Abstract
Controlled-release phosphate fertilizers include phosphate rocks (PRs) for direct application, partially acidulated phosphate rocks (PAPRs) and thermal phosphates. Phosphate rocks contain apatite as the main P containing mineral, the composition and the chemical nature of which vary between PRs. Based on the solubility in chemical extractants PRs are broadly grouped into ‘reactive’ and ‘unreactive’. The ‘reactivity’ of PRs is influenced strongly by the extent of carbonate substitution for phosphate in the apatite minerals. Under certain soil and climatic conditions reactive PRs (RPRs) can be used as a source of P for direct application.
Partially acidulated phosphate rocks (PAPRs) are produced either by direct partial acidulation of PRs with mineral acids or by mixing PRs with fully acidulated superphosphate reaction mixtures. Partial acidulation of PRs with H3PO4 generally results in higher water soluble P contents than those acidulated with H2SO4. Mixing of RPRs with superphosphate reaction mixtures sometimes results in the preferential consumption of free acid and thereby increases the amounts of residual unreacted PRs.
Thermal phosphates are produced by either heating PRs below melting point both in the presence and the absence of silica (calcined phosphates) or heating PRs with silica above melting point (fused phosphate). These phosphates are alkaline in nature and hence suitable for acidic soils.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Amberger A (1979) Experiences with soft rock phosphates for direct application. In: Seminar on Phosphate Rock for Direct Application. Special Publication IFDCSI, pp 349–366. International Fertilizer Development Centre, Muscle Shoals, Alabama
Ando J (1987) Thermal phosphate. In: Nielsson FT (ed) Manual of Fertilizer Processing, pp 93–124. Marcel Dekker Inc, New York
Barbarick KA, Lai TM and Eberl DD (1990) Exchange fertilizer (phosphate rock plus ammonium-zeolite) effects on sorghum-sudangrass. Soil Sci Soc Am J 54: 911–916
Bolan NS, Hedley MJ, Harrison R and Braithwaite AC (1990) Influence of manufacturing variables on characteristics and the agronomic value of partially acidulated phosphate fertilizers. Fert Res 26: 119–138
Bolan NS, Hedley MJ, Syers JK and Tillman RW (1987) Single superphosphate-reactive phosphate rock mixture. 1. Factors affecting the chemical composition. Fert Res 13: 223–239
Bolan NS, White RE and Hedley MJ (1990) A review of the use of phosphate rocks as fertilizers for direct application in Austrailia and New Zealand. Aust J Exp Agric 30: 297–313
Bolland MDA and Gilkes RJ (1987) How effective are calciphos and phospal. Fert Res 12: 229–239
Braithwaite AC (1986a) A comparison of fertilizers made by partially and fully acidulated phosphate rocks with phosphoric acid. NZJ Technol 2: 3–42
Braithwaite AC (1986b) Effect of metallic ion impurities on the production of partially acidulated phosphate rocks using phosphoric acid. NZ Fertilizer Manufacturers Research Association Research Reports: 257-265
Braithwaite AC (1987a) Partially acidulated phosphate rock fertilizers-an FMRA Research Review. In: White RE and Currier LD (eds) The use of Reactive Phosphate Rocks and their derivatives as Fertilizers, Occasional Report No 1, pp 18–26. Fertilizer and Lime Research Centre, Massey University, NZ
Braithwaite AC (1987b) Processing aspects of the production of partially acidulated phosphate rock fertilizers using phosphoric acid. Fert Res 13: 87–95
Braithwaite AC and Crump RT (1980) Addition of North Carolina rock to ex-den superphosphate. Part 1. NZ Fertilizer Manufacturers Research Association Research Reports: 187-191
Braithwaite AC and Rogers DA (1987) Partially acidulated phosphate rocks made from phosphoric acid using direct acidulation-granulation techniques. Fert Res 12: 85–98
Braithwaite AC, Eaton AC and Groom PS (1992) Chemical segregation effects in commercial and laboratory mixtures of reactive phosphate rock and acidulated fertilizers. Fert Res 31: 111–118
Carmon S (1979) Methods of granulation In: Seminar on Phosphate Rock for Direct Application. Special Publication IFDC-SI, pp 413–425. International Fertilizer Development Centre, Muscle Shoals, Alabama
Caro JH and Hill WL (1956) Characteristics and fertilizer values of phosphate rock from different fields. Agric Food Chem 4: 684–687
Charleston AG (1987) A process for the introduction of elemental sulphur into high analysis phosphate fertilizers. Fert Res 11: 185–192
Charleston AG, Condron LM and Brown MW (1989) The nature of the residual apatites remaining after partial acidulation of phosphate rocks with phosphoric and sulphuric acids. Fert Res 18: 257–273
Chien SH (1977) Thermodynamic considerations on the solubility of phosphate rock. Soil Sci 123: 117–121
Chien SH and Hammond LL (1978a) A simple chemical method for evaluating the agronomic potential of granulated phosphate rock. Soil Sci Soc Am J 42: 615–617
Chein SH and Hammond LL (1978b) A comparison of various laboratory methods for predicting the agronomic potential of phosphate rocks for direct application. Soil Sci Soc Am J 42: 935–939
Davis KA (1947) The phosphate deposits of the eastern province, Uganda. Econ Geol 42: 137–146
Doak BW, Gallaher PJ, Evans L and Muller FB (1965) Low temperature calcination of C grade phosphate from Christmas Island. NZJ Agric Res 8: 15–29
Frazier AW and Kim YK (1989) Redistribution of impurities in commercial wet processes acid. Fert Res 21: 45–60
Garbouchev IP (1981) The manufacture and agronomic efficiency of a partially acidulated phosphate rock fertilizer. Soil Sci Soc Am J 45: 970–974
Gillion I and Hagin J (1979) Method for estimating granulated phosphate rock availability for crops. In: Seminar on Phosphate Rock for Direct Application. Special Publication IFDC-SI, pp 222–233. International Fertilizer Development Centre, Muscle Shoals, Alabama
Gillion I, Reinhorm T, Semiat R and Hagin J (1979) Evaluation of granulated phosphate rock for direct application In: Seminar on Phosphate Rock for Direct Application. Special Publication IFDC-SI, pp 378–394. International Fertilizer Development Centre, Muscle Shoals, Alabama
Hammond LL, Chien SH and Mokwunye AU (1986) Agronomic value of unacidulated and partially acidulated phosphate rocks indigenous to the tropics. Adv Agron 40: 89–140
Hammond LL, Chien SH, Roy AH and Mokwayne AU (1989) Solubility and agronomic effectiveness of partially acidulated phosphate rocks as influenced by their iron and aluminum oxide content. Fert Res 19: 93–99
Harrison R and Hedley MJ (1989) Partially acidulated phosphate rock fertilizers. Report submitted to Ravensdown Fertilizer Cooperative, New Zealand
Hedley MJ, Bolan NS and Braithwaite AC (1988) Single superphosphate-reactive phosphate rock mixtures. 2. The effect of phosphate rock type and denning time on the amounts of acidulated and extractable phosphate. Fert Res 16: 179–194
Hedley MJ, Bolan NS and Wallace G (1989) Granulation of partially acidulated phosphate rock fertilizers. Report submitted to Ravensdown Fertilizer Cooperative, New Zealand
Hedley MJ and Rowarth JS (1988) Dissolution of phosphate rocks. Report submitted to Ravensdown Fertilizer Cooperative, New Zealand
Hedley MJ, Tillman RW and Wallace G (1989) The use of nitrogen fertilizers for increasing the suitability of reactive phosphate rocks for use in intensive agriculture. In: White RE and Currie LD (eds) Nitrogen Fertilizer Use in New Zealand Agriculture and Horticulture. Occasional Report No 3, pp 311–320. Fertilizer and Lime Research Centre, Massey University, New Zealand
Khasawneh FE and Doll EC (1978) The use of phosphate rock for direct application to soils. Adv Agron 30: 159–206
Kirk GJD and Nye PH (1986a) A simple model for predicting the rates of dissolution of sparingly soluble calcium phosphates in soil. I. The Basic model. J Soil Sci 37: 529–540
Kirk GJD and Nye PH (1986b) A simple model for predicting the rates of dissolution of sparingly soluble calcium phosphates in soil. II. Applications of the model. J Soil Sci 37: 541–554
Lai TM and Eberl DD (1986) Controlled and renewable release of phosphorus in soils from mixtures of phosphate rock and NH −4 exchanged clinopitilolite. Zeolites 6: 129–132
Lehr JR and McClellan GH (1972) A revised laboratory reactivity scale for evaluating phosphate rocks for direct application. Bull Y-43, Tennessee valley Authority, Muscle Shoals, Alabama, 36 p
Lindsay WL and Vlek PLG (1977) Phosphate minerals. In: Dixon JB and Weed SB (eds) Minerals in the Soil Enviroment pp 539–672. Soil Sci Soc Am, Madison, Wisconsin
Livingston OW (1979) Minigranulation-a method for improving the properties of phosphate rock for direct application. In: Seminar on Phosphate Rock for Direct Application. Special Publication IFDC-SI, pp 367–377. International Fertilizer Development Centre, Muscle Shoals, Alabama
Loganathan P and Hedley MJ (1992) Single superphosphate-reactive phosphate rock mixtures. 3. The use of concentration ratios of elements to identify the nature and amounts of unaciduated rock residues in the mixtures. Submitted to Fertilizer Research
Loganathan P, Hedley MJ, Toes HB and Bretherton MR (1991) Manufacture and field trial evaluation of granulated reactive phosphate rocks. Report submitted to Quinphos Fertilizers (NZ) Ltd, 11 p.
Lupin MS and Le ND (1983) Alternative Approach for Granular Fertilizers-Compaction. Technical Bulletin. IFDC-T 25. International Fertilizer Development Centre, Muscle Shoals, Alabama
MacKay AD, Syers JK, Gregg PEH and Springett JA (1981) Techniques for assessing the agronomic effectiveness of phosphate rock materials. In: Sayers JK and Gregg PEH (eds) Proceedings, Technical Workshop on Potential of Phosphate Rock as a Direct Application Fertilizer in New Zealand, pp 42-50. Massey University
McClellan GH and Gremillion LC (1980) Evaluation of Phosphatic Raw Materials. In: Khasawneh FE, Sample EC and Kamprath EJ (eds) The Role of Phosphorus in Agriculture, pp 45–85. ASA-CSSA-SSA Madison, Wisconsin, USA
McClellan GH and Lehr JR (1969) Crystal chemical investigation of natural apatites. Am Mineral 54: 1374–1391
McKelvey VE (1973) Abundance and distribution of phosphorus in the lithosphere. In: Griffith EJ, Beeton A, Spensor JM and Mitchell DT (eds) Environmental Phosphorus Handbook, pp 13–31. John Wiley and Sons, New York
Murdock JT and Seay WA (1955) The availability to greenhouse crops of rock phosphate phosphorus and calcium in superphosphate-rock phosphate mixtures. Soil Sci Soc Am Proc 19: 199–203
Officer SJ (1989) An Investigation of the Agronomic Value of Fine Grinding and Granulating Reactive Phosphate Rocks. Unpublished MSc thesis submitted to Massey Unversity, 207 p.
Palmer B (1980) A Chemical, mineralogical and biological evaluation of calcined christmas Island C-grade rock phosphate. PhD thesis, Unversity of Western Australia
Rajan SSS (1982) Influence of phosphate rock reactivity and granule size on the effectiveness of ‘biosuper’. Fert Res 3: 3–12
Rajan SSS (1985) Partial acidulation of an “unground” phosphate rock. 1. Preparation and characteristics. Fert Res 8: 147–155
Rajan SSS and Marwaha BC (1993) Use of partially acidulated phosphate rocks as phosphate fertilizers 35: 47-59 (This issue)
Sanyal SK and DeDatta SK (1991) Chemistry of Phosphorus Transformations in Soil. Adv Soil Sci 16: 1–120
Shand SJ (1932) The granite-syenite-limestone complex of Palabora, E Transvel. Trans Geol Soc S Africa 34: 81–105
Slansky M (1986) Geolog of Sedimentary Phosphate. North Oxford Academic Publishers Ltd, London, 210 p.
Stangel PJ (1979) The IFDC phosphate program. In: Seminar on Phosphate Rock for Direct Application, pp 3–35. Special Publication. IFDC-SI. International Fertilizer Development Centre, Muscle Shoals, Alabama
Swaby RJ (1983) Production and uses of biological superphosphate. In: Soils -an Australian Viewpoint, pp 817–823. Division of Soils, CSIRO, Austrailia
Syers JK, MacKay AD, Brown MW and Currie LD (1986) Chemical and Physical characteristics of phosphate rock materials of varying reactivity. J Sci Food Agric 37: 1057–1064
White RE, Hedley MJ, Bolan NS and Gregg PEH (1989) Recent development in the use of phosphate fertilizers in New Zealand pastures. J Aust Inst Agric Sci 2: 28–32
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Bolan, N.S., Hedley, M.J. & Loganathan, P. Preparation, forms and properties of controlled-release phosphate fertilizers. Fertilizer Research 35, 13–24 (1993). https://doi.org/10.1007/BF00750216
Issue Date:
DOI: https://doi.org/10.1007/BF00750216