Abstract
Those aspects of the quantitative methanolysis of fats with fatty acids containing four or more carbon atoms and the gas liquid chromatographic analysis of the methyl esters which have not been adequately dealt with to date were investigated. Accurate analysis of the esters requires the optimization of the total chromatographic system using a carefully prepared methyl ester primary standard and applying, as the only correction factors, the theoretical flame ionization detector response factors of Ackman and Sipos. These factors now have also been shown to be highly accurate for short chain saturated fatty acid methyl esters, in particular methyl butyrate and methyl caproate. Under the conditions specified by the international methods for the methylation (methanolic KOH) of fats with fatty acids containing four or more carbon atoms, saponification of the esters, once formed, proceeds much more rapidly for short chain than for long chain esters. This problem is easily overcome by neutralizing the catalyst, which then leads to very stable solutions and contributes to column life. This step should be mandatory in the international procedures. Tristearin methylated more slowly than other triacylglycerols under the standard conditions, but there was no difficulty in the case of unsaturated fatty acids of this chain length. Satisfactory results could not be obtained when sodium methoxide was the catalyst. The optimum procedure rendered unnecessary the use of methyl pentanoate as an internal standard for the accurate quantitation of methyl butyrate.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Firestone, D., and W. Horwitz, J. Assoc. Off. Anal. Chem. 62:709 (1979).
Standard Methods for the Analysis of Oils, Fats and Derivatives. International Union of Pure and Applied Chemistry (IUPAC), Applied Chemistry Division, Commission on Oils, Fats and Derivatives, Part 1 (Sections 1 and 2), Pergamon Press, Oxford, 6th ed., 1979, Method 2.301, Section 5.
Ibid.,Method 2.302.
Badings, H.T., and C. De Jong, J. Chromatogr. 493:49 (1983).
Christopherson, S.W., and R.L. Glass, J. Dairy Sci. 52:1289 (1969).
International Standard, International Organization for Standardization (ISO), Geneva, 1st ed., 1978, Ref. No. ISO-5509-1978 (E), Section 6.
Ibid., Ref. No. ISO-5508-1978 (E).
Shehata, A.Y., J.M. DeMan and J.C. Alexander, Can. Inst. Food Technol. J. 3:85 (1970).
Glass, R.L., Lipids 6:919 (1971).
Bannon, C.D., G.J. Breen, J.D. Craske, N.T. Hai, N.L. Harper and K.L. O’Rourke, J. Chromatogr. 247:71 (1982).
Christie, W.W., J. Lipid Res. 23:1072 (1982).
Smith, L.M., J. Daity Sci. 44:607 (1961).
DeMan, J.M., Lab. Pract. 16:150 (1967).
Ackman, R.G., and J.C. Sipos, JAOCS 41:377 (1964).
Albertyn, D.E., C.D. Bannon, J.D. Craske, N.T. Hai, K.L. O’Rourke and C. Szonyi, J. Chromatogr. 247:47 (1982).
Bannon, C.D., J.D. Craske and A.E. Hilliker, JAOCS, in press.
Bannon, C.D., J.D. Craske, N.T. Hai, N.L. Harper and K.L. O’Rourke, J. Chromatogr. 247:63 (1982).
Author information
Authors and Affiliations
About this article
Cite this article
Bannon, C.D., Craske, J.D. & Hilliker, A.E. Analysis of fatty acid methyl esters with high accuracy and reliability. IV. Fats with fatty acids containing four or more carbon atoms. J Am Oil Chem Soc 62, 1501–1507 (1985). https://doi.org/10.1007/BF02541903
Received:
Issue Date:
DOI: https://doi.org/10.1007/BF02541903