Abstract
The production of ash-free coal as a clean fuel for high temperature fuel cell was investigated. The ash-free coal was made from a bituminous coal. It was prepared by solvent extraction using a microwave. The solvent-to-coal ratio and microwave irradiation time of raw coal were parameters for the extraction yield. The microwave method showed merits in terms of faster extraction and higher extraction yield than conventional heating methods. In addition, gasification behaviors of the ash-free coal were investigated by gas chromatography. Contrary to carbon, ash-free coal showed hydrogen as a dominant gas species in its gasification and did not require carbonate catalyst. The electrical conductivity of ash-free coal was found very low close to zero.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
E. Jorhani, H. Ghasemi Chapi and M. Tayebi Khorami, Fuel Process. Technol., 92, 1898 (2011).
T. Yoshida, T. Takanohashi, K. Sakanishi, I. Saito, M. Fujita and K. Mashimo, Fuel, 81, 1463 (2002).
N. Okuyama, N. Komatsu, T. Shigehisa, T. Kaneko and S. Tsuruya, Fuel Process. Technol., 85, 947 (2004).
M. Iino, T. Takanohashi, H. Ohsuga and K. Toda, Fuel, 67, 1639 (1988).
K. Renganathan, J.W. Zondlo, E.A. Mintz, P. Kneisl and A.H. Stiller, Fuel Process. Technol., 18, 273 (1988).
K. Ouchi, S. Itoh, M. Makabe and H. Itoh, Fuel, 68, 735 (1989).
K. Miura, M. Shimada and H. Huan, Fuel, 80, 1573 (2001).
C. Li, T. Takanohashi, I. Saito, M. Iino, H. Aoki and K. Mashimo, Energy Fuels, 18, 97 (2004).
L. Zhang, H. Kawashima, T. Takanohashi, T. Nakazato, I. Saito and H. Tao, Energy Fuels, 22, 1183 (2008).
R. Yoshiie, H. Watanabe, S. Uemiya, A. Furuya, N. Okuyama and N. Komatsu, Fuel, 102, 26 (2012).
O. Somnez and E. Giray, Fuel, 90, 2125 (2011).
Z. Lei, L. Wu, Y. Zhang, H. Shui, Z. Wang, C. Pan, H. Li, S. Ren and S. Kang, Fuel, 95, 630 (2012).
C.-G. Lee, H. Hur and M.-B. Song, J. Electrochem. Soc., 158, B410 (2011).
A. Sharma, T. Takanohashi, K. Morishita, T. Takarada and I. Saito, Fuel, 87, 491 (2008).
K. Masaki, T. Yoshida, C. Li, T. Takanohashi and I. Saito, Energy Fuels, 18, 995 (2004).
S.-H. Lee, Development of ashless coal production and application technology (III), KIER-A82801, A report of Korea Institute of Energy Research (2008).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Lee, CG., Kim, WK. & Vu, DL. Gasification of ash-free coal prepared with microwave method. Korean J. Chem. Eng. 32, 1784–1788 (2015). https://doi.org/10.1007/s11814-014-0370-2
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11814-014-0370-2