Abstract
Commercially available butter, regular-fat margarine, and a fat-reduced margarine (38% fat w/w) were stored between 10 and 35°C for up to 4 d to elaborate on the relationship between droplet size and solid fat content (SFC) that exists in these spreads. At 10°C, the mean volume-weighted droplet size for butter was 4.22±0.40 μm followed by margarine (6.22±0.10 μm) and fat-reduced margarine (12.62±0.28 μm). At higher temperatures, as a result of decreasing SFC, the mean droplet size increased as did the droplet size distribution, leading to eventual coalescence and destabilization in all spreads. In butter, the critical SFC was ∼9%, whereas in margarine notable coalescence occurred at ∼5% SFC. The fat-reduced margarine destabilized at lower temperatures than the other spreads (∼20°C vs. ∼30°C), at an SFC of ∼6.5%. In these spreads, two different mechanisms influenced dispersed phase stability: (i) steric stabilization against coalescence via fat crystals located at the droplet interface, known as Pickering stabilization, and (ii) stabilization against droplet sedimentation (and droplet encounters) due to the presence of the fat crystal network.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Pickering, S.U., Emulsions, J. Chem. Soc. 91:2001–2021 (1907).
Rousseau, D., Fat Crystals and Emulsion Stability—A Review, Food Res. Int. 33:1–14 (2000).
Borwankar, R.P., L.A. Frye, A.E. Blaurock, and F.J. Sasevich, Rheological Characterization of Melting of Margarines and Tablespreads, J. Food Eng. 16:55–74 (1992).
Borwankar, R.P., and G.S. Buliga, Emulsion Properties of Margarines and Lowfat Spreads, Am. Inst. Chem. Eng. Symp. Series 86:44–52 (1990).
Heertje, I., Fat Crystals, Emulsifiers and Liquid Crystals: From Structure to Functionality, Pol. J. Food Nutr. Sci. 7 (Suppl.): 2S-18S (1998).
Ambrosone, L., A. Ceglie, G. Colafemmina, and G. Pallzo, Emulsions: A Time-Saving Evaluation of the Droplets’ Polydispersity and of the Dispersed Phase Self-Diffusion Coefficient, Langmuir 15:6775–6780 (1999).
Packer, K.J., and C. Rees, Pulsed NMR Studies of Restricted Diffusion. I. Droplet Size Distributions in Emulsions, J. Colloid Interface Sci. 40:206–218 (1972).
Van den Enden, J.C., D. Waddington, H. Van Aalst, C.G. Van Kralingen, and K.J. Packer, Rapid Determination of Water Droplet Size Distributions by PFG-NMR, 140:105–113 (1990).
Li, X., J.C. Cox, and R.W. Flumerfelt, Determination of Emulsion Size Distribution by NMR Restricted Diffusion Measurement, AIChE J. 38:1671–1674 (1991).
Balinov, B., O. Söderman, and T. Wärnhelm, Determination of Water Droplet Size in Margarine and Low-Calorie Spreads by Nuclear Magnetic Resonance Self-Diffusion, J. Am. Oil Chem. Soc. 71:513–518 (1994).
Lee, H.-Y., M.J. McCarthy, and S.R. Dungan, Experimental Characterization of Emulsion Formation and Coalescence by Nuclear Magnetic Resonance Restricted Diffusion Techniques, 75:463–475 (1998).
Lucassen-Reynders, E.H., Stabilization of Water in Oil Emulsions by Solid Particles, Ph.D. Thesis, Wageningen Agricultural University, Wageningen, The Netherlands, 1962.
Lee, R.F., Agents Which Promote and Stabilize Water-in-Oil Emulsions, Spill Sci. Technol. Bull. 5:117–126 (1999).
Edwards, D.A., and D.T. Wasan, A Micromechanical Model of Linear Surface Rheological Behavior, Chem. Eng. Sci. 46:1247–1257 (1991).
Tambe, D.E., and M.M. Sharma, Factors Controlling the Stability of Colloid-Stabilized Emulsions. I. An Experimental Investigation, J. Colloid Interface Sci. 157:244–253 (1993).
Author information
Authors and Affiliations
Corresponding author
About this article
Cite this article
Rousseau, D., Zilnik, L., Khan, R. et al. Dispersed phase destabilization in table spreads. J Amer Oil Chem Soc 80, 957–961 (2003). https://doi.org/10.1007/s11746-003-0803-0
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/s11746-003-0803-0