Abstract
Undoped and copper (Cu) doped zinc oxide (Zn1−xCuxO, where x = 0-0.065) nano crystal thin films have been deposited on glass substrate via RF/DC reactive co-sputtering technique. The aim of this work is to investigate the crystal structure of ZnO and Cu doped ZnO thin films and also study the effect of Cu doping on optical band gap of ZnO thin films. The identification and confirmation of the crystallinity, film thickness and surface morphology of the nano range thin films are confirmed by using X-ray diffractometer (XRD), scanning electron microscope and atomic force microscope. The XRD peak at a diffractive angle of 34.44°and Miller indices at (002) confirms the ZnO thin films. Crystallite size of undoped ZnO thin films is 27 nm and decreases from 27 nm to 22 nm with increasing the atomic fraction of Cu (xCu) in the ZnO thin films from 0 to 6.5% respectively, which is calculated from XRD (002) peaks. The different bonding information of all deposited films was investigated by Fourier transform infrared spectrometer in the range of wave number between 400 cm−1 to 4000 cm−1. Optical band gap energy of all deposited thin films was analyzed by ultraviolet visible spectrophotometer, which varies from 3.35 eV to 3.19 eV with the increase of xCu from 0 to 6.5% respectively. Urbach energy of the deposited thin films increases from 115 meV to 228 meV with the increase of xCu from 0to6.5% respectively.
摘要
采用射频/直流反应溅射技术在玻璃衬底上制备了未掺杂和掺铜氧化锌(Zn1−xCuxO,其中x = 0∼0.065)的纳米晶体薄膜。本工作旨在研究ZnO和Cu掺杂ZnO薄膜的晶体结构,并研究Cu掺杂 对ZnO薄膜光学带隙的影响。利用X射线衍射仪(XRD)、扫描电子显微镜和原子力显微镜对纳米 级薄膜的结晶度、薄膜厚度和表面形貌进行了鉴定和确认。在衍射角34.44°密勒指数(002)的XRD 峰值证实了ZnO薄膜的存在。由XRD(002)峰计算得出,当ZnO薄膜中Cu的原子分数(xCu)从 0增加到6.5%时,未掺杂ZnO薄膜的晶粒尺寸从27 nm减小到22 nm。通过傅里叶变换红外光谱仪 研究了在400∼4000 cm−1波数范围内所有沉积薄膜的不同键合信息。通过紫外可见分光光度计分析了 所有沉积薄膜的光学带隙能:随着xCu从0增加到6.5%,其变化范围为3.35 eV到3.19 eV。随着xCu 从0增加到6.5%,沉积薄膜的Urbach能量从115 meV增加到228 meV°
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
SAJJAD M, ULLAH I, KHAN M I, et al. Structural and optical properties of pure and copper doped zinc oxide nanoparticles [J]. Results in Physics, 2018, 9: 1301–1309.
IMRAN M, AHMAD R, AFZAL N, et al. Copper ion implantation effects in ZnO film deposited on flexible polymer by DC magnetron sputtering [J]. Vacuum, 2019, 165: 72–80.
YUSOF A S, HASSAN Z, ZAINAL N. Fabrication and characterization of copper doped zinc oxide by using co-sputtering technique [J]. Materials Research Bulletin, 2018, 97: 314–318.
MAITI U N, GHOSH P K, AHMED S F, et al. Structural, optical and photoelectron spectroscopic studies of nano/micro ZnO: Cd rods synthesized via sol-gel route [J]. Journal of Sol-Gel Science and Technology, 2007, 41(1): 87–92.
MUKHERJEE N, AHMED S F, CHATTOPADHYAY K K, et al. Role of solute and solvent on the deposition of ZnO thin films [J]. Electrochimica Acta, 2009, 54(16): 4015–4024.
CAGLAR Y, CAGLAR M, ILICAN S, et al. Effect of channel thickness on the field effect mobility of ZnO-TFT fabricated by sol gel process [J]. Journal of Alloys and Compounds, 2015, 621: 189–193.
AL-HARDAN N H, ABDULLAH M J, AHMAD H, et al. Investigation on UV photodetector behavior of RF-sputtered ZnO by impedance spectroscopy [J]. SolidState Electronics, 2011, 55(1): 59–63.
KHOSRAVI P, KARIMZADEH F, SALIMIJAZI H R, et al. Structural, optical and electrical properties of co-sputtered p-type ZnO: Cu thin-films [J]. Ceramics International, 2019, 45(6): 7472–7479.
KIM H, PIQUE A, HORWITZ J S, et al. Effect ofalu-minum doping on zinc oxide thin films grown by pulsed laser deposition for organic light-emitting devices [J]. Thin Solid Films, 2000, 377/378: 798–802.
ZARGAR R A, KHAN S U D, KHAN M S, et al. Synthesis and characterization of screen printed Zn0.97Cu0.03 O thick film for semiconductor device applications [J]. Physics Research International, 2014, 2014: 464809.
ISHERWOOD P J M. Copper zinc oxide: Investigation into a p-type mixed metal oxide system [J]. Vacuum, 2017, 139: 173–177.
PANDEY B, GHOSH S, SRIVASTAVA P, et al. Synthesis of nanodimensional ZnO and Ni-doped ZnO thin films by atom beam sputtering and study of their physical properties [J]. Physica E: Low-Dimensional Systems and Nanostructures, 2009, 41(7): 1164–1168.
MUTHUKUMARAN S, GOPALAKRISHNAN R. Structural, FTIR and photoluminescence studies of Cu doped ZnO nanopowders by co-precipitation method [J]. Optical Materials, 2012, 34(11): 1946–1953.
GHOMRANI F Z, AISSAT A, ARBOUZ H, et al. Al concentration effect on ZnO based thin films: For photovoltaic applications [J]. Energy Procedia, 2015, 74: 491–498.
SREEDHAR A, KWON J H, YI J, et al. Enhanced photoluminescence properties of Cu-doped ZnO thin films deposited by simultaneous RF and DC magnetron sputtering [J]. Materials Science in Semiconductor Processing, 2016, 49: 8–14.
YAO C B, WEN X, LI Q H, et al. The saturable absorption and reverse saturable absorption properties of Cu doped zinc oxide thin films [J]. Chemical Physics Letters, 2017, 671: 113–117.
AYDOGU S, SENDIL O, COBAN M. The optical and structural properties of ZnO thin films deposited by the spray pyrolysis technique [J]. Chinese Journal of Physics, 2012, 50(1): 89–100.
GHOSH A, GHULE A, SHARMA R. Effect of Cu doping on LPG sensing properties of soft chemically grown nano-structured ZnO thin film [J]. Journal of Physics: Conference Series, 2012, 365: 012022.
SHUKLA R K, SRIVASTAVA A, KUMAR N, et al. Optical and sensing properties of Cu doped ZnO nanocrystalline thin films [J]. Journal of Nanotechnology, 2015, 2015: 172864.
MAITI U N, AHMED S F, MITRA M K, et al. Novel low temperature synthesis of ZnO nanostructures and its efficient field emission property [J]. Materials Research Bulletin, 2009, 44(1): 134–139.
AZUMA M, ICHIMURA M. Fabrication of ZnO thin films by the photochemical deposition method [J]. Materials Research Bulletin, 2008, 43(12): 3537–3542.
CHICHVARINA O, HERNG T S, PHUAH K C, et al. Stable zinc-blende ZnO thin films: Formation and physical properties [J]. Journal of Materials Science, 2015, 50(1): 28–33.
KHAN M, AHMED S F. Effect of distance between cathode and substrate on structural and optical properties of zinc oxide thin films deposited by RF sputtering technique [J]. Materials Physics and Mechanics, 2021, 47: 872–884.
BABU K S, REDDY A R, SUJATHA C, et al. Synthesis and optical characterization of porous ZnO [J]. Journal of Advanced Ceramics, 2013, 2(3): 260–265.
JOHAN M R, SUAN M S M, HAWARI N L, et al. Annealing effects on the properties of copper oxide thin films prepared by chemical deposition [J]. International Journal of Electrochemical Science, 2011, 6: 6094–6104.
SERIN N, SERIN T, HORZUM S, et al. Annealing effects on the properties of copper oxide thin films prepared by chemical deposition [J]. Semiconductor Science and Technology, 2005, 20(5): 398–401.
FATTAH Z A. Synthesis and characterization of nickel doped zinc oxide nanoparticles by sol-gel method [J]. International Journal of Engineering Sciences and Research Technology, 2016, 5: 418–429.
KHAN Z R, KHAN M S, ZULFEQUAR M, et al. Optical and structural properties of ZnO thin films fabricated by sol-gel method [J]. Materials Sciences and Applications, 2011, 2(5): 340–345.
HAO Y M, LOU S Y, ZHOU S M, et al. Structural, optical, and magnetic studies of manganese-doped zinc oxide hierarchical microspheres by self-assembly of nanoparticles [J]. Nanoscale Research Letters, 2012, 7(1): 100.
KAYANI Z N, IQBAL M, RIAZ S, et al. Fabrication and properties of zinc oxide thin film prepared by Solgel dip coating method [J]. Materials Science-Poland, 2015, 33(3): 515–520.
SHUKLA R K, KUMAR N, SRIVASTAVA A, et al. Optical and sensing properties of Al doped ZnO nanocrystalline thin films prepared by spray pyrolysis [J]. Materials Today: Proceedings, 2018, 5(3): 9102–9107.
KHAN M, ALAM M S, SAHA B, et al. Synthesis and characterization of cadmium sulfide (CdS) thin films by cyclic voltammetry technique [J]. Materials Today: Proceedings, 2021, 47: 2351–2357.
CHUNG S M, SHIN J H, LEE J M, et al. Structural and optical properties of Cu doped ZnO thin films by co-sputtering [J]. Journal of Nanoscience and Nan-otechnology, 2011, 11(1): 782–786.
AHMED S F, KHAN S, GHOSH P K, et al. Effect of Al doping on the conductivity type inversion and electro-optical properties of SnO2 thin films synthesized by sol-gel technique [J]. Journal of Sol-Gel Science and Technology, 2006, 39(3): 241–247.
FERHAT M, ZAOUI A, AHUJA R. Magnetism and band gap narrowing in Cu-doped ZnO [J]. Applied Physics Letters, 2009, 94(14): 142502.
MURSAL, IRHAMNI, BUKHARI, et al. Structural and optical properties of zinc oxide (ZnO) based thin films deposited by Sol-gel spin coating method [J]. Journal of Physics: Conference Series, 2018, 1116: 032020.
RAI R C. Analysis of the Urbach tails in absorption spectra of undoped ZnO thin films [J]. Journal of Applied Physics, 2013, 113(15): 153508.
ISLAM M A, HOSSAIN M S, ALIYU M M, et al. Comparison of structural and optical properties of CdS thin films grown by CSVT, CBD and sputtering techniques [J]. Energy Procedia, 2013, 33: 203–213.
AHMED S F, BANERJEE D, CHATTOPADHYAYK K. The influence of fluorine doping on the optical properties of diamond-like carbon thin films [J]. Vacuum, 2010, 84(6): 837–842.
VETTUMPERUMAL R, KALYANARAMAN S, SANTOSHKUMAR B, et al. Estimation of electron-phonon coupling and Urbach energy in group-I elements doped ZnO nanoparticles and thin films by sol-gel method [J]. Materials Research Bulletin, 2016, 77: 101–110.
Author information
Authors and Affiliations
Corresponding author
Additional information
Foundation item
the Maulana Azad National Fellowship (MANF) Scheme of University Grants Commission, New Delhi, India
Rights and permissions
About this article
Cite this article
Khan, M., Alam, M.S. & Ahmed, S.F. Synthesis and Characterization of Copper Doped Zinc Oxide Thin Films Deposited by RF/DC Sputtering Technique. J. Shanghai Jiaotong Univ. (Sci.) 28, 172–179 (2023). https://doi.org/10.1007/s12204-022-2462-1
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12204-022-2462-1
Key words
- Cu-ZnO thin films
- RF/DC sputtering technique
- X-ray diffraction
- atomic force microscope
- optical property
- Urbach energy