Abstract
The Liquid Phase Methanol Synthesis (LPMeOHTM) process has been investigated in our laboratories since 1982The reaction chemistry of liquid phase methanol synthesis over commercial Cu/ZnO/Al2O3 catalysts, established for diverse feed gas conditions including H2-rich, CO-rich, CO2-rich, and CO-free environments, is predominantly based on the CO2 hydrogenation reaction and the forward water-gas shift reactionImportant aspects of the liquid phase methanol synthesis investigated in this in-depth study include global kinetic rate expressions, external mass transfer mechanisms and rates, correlation for the overall gas-to-liquid mass transfer rate coefficient, computation of the multicomponent phase equilibrium and prediction of the ultimate and isolated chemical equilibrium compositions, thermal stability analysis of the liquid phase methanol synthesis reactor, investigation of pore diffusion in the methanol catalyst, and elucidation of catalyst deactivation/regenerationThese studies were conducted in a mechanically agitated slurry reactor as well as in a liquid entrained reactorA novel liquid phase process for co-production of dimethyl ether (DME) and methanol has also been developedThe process is based on dual-catalytic synthesis in a single reactor stage, where the methanol synthesis and water gas shift reactions takes place over Cu/ZnO/Al2O3 catalysts and the in-situ methanol dehydration reaction takes place over γ-Al2O3 catalystCo-production of DME and methanol can increase the single-stage reactor productivity by as much as 80%. By varying the mass ratios of methanol synthesis catalyst to methanol dehydration catalyst, it is possible to co-produce DME and methanol in any fixed proportion, from 5% DME to 95% DMEAlso, dual catalysts exhibit higher activity, and more importantly these activities are sustained for a longer catalyst on-stream life by alleviating catalyst deactivation.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Sherwin M., Blum D., Liquid Phase Methanol, Final Report EPRI AF-1291 (Project 317-2) Electric Power Research Institute, Palo Alto, CA.
A. Cybulski (1994) Cat. Rev. Sci. Eng. 36 IssueID4 557
Lee S., Berty J.M., Greene H.L., Desirazu S., Ko M., Parameswaran V. Sawant A., Research to Support Development of the Liquid-phase Methanol Synthesis Process Quarterly Report, University of Akron, Jan. 7, 1984.
S, Lee, Berty J.M., Greene H.L., Desirazu S., Ko M., Parameswaran V. Sawant A., Thermodynamics, kinetics, and thermal stability of liquid phase methanol synthesis, Electric Power Research Institute, EPRI AP-3825-SR, Proceedings, Ninth Annual EPRI Contractor’s Conference on Coal Liquefaction, Palo Alto, May 1984.
Lee S., Sawant A., Parameswaran V. Sullivan T., Research into thermodynamics, mass transfer, oil and catalyst degradation in liquid phase methanol, Electric Power Research Institute, Proceedings, Ninth Annual EPRI Contractor’s Conference on Clean Liquid and Solid Fuels, Special Report EPRI AP-4253-SR, Palo Alto, 1985.
Lee S., Berty J., Desirazu S., Gray J., Greene H., Ko M., Parameswaran V., Pelc F., Polasky M., Rangarajan R., Sawant A. Sivagnanam K., Research to support development of the liquid phase methanol synthesis process, EPRI-AP-4429, 1–312, Research project 2146–2142, University of Akron, Feb. 1986.
Lee S., Parameswaran V., Sawant A. Ko M., Mass Transfer in the Liquid Phase Methanol Synthesis Process, Interim Report, EPRI AP-5758, 1986.
M. Ko S. Lee (1987) Energy & Fuels 1 211–216
Ko M., Mass Transfer Study for Liquid Phase Methanol Synthesis Process, Ph. Dissertation D., University of Akron, 1987.
Lee S., Parameswaran V., Sawant A., Ko M., Cho D., Research on once through methanol, Electric Power Research Institute, EPRI AP-5043-SR, Proceedings, Eleventh Annual EPRI Contractor’s Conference on Clean Liquid and Solid Fuels, Special Report EPRI AP-4253-SR, Palo Alto, 1987.
Parameswaran V., Roles of Carbon Dioxide and Water in Liquid Phase Methanol Synthesis, Ph. Dissertation D., University of Akron, 1987.
Sawant A., Effects of Water and Thermal Aging on the Methanol Synthesis Catalyst, Ph. Dissertation D., University of Akron, 1987.
V. Parameswaran S. Lee (1987) Energy & Fuels 1 IssueID2 217
A. Sawant M. Ko V. Parameswaran S. Lee C. Kulik (1987) Fuel Science Technology, International, “ In-situ Reduction of a Methanol Synthesis Catalyst in a Three Phase Slurry Reactor”, 5 IssueID1 77
Lee S., Mass Transfer Characteristics of the Liquid Phase Methanol Synthesis Process, Electric Power Research Institute, pp. 1–214, EPRI AP-5758, Palo Alto, CA, April, 1988.
A. Sawant S. Lee C. Kulik (1988) Fuel Sci. Tech. Int. 6 IssueID2 151
A. Sawant S. Lee A. Foos (1988) Fuel. Sci. Tech. Intl. 6 IssueID5 569
Lee B.G., Post-treatment and Regeneration of Methanol Synthesis Catalyst, Ph. Dissertation D., University of Akron, 1989.
Lee S., Lee B.G. Parameswaran V., Fundamentals of methanol synthesis, Electric Power Research Institute, Proceedings, Thirteenth Annual EPRI Contractor’s Conference on Clean Liquid and Solid Fuels, Palo Alto, Jan 1989.
V. Parameswaran S. Lee I. Wender (1989) Fuel Sci. Tech. Intl. 7 IssueID7 899
V. Parameswaran C. Kulik I. Wender S. Lee (1989) Fuel Sci. Tech. Intl. 7 IssueID8 1021
A. Sawant K. Rodrigues S. Lee C.J Kulik (1989) Energy & Fuels 3 IssueID1 2
S. Lee (1990) Methanol Synthesis Technology CRC Press Boca Raton FL
Lee S. Parameswaran V., Reaction Mechanism in Liquid-Phase Methanol Synthesis, Electric Power Research Institute, pp. 1–206, ER/GS-6715, Palo Alto, CA, February 1990.
Lee S., Sawant A. Kulik C., Process for Methanol Catalyst Regeneration Using Crystallite Redispersion, Patent U.S., No. 5,004,717, April 2, 1991.
B.G. Lee S. Lee C.J. Kulik (1991) Fuel Sci. Tech. Intl. 9 IssueID5 587
V. Parameswaran M. Gogate B.G. Lee S. Lee (1991) Fuel Sci. Tech. Intl. 9 IssueID6 695
B.G. Lee S. Lee (1991) Fuel Sci. Tech. Intl. 9 IssueID8 977
M. Gogate S. Desirazu J. Berty S. Lee (1992) Fuel Sci. Tech. Intl. 10 IssueID10 1709
P. Vijayaraghavan S. Lee C.J. Kulik (1992) Fuel Sci. Tech. Intl. 10 IssueID9 1501
P. Vijayaraghavan S. Lee (1993) Fuel Sci. Tech. Intl. 11 IssueID2 243
P. Vijayaraghavan S. Lee (1993) Fuel Sci. Tech. Intl. 11 IssueID11 1577
Vijayaraghavan P., Entrained Reactor Studies on the Liquid Phase Methanol Synthesis Process, Ph. Dissertation D., University of Akron, 1994.
P. Vijayaraghavan S. Lee (1993) Fuel Sci. Tech. Intl. 11 IssueID10 1459
M. Gogate S. Lee (1994) Fuel Sci. Tech. Intl. 12 IssueID1 35
P. Vijayaraghavan S. Lee C. Kulik (1995) Fuel Sci Tech Intl. 13 IssueID3 317
P. Vijayaraghavan S. Lee (1995) Fuel Sci. Tech. Intl. 13 IssueID3 331
P. Vijayaraghavan S. Lee (1996) Fuel Sci. Tech. Intl. 14 IssueID5 685
P. Vijayaraghavan S. Lee (1996) Fuel Sci. Tech. Intl. 14 IssueID5 695
T. Tartamella S. Lee (1996) Fuel Sci. Tech. Intl. 14 IssueID5 713
Lee S., Parameswaran V. Kulik C., Post-reduction Treatment of Alcohol Synthesis Catalysts with Carbon Dioxide, Patent U.No S.. 5,622,907, 1997.
Brown D.M., Hsuing T.H., Studer D.W. Henderson J.L., A Novel Liquid Phase System for Methanol Synthesis, TOCAT 1, 1st Tokyo Conf. Adv. Catalytic Sci. Technol. Tokyo, Julyl 1–5, 1990.
Markiewicz G.S., Tsao T.R., Heydorn E.C. Henderson J.L., Design, construction, operation of the LPMeOH process development unit, Synfuels 4th Worldwide Symposium, Washington D.C., Nov. 7–9, 1984.
Kornosky R., Liquid phase methanol (LPMeOHTM) process demonstration project, http://www.netl.doe.gov/publications/success/fetcss_lpmeoh.html.
M. Gogate S. Lee C. Kulik (1991) Fuel Sci. Tech Intl. 9 IssueID6 653
M. Gogate S. Lee (1991) Fuel Sci. Tech. Intl. 9 IssueID7 889
M. Gogate S. Lee (1991) Fuel Sci. Tech. Intl. 9 IssueID8 949
Lee S. Gogate M., Development of a Single Stage, Liquid Phase Synthesis Process of Dimethyl Ether from Syngas, EPRI TR-100246, pp. 1–179, EPRI, Palo Alto, CA, February, 1992.
Gogate M., A Novel Single-step Dimethyl Ether Synthesis Process from Syngas, Ph. Dissertation D., University of Akron, 1992.
M. Gogate P. Vijayaraghavan C. Kulik (1992) Fuel Sci. Tech. Intl. 10 IssueID3 281
M. Gogate C. Kulik S. Lee (1992) Chem. Eng. Sci. 47 IssueID13/14 3769
A. Sardesai S. Lee (1998) Rev Process Chem. and Eng. 1 IssueID2 141
F. Keil (1999) Micropor. Mesopor. Mat. 29 49
A. Sardesai A. Gunda T. Tartamella S. Lee (2000) Energy Sources 22 IssueID1 77
Lee S., Gogate M. Fullerton K., Dimethyl Ether to Hydrocarbons/Gasoline Process, Patent U.No S.. 5,459,166, October 17, 1995.
M. Gogate S. Lee C. Kulik (1995) Fuel Sci. Tech. Intl. 13 IssueID8 1039
A. Sardesai T. Tartamella M. Gogate S. Lee (1995) Fuel Sci. Tech. Intl. 13 IssueID8 1059
A. Sardesai T. Tartamella C. Midha S. Lee (1996) Fuel Sci. Tech. Intl. 14 IssueID5 669
A. Sardesai T. Tartamella S. Lee (1996) Fuel Sci. Tech. Intl. 14 IssueID5 703
Sardesai A., Catalytic Conversion of Dimethyl Ether to Lower Olefins: Process and Catalyst Deactivation Studies, Ph. Dissertation D., University of Akron, 1997.
A. Sardesai T. Tartamella S. Lee (1999) Petroleum Sci. Technol. 17 IssueID3,4 273
A. Sardesai T. Tartamella S. Lee (2002) Energy Sources 24 IssueID4 301
D.M. Brown B.L. Bhatt T.H. Hsuing F.J. LewnardJ.J. Waller (1991) Catal Today 8 279
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Lee, S., Sardesai, A. Liquid phase methanol and dimethyl ether synthesis from syngas. Top Catal 32, 197–207 (2005). https://doi.org/10.1007/s11244-005-2891-8
Issue Date:
DOI: https://doi.org/10.1007/s11244-005-2891-8