Abstract
The recovery of fine clean coal from waste streams using column flotation is recognized as an efficient and economical technique. However, due to the low percent solids (≈3% by weight) found in these fine waste slurries, the flotation columns have low capacities and are, thus, underutilized. In this study, a 3% (by weight) solids suspension of Upper Freeport coal was flocculated with polymers and concentrated to 10% (by weight) solids. The flocculated slurry was then floated using 250 git No. 2 fuel oil and 250 git MIBC, which provided a clean coal with 12% ash at an 80% yield. The results showed that flocculated coal could be floated effectively. Zeta potential and contact-angle data showed that the presence of polymer on the surface of the coal did not affect its hydrophobicity, and in some cases it improved the hydrophobicity as indicated by larger contact angles.
Article PDF
Similar content being viewed by others
Explore related subjects
Discover the latest articles, news and stories from top researchers in related subjects.Avoid common mistakes on your manuscript.
References
Osasere, O.F., 1998, “Estimation of the wettability of coal from contact angles using coagulants and flocculants,” Fuel, Vol. 77, pp. 1107–1111.
Osasere, O.F., 2000, “Relationship of contact angle data to Hallimond tube flotation of coal with coagulants and flocculants,” Fuel, Vol. 79, pp. 193–199.
Parekh, B.K., and Brauch, P.T., 1999, “Flotation of flocculated coal slurry,” in Mineral Processing, J.S. Laskowski, ed., The Canadian Institute of Mining, Metallurgy and Petroleum, Montreal, Quebec, pp. 571–578.
Parekh, B.K., and Groppo, J.G., 1988, “Recovery of fine coal from preparation plant refuse using column flotation,” in Column Flotation ’88, KV.S. Sastry, ed., pp. 227–233.
Tjioangandjara, K.F., and Somasundaran, P., 1991, “Effects of changes in adsorbed polyacrylic acid confirmations on alumina flocculation,” Colloids and Surfaces, Vol. 55, pp. 245–255.
Yoon, R.H., Luttrell, G.H., Adel, G.T., and Mankosa, M, 1992, “The Application of Microcel Column Flotation to Fine Coal Cleaning,” Coal Preparation, Vol. 10, pp. 177–188.
Author information
Authors and Affiliations
Additional information
Nonmeeting paper number 03-313. Discussion of this peer-reviewed and approved paper is invited and must be submitted to SME Publications Dept. prior to May 28, 2005.
Rights and permissions
About this article
Cite this article
Parekh, B.K., Chen, Z. Recovery of clean coal from polymer flocculated raw coal slurry. Mining, Metallurgy & Exploration 21, 214–216 (2004). https://doi.org/10.1007/BF03403188
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/BF03403188