuyler,Solar Cells 24, 135 (1988).
S.A. McHugo and W.D. Sawyer,Appl. Phys. Lett. 62, 2519 (1993).
D. Gilles, E.R. Weber and S. Hahn,Phys. Rev. Lett. 64, 196 (1990).
D. Gilles, E.R. Weber and S. Hahn,Semiconductor Silicon 90, 697 (1990).
F.S. Ham,J. Phys. Chem. Solids 6, 335 (1958).
J. Bailey and E.R. Weber,Phys. Stat. Sol. (a) 137, 515 (1993).
S.K. Pang, A. Rohatgi, B. L. Sopori and G. Fiegl,J. Electrochem. Soc. 137, 1977 (1990).
S.K. Pang and A. Rohatgi,Appl. Phys. Lett. 59, 195 (1991).
H. Lemke,Phys. Stat. Sol. (a) 64, 215 (1981).
L.C. Kimerling and J.L. Benton,Physica 116B, 297 (1983).
L. Jastrzebski, W. Henley and C. J. Nuese,Solid State Technol. 35, 27 (1992).
J. Lagowski, P. Edelman, M. Dexter and W. Henley,Semicond. Sci. Technol. 7, A185 (1992).
E.R. Weber,Appl. Phys. A 30, 1 (1983).
J.P. Kalejs, L. Jastrzebski, L. Lagowski, W. Henley, D. Schielein, S.G. Balster and D.K. Schroder,Proc. 12th European PV SEC, Amsterdam, 1994. Independent confirmation by the authors.
ASTM Annual Book of Standards, 10.05, 191 (1989).
T. Higuchi, E. Gaylord, G.A. Rozgonyi and E. Shimura,Appl. Phys. Lett. 53, 1850 (1988).
T. Munakata and I. Tanasawa,J. Cryst. Growth 106, 566 (1990).
J.P. Kalejs and B. Chalmers,J. Cryst. Growth 79, 487 (1986).
J.P. Kalejs and LA. Ladd,Appl. Phys. Lett. 45, 540 (1984).
R. Gleichmann, J.P. Kalejs and D.G. Ast,Mater. Res. Soc. Symp. Proc. 36, 181 (1985).
Q. Sun, K.H. Yao, J. Lagowski and H.C. Gatos,J. Appl. Phys. 67, 4313 (1990).
R. Murphy and B.L. Sopori,Mater. Res. Soc. Spring Mtg., 1995, Symp. B, San Francisco, CA, 1995.
P. Sana, A. Rohatgi, J.P. Kalejs and R.O. Bell,Appl. Phys. Lett. 64, 97 (1994).
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Bailey, J., Mc Hugo, S.A., Hieslmair, H. et al. Efficiency-limiting defects in silicon solar cell material. J. Electron. Mater. 25, 1417–1421 (1996). https://doi.org/10.1007/BF02655376
Received:
Revised:
Issue Date:
DOI: https://doi.org/10.1007/BF02655376