Abstract
We successfully prepared activated carbon derived from polyethylene terephthalate (PET) via carbonization and subsequent activation under various conditions and applied it as active material for supercapacitors. In the activation, we used CO2 for physical activation or KOH for chemical activation and varied the activation temperature from 600 °C to 1,000 °C. We found that CO2 activation is unsuitable because of insufficient pore formation or low activation yield. Interestingly, PET-derived activated carbon obtained using KOH (PETK) at 700 °C–900 °C exhibited higher specific surface areas than YP50f, which is a commercial activated carbon. Furthermore, some PETKs even displayed a dramatic increase in crystallinity. In particular, the PET-derived activated carbon prepared at 900 °C with KOH (PETK900) had the highest retention rate at a high charge-discharge rate and better durability after 2500 cycles than YP50f. Furthermore, employing the same process that we used with the PET chips, we successfully converted waste PET bottles into activated carbon materials. Waste PET-derived activated carbons exhibited good electrochemical performance as active material for supercapacitors. We thus found chemical activation with KOH to be an appropriate method for manufacturing PET-derived activated carbon and PETKs derived both from PET chips and waste PET have considerable potential for commercial use as active materials for supercapacitors.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
E. Frackowiak, Q. Abbas and F. Béguin, J. Energy Chem., 22, 226 (2013).
A. González, E. Goikolea, J. A. Barrena and R. Mysyk, Renew. Sust. Energy Rev., 58, 1189 (2016).
L. Zhang, X. Hu, Z. Wang, F. Sun and D. G. Dorrell, Renew. Sust. Energy Rev., 81, 1868 (2018).
G. Wang, L. Zhang and J. Zhang, Chem. Soc. Rev., 41, 797 (2012).
T. Sato, S. Marukane, T. Morinaga, T. Kamijo, H. Arafune and Y. Tsujii, J. Power Sources, 295, 108 (2015).
G. G. Prasad, N. Shetty, S. Thakur, Rakshitha and K. B. Bommegowda, Mater. Sci. Eng., 561, 012105 (2019).
M. Ciszewski, A. Koszorek, T. Radko, P. Szatkowski and D. Janas, J. Electron. Mater., 48, 717 (2019).
Z. Yu, L. Tetard, L. Zhai and J. Thomas, Energy Environ. Sci., 8, 702 (2015).
E. Frackowiak and F. Béguin, Carbon, 39, 937 (2001).
P. Simon and Y. Gogotsi, Nat. Mater., 7, 845 (2008).
T. V Pham, J.-G. Kim, J. Y. Jung, J. H. Kim, H. Cho, T. H. Seo, H. Lee, N. D. Kim and M. J. Kim, Adv. Funct. Mater., 29, 1905511 (2019).
D. Gastol, J. Walkowiak, K. Fic and E. Frackowiak, J. Power Sources, 326, 587 (2016).
N. Jäckel, D. Weingarth, M. Zeiger, M. Aslan, I. Grobelsek and V. Presser, J. Power Sources, 272, 1122 (2014).
Z. Zhu, S. Tang, J. Yuan, X. Qin, Y. Deng, R. Qu and G. M. Haarberg, Int. J. Eletrochem. Sci., 11, 8270 (2016).
M. Aslan, D. Weingarth, N. Jäckel, J. S. Atchison, I. Grobelsek and V. Presser, J. Power Sources, 266, 374 (2016).
S. Ajit, S. Palaniappan and S. Gopukumar, Synth. Met., 180, 43 (2013).
C. Bauer, A. Bilican, S. Braxmeier, G. Reichenauer and A. Krueger, Carbon, 197, 555 (2022).
G. Yang, T. Takei, Y. Zhu, E. Iranmanesh, B. Liu, Z. Li, J. Wang, P. Hiralal, G. A. J. Amaratunga, O. Fontaine and H. Zhou, Electrochim. Acta, 397, 139242 (2021).
N. Jäckel, D. Weingarth, A. Schreiber, B. Krüner, M. Zeiger, A. Tolosa, M. Aslan and V. Presser, Electrochim. Acta, 191, 284 (2016).
Y. Hamano, S. Tsujimura, O. Shirai and K. Kano, Mater. Lett., 128, 191 (2014).
S. J. Taylor, M. D. Haw, J. Sefcilk and A. J. Fletcher, Langmuir, 30, 10231 (2014).
F. N. Ajjan, M. Vagin, T. Rębiś, L. E. Aguirre, L. Ouyang and O. Inganäs, Adv. Sustainable Syst., 1, 1700054 (2017).
Z. Liu, S. Liu, R. Dong, S. Yang, H. Lu, A. Narita, X. Feng and K. Müllen, Small, 13, 1603388 (2017).
P. Ratajczak, M. E. Suss, F. Kaasik and F. Béguin, Energy Storage Mater., 16, 126 (2019).
J. Choi, I. Yang, S.-S. Kim, S. Y. Cho and S. Lee, Macromol. Rapid Commun., 43, 2100467 (2021).
I. Yang, S.-G. Kim, S. H. Kwon, M.-S. Kim and J. C. Jung, Electrochim. Acta, 223, 21 (2017).
J.-A. Kim, I.-S. Park, J.-H. Seo and J.-J. Lee, Trans. Electr. Electron. Mater., 15, 81 (2014).
F. Xu, Y. Qiu, G. Jiang, B. Ding, J. Li, Q. Liu, J. Wu, X. Xu, H. Wang and Y. Liang, Macromol. Rapid Commun., 40, 1800770 (2019).
Y. Liu, P. Liu, Lin, Li, S. Wang, Z. Pan, C. Song and T. Wang, J. Electroanal. Chem., 903, 115828 (2021).
M. Jung, I. Yang, J. Yoo, M.-S. Kim and J. C. Jung, J. Electrochem. Soc., 168, 080532 (2021).
I. Yang, J. Yoo, J. Lee, M.-S. Kim and J. C. Jung, J. Electrochem. Soc., 166, A3950 (2019).
D. R. Lobato-Peralta, R. Amaro, D. M. Arias, A. K. Cuentas-Gallegos, O. A. Jaramillo-Quintero, P. J. Sebastian and P. U. Okoye, J. Electroanal. Chem., 901, 115777 (2021).
X. Yuan, M.-K. Cho, J. G. Lee, S. W. Choi and K. B. Lee, Environ. Pollut., 265, 114868 (2020).
C. Yuwen, B. Liu, Q. Rong, L. Zhang and S. Guo, Sci. Total Environ., 817, 152995 (2022).
S. Sharifian and N. Asasian-Kolur, J. Anal. Appl. Pyrolysis, 163, 105496 (2022).
I. Yang, J. H. Mok, M. Jung, J. Yoo, M.-S. Kim, D. Choi and J. C. Jung, Macromol. Rapid. Commun., 43, 2200006 (2022).
S. Chen, Z. Liu, S. Jiang and H. Hou, Sci. Total Environ., 710, 136250 (2020).
M. Karakoti, S. Pandey, R. Jangra, P. S. Dhapola, P. K. Singh, S. Mahendia, A. Abbas and N. G. Sahoo, Mater. Manuf., 36, 171 (2021).
E. Azwar, W. A. W. Mahari, J. H. Chuah, D.-V. N. Vo, N. L. Ma, W. H. Lam and S. S. Lam, Int. J. Hydrog. Energy, 43, 20811 (2018).
K. R. Vanapalli, H. B. Sharma, V. P. Ranjan, B. Samal, J. Bhattacharya, B. K. Dubey and S. Goel, Sci. Total Environ., 750, 141514 (2021).
K. S. Khoo, L. Y. Ho, H. R. Lim, H. Y. Leong and K. W. Chew, J. Hazard. Mater., 417, 126108 (2021).
J. Huang, A. Veksha, W. P. Chan, A. Giannis and G. Lisak, Renew. Sust. Energ. Rev., 154, 111866 (2022).
A. L. P. Silva, J. C. Prata, T. R. Walker, A. C. Duarte, W. Ouyang, D. Barcelò and T. Rocha-Santos, Chem. Eng. J., 405, 126683 (2021).
S. Brunauer, P. H. Emmett and E. Teller, J. Am. Chem. Soc., 60, 309 (1938).
I. Yang, D. Kwon, M.-S. Kim and J. C. Jung, Carbon, 132, 503 (2018).
I. Yang, M. Jung, M.-S. Kim, D. Choi and J. C. Jung, J. Mater. Chem. A, 9, 9815 (2021).
J. Yoo, I. Yang, D. Kwon, M. Jung, M.-S. Kim and J. C. Jung, Energy Technol., 9, 2000918 (2021).
D.-W. Kim, H.-S. Kil, K. Nakabayashi, S.-H. Yoon and J. Miyawaki, Carbon, 114, 98 (2017).
K. Lászlo, A. Bóta and I. Dékány, Carbon, 41, 1205 (2003).
A. C. Ferrari and J. Robertson, Phys. Rev. B, 61, 14095 (2000).
A. C. Ferrari, Solid State Commun., 143, 47 (2007).
F. Tuinstra and J. L. Koenig, J. Chem. Phys., 53, 1126 (1970).
D. Qu and H. Shi, J. Power Sources, 74, 99 (1998).
H. D. Yoo, J. H. Jang, J. H. Ryu, Y. Park and S. M. Oh, J. Power Sources, 267, 411 (2014).
C. Lei, F. Markoulidis, Z. Ashitaka and C. Lekakou, Electrochim. Acta, 92, 183 (2021).
C. Portet, P. L. Taberna, P. Simon and C. Laberty-Robert, Electrochim. Acta, 49, 905 (2004).
B.-A. Mei, O. Munteshari, J. Lau, B. Dunn and L. Pilon, J. Phys. Chem. C, 122, 194 (2018).
X. Liu, L. Juan, L. Zhan, L. Tang, Y. Wang, W. Qiao, X. Liang and L. Ling, J. Electroanal. Chem., 642, 75 (2010).
Acknowledgements
This work was supported by the National Research Foundation of Korea (NRF) grant funded by the Korea government (MSIT) (2021R1F1A1046272).
Author information
Authors and Affiliations
Corresponding authors
Additional information
Supporting Information
Additional information as noted in the text. This information is available via the Internet at http://www.springer.com/chemistry/journal/11814.
Rights and permissions
About this article
Cite this article
Jung, M., Yang, I., Choi, D. et al. Activated carbons derived from polyethylene terephthalate for coin-cell supercapacitor electrodes. Korean J. Chem. Eng. 40, 2442–2454 (2023). https://doi.org/10.1007/s11814-023-1466-3
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11814-023-1466-3