Skip to main content
SpringerLink
Log in

The Dispersive Effect of Sodium Silicate on Kaolinite Particles in Process Water: Implications for Iron-Ore Processing

  • Published:
Clays and Clay Minerals

Abstract

Kaolinite is a common gangue mineral in iron ore and sodium silicate has been used widely as a dispersant of silicate gangue minerals including kaolinite in various iron-ore flotation methods over a wide range of pH. Its actual dispersive effect on kaolinite under iron-ore flotation conditions has received very limited attention, however. The presence of hydrolyzable metal cations in process water further complicates sodium silicate—kaolinite interactions. In the present study, the dispersive effect of sodium silicate on kaolinite particles in distilled water as well as in CaCl2 and MgCl2 solutions was investigated systematically through electrophoretic mobility and colloid-stability studies. The studies were based on controlled pH, which eliminated the dispersive effect of sodium silicate induced by increasingpulp pH, in order to simulate the conditions of iron-ore processing. With pH controlled at constant levels, sodium silicate dispersed kaolinite only when positively charged sites were present on kaolinite surfaces and the zeta potential of kaolinite was more negative than ~−30 mV. Over the pH range from 5 to 10.5, a significant dispersive effect of sodium silicate was only observed at pH 7. In process water, when Ca and Mgwere present, the strong coagulation of kaolinite particles caused by the hydrolyzable metal cations could not be dispersed effectively with sodium silicate.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Subscribe and save

Springer+ Basic
$34.99 /Month
  • Get 10 units per month
  • Download Article/Chapter or eBook
  • 1 Unit = 1 Article or 1 Chapter
  • Cancel anytime
Subscribe now

Buy Now

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  • Amorós, J.L., Beltrán, V., Sanz, V., and Jarque, J.C. (2010) Electrokinetic and rheological properties of highly concentrated kaolin dispersions: Influence of particle volume fraction and dispersant concentration. Applied Clay Science, 49, 33–43.

    Article  Google Scholar 

  • Andreola, F., Romagnoli, M., Castellini, E., Lusvardi, G., and Menabue, L. (2006) Role of the surface treatment in the deflocculation of kaolinite. Journal of the American Ceramic Society, 89, 1107–1109.

    Article  Google Scholar 

  • Andreola, F., Castellini, E., Lusvardi, G., Menabue, L., and Romagnoli, M. (2007) Release of ions from kaolinite dispersed in deflocculant solutions. Applied Clay Science, 36, 271–278.

    Article  Google Scholar 

  • Aveston, J. (1965) Hydrolysis of sodium silicate: ultracentrifugation in chloride solutions. Journal of Chemical Society, 1965, 4444–4448.

    Article  Google Scholar 

  • Bass, J.L. and Turner, G.L. (1997) Anion distributions in sodium silicate solutions. characterization by 29SI NMR and infrared spectroscopies and vapor phase osmometry. Journal of Physical Chemistry B, 101, 10638–10644.

    Article  Google Scholar 

  • Diz, H.M.M. and Rand, B. (1989) The variable nature of the isoelectric point of the edge surface of kaolinite. British Ceramic Transactions and Journal, 88, 162–166.

    Google Scholar 

  • Diz, H.M.M. and Rand, B. (1990) The mechanism of deflocculation of kaolinite by polyanions. British Ceramic Transactions and Journal, 89, 77–82.

    Google Scholar 

  • Flegmann, A.W., Goodwin, J.W., and Ottewill, R.H. (1969) Rheological studies on kaolinite suspensions. Proceedings of the British Ceramic Society, 13, 31–45.

    Google Scholar 

  • Gjaldbaek, J.K. (1925) Untersuchungen liber die Loslichkeit des magnesium hydroxyds. Zeitschrift für Anorganische und Allgemeine Chemie, 144, 269–288.

    Article  Google Scholar 

  • Harman, R.W. (1928) Aqueous solutions of sodium silicates, part VIII. General summary and theory of constitution. Sodium silicates as colloidal electrolytes. Journal of Physical Chemistry, 32, 44–60.

    Google Scholar 

  • Harris, R.K. and Newman, R.H. (1977) 29Si NMR studies of aqueous silicate solutions. Journal of the Chemical Society - Faraday Transactions, 73, 1204–1215.

    Article  Google Scholar 

  • Hast, N. (1956) A reaction between silica and some magnesium compounds at room temperature and at +37°C. Arkivför Kemi, 9, 343–360.

    Google Scholar 

  • Herrington, T.M., Clarke, A.Q., and Watts, J.C. (1992) The surface charge of kaolin. Colloids and Surfaces, 68, 161–169.

    Article  Google Scholar 

  • Ingri, N. (1959) Equilibrium studies of polyanions, IV. Silicate ions in NaCl medium. Acta Chemica Scandinavica, 13, 758–775.

    Article  Google Scholar 

  • Iwasaki, I., Smith, K.A., Lipp, R.J., and Sato, H. (1980) Effect of calcium and magnesium ions on selective desliming and cationic flotation of quartz from iron ore. Pp. 1057–1082 in: Fine Particles Processing (P. Somasundaran, editor). Vol. 2, American Institute of Mechanical Engineers, New York.

    Google Scholar 

  • James, R.O. and Healy, T.W. (1972a) Adsorption of hydrolyzable metal ions at the oxide-water interface, part III. Journal of Colloid and Interface Science, 40, 65–81.

    Article  Google Scholar 

  • James, R.O. and Healy, T.W. (1972b) Adsorption of hydrolyzable metal ions at the oxide-water interface, part I. Journal of Colloid and Interface Science, 40, 42–52.

    Article  Google Scholar 

  • James, R.O. and Healy, T.W. (1972c) Adsorption of hydrolyzable metal ions at the oxide-water interface, part II. Journal of Colloid and Interface Science, 40, 53–63.

    Article  Google Scholar 

  • Johnson, S.B., Russell, A.S., and Scales, P.J. (1998) Volume fraction effects in shear rheology and electroacoustic studies of concentrated alumina and kaolin suspensions. Colloids and Surfaces A, 141, 119–130.

    Article  Google Scholar 

  • Johnson, S.B., Franks, G.V., Scales, P.J., Boger, D.V., and Healy, T.W. (2000) Surface chemistry-rheology relationships in concentrated mineral suspensions. International Journal of Mineral Processing, 58, 267–304.

    Article  Google Scholar 

  • Lagerström, G. (1959) Equilibrium studies of polyanions — the silicate ions in NaClO4 medium. Acta Chemica Scandinavica, 13, 722–736.

    Article  Google Scholar 

  • Leja, J. (1982) Surface Chemistry of Froth Flotation. Plenum Press, New York.

    Google Scholar 

  • Ma, X. (2010) Role of hydrolyzable metal cations in starchkaolinite interactions. International Journal of Mineral Processing, 97, 100–103.

    Article  Google Scholar 

  • Ma, X. and Bruckard, W. (2010) Effect of pH and ionic strength on starch-koalinite interactions. International Journal of Mineral Processing, 94, 111–114.

    Article  Google Scholar 

  • Ma, X. (2011) Effect of a low-molecular-weight polyacrylic acid on the coagulation of kaolinite particles. International Journal of Mineral Processing, 99, 17–20.

    Article  Google Scholar 

  • Manfredini, T., Pellacani, G.C., and Pozzi, P. (1987) Sodium silicates as deflocculating agents for clays. Industrial Ceramics, 7, 85–87.

    Google Scholar 

  • Melton, I.E. and Rand, B. (1977) Particle interactions in aqueous kaolinite suspensions: II. Comparison of some laboratory and commercial kaolinite samples. Journal of Colloid and Interface Science, 60, 321–330.

    Article  Google Scholar 

  • Miller, J.D., Nalaskowski, J., Abdul, B., and Du, H. (2007) Surface characteristics of kaolinite and other selected two layer silicate minerals. Canadian Journal of Chemical Engineering, 85, 617–624.

    Article  Google Scholar 

  • Missanal, T. and Adell, A. (2000) On the applicability of DLVO theory to the prediction of clay colloids stability. Journal of Colloid and Interface Science, 230, 150–156.

    Article  Google Scholar 

  • Osswald, J. and Fehr, K.T. (2006) FTIR spectroscopic study on liquid silica solutions and nanoscale particle size determination. Journal of Materials Science, 41, 1335–1339.

    Article  Google Scholar 

  • Pushkarev, V.V. (1956) Adsorption of radioactive isotopes on ferric hydroxide. Russian Journal of Inorganic Chemistry, 1, 176–185.

    Google Scholar 

  • Rand, B. and Melton, I.E. (1975) Isoelectric point of the edge surface of kaolinite. Nature, 257, 214–216.

    Article  Google Scholar 

  • Rand, B., Diz, H.M.M., Li, J., and Inwang, I.B. (1988) Deflocculation of kaolinitic clay suspensions by sodium silicate. Science of Ceramics, 4, 231–236.

    Google Scholar 

  • Rao, F., Ramirez-Acosta, F.J., Sanchez-Leija, R.J., Song, S., and Lopez-Valdivieso, A. (2011) Stability of kaolinite dispersions in the presence of sodium and aluminum ions. Applied Clay Science, 51, 38–42.

    Article  Google Scholar 

  • Rossington, K.R., Senapati, U., and Carty, M. (1998) A critical evaluation of dispersants for clay-based systems. Ceramic Engineering and Science Proceedings, 19, 77–87.

    Google Scholar 

  • Sjöberg, S., Öhman, L.-O., and Ingri, N. (1985) Equilibrium and structural studies of silicon(IV) and aluminium(III) in aqueous solution. 11. Polysilicate formation in alkaline aqueous solution. A combined potentiometric and 29Si NMR study. Acta Chemica Scandinavica, 39, 93–107.

    Google Scholar 

  • Smoluchowski, M. (1903) Contribution à la théorie de l’endosmose électrique et de quelques phénomènes corrélatifs. Bulletin International de l’Academie des Sciences de Cracovie, 1, 182–199.

    Google Scholar 

  • Stumm, W., Huper, H. and Champlin, R.L. (1967) Formation of polysilicates as determined by coagulation effects. Environmental Science & Technology, 1, 221–227.

    Article  Google Scholar 

  • Svensson, I.L., Sjöberg, S., and Öhman, L. (1986) Polysilicate equilibria in concentrated sodium silicate solutions. Journal of Chemistry Society - Faraday Transaction, 82, 3635–3646.

    Article  Google Scholar 

  • Weldes, H.H. and Lange, R.R. (1969) Properties of soluble silicates. Industrial and Engineering Chemistry, 61, 29–44.

    Article  Google Scholar 

  • Williams, D.J.A. and Williams, K.P. (1978) Electrophoresis and zeta potential of kaolinite. Journal of Colloid and Interface Science, 65, 79–87.

    Article  Google Scholar 

  • Yang, X., Roonasi, P., and Holmgren, A. (2008) A study of sodium silicate in aqueous solution and sorbed by synthetic magnetite using in situ ATR-FTIR spectroscopy. Journal of Colloid and Interface Science, 328, 41–4.

    Article  Google Scholar 

  • Zaman, A.A., Tsuchiya, R., and Moudgil, B.M. (2002) Adsorption of a low-molecular-weight polyacrylic acid on silica, alumina, and kaolin. Journal of Colloid and Interface Science, 256, 73–78.

    Article  Google Scholar 

Download references

Author information

Authors and Affiliations

  1. CSIRO Process Science and Engineering, Box 312, 3168, Clayton, Victoria, Australia

    Mark Ma

Authors
  1. Mark Ma
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Mark Ma.

Rights and permissions

Reprints and permissions

About this article

Cite this article

Ma, M. The Dispersive Effect of Sodium Silicate on Kaolinite Particles in Process Water: Implications for Iron-Ore Processing. Clays Clay Miner. 59, 233–239 (2011). https://doi.org/10.1346/CCMN.2011.0590302

Download citation

  • Received:

  • Revised:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1346/CCMN.2011.0590302

Key Words

Search

Navigation