Abstract
AlGaN-based vertical-cavity surface-emitting lasers (VCSELs) have garnered recent interest due to their superior material properties and device benefits. Nevertheless, AlGaN-based VCSELs are extremely difficult to realize due to numerous technical limitations associated with both material epitaxial growth and chip fabrication. This study fabricated a high-quality AlGaN multiple quantum wells (MQWs) structure using epitaxial lateral overgrowth and analyzed it using X-ray diffraction (XRD) and photoluminescence (PL) measurements. With an edge dislocation density (DD) of 109 cm−2, XRD measurements reveal that the AlN template is nearly fully relaxed. The subsequent AlGaN/AlN superlattice (SL) layer is introduced to decrease the edge DD, and the edge DD in the MQWs is ∼108 cm−2. According to PL measurements, the internal quantum efficiency of the MQWs is as high as 62%, and radiative recombination dominated the emission of the MQWs at room temperature. Using these epitaxial wafers, ultraviolet radiation C (UVC) VCSELs were fabricated using various techniques, including laser lift-off (LLO) and chemical mechanical polishing (CMP). The crystallinity of the MQWs was unaffected by sapphire substrate removal using LLO. After removing the sapphire substrate using LLO and CMP, UVC surface-stimulated emission was observed in MQWs. AlGaN-based UVC VCSELs with lasing wavelengths of 275.91, 276.28, and 277.64 nm have been fabricated. The minimum threshold for UVC VCSELs is 0.79 MW cm−2, which is a record low.
摘要
AlGaN基垂直腔面发射激光器(VCSEL)因其优越的材料性质和 器件优点吸引了很多关注. 然而, 由于材料外延生长和器件制备工艺的 局限, AlGaN基VCSEL制备很困难. 本工作通过侧向外延生长技术制备 了高质量的AlGaN多量子阱(MQWs)结构的外延片, 并通过X射线衍射 (XRD)和光致发光(PL)实验对外延片进行了分析. XRD测量显示, 外延 片中的AlN模板层几乎是弛豫的, 刃位错密度为109 cm−2. 随后, 生长的 AlGaN/AlN超晶格(SL)层被用来减少刃位错密度, 使得量子阱中的位错 密度为108 cm−2. 根据PL测试结果, MQWs的内量子效率(IQE)为62%, 且在室温下的发光以辐射复合为主. 通过激光剥离(LLO)和化学机械抛 光(CMP)技术, 将这些外延片制备成UVC VCSEL. 经过这些工艺, MQWs的晶体质量没有受到影响, 还在抛光之后的表面观察到了UVC 波段的受激辐射. 这些AlGaN基UVC VCSEL在275.91, 276.28和 277.64 nm实现了激射, 最小激射阈值为0.79 MW cm−2.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Vurgaftman I, Meyer JR. Band parameters for nitrogen-containing semiconductors. J Appl Phys, 2003, 94: 3675–3696
Zheng Z, Mei Y, Long H, et al. AlGaN-based deep ultraviolet vertical-cavity surface-emitting laser. IEEE Electron Device Lett, 2021, 42: 375–378
Mei Y, Weng GE, Zhang BP, et al. Quantum dot vertical-cavity surface-emitting lasers covering the’ green gap’. Light Sci Appl, 2016, 6: e16199
Lu TC, Kao CC, Kuo HC, et al. CW lasing of current injection blue GaN-based vertical cavity surface emitting laser. Appl Phys Lett, 2008, 92: 141102
Kuramoto M, Kobayashi S, Akagi T, et al. High-output-power and high-temperature operation of blue GaN-based vertical-cavity surface-emitting laser. Appl Phys Express, 2018, 11: 112101
Kuramoto M, Kobayashi S, Akagi T, et al. Watt-class blue vertical-cavity surface-emitting laser arrays. Appl Phys Express, 2019, 12: 091004
Hjort F, Enslin J, Cobet M, et al. A 310 nm optically pumped AlGaN vertical-cavity surface-emitting laser. ACS Photonics, 2021, 8: 135–141
Li D, Jiang K, Sun X, et al. AlGaN photonics: Recent advances in materials and ultraviolet devices. Adv Opt Photon, 2018, 10: 43–110
Ban K, Yamamoto J, Takeda K, et al. Internal quantum efficiency of whole-composition-range AlGaN multiquantum wells. Appl Phys Express, 2011, 4: 052101
Jain R, Sun W, Yang J, et al. Migration enhanced lateral epitaxial overgrowth of AlN and AlGaN for high reliability deep ultraviolet light emitting diodes. Appl Phys Lett, 2008, 93: 051113
Wang HM, Zhang JP, Chen CQ, et al. AlN/AlGaN superlattices as dislocation filter for low-threading-dislocation thick AlGaN layers on sapphire. Appl Phys Lett, 2002, 81: 604–606
Zhang JP, Wang HM, Gaevski ME, et al. Crack-free thick AlGaN grown on sapphire using AlN/AlGaN superlattices for strain management. Appl Phys Lett, 2002, 80: 3542–3544
Sun WH, Zhang JP, Yang JW, et al. Fine structure of AlN/AlGaN superlattice grown by pulsed atomic-layer epitaxy for dislocation filtering. Appl Phys Lett, 2005, 87: 211915
Zheng Z, Li Y, Paul O, et al. Loss analysis in nitride deep ultraviolet planar cavity. J Nanophoton, 2018, 12: 1
Zheng Z, Long H, Matta S, et al. Photoassisted chemical smoothing of AlGaN surface after laser lift-off. J Vac Sci Tech B, 2020, 38: 042207
Moram MA, Vickers ME. X-ray diffraction of III-nitrides. Rep Prog Phys, 2009, 72: 036502
Mártil I, Redondo E, Ojeda A. Influence of defects on the electrical and optical characteristics of blue light-emitting diodes based on III–V nitrides. J Appl Phys, 1997, 81: 2442–2444
Wang H, Ji Z, Qu S, et al. Influence of excitation power and temperature on photoluminescence in InGaN/GaN multiple quantum wells. Opt Express, 2012, 20: 3932–3940
Xu RB, Xu H, Mei Y, et al. Emission dynamics of GaN-based blue resonant-cavity light-emitting diodes. J Lumin, 2019, 216: 116717
Yasan A, McClintock R, Mayes K, et al. Photoluminescence study of AlGaN-based 280 nm ultraviolet light-emitting diodes. Appl Phys Lett, 2003, 83: 4083–4085
Wang TY, Tasi CT, Lin CF, et al. 85% internal quantum efficiency of 280-nm AlGaN multiple quantum wells by defect engineering. Sci Rep, 2017, 7: 14422
Banal RG, Funato M, Kawakami Y. Extremely high internal quantum efficiencies from AlGaN/AlN quantum wells emitting in the deep ultraviolet spectral region. Appl Phys Lett, 2011, 99: 011902
Bhattacharyya A, Moustakas TD, Zhou L, et al. Deep ultraviolet emitting AlGaN quantum wells with high internal quantum efficiency. Appl Phys Lett, 2009, 94: 181907
Shatalov M, Sun W, Lunev A, et al. AlGaN deep-ultraviolet light-emitting diodes with external quantum efficiency above 10%. Appl Phys Express, 2012, 5: 082101
Dong P, Yan J, Zhang Y, et al. AlGaN-based deep ultraviolet light-emitting diodes grown on nano-patterned sapphire substrates with significant improvement in internal quantum efficiency. J Cryst Growth, 2014, 395: 9–13
Zeng J, Li W, Yan J, et al. Temperature-dependent emission shift and carrier dynamics in deep ultraviolet AlGaN/AlGaN quantum wells. Phys Status Solidi RRL, 2013, 7: 297–300
Rodríguez-de Marcos LV, Larruquert JI, Méndez JA, et al. Self-consistent optical constants of SiO2 and Ta2O5 films. Opt Mater Express, 2016, 6: 3622–3637
Hakoe F, Tokoro H, Ohkoshi S. Dielectric and optical constants of X-Ti3O5 film measured by spectroscopic ellipsometry. Mater Lett, 2017, 188: 8–12
Kruchinin VN, Perevalov TV, Atuchin VV, et al. Optical properties of TiO2 films deposited by reactive electron beam sputtering. J Elec Materi, 2017, 46: 6089–6095
Denton AR, Ashcroft NW. Vegard’s law. Phys Rev A, 1991, 43: 3161–3164
Romano LT, Van de Walle CG, Ager III JW, et al. Effect of Si doping on strain, cracking, and microstructure in GaN thin films grown by metalorganic chemical vapor deposition. J Appl Phys, 2000, 87: 7745–7752
Ambacher O, Majewski J, Miskys C, et al. Pyroelectric properties of Al (In)GaN/GaN hetero- and quantum well structures. J Phys-Condens Matter, 2002, 14: 3399–3434
Dong L, Mantese JV, Avrutin V, et al. Strain induced variations in band offsets and built-in electric fields in InGaN/GaN multiple quantum wells. J Appl Phys, 2013, 114: 043715
Li J, Li S, Kang J. Quantized level transitions and modification in InGaN/GaN multiple quantum wells. Appl Phys Lett, 2008, 92: 101929
Dong L, Yadav SK, Ramprasad R, et al. Band gap tuning in GaN through equibiaxial in-plane strains. Appl Phys Lett, 2010, 96: 202106
Kueller V, Knauer A, Brunner F, et al. Growth of AlGaN and AlN on patterned AlN/sapphire templates. J Cryst Growth, 2011, 315: 200–203
Ni R, Chen X, Yan J, et al. Reducing stimulated emission threshold power density of AlGaN/AlN multiple quantum wells by nano-trench-patterned AlN template. J Alloys Compd, 2019, 777: 344–349
Li X, Xie H, Ponce FA, et al. Onset of surface stimulated emission at 260 nm from AlGaN multiple quantum wells. Appl Phys Lett, 2015, 107: 241109
Redwing JM, Loeber DAS, Anderson NG, et al. An optically pumped GaN-AlGaN vertical cavity surface emitting laser. Appl Phys Lett, 1996, 69: 1–3
Cosendey G, Castiglia A, Rossbach G, et al. Blue monolithic AlInN-based vertical cavity surface emitting laser diode on free-standing GaN substrate. Appl Phys Lett, 2012, 101: 151113
Feltin E, Christmann G, Dorsaz J, et al. Blue lasing at room temperature in an optically pumped lattice-matched AlInN/GaN vcsel structure. Electron Lett, 2007, 43: 924–926
Chyi J-I, Fujioka H, Morkoç H, et al. Development for ultraviolet vertical cavity surface emitting lasers. In: Proceedings Volume 9748, Gallium Nitride Materials and Devices XI. San Francisco, 2016
Liu YS, Saniul Haq AFM, Mehta K, et al. Optically pumped vertical-cavity surface-emitting laser at 374.9 nm with an electrically conducting n-type distributed Bragg reflector. Appl Phys Express, 2016, 9: 111002
Park YJ, Detchprohm T, Mehta K, et al. Optically pumped vertical-cavity surface-emitting lasers at 375 nm with air-gap/Al0.05Ga0.95N distributed Bragg reflectors In: Proceedings of SPIE, Vertical-Cavity Surface-Emitting Lasers XXIII San Francisco, 2019
Shen C, Leonard J, Young E, et al. GHz modulation bandwidth from single-longitudinal mode violet-blue VCSEL using nonpolar InGaN/GaN QWs. In: 2016 Conference on Lasers and Electro-Optics. San Jose, 2016
Ikeyama K, Kozuka Y, Matsui K, et al. Room-temperature continuous-wave operation of GaN-based vertical-cavity surface-emitting lasers with n-type conducting AlInN/GaN distributed Bragg reflectors. Appl Phys Express, 2016, 9: 102101
Furuta T, Matsui K, Kozuka Y, et al. 1.7-mW nitride-based vertical-cavity surface-emitting lasers using AlInN/GaN bottom DBRs. In: 2016 International Semiconductor Laser Conference (ISLC). Kobe, 2016
Matsui K, Kozuka Y, Ikeyama K, et al. Gan-based vertical cavity surface emitting lasers with periodic gain structures. Jpn J Appl Phys, 2016, 55: 05FJ08
Furuta T, Matsui K, Horikawa K, et al. Room-temperature CW operation of a nitride-based vertical-cavity surface-emitting laser using thick GaInN quantum wells. Jpn J Appl Phys, 2016, 55: 05FJ11
Chang TC, Kuo SY, Lian JT, et al. High-temperature operation of GaN-based vertical-cavity surface-emitting lasers. Appl Phys Express, 2017, 10: 112101
Lu TC, Chen SW, Wu TT, et al. Continuous wave operation of current injected GaN vertical cavity surface emitting lasers at room temperature. Appl Phys Lett, 2010, 97: 071114
Faraon A, Zhou W, Koyama F, et al. Gan vertical-cavity surface-emitting laser with a high-contrast grating reflector. In: Proceedings Volume 10542, High Contrast Metastructures VII. San Francisco, 2018
Higuchi Y, Omae K, Matsumura H, et al. Room-temperature CW lasing of a GaN-based vertical-cavity surface-emitting laser by current injection. Appl Phys Express, 2008, 1: 121102
Omae K, Higuchi Y, Nakagawa K, et al. Improvement in lasing characteristics of GaN-based vertical-cavity surface-emitting lasers fabricated using a GaN substrate. Appl Phys Express, 2009, 2: 052101
Terao K, Nagai H, Morita D, et al. Blue and green GaN-based vertical-cavity surface-emitting lasers with AlInN/GaN DBR. In: Proceedings of SPIE 11686, Gallium Nitride Materials and Devices XVI. Online only, 2021
Kasahara D, Morita D, Kosugi T, et al. Demonstration of blue and green GaN-based vertical-cavity surface-emitting lasers by current injection at room temperature. Appl Phys Express, 2011, 4: 072103
Chen R, Sun HD, Wang T, et al. Optically pumped ultraviolet lasing from nitride nanopillars at room temperature. Appl Phys Lett, 2010, 96: 241101
Yeh PS, Chang CC, Chen YT, et al. GaN-based vertical-cavity surface emitting lasers with sub-milliamp threshold and small divergence angle. Appl Phys Lett, 2016, 109: 241103
Park SH, Kim J, Jeon H, et al. Room-temperature GaN vertical-cavity surface-emitting laser operation in an extended cavity scheme. Appl Phys Lett, 2003, 83: 2121–2123
Izumi S, Fuutagawa N, Hamaguchi T, et al. Room-temperature continuous-wave operation of GaN-based vertical-cavity surface-emitting lasers fabricated using epitaxial lateral overgrowth. Appl Phys Express, 2015, 8: 062702
Hamaguchi T, Fuutagawa N, Izumi S, et al. Milliwatt-class GaN-based blue vertical-cavity surface-emitting lasers fabricated by epitaxial lateral overgrowth. Phys Status Solidi A, 2016, 213: 1170–1176
Hamaguchi T, Hoshina Y, Hayashi K, et al. Room-temperature continuous-wave operation of green vertical-cavity surface-emitting lasers with a curved mirror fabricated on {20–21} semi-polar GaN. Appl Phys Express, 2020, 13: 041002
Kuramoto M, Kobayashi S, Akagi T, et al. Enhancement of slope efficiency and output power in GaN-based vertical-cavity surface-emitting lasers with a SiO2-buried lateral index guide. Appl Phys Lett, 2018, 112: 111104
Someya T, Werner R, Forchel A, et al. Room temperature lasing at blue wavelengths in gallium nitride microcavities. Science, 1999, 285: 1905–1906
Leonard JT, Cohen DA, Yonkee BP, et al. Nonpolar III-nitride vertical-cavity surface-emitting lasers incorporating an ion implanted aperture. Appl Phys Lett, 2015, 107: 011102
Holder CO, Leonard JT, Farrell RM, et al. Nonpolar III-nitride vertical-cavity surface emitting lasers with a polarization ratio of 100% fabricated using photoelectrochemical etching. Appl Phys Lett, 2014, 105: 031111
Leonard JT, Young EC, Yonkee BP, et al. Demonstration of a III-nitride vertical-cavity surface-emitting laser with a III-nitride tunnel junction intracavity contact. Appl Phys Lett, 2015, 107: 091105
Leonard JT, Yonkee BP, Cohen DA, et al. Nonpolar III-nitride vertical-cavity surface-emitting laser with a photoelectrochemically etched airgap aperture. Appl Phys Lett, 2016, 108: 031111
Holder C, Speck JS, DenBaars SP, et al. Demonstration of nonpolar GaN-based vertical-cavity surface-emitting lasers. Appl Phys Express, 2012, 5: 092104
Mei Y, Yang TR, Ou W, et al. Low-threshold wavelength-tunable ultraviolet vertical-cavity surface-emitting lasers from 376 to 409 nm. Fundamental Res, 2021, 1: 684–690
Liu WJ, Hu XL, Ying LY, et al. Room temperature continuous wave lasing of electrically injected GaN-based vertical cavity surface emitting lasers. Appl Phys Lett, 2014, 104: 251116
Weng G, Mei Y, Liu J, et al. Low threshold continuous-wave lasing of yellow-green InGaN-QD vertical-cavity surface-emitting lasers. Opt Express, 2016, 24: 15546–15553
Zhang JY, Cai LE, Zhang BP, et al. Blue-violet lasing of optically pumped GaN-based vertical cavity surface-emitting laser with dielectric distributed Bragg reflectors. J Lightwave Technol, 2009, 27: 55–59
Acknowledgements
This work was supported by the National Key Research and Development Program of China (2017YFE0131500) and the National Natural Science Foundation of China (62104204 and U21A20493).
Author information
Authors and Affiliations
Contributions
Zheng Z fabricated the devices, measured the devices and epilayers, and wrote the manuscript. Hoo J grew the epitaxial structures and helped to measure the epilayers. Zhang B proposed the outline of the manuscript and revised the manuscript. Guo S helped to revise the manuscript. All the authors contributed to the discussion of the work.
Corresponding authors
Additional information
Conflict of interest
The authors declare that they have no conflict of interest.
Supplementary information
Experimental details and supporting data are available in the online version of the paper.
Zhongming Zheng is a postdoctoral researcher at Xiamen University. He earned his PhD degree from Xiamen University in 2021. His research focuses on III-nitride materials and devices.
Shiping Guo received his PhD degree in semiconductor physics and device physics from Shanghai Institute of Technical Physics, Chinese Academy of Sciences, in 1994. Currently, he serves as Group Vice President and General Manager of MOCVD Product Division at AMEC. His research interests include MOCVD hardware development, project management and epitaxial growth process development of III-N based materials and devices. Before AMEC, he worked at IQR RF LLC and EMCORE Corp. from 2001 to 2012 and at several research groups at the City University of New York, Tohoku University and Shanghai Institute of Technical Physics.
Baoping Zhang was born in Hebei, China, in 1963. He received the BS degree in physics from Lanzhou University, Lanzhou, China, in 1983, the ME degree in microelectronics from Hebei Semiconductor Research Institute, Shijiazhuang, China, and the Dr. Eng. degree in applied physics from the University of Tokyo, Tokyo, Japan, in 1994. He is currently a distinguished professor at the School of Electronic Science and Engineering, Xiamen University, China, where he is engaged in wide-gap semiconductor materials and devices, especially GaN-based light-emitting diodes (LEDs) and VCSELs.
Electronic Supplementary Material
Rights and permissions
About this article
Cite this article
Zheng, Z., Wang, Y., Hoo, J. et al. High-quality AlGaN epitaxial structures and realization of UVC vertical-cavity surface-emitting lasers. Sci. China Mater. 66, 1978–1988 (2023). https://doi.org/10.1007/s40843-022-2310-5
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s40843-022-2310-5