Abstract
The gasification rates of Shenmu coal chars with CO2 were experimentally studied with a pressurized thermo- gravimetric analyzer (PTGA). Shenmu coal is a typical Chinese coal, and the coal char was prepared by a fixed-bed reactor in nitrogen at 900 °C. The experiments were carried out in the dynamic heating segments from 750 °C to 1,000 °C, and the reaction pressure increased from 0.1MPa to 3.1MPa with pure CO2. The external diffusion resistances were minimized by increasing the flow rates and decreasing the thickness of sample layer before the test, to ensure the reactions were under kinetic control. The results show that the gasification rates increase proportionally to the 0.1 power of the CO2 partial pressure. The unreacted-core shrinking model was applied to predict the reaction rate by changing the molar fraction of CO2 at 0.6Mpa and 1.6Mpa total pressures, which showed a good match with experimental data.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
R. C. Messenbock, D. R. Dugwell and R. Kandiyoti, Energy & Fuels, 13, 122 (1999).
D. H. Ahn, et al., Fuel, 80, 1651 (2001).
S. Kajitani, S. Hara and H. Matsuda, Fuel, 81, 539 (2002).
F. F. Peng, I.C. Lee and R.Y.K. Yang, Fuel Processing Technology, 41, 233 (1995).
D. G. Roberts and D. J. Harris, Energy & Fuels, 14, 483 (2000).
J. Ochoa, et al., Fuel Processing Technology, 74, 161 (2001).
G.-s. Liu and S. Niksa, Progress in Energy and Combustion Science, 30, 679 (2004).
P. Ollero, et al., Fuel, 81, 1989 (2002).
T. F. Wall, et al., Progress in Energy and Combustion Science, 28, 405 (2002).
J.W. Kuang, Z. L. Liu and S. F. Li, Transactions of Tianjin University, (2), 48 (1991).(in Chinese)
Y.H. Xiang, et al., Journal of Fuel Chemistry and Technology, 30(5), 398 (2002). (in Chinese)
J. Zhou, X. Gong and Z.H. Yu, Coal Conversion, 26(1), 78 (2003). (in Chinese)
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Wang, M., Zhang, J., Zhang, S. et al. Experimental studies on gasification of the Shenmu coal char with CO2 at elevated pressures. Korean J. Chem. Eng. 25, 1322–1325 (2008). https://doi.org/10.1007/s11814-008-0216-x
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11814-008-0216-x